power steering NISSAN 350Z 2006 Owner´s Manual
[x] Cancel search | Manufacturer: NISSAN, Model Year: 2006, Model line: 350Z, Model: NISSAN 350Z 2006Pages: 297, PDF Size: 3.36 MB
Page 223 of 297
Windshield defroster:Check that the air
comes out of the defroster outlets properly and
in good quantity when operating the heater or air
conditioner.Under the hood and the vehicleThe maintenance items listed here should be
checked periodically (for example, each time you
check the engine oil or refuel).
Battery*:Check the fluid level in each cell. It
should be between the MAX and MIN lines.
Vehicles operated in high temperatures or under
severe conditions require frequent checks of the
battery fluid level.
Brake and clutch fluid levels*:Make sure that
the brake and clutch fluid levels are between the
MAX and MIN lines on the reservoir.
Engine coolant level*:Check the coolant level
when the engine is cold.
Engine drive belts*:Make sure that no belt is
frayed, worn, cracked or oily.
Engine oil level*:Check the level on the
dipstick after parking the vehicle on a level spot,
turning off the engine and waiting 10 minutes.
Exhaust system:Make sure there are no loose
supports, cracks or holes. If the sound of the
exhaust seems unusual or there is a smell of
exhaust fumes, immediately locate the troubleand correct it. (See “Precautions when starting
and driving” in the “5. Starting and driving”
section for exhaust gas (carbon monoxide).)
Fluid leaks:Check under the vehicle for fuel,
oil, water or other fluid leaks after the vehicle has
been parked for a while. Water dripping from the
air conditioner after use is normal. If you should
notice any leaks or if gasoline fumes are evident,
check for the cause and have it corrected imme-
diately.
Power steering fluid level* and lines:Check
the level in the reservoir tank with the engine off.
Check the lines for proper attachment, leaks,
cracks, etc.
Radiator and hoses:Check the front of the
radiator and clean off any dirt, insects, leaves,
etc., that may have accumulated. Make sure the
hoses have no cracks, deformation, deterioration
or loose connections.
Underbody:The underbody is frequently ex-
posed to corrosive substances such as those
used on icy roads or to control dust. It is very
important to remove these substances, other-
wise rust will form on the floor pan, frame, fuel
lines and around the exhaust system. At the end
of winter, the underbody should be thoroughly
flushed with plain water, being careful to clean
those areas where mud and dirt may accumu-
late. For additional information, see “Cleaningexterior” in the “7. Appearance and care” sec-
tion.
Window washer fluid*:Check that there is
adequate fluid in the tank.8-4
Maintenance and do-it-yourself
06.1.17/Z33-D/V5.0
Page 226 of 297
1. Fuse/fusible link holder
2. Battery
3. Engine oil filler cap
4. Brake fluid reservoir
5. Clutch fluid reservoir (M/T models)
6. Windshield washer fluid reservoir
7. Power steering fluid reservoir
8. Engine coolant reservoir
9. Radiator filler cap
10. Engine oil dipstick
11. Air cleaner
Do not tamper with the strut tower bar
adjustment
A. The strut tower bar has
been adjusted to the most suitable posi-
tion at the factory.CAUTION
Tampering with the strut tower bar ad-
justment may cause a noise while driv-
ing or damage to the hood or engine.
SDI1519
ENGINE COMPARTMENT CHECK
LOCATIONS
Maintenance and do-it-yourself
8-7
06.1.17/Z33-D/V5.0
Page 232 of 297
Check the fluid level in the reservoir tank.
The fluid level should be checked using the HOT
range at fluid temperatures of 122 - 176°F (50 -
80°C) or using the COLD range at fluid tem-
peratures of 32 - 86°F (0 - 30°C).
If the fluid is below the MIN line, add Genuine
NISSAN PSF fluid. Remove the cap and fill
through the opening.
CAUTION
Do not overfill.
Recommended fluid is Genuine
NISSAN PSF or equivalent.For additional brake and clutch fluid information,
refer to “Capacities and recommended fuel/
lubricants” in the “9. Technical and consumer
information” section of this manual.
WARNING
Use only new fluid. Old, inferior or con-
taminated fluid may damage the brake
system. Do not add synthetic brake
fluid. The use of improper fluids can
damage the brake system and affect the
vehicle’s stopping ability.
CAUTION
Do not spill the fluid on any painted
surfaces. This will damage the paint. If
fluid is spilled, immediately wash the
surface with water.
SDI1443
POWER STEERING FLUID BRAKE AND CLUTCH FLUID
Maintenance and do-it-yourself
8-13
06.1.17/Z33-D/V5.0
Page 236 of 297
JUMP STARTINGIf jump starting is necessary, see “Jump starting”
in the “6. In case of emergency” section. If the
engine does not start by jump starting, the
battery may have to be replaced. Contact a
NISSAN dealer.1. Power steering fluid pump
2. Alternator
3. Crankshaft pulley
4. Air conditioner compressor
: Tension checking points
WARNING
Be sure the ignition key is in the OFF or
LOCK position. The engine could rotate
unexpectedly.1. Visually inspect each belt for signs of unusual
wear, cuts, fraying, oil adhesion or looseness.
If the belt is in poor condition or loose, have
it replaced or adjusted by a NISSAN dealer.
2. Have the belts checked regularly for condi-
tion and tension.
SDI1480
SDI1389A
DRIVE BELTS
Maintenance and do-it-yourself
8-17
06.1.17/Z33-D/V5.0
Page 261 of 297
The following are approximate capacities. The actual refill capacities may be a little different. When refilling, follow the procedure
instructed in the “8. Maintenance and do-it-yourself” section to determine the proper refill capacity.
Capacity (Approximate)
Recommended
specifications US
measureImp
measureLiter
Fuel 20 gal 16-5/8 gal 76 Unleaded premium gasoline with an octane rating of at least 91 AKI (RON 96)*1
Engine oil (Drain and refill)*2
With oil filter change 5 qt 4-1/8 qt 4.7API Certification Mark*3, *4
API grade SG/SH, Energy ConservingI&IIorAPIgradeSJorSL,Energy Conserving*3, *4
ILSAC grade GF-I, GF-II & GF-III*2, *3 Without oil filter change 4-5/8 qt 3-7/8 qt 4.4
Cooling system
With reservoir 9-1/4 qt 7-5/8 qt 8.7
Genuine NISSAN Long Life Antifreeze/Coolant or equivalent
Reservoir 7/8 qt 3/5 qt 0.8
Automatic transmission fluid — — — Genuine NISSAN Matic J ATF*5
Manual transmission gear oil — — —Genuine NISSAN Manual Transmission Fluid (MTF) HQ Multi 75W-85 or API GL-4, Viscosity
SAE 75W-85 or 75W-90
Differential gear oil — — — API GL-5, Viscosity SAE 80W-90*6
Power steering fluid (PSF)
Refill to the proper fluid level according to the instructions in
the “8. Maintenance and do-it-yourself” section.Genuine NISSAN PSF or equivalent*7
Brake and clutch fluidGenuine NISSAN Super Heavy Duty Brake Fluid*8 or equivalent DOT 3 (U.S. FMVSS No. 116)
Multi-purpose grease — — — NLGI No. 2 (Lithium soap base)
Air conditioning system refrigerant — — — HFC-134a (R-134a)*9
Air conditioning system lubricants — — — NISSAN A/C System Oil Type S or exact equivalent
Windshield washer fluid — — — Genuine NISSAN Windshield Washer Concentrate Cleaner & Anti-freeze or equivalent
*1: For additional information, see “Fuel recommendation” later in this section.
*2: For additional information, see “Engine oil” in the “8. Maintenance and do-it-yourself” section for changing engine oil.
*3: For additional information, see “Engine oil and oil filter recommendation” later in this section.
*4: For additional information, see “Recommended SAE viscosity number” later in this section.
*5:Using automatic transmission fluid other than Genuine NISSAN Matic J ATF will cause deterioration in driveability and automatic transmission
durability, and may damage the automatic transmission, which is not covered by the NISSAN new vehicle limited warranty.
*6: For hot areas, viscosity SAE 90 is suitable for ambient temperatures above 32°F (0°C).
*7: For Canada, Nissan Automatic Transmission Fluid (ATF), DEXRON
TMIII/MERCON
TMor equivalent ATF may also be used.
*8: Available in mainland US through a NISSAN dealer.
*9: For additional information, see “Vehicle identification” in this section for air conditioner specification label.
CAPACITIES AND
RECOMMENDED FUEL/
LUBRICANTS9-2
Technical and consumer information
06.1.17/Z33-D/V5.0
Page 289 of 297
Clutch fluid.................................................................. 8-13
Coat hook.................................................................... 2-39
Cold weather driving ................................................ 5-25
Compact Disc (CD) changer operation .............. 4-26
Compact Disc (CD) player (See audio
system) ......................................................................... 4-21
Compact spare tire ................................................... 8-39
Console box................................................................ 2-36
Control panel buttons (models with navigation
system) ........................................................................... 4-2
Controls
Control panel buttons (display with
navigation system) ................................................ 4-2
Heater and air conditioner controls
(automatic) .............................................................. 4-9
Steering wheel audio controls ........................ 4-29
Coolant
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Changing engine coolant .................................... 8-9
Checking engine coolant level........................... 8-8
Corrosion protection ................................................... 7-6
Cruise control............................................................. 5-16
Cup holders ................................................................ 2-35
Curtain side-impact air bag system (See
supplemental side air bag and curtain air bag
system) ......................................................................... 1-37
D
Daytime running light system ................................. 2-26
Defroster switch, Rear window and outside
mirror defroster switch ............................................. 2-24
Dimensions and weights ............................................ 9-9Display controls (See control panel buttons),
With navigation system .............................................. 4-2
Door open warning light .......................................... 2-13
Drive belts ................................................................... 8-17
Driving
Cold weather driving ......................................... 5-25
Driving with automatic transmission........ 5-6, 5-9
Driving with manual transmission .......... 5-7, 5-13
Precautions when starting and driving ............ 5-2
E
Economy, Fuel............................................................ 5-18
Elapsed time ............................................................... 2-10
Emission control information label ........................ 9-11
Emission control system warranty......................... 9-24
Engine
Before starting the engine .................................. 5-8
Break-in schedule............................................... 5-18
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Changing engine coolant .................................... 8-9
Changing engine oil and filter ......................... 8-10
Checking engine coolant level........................... 8-8
Checking engine oil level ................................. 8-10
Coolant temperature gauge ............................... 2-6
Engine block heater ........................................... 5-26
Engine compartment check locations.............. 8-7
Engine cooling system ......................................... 8-8
Engine oil .............................................................. 8-10
Engine oil and oil filter recommendation......... 9-5
Engine oil viscosity ............................................... 9-5
Engine serial number ......................................... 9-11
Engine specifications ........................................... 9-8If your vehicle overheats ...................................... 6-9
Oil pressure gauge ............................................... 2-7
Starting the engine ............................................... 5-9
Event data recorders ................................................ 9-26
Exhaust gas (Carbon monoxide).............................. 5-2
F
Filter
Air cleaner housing filter ................................... 8-18
Changing engine oil and filter ......................... 8-10
Flashers (See hazard warning flasher switch) ... 2-27
Flat tire............................................................................ 6-2
Flat tire, Tire pressure monitoring system
(TPMS) .......................................................................... 5-3
Flat towing .................................................................. 9-22
Floor mat cleaning ....................................................... 7-5
Fluid
Automatic transmission fluid (ATF) ................ 8-12
Brake and clutch fluid ....................................... 8-13
Brake fluid............................................................. 8-14
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Engine coolant ....................................................... 8-8
Engine oil .............................................................. 8-10
Power steering fluid ........................................... 8-13
Window washer fluid ......................................... 8-14
FM-AM radio with Compact Disc (CD)
player ............................................................................ 4-19
FM-AM-SAT radio with Compact Disc (CD)
changer ........................................................................ 4-23
Front manual seat adjustment .................................. 1-3
Front power seat adjustment........................... 1-4, 1-5
06.1.17/Z33-D/V5.0
10-2
Page 291 of 297
Trunk light ............................................................. 2-43
Vanity mirror light ................................................ 2-42
Warning/indicator lights and audible
reminders .................................................. 2-12, 2-16
Xenon headlights ................................................ 2-24
Lights, Exterior and interior light replacement ... 8-28
Loading information (See vehicle loading
information) ................................................................. 9-14
Lock
Door locks ............................................................... 3-3
Power door lock .................................................... 3-3
Rear floor box ...................................................... 2-36
Top latch lever ..................................................... 3-16
Trunk lid lock........................................................ 3-10
Low tire pressure warning light ............................. 2-14
Luggage compartment light.................................... 2-42
M
Maintenance
Battery ................................................................... 8-15
General maintenance ........................................... 8-2
Inside the vehicle................................................... 8-3
Maintenance information (display) .................... 4-3
Maintenance precautions .................................... 8-5
Maintenance requirements.................................. 8-2
Outside the vehicle............................................... 8-2
Seat belt maintenance ...................................... 1-17
Under the hood and vehicle ............................... 8-4
Malfunction indicator lamp (MIL) ........................... 2-16
Meters and gauges ..................................................... 2-3
Meters and gauges, Instrument brightness
control .......................................................................... 2-27Mirror
Automatic anti-glare inside mirror .................. 3-26
Inside mirror ......................................................... 3-26
Outside mirror control ....................................... 3-27
Outside mirrors ................................................... 3-27
N
Net, Cargo net ........................................................... 2-34
Net, Ventilated net seats ........................................... 1-6
New vehicle break-in ................................................ 5-18
NISSAN Vehicle Immobilizer System ................... 2-19
Engine start............................................................. 5-8
O
Obtaining an air bag ON/OFF switch ................. 1-13
Odometer ....................................................................... 2-4
Oil
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Changing engine oil and filter ......................... 8-10
Checking engine oil level ................................. 8-10
Engine oil .............................................................. 8-10
Engine oil pressure gauge .................................. 2-7
Engine oil viscosity ............................................... 9-5
Opening the soft top ................................................ 3-13
Outside mirror control .............................................. 3-27
Outside mirrors .......................................................... 3-27
Overheat, If your vehicle overheats ......................... 6-9
Owner’s Manual/Service Manual order
information................................................................... 9-26P
Parking
Brake check ......................................................... 8-21
Parking brake break-in ...................................... 5-21
Parking brake check .......................................... 5-15
Parking brake operation .................................... 5-15
Parking on hills .................................................... 5-15
Parking/parking on hills ........................................... 5-19
Phone, Car phone or CB radio ............................. 4-30
Power
Power door lock .................................................... 3-3
Power front seat adjustment ..................... 1-4, 1-5
Power outlet ......................................................... 2-32
Power steering fluid ........................................... 8-13
Power steering system ...................................... 5-20
Power windows................................................... 2-39
Pre-tensioner seat belt system .............................. 1-39
Precautions
Audio operation ................................................... 4-13
Braking precautions ........................................... 5-20
Child restraints .................................................... 1-17
Cruise control ...................................................... 5-16
Maintenance ........................................................... 8-5
Seat belt usage ................................................... 1-10
Supplemental restraint system ........................ 1-30
When starting and driving .................................. 5-2
Push starting ................................................................. 6-9
06.1.17/Z33-D/V5.0
10-4
Page 292 of 297
R
Radio ............................................................................ 4-12
Car phone or CB radio ..................................... 4-30
FM-AM-SAT radio with Compact Disc
(CD) changer ....................................................... 4-23
FM-AM radio with Compact Disc (CD)
player ..................................................................... 4-19
Steering wheel audio controls ........................ 4-29
Readiness for inspection/maintenance (I/M)
test (US only) ............................................................. 9-25
Rear floor box ............................................................. 2-36
Rear hatch ..................................................................... 3-9
Rear parcel box ......................................................... 2-37
Rear power point....................................................... 2-32
Rear window and outside mirror defroster
switch ........................................................................... 2-24
Recorders, Event data ............................................. 9-26
Registering your vehicle in another country ....... 9-10
Remote keyless entry system ................................... 3-5
Reporting safety defects (US only) ...................... 9-24
Rollover........................................................................... 5-5
Roof, Soft top............................................................. 3-13
S
Safety
Child seat belts ................................................... 1-12
Reporting safety defects (US only)................ 9-24
Towing safety....................................................... 9-19
Satellite (SAT) radio ................................................. 4-13
Seat
Lever, Tilting passenger’s seat .......................... 1-7Seat adjustment
Front manual seat adjustment............................ 1-3
Front power seat adjustment .................... 1-4, 1-5
Seatback tilt cancel switch ....................................... 1-9
Seat belt(s)
Child safety .......................................................... 1-12
Infants .................................................................... 1-13
Injured persons.................................................... 1-14
Larger children .................................................... 1-13
Pre-tensioner seat belt system ....................... 1-39
Precautions on seat belt usage ...................... 1-10
Pregnant women ................................................. 1-14
Seat belt cleaning ................................................. 7-5
Seat belt extenders ............................................ 1-16
Seat belt maintenance ...................................... 1-17
Seat belts ............................................................. 1-10
Shoulder belt arm ............................................... 1-16
Small children ...................................................... 1-13
Seat belt warning light ...................................... 2-15
Three-point type with retractor ....................... 1-14
Seat(s)
Heated seats........................................................ 2-28
Seats ........................................................................ 1-2
Ventilated net seats .............................................. 1-6
Secondary rear hatch release ................................ 3-10
Secondary trunk lid release .................................... 3-12
Security system, Vehicle security system ........... 2-19
Security systems (NISSAN Vehicle Immobilizer
System), Engine start ............................................... 2-20
Security systems (See vehicle security
system) ......................................................................... 2-19
Servicing air conditioner................................. 4-9, 4-12
Shift lock release ....................................................... 5-12Shifting
Automatic transmission .............................. 5-6, 5-9
Manual transmission ................................. 5-7, 5-13
Shoulder belt arm...................................................... 1-16
Side air bag system (See supplemental side
air bag and curtain air bag system) ..................... 1-37
Soft top
Care and cleaning ............................................... 7-2
If the top does not open or close ................. 3-19
Soft top care and cleaning ................................. 7-2
Soft top indicator light ........................... 2-17, 3-17
Soft top operation .............................................. 3-13
Spark plugs................................................................. 8-18
Speed, Average speed ............................................ 2-10
Speed, Speed indicator ............................................. 2-9
Speedometer ................................................................ 2-4
Starting
Before starting the engine .................................. 5-8
Jump starting .......................................................... 6-7
Precautions when starting and driving ............ 5-2
Push starting .......................................................... 6-9
Starting the engine ............................................... 5-9
Steering
Power steering fluid ........................................... 8-13
Power steering system ...................................... 5-20
Steering wheel switch for audio controls..... 4-29
Tilting steering wheel......................................... 3-25
Stopwatch ................................................................... 2-10
Storage ........................................................................ 2-33
Stowing golf bags ..................................................... 2-37
Sun visors ................................................................... 3-25
Sunglasses holder .................................................... 2-33
Supplemental air bag warning labels................... 1-40
Supplemental air bag warning light .......... 1-41, 2-15
06.1.17/Z33-D/V5.0
10-5
Page 293 of 297
Supplemental restraint system............................... 1-30
Precautions on supplemental restraint
system.................................................................... 1-30
Supplemental side and curtain air bag
system .......................................................................... 1-37
Switch
Audio control steering wheel switch ............. 4-29
Hazard warning flasher switch ........................ 2-27
Headlight switch ................................................. 2-25
Ignition switch ........................................................ 5-6
Ignition switch automatic transmission
models ............................................................ 5-6, 5-9
Ignition switch manual transmission
models .......................................................... 5-7, 5-13
Power door lock switch....................................... 3-4
Rear window and outside mirror defroster
switch..................................................................... 2-24
Traction control system (TCS) off switch .... 2-30
Turn signal switch .............................................. 2-27
Vehicle dynamic control (VDC) off switch ... 2-29
T
Tachometer.................................................................... 2-5
Temperature gauge, Engine coolant
temperature gauge ...................................................... 2-6
Theft (NISSAN Vehicle Immobilizer System),
Engine start................................................................. 2-20
Three way catalyst ....................................................... 5-3
Tilting passenger’s seat ............................................. 1-7
Tilting steering wheel ............................................... 3-25
Tire
Flat tire ..................................................................... 6-2
Pressure indicator............................................... 2-10Pressure, Low tire pressure warning light ... 2-14
Tire pressure monitoring system (TPMS) ....... 5-3
Uniform tire quality grading .............................. 9-23
Tires
Spare tire .............................................................. 8-39
Tire and loading information label ...... 8-32, 9-12
Tire chains ............................................................ 8-37
Tire dressing ........................................................... 7-4
Tire pressure ........................................................ 8-30
Tire rotation .......................................................... 8-37
Types of tires ....................................................... 8-36
Wheel/tire size ....................................................... 9-9
Wheels and tires ................................................ 8-30
Top
If the top does not open or close ................. 3-19
Soft top operation .............................................. 3-13
Top latch lever ..................................................... 3-16
Top tether strap child restraint........................ 1-25
Towing
Flat towing ............................................................ 9-22
Tow truck towing ................................................ 6-10
Towing a trailer.................................................... 9-18
Towing load/specification chart ...................... 9-18
Towing safety....................................................... 9-19
TPMS, Tire pressure monitoring system................ 5-3
Traction control system (TCS)............................... 5-22
Traction control system (TCS) off switch ........... 2-30
Trailer towing .............................................................. 9-18
Transceiver, HomeLink
Universal
Transceiver .................................................................. 2-43
Transmission
Automatic transmission fluid (ATF) ................ 8-12
Driving with automatic transmission........ 5-6, 5-9
Driving with manual transmission .......... 5-7, 5-13Transmission selector lever lock release ...... 5-12
Transmitter (See remote keyless entry system) ... 3-5
Traveling or registering your vehicle in another
country ......................................................................... 9-10
Trip computer ............................................................... 2-8
Trunk
Trunk lid................................................................. 3-10
Trunk light ............................................................. 2-43
Interior trunk lid release .................................... 3-11
Secondary trunk lid release ............................. 3-12
Turn signal switch ..................................................... 2-27
U
Underbody cleaning .................................................... 7-3
Uniform tire quality grading .................................... 9-23
Up-shift indicator (M/T models) ............................ 5-14
Up-shift indicator setting (rpm) (M/T models) ... 2-11
V
Vanity mirror light ...................................................... 2-42
Vehicle
Dimensions and weights ..................................... 9-9
Identification number (VIN)............................... 9-10
Loading information............................................ 9-14
Recovery (freeing a stuck vehicle) ................. 6-12
Security system ................................................... 2-19
Vehicle dynamic control (VDC) off switch ... 2-29
Vehicle dynamic control (VDC) system ........ 5-23
Ventilated net seats..................................................... 1-6
Ventilators ...................................................................... 4-8
Volt meter ...................................................................... 2-8
06.1.17/Z33-D/V5.0
10-6
Page 297 of 297
1. Engine oil (P.8-10)
2. Brake fluid (P.8-13)
3. Meters and gauges (P.2-3)
4. Fuel-filler door release (P.3-23)
5. Hood release (P.3-8)
6. Seat belt (P.1-10)
7. Door lock/key (P.3-2)
8. Rear hatch release (Coupe) (P.3-9) or Trunk
lid release (Roadster) (P.3-10)
9. Engine coolant (P.8-8)
10. Window washer fluid (P.8-14)
11. Power steering fluid (P.8-13)
12. Battery (P.8-15)
13. Audio system (P.4-12)/
Heater and air conditioner (P.4-9)
14. Soft top (Roadster models) (P.3-13)
15. Fuel (P.3-23, P.9-3)
16. Spare tire (P.6-3, P.8-39)
STI0364
QUICK REFERENCE
06.1.17/Z33-D/V5.0