cooling OLDSMOBILE SILHOUETTE 1993 User Guide

Service & Appearance Care
Engine Coolant (CONT.)
I
fmIlTIfi I I
Adding only plain water to I
L L your cooling system can be
aangerous. Plain water, or some
other liquid like alcohol, can boil
before the proper coolant mix will.
Your vehicle’s coolant warning
I
system is set for the proper coolant
mix. With plain water or the
wrong
mix, your engine could get
too hot but you wouldn’t get the
overheat warning. Your engine
could catch fire and you or others
could be burned. Use
a 50/50 mi
of clean water and a proper
antifreeze.
I
I’
NOTICE
If you use an improper coolant
mix, your engine could overheat
and be badly damaged. The repail
cost wouldn’t
be covered by your
warranty. Too much water
in the
mix can freeze and crack the
engine, radiator, heater core and
other parts.
I
Adding Coolant
To Check Coolant:
When your engine is cold, the coolant
level should be
at COLD, or a little
higher. When
your engine is warm, the
level should be
up to mJLL HOT, or a
little higher.
ProCarManuals.com

Used Replacement Wheels Tire Chains
Using the wrong replacement
b wheels, wheel bolts, or wheel
nuts on your vehicle can be
dangerous. It could affect the
braking and handling
of your
vehicle, make your tires lose air
and make you lose control. You
could have a collision in which you
)r others could be injured. Always
lse the correct wheel, wheel bolts,
1 and wheel nuts for replacement.
IL
The wrong wheel can also cause
problems with bearing life, brake cooling, speedometer/odometer
calibration, headlight aim, bumper
height,
vehicle ground clearance,
adtire
or tire chain clearance to
.the-body
.~ and chassis,;f,;,ir, ~ ~~~ .. .~. ..~ = ~ ~=.=.=~~~~ ... ~~
Putting a used wheel on your
vehicle is dangerous. You
can t
know how it’s been used or
how many miles it’s been driven. It
-ould fail suddenly and cause an
,ccident. If
you have to replace a
wheel, use
a new GM original
equipment wheel.
e
Use tire chains only when y
must. Use only SAE Class ‘23’’
type chains that are the proper size
for your tires. Install them on the
front tires and tighten them as
tightly as possible with the ends
securely fastened. Drive slowly
and follow the chain manu-
facturer’s instructions. If
you can
hear the chains contacting your
vehicle, stop and retighten them.
If
the contact continues, slow down
until it stops. Driving too fast with chains on will damage your
vehicle.
:l I ’
I
. .. ..
253
ProCarManuals.com

t
Fuse Pane/ (3.1L V6 ENGINE)
Position Rating
(AMP.)
CTSY ELC
HORN
STOP
HA2
15
20
15
15
F PUMP 10
AUX 20
TAIL 15
ECM
TURN B/U
GAGE
LPS
ABS
RD02
R/WIPER F/WIPER
IGN
HTR A/C
RR BLWR
10
15
7.5
7.5
3
15
20
25
15
25
25
Circuitry
Dome Lamps, Courtesy Lamps, Power Door Lock Switches, Glove
Box Lamp, Power Mirrors, Power Sliding Delay Lock Module
Auto Level Control, Underhood Lamp
Horns. Horn Relay, Safety Belt Buzzer
Front/Rear Turn Lamps, Front Side Marker Lamps, Rear Stop
Lamps, Instrument Cluster Turn Indicator Lamps, Cruise Brake
Switch
Fuel Pump, Oil Pressure Sender/Fuel Pump Switch
Radio, Front Cigar Lighter, Accessory Power Outlet
Front Park Lamps. Rear Tail Lamps, Front Side Marker Lamps,
License Plate Lamp, Radio, Heat/Vent/AC Control Head, Power
Sliding Door
Throttle Body Fuel Injection, Fuel Pump Relay, Elec. Vac. Reg. Valve,
Elec. Control Module, Elec. Spark Control Module
Front/Redr Turn Lamps, Front Side Marker Lamps, Cluster Turn
Telltale, Back-up Lamps, Fog Lamps
Cluster, Anti-Lock Brake System Lamp Module, Elec. Level Control
Sensor
Cluster, Radio, Wiper Switch, Headlamp Switch, Rear Blower
Switch, Heat/Vent/AC Control Head, Door Switch Illumination.
Front/Rear Ashtray Illumination Bulbs
Anti-Lock Brake System Radio
Rear WipedWasher Motors; Overhead Console Compass
Front Wiper/Washer Motor
A/C Compressor, A/C Solenoid Box, Compressor Relay, Temp. Door
Motor, Low Blower Relay; Heat/Vent/AC Control Head; Cruise
Module; Cooling Fan Relay; Rear Defogger Relay; Key Chime;
Vehicle Speed Sensor Buffer and Generator Charge Discrete,
Transaxle Converter Clutch Switch Front/Rear Blower Motors, High Blower Relay
Rear Blower, Rear Heat/Vent/AC
265
ProCarManuals.com

Service di Appearance Care
266
1 d HORN
I STOP-HAZ
'tf4 1 RDO1 ..., X
. ECW
Ca
p"1
TURN 0IU
GAGE
INJ 3365
F-WIPF"
H1 n
Fuse Panel (3800 v6 ENGINE)
Position Rating
(AMP.)
CTSY ELC
HORN
STOP HAZ
RDOl/AUX TAIL
ABS
ECM
TURN B/U
GAGE LPS
RD02
R/WIPER
F/WIPER IGN
HTR A/C
RR BLWR 15
20
15
15
20 15
3
10
15
7.5
7.5
15
20 25
15
25
25 Circuitry
Dome Lamps, Courtesy Lamps, Power Door Lock Switches, Glove
Box Lamp, Power Mirrors, Power Sliding Delay Lock Module
Auto Level Control, Underhood Lamp
Horns, Horn Relay, Safety Belt Buzzer
Front/Rear Turn Lamps, Front Side Marker Lamps, Rear Stop
Lamps, Instrument Cluster Turn Indicator Lamps
Radio, Front Cigar Lighter, Accessory Power Outlet
Front Park Lamps, Rear Tail Lamps, Front Side Marker Lamps,
License Plate Lamp, Radio, Heat/Vent/AC Control Head, Power
Sliding Door
Anti-Lock Brake System
Mass Air Flow Sensor, Electronic Control Module
Front/Rear Turn Lamps, Front Side Marker Lamps, Cluster
Turn
Telltale, Back-up Lamps, Fog Lamps
Cluster, Anti-Lock Brake System Lamp Module, Elec. Level Control
Sensor
Cluster, Radio, Wiper Switch, Headlamp Switch, Rear Blower Switch, HeatlVentiAC Control Head, Door Switch Illumination,
Front/Rear Ashtray Illumination Bulbs
Radio
Rear Wiper/Wdsher Motors; Overhead Console Compass
Front Wiper/Washer Motor A/C Solenoid
Box, Temp. Door Motor, Low Blower Relay;
Heat/Vent/AC Control Head; Cooling Fan Relay; Rear Defogger
Relay; Key Chime; Transaxle Converter Clutch Solenoid and
Generator Charge Discrete
Front/Rear Blower Motors, High Blower Relay
Rear Blower, Rear Heat/Vent/AC
ProCarManuals.com

Capacities & Specifications
Engine Crankcase (All Models) .........................
When changing filter, up to '/2 quart (1/2 liter)
more oil
my be needed.
When draining
or replacing torque converter,
more fluid
may be needed.
3-Speed:
Automatic Transaxle
Pan Removal
and Replacement .......................
After Complete Overhaul ...........................
Pan Removal and Replacement .......................
After Complete Overhaul ...........................
4-Speed:
Cooling System
3.lL V6 Engine:
4 quarts
4 quarts
7 quarts
6 quarts
8 quarts
With Air Conditioning
.............................. 12% quarts
With Rear Climate Control
.......................... 14% quarts
With Air Conditioning.
............................. 11% quarts
With Rear Climate Control
.......................... 13 Y2 quarts
3800 V6 Engine:
3.75 L
3.80 L
6.60 L
5.70 L
6.70 L
12.00 L
13.50 L
11.05 L
12.65 L
NOTE: All capacities are approximate. When adding, be sure to fill to the appropriate level, as recommended in this manual.
269
ProCarManuals.com

ITEM
NO.
5
6
7
SERVICE
Engine Accessory Drive Belt Inspection-
Inspect the drive belt for cracks, hying, wear and
proper tension. Replace as needed.
Cooling
System Service*-Drain, flush and refill
the system with new or approved recycled coolant
conforming to
GM Specification 1825M. Keep
coolant at the proper mixture as specified. See the
Index under Coolant. This provides proper freeze
protection, corrosion inhibitor level and engine operating temperature.
Inspect hoses and replace if they
are cracked,
swollen or deteriorated. Tighten screw-type hose
clamps. Clean the outside of the radiator and air
conditioning condenser. Wash the pressure cap and
neck.
To help ensure proper operation, we recornmend a
pressure test of both the cooling system
and the
pressure cap.
Transaxle Service-Change both the fluid and
filter every
15,000 miles (25 000 km) if the vehicle
is mainly driven under one or more
of these
conditions:
ITEM
NO. SERVICE
In heavy city traffic where the outside tem-
perature regularly reaches
90" F (32" C) or
higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police car or delivery
If you do not use your vehicle under any of
these conditions, change both the fluid and filter
every
100,OOO miles (160 000 km).
with the proper type. See the Index under
Replacement Parts.
9 Spark Plug Wire Inspection*-Inspect for burns,
cracks
or other damage. Check the boot fit at the
distributor or coils and at the spark plugs. Replace
wires as needed. service.
8 Spark Plug
Replacement*-Replace spark plugs
285
ProCarManuals.com