wiper fluid MITSUBISHI SPYDER 1990 Service Repair Manual

STEERING Power Steering Gear.
POWER STEERING GEAR BOX
REMOVAL AND INSTALLATION
Engine (Non-turbo)>
Pre-removal OperationPower Steering Fluid Draining (Refer to Stabilizer Bar Removal (Refer to GROUP Stabilizer Bar.)l Washer Tank Removal(Refer to GROUP 51 Windshield Wiper andWasher.)
tive, risking serious driver injury.
Nm Nm Nm51-58
3720039007~
TSB Revision
Removal steps
1. Joint assembly and gear boxconnecting bolt2. Power steering pipe connection
3. Cotter pin
4. Tie rod end and knuckle connec-
tion5. Stay (L.H.)
6. Stay (R.H.) Post-installation
lStabilizer Bar Installation (Refer to GROUP Stabilizer Bar.)lWasher Tank (Refer to GROUP Windshield Wiper and Washer.),lPower Steering Fluid l
Power Steering Fluid Line Bleeding (Refer to
l Wheel Position with Wheels StraightAhead Checkingl Front Wheel Alignment Adjustment
(Refer to GROUP On-vehicle Service.)
6951
7. Center member assembly
8. Clamp
Gear box assembly
CautionThe fasteners marked should be temporarily tightened
before they are finally tightened once the total we ight of
the engine has been placed on the vehicle body.

STEERINGPower Steering Hoses
Operation
l Fluid, Draining (Refer to l Front Bumper Removal(Refer to GROUP 51 Front Bumper.)l Tank Removal (Refer to GROUP 51 Windshield Wiper and
POWER STEERING HOSES ENGINE
REMOVAL AND
11 Nm
11
3.9 Nm2.9
Removal steps
1.Oil reservoir
h o s e
Suction hose5.Return hose6.Return hose7.Pressure tube
8.Return tube
T S B R e v i s i o n
9.Pressure10. Return 11.Pressure tubs
12.tube13. fascia bracketFront14.Air guide duct15.Cooler tubs

EXTERIOR Wiper and .
WINDSHIELD WIPER ANDWASHER
GENERAL
OPERATION
Low-speed (and high-speed) wiper operation
l When the wiper switch is placed in the LO
position with the ignition switch in the ACC
or ON position, wipers operate continuously
at low speed.
l Placing the wiper switch in the HI position
causes the wipers to operate at high speed.
Auto wiper stop operation
lWhen the wiper switch is placed in the OFF position, the cam contacts of wiper motor
causes current to flow through the auto wiper
stop circuit, allowing the wiper blades to cycle
before they reach to the stop positions.
Intermittent wiper operation
l When the wiper switch is placed in the
position with the ignition switch in ACC or ON
position,the intermittent wiper relay is
energized causing the intermittent wiper relay
contacts to close and open repeatedly.
lWhen the contacts are closed, motor
is energized.
lWhen the wiper motor is energized, the
contacts open; however, the
the wiper motor energized until the wiper
return to their stop position.
W a s h e r - w i p e r o p e r a t i o n -
l When the washer switch
ON, the
intermittent wiper relay causing
wipers to cycle’ one to two times.
Remark
lThe washer-wiper operates in the priority even
during intermittent operation of the wiper.
Washer fluid level warning light
lWhen the washer fluid level goes down below
a predetermined level with the ignition switch
in ON position, the washer level switch makes
the washer fluid level warning light illuminate.
SERVICE SPECIFICATION51100030140
Item
Windshield wiper blade installation position mm (in .)Standard value(A):
TSB Revision

8ALPHABETICAL INDEX
PRINTED-HEATER LINE
Check. . . . . . . . . . . . . . . . . . . . . . . . . .
Repair . . . . . . . . . . . . . . . . . . . . . . . . . . .
PROPELLER SHAFT . . . . . . . . . . . . . . . . . . . . . .
PROPORTIONING VALVE
. . . . . . . . . . . . . . . . . . . . . . . . . . . Brakes> . . . . . . . . . . . . . . . , . . . . . . . . . . . .
Function Test . . . . . . . . .
PUMPFuel, Operation Check ENGINE (TURBO) AND ENGINE>. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Oil. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil, Pressure Test. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Water ENGINE (NON-TURBO)>.. . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE>. . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
I
PURGE CONTROL SYSTEM
Check
ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . . ENGINE (TURBO) . . . . . . . . . . . . . . . . . . . . ENGINE>. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .PURGE CONTROL VALVE ENGINE (TURBO)> . . . . .
PURGE PORT VACUUM
Check ENGINE (NON-TURBO)> . . . . . . . . . . .
ENGINE (TURBO) AND .
QUARTER WINDOW GLASS . . . . . . . . , . . . . . . . . .
RADIATOR. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .RADIO. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .REAR AXLE, Total Backlash Check . . . . . . . . . . . . . .REAR AXLE OIL, Maintenance. . . . . . . . . . . . . . . . . . . . . . . . . .REAR BRAKE DISC
Run-out Check. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Run-out Correction. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Thickness Check. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .REAR BUMPER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .REAR CLUTCH
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .REAR COMBINATION LIGHT. . . . . . . . . . . . . . . . . . . . . . . . . .REAR DISC BRAKE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .REAR DISC BRAKE PAD, Check and Replacement. . . . . .REAR DRUM BRAKE LININGS. Maintenance. . . . . . . . . . . . .REAR DRUM BRAKE SHOE. . . . . . . . . . . . . . . . . . . . . . . . . .REAR DRUM BRAKE WHEEL CYLINDER. . . . . . . . . . . . .REAR HUB
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rotary-Sliding Resistance Check . . . . . . . . . . . . . . .REAR SEAT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .REAR SUSPENSION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .REAR VIEW MIRROR, Inside. . . . . . . . . . . . . . . . . . . . . . . . .REAR WASHER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .REAR WHEEL ALIGNMENT, Check and Adjustment. . . . . . . .REAR WHEEL CYLINDERS, Maintenance. . . . . . . . . . . . . . . .REAR WINDOW DEFOGGER. . . . . . . . . . . . . . . . . . . . . . . . .REAR WINDOW DEFOGGER SWITCH. . . . . . . . . . . . . . . . .REAR WIPER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .RECEIVER DRIER, Test. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
REDUCING PRESSURE, Adjustment ENGINE (TURBO)
AND ENGINE> , . . . . . . . . . . . . . . . . . . . . . . , . . . . , . . .
REFRIGERANT LINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
REFRIGERANT, Leak Repair . . . . . . . . . . . . . . . . . . . . . . . . .
REGULATED VOLTAGE
Test ENGINE (NON-TURBO)> . . . . . . . . . . . . . . . . ENGINE (TURBO) AND ENGINE> . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
RELAY
ASD, On-vehicle Inspection
ENGINE (NON-TURBO)> . . . . . . . . . . . . . . .
Fuel Injection On-vehicle Inspection ENGINE (NON-TURBO)> . . . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE>. . . .
Power, Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
RESISTANCE, Rotary-sliding, Rear Hub, Check . . .
RESISTOR . . . . . . . . . . . . . . . . . . , . . . . . . . . . . . . . . . . . . . . . . . .
RESISTOR, On-vehicle Inspection ENGINE (TURBO)> . . . . . . . . . . . . . . . . . . . . . . . . .
RHEOSTAT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ROCKER ARMS
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ROLL STOPPER, Engine.. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ROTARY-SLIDING RESISTANCE, Rear Hub, Check. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .ROTOR, Disc Brake, Front, Check. . . . . . . . . . . . . . . . . . . . .
ROWER STEERING PRESSURE SWITCH, Check. . . . . .
RUN-OUT
Front Brake Disc, Check. . . . . . . . . . . . . . . . . . . . . . . . . . .Front Brake Disc, Correction. . . . . . . . . . . . . . . . . . . . . . .
Rear Brake Disc, Check. . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Brake Disc, Correction. . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SCHEMATIC. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SEAL(S)
Ball Joint, Maintenance
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Oil. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Steering. . . . . . . . . . . . . . . . . . . . . . .
SEAT BELT, Front. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SEAT BELT, Rear. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .SEAT
Front. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . .
Rear. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SELECTOR LEVER
Operation Check ENGINE . . . . . . . . . . . . . . . ENGINE . . . .
SENSOR
Brake Fluid Level, Check . . , . . . . . . . . . . . . . . . . . . , . . . .Camshaft Position ENGINE . .
ENGINE (TURBO)> . . . . . . . .
. . . . . . . . . . . . . . . . .
Crankshaft Position ENGINE (NON-TURBO)> . . .
ENGINE (TURBO)> . . . . . . . .
. . . . . . . . . . . . . . . . .
Engine Coolant Temperature ENGINE (NON-TURBO)> . . . . . . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE>. . . . . . .
Engine Coolant Temperature, On-vehicle Inspection ENGINE (NON-TURBO)> . . . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE>. . . .
Heated 0 On-vehicle Inspection (NON-TURBO)> . . . . . . . . . . . . . ENGINE (TURBO) AND ENGINE> . . . .
Intake Air Temperature ENGINE (NON-TURBO)> . . . . . . . . . . . . . . . . . . .