manual transmission OLDSMOBILE BRAVADA 1994 Owner's Manual

To Check the Fluid Hot or Cold:
Park your vehicle on a level place.
With the parking brake applied, place
With your foot on the brake pedal,
the
shift lever in
P (Park).
move the shift lever through each gear
range, pausing for about three
seconds in each range. Then, position
the shift lever in
P (Park).
minutes or more.
Let the engine run at idle for three Then, Without Shutting off the
Engine, Follow These Steps:
1. Flip the handle up and then pull out
the dipstick and wipe it with a clean
rag or paper towel.
2. Push it back in all the way, wait three
seconds and then pull it back
out
again.
3. Check both sides of the dipstick, and
read the lower level. The fluid level
must be in the
COLD area for a cold
check or in the
HOT area or cross-
hatched area for a hot check.
4. If the fluid level is in the acceptable
range, push the dipstick back in all
the way; then flip the handle down to
lock the dipstick in place.
How to Add FIuid
Refer to the Maintenance Schedule to
determine what kind
of transmission
fluid to use. See
Recommended Fluids
G Lubricants in the index.
If the fluid level is low, add only enough
of the proper fluid to bring the level up
to the COLD area for a cold check or
the HOT area for a hot check. It doesn’t
take much fluid, generally less than a
pint
(OSL) . Don’t overfill. We
recommend you use only fluid labeled
DEXRONB-I11 or DEXRONB-IIE,
because fluids with that label are made
especially for your automatic
transmission. Damage caused by fluid
other than DEXRONB-I11 or
DEXRONB-IIE is not covered by your
new vehicle warranty.
I 73
ProCarManuals.com

I Capacities & Specifications
I Automatic Transmission
Pan Removal and Replacement ................................... 5 quarts
After Complete Overhaul
............................................ 10.5 quarts
Cooling System ................................................................... 11.8 quarts
Refrigerant (R-12), Air Conditioning .............................. 2 lb. 5 oz.
4.7 L
9.9 L
11.2 L
1.13 kg
Not all air conditioning refrigerants are the same. If
the air conditioning system in your vehicle needs
refrigerant, be
sure the proper refrigerant is used. If
you’re not sure, ask your Oldsmobile dealer. For
additional information, see your “Warranty and
Owner Assistance Information” booklet.
Engine Crankcase
Without filter ................................................................ 4 quarts 3.8 L
With filter ..................................................................... 4.5 quarts 4.3 L
Fuel Tank ........................................................................\
.... 20 gallons 76 L
Wheel Nut Torque .............................................................. 95 pound-feet 130 N*m
NOTE: All capacities are approximate. When adding, be sure to fill to the appropriate level on the dipstick, or as
Tire Pressure, All ................................................................ 35 psi 240 ltPa
recommended in this manual.
199
ProCarManuals.com

Fluids & Lubricants
I ITEM APPLICATION GM PART NUMBER SIZE
Antifreeze Coolant ................................ Year-round antifreeze for .............. 1052103 1 gal. (3.8 L)
(Ethylene Glycol Base) coolant mixtures
(Grease Gun Insert) 1052497
Chassis
Lubricant
................................. General chassis lube, etc. .............. 12346003 or 14 oz. (397 g)
Delco Supreme 110 Brake Fluid ......... Brake System ................................. 1052535 16 02. (0.5 L)
Automatic Transmission Fluid
............ Automatic Transmission, Transfer Case
DEXRON@-I11
........................................................................\
................... 12346143 32 02. (1.0 L)
DEXRONB-IIE ........................................................................\
.................. 12345881 32 02. (1.0 L)
Engine Oil ............................................. Engine lubrication .......................... See the Index under Engine OiZ.
Gear Lubricant 8OW-90 ....................... Limited Slip Differential , ................ 1052271
GM Engine Oil Supplement
(E.O.S.) ... See your dealer for advice ............. 1052367
Engine Oil
............................................. Hood, tailgate and door hinges
Windshield Washer Solvent
................. Windshield washer fluid
Power Steering Fluid
........................... Power Steering System .................. 1050017 32 oz. (1 .O L)
1052884 16 02. (0.5 L)
Front Differential
Silicone Grease
.................................... Weatherstrips ................................. 12345579 1 02. (28 g)
Spray-A-Squeak Silicone Lubricant
.... General purpose silicone ................ 1052276 (aerosol) 4.5 oz. (127 g)
lubricant, weatherstrips
............. 1052277 12 oz. (0.35 L)
16 oz. (0.5 L)
201
ProCarManuals.com

Maintenance Schedule
206
Schedule I
Follow Schedule I if your vehicle is
MAINLY driven under one or more of
the following conditions:
When most trips are less than 4 miles
When most trips are less than 10
(6 lun) .
miles (16 lm) and outside
temperatures remain below freezing.
When most trips include extended
idling and/or frequent low-speed
operation, as in stop-and-go traffic.
When towing a trailer.
When operating in dusty areas or off-
Schedule I should also be followed if
the vehicle is used for delivery service,
police, taxi or other commercial
applications.
road frequently.
ITEM TO BE SERVICED
Nom See Explanation of Scheduled Maintenance
Services
following Schedules I and 11.
WHEN TO PERFORM
Miles (kilometers) or Months
(whichever occurs first).
2 1 Chassis Lubrication 1 Everv 3.000 Miles (5 000 kml or 12 Months. I
4 I Engine Accessory Drive Belt Inspection (erv 60.000 Miles (100 000 kml. I
6 I Transmission Service See Explanation
of Scheduled Maintenance
Services
following Schedules I and 11. I
8 I Spark Plug Wire 1nspection"t I Every 60,000 Miles (100 000 lm). I
10 I Fuel Tank, Cap & Lines Inspection*t I000 Miles (100 000 lun). I
12 I Fuel Filter Replacement*t I Everv 30.000 Miles (50 000 lun). I
16 I Transfer Case Fluid Change I See Explanation of Scheduled Maintenance
Services
followinrr Schedules I and 11. I
ProCarManuals.com

210
Explanation of Scheduled
Maintenance Services
Below are explanations of the services
listed in Schedule I and Schedule 11.
The proper fluids and lubricants to use
are listed in Section
D. Make sure
whoever services your vehicle uses
these. All parts should be replaced and
all necessary repairs done before you or
anyone else drives the vehicle.
ITEM SERVICE
NO.
1. Engine Oil and Filter Change* -
Always use SH or SG Energy
Conserving I1 oils of proper viscosity.
The
“SH” or “SG” designation may be
shown alone or in combination with
others, such as “SH/CD,”
“SH, SG,
CD,” “SG/CD,” etc. To determine the
preferred viscosity for your vehicle’s engine (e.g., SAE 5W-30 or SAE 1OW-
30), see the Index under Engine Oil.
2. Chassis Lubrication - Lubricate the
transmission shift linkage, parking
brake cable guides, underbody contact points and linkage. Lubricate the front
suspension and steering linkage.
3. Tire and Wheel Rotation and
Inspection
- For proper wear and
maximum tire life, rotate your tires
following the instructions
in this
manual. See
Tires, Inspection G.
Rotation in the Index. Check the
tires for uneven wear or damage. If
you see irregular or premature wear,
check the wheel alignment. Check for
damaged wheels also.
Inspection - Inspect the drive belt
for cracks, fraying, wear and proper
tension. Replace as needed.
5. Cooling System Service‘: - Drain,
flush and refill the system with new
or approved recycled coolant
conforming to
GM Specification
6038-M. Keep coolant at the proper
mixture as specified. See
CooZant in
the
Index. This provides proper
freeze and boil protection, corrosion
inhibitor level and maintains proper
engine operating temperature.
Inspect hoses and replace if they are
cracked, swollen or deteriorated.
Tighten screw-type hose clamps. Clean the outside of the radiator and
air conditioning condenser. Wash the
pressure cap and neck.
4. Engine Accessory Drive Belt
To help ensure proper operation, we
recommend
a pressure test of both the
cooling system and the pressure cap.
6. Transmission Service - Change
both the fluid and filter every 15,000
miles
(25 000 lun) if the vehicle is
mainly driven under one or more of
these conditions:
In heavy city traffic where the
outside temperature regularly
reaches
90°F (32°C) or higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police
If you do not use your vehicle under
any of these conditions, change both
the fluid and filter every
100,000
miles (166 000 lun) .
Replace spark plugs with the proper
type. See
Replacement Parts in the
Index.
8. Spark Plug Wire Inspection‘%t -
Inspect for burns, cracks or other
damage. Check the boot
fit at the
coils and at the spark plugs. Replace
wires as needed.
car
or delivery service.
7. Spark Plug Replacement” -
ProCarManuals.com

Maintenance Schedule
214
At Least Once a Year (cant.)
CHECK
OR SERVICE
Parking Brake
and Automatic
Transmission
P (Park)
Mechanism Check
Underbody Flushing
Differential Service
Transfer Case
WHAT TO DO
CAUTION: When you are doing this check, your vehicle could begin to move. You or others
could be injured and property could be damaged. Make sure ther\
e is room in front
of your
vehicle in case it begins
to roll. Be ready to apply the regular brake at once should the vehicle
begin to move.
Park on a fairly steep hill, with the vehicle facing downhill. Keeping your foot on the regular
brake, set the parking brake.
To check the parking brake: With the engine running and transmission in N (Neutral), slowly
remove foot pressure
from the regular brake pedal. Do this until the vehicle is held by the
parking brake only.
To check the P (Park) mechanism's holding ability: Shift to P (Park). Then release all brakes.
At least every spring, use plain water to flush any corrosive materials from the underbody. Take
care to clean thoroughly any areas where mud and other debris can collect.
Check rear/front differential fluid level and add as needed. Check constant velocity joints and
axle seals for leaking.
Check transfer case fluid level. Check vent hose at transfer case for ltinlts and proper installation.
More frequent lubrication may be required on heavy-duty off-road use.
A fluid loss may indicate a
problem. Have it inspected and repaired
at once.
ProCarManuals.com

Section D: Recommended Fluids & Lubricants
NOTE: Fluids and lubricants identified below by name, part number or specification may be obtained from your GM dealer
USAGE
Engine Oil
Engine Coolant
Hydraulic Brake
System
Parking Brake Guides
Power Steering System
Automatic Transmission
Locking Differential
Key Lock Cylinders
Automatic Transmission Shift
Linkage
FLUID/LUBRICANT
API service SH or SG Energy Conserving I1 oils of the proper viscosity. The “SH” or “SG” designation
may be shown alone or in combination with others, such as “SH/CD,” “SH,SG,CD,” “SG/CD,” etc.
To determine the preferred viscosity for your vehicle’s engine, see
Engine Oil in the Index.
A 50/50 mixture of water (preferably distilled) and good quality ethylene glycol base antifreeze
(GM Part No. 1052103 or equivalent) conforming to GM Specification 6038-M.
Delco Supreme
1 I@ Brake Fluid (GM Part No. 1052535 or equivalent DOT-3 brake fluid).
Chassis lubricant (GM Part No. 1052497 or equivalent) or lubricant meeting requirements of
NLGI Grade
2, Category LB or GC-LB.
GM Hydraulic Power Steering Fluid (GM Part No. 1052884 or equivalent).
DEXRONo-I11 or DEXRONB-IIE Automatic Transmission Fluid.
SAE 8OW-90 Gear Lubricant (GM Part No. 1052271).
Lubricate with Multi-Purpose Lubricant (GM Part
No. 123451120), synthetic SAE 5W-30 engine oil ~ ~~
Engine oil.
21 7
ProCarManuals.com

Maintenance Schedule
USAGE
Transfer Case Chassis Lubrication
Windshield Washer Solvent
Hood Latch Assembly
a. Pivots and Spring
b. Release Pawl Anchor
Hood, Door and
Tailgate Hinges, Rear Folding Seat, Fuel
Door Hinge, Rear
Compartment Lid
Hinges
Weatherstrips
Tailgate Mounted Spare Tire Carrier
(if equipped)
FLUID/LUBRICANT
DEXRONB-I11 or DEXRONo-IIE Automatic Transmission Fluid (GM Part No. 12345881).
Chassis lubricant (GM Part No. 1052497 or equivalent) or lubricant meeting requirements
of
NLGI Grade 2, Category LB or GC-LB.
GM Optildeen@ Washer Solvent (GM Part No.
1051515) or equivalent.
a. Engine oil.
b. Chassis lubricant meeting requirements
of NLGI Grade 2, Category LB (GM Part No.
1052497 or equivalent) or GC-LB.
Engine oil or Lubriplate Lubricant (GM Part No. 1050109).
Dielectric Silicone Grease (GM Part No. 12345579 or equivalent).
Multi-purpose lubricant meeting requirements of GM Part
No. 12345120.
See
RepZacernsnt Parts in the Index for recommended- replacement filters, valves and spark plugs.
218
ProCarManuals.com

Index
ABS Warning Light ......................... 88
Accelerator Control System ............. 185
Accessory Belt Drive ........................ 184
Accessory Power Outlets
................... 71
Fluid
............................ 176. 199. 201
Adding
Automatic Transmission
Brake Fluid
............................. 178. 201
Electrical Equipment
......... 46. 95. 196
Engine Coolant
...... 174. 177. 199. 201
Engine Oil
...................... 168. 199. 201
Power Steering Fluid
............. 176. 201
Windshield Washer Fluid
...... 177. 201
Add-on Equipment
.......................... 184
Air Cleaner
................................ 171. 200
Air Conditioner
.......................... 92. 184
Alcohol. Driving Under the
Influence of
.................................... 106
Alcohol in Gasoline
.......................... 163
All-Wheel Drive
................................ 108
Aluminum Wheels. Cleaning
........... 194
Antenna
............................................ 103
Anti-Lock Brakes (ABS)
Antifreeze
......................... 174.
199. 201
Using ABS
...................................... 110
Warning Light
.................................. 88
Appearance Care .............................. 190
Ashtrays and Lighter
.......................... 73 Audio
Systems
.................................... 95
AM/FM Stereo Radio with
Cassette Player
& Equalizer ......... 96
AM/FM Stereo Radio with
Compact Disc Player
..................... 98
Care of Compact Discs .................. 102
Care of Cassette Player
.................. 102
Radio Reception. For the Best
....... 101
Setting the Clock
.............................. 95
Automatic Transmission Adding Fluid
.................................. 173
Checking Fluid
............................... 172
Shifting
............................................. 48
Battery
........................................... 180
Jump Starting
................................. 140
Light
........................................... 87. 90
Belt. Accessory Drive
....................... 184
Blizzard
............................................. 13 1
Block Heater. Engine ................. 47. 170
Blowout. Tire
.................................... 15 1
Brake
Adjustment
..................................... 179
Fluid
....................................... 178. 201
Master Cylinder
............................. 178
Parking
............................................. 51
Rear Drum ...................................... 179
Replacing Brake System Parts
....... 179
Warning Light
.................................. 88
Wear Indicators .............................. 179 Brake
System Warning Light
............. 88
Braking .............................................. 109
Braking in Emergencies
.................... 111
Break.1n. New Vehicle ............... 44. 132
Buckling Up (see
Safety Belts)
Bulb Replacement Brakes. Anti-Lock
............................ 110
Braking Technique
........................... 109
Fog Light
........................................ 182
Headlight ........................................ 181
Taillight .......................................... 182
Bulbs. Replacement
.......................... 202
Capacities
& Specscations .......... 199
Carbon Monoxide in
Exhaust
...................... 53. 54. 131. 135
Cargo Bed Liner .................................. 75
Cassette Tape Player
(see
Audio Systems )
CD Player (see Audio Systems)
Center Passenger Position
Certificatioflire Label
.................... 186
Chains. Tire ...................................... 190
Changing a Flat Tire
......................... 151
Checking
Brake Fluid
..................................... 178
Engine
Oil ...................................... 168
(see Safety Belts )
Engine Coolant .............................. 174
233
ProCarManuals.com

234
Power Steering Fluid ..................... 176
Safety Belt Systems
.......................... 34
Transmission Fluid
........................ 172
Child Restraints
.................................. 26
Children and Safety Belts
................... 25
Cigarette Lighter
................................. 73
Circuit Breakers
& Fuses ................. 196
Checking Things Under
the Hood
.... 165
City Driving
...................................... 126
Cleaner. Air
............................... 171. 200
Cleaning Aluminum Wheels
......................... 194
Antenna
.......................................... 103
Cassette Player
............................... 102
Fabric .............................................. 191
Glass
............................................... 192
Inside
of Your Vehicle ................... 190
Outside
of Your Vehicle ................ 193
Safety Belts
.................................... 192
Special Problems
............................ 191
Vinyl or Leather
............................. 192
Warnings
................ 192. 193. 194. 196
Weatherstrips
................................. 194
Underbody
Maintenance
............... 194
Windshield
..................................... 193
Climate Controls
................................. 92
Clock. Setting the
............................... 95
Clusters. Instrument Panel
................. 78
Coin Holder
........................................ 72
Comfort Controls
................................ 92 Air Conditioner
........................ 92.
184
Heater
............................................... 92
Ventilation 94 .. ........................................
Compass .............................................. 64
Control
of a Vehicle .......................... 108
Convex Outside Mirror
...................... 70
Coolant
..................................... 176. 203
Console
Storage
............................ 64. 71
Checking
& Adding ............... 149. 177
Proper Mixture to
Use ........... 149. 177
Safety Warnings About ..... 149.177. 178
Temperature Gage ..................... 85. 88
Cruise Control .................................... 59
Curves. Driving on
........................... 111
Customer Assistance Information ...... 221
Cup
Holder
......................................... 71
Dead Battery: What to Do
............ 140
Defensive Driving
............................. 106
Defogger. Rear Window
..................... 94
Defrosting
........................................... 93
Dome Lights
....................................... 68
Door Locks
......................................... 39
Driver Position
...................... ............ 18
Driving At Night
.......................................... 124
City
................................................. 126
Controlling a Slid
.......................... 114
Defensively
..................................... 106
Drunken
......................................... 106 Freeway
.......................................... 127
Guidelines
...................................... 115
Hill and Mountain ................. 118. 129
In a Foreign Country
..................... 164
In Mud. Sand. Snow. or Ice
.......... 122
In the Rain
...................................... 125
In Water
......................................... 123
Loss of Control
.............................. 114
Off-Road
................................. 115. 123
On Curves
...................................... 111
On Inclines ..................................... 121
Through Deep Standing Water
....... 46
Winter Driving
............................... 130
With a Trailer
................................. 132
Drunken Driving
.............................. 106
Long
Distance
................................ 128
Passing.,
.......................................... 113
Electric Outside Mirror Control ..... 70
Electrical Equipment.
Adding
................................ 46. 95. 196
Electronic Cluster
............................... 79
Emergencies on the Road
................. 139
Emergencies. Braking
in
................... 111
Emergencies. Steering in .................. 112
Emergency Starting
.......................... 140
Emergency Towing
........................... 144
Engine Coolant
......................... 174. 201
E/M Switch ......................................... 83
Engine Block Heater
.................. 47. 170
.
ProCarManuals.com