towing OPEL ASTRA SALOON 2014 User Guide

Vehicle care199
The spare wheel well is not designedfor all permitted tyre sizes. If a wheel
wider than the spare must be stowed
in the spare wheel well after changing
wheels, the floor cover can be placed on the projecting wheel.
This must be taken into consideration
when the load compartment is being
loaded, particularly with the Astra
TwinTop 3 41.
Station wagon
Take adapter and hooks from the rails
in the load compartment walls. Raise
the rear lashing eyes and lift the floor cover to the vertical position so that it
rests on the roof lining. When closing,
guide the lashing eyes through the
slots in the floor cover. Vehicles with
cargo box: removal 3 75.
TwinTop
Accessing the spare wheel when the roof is open: Engage load
compartment cover on the rear
window frame and activate the
loading aid 3 77 . Raise the floor cover
in the load compartment.
Temporary spare wheel
Use of the temporary spare wheel
could affect driveability. Have the
defective tyre renewed or repaired as soon as possible.
Only mount one temporary spare
wheel. Do not drive faster than
80 km/h. Take curves slowly. Do not
use for a long period of time.
The use of the temporary spare wheel
on the rear axle is not permitted while
towing another vehicle. Therefore
mount the temporary spare wheel on
the front axle and a full-size tyre on
the rear axle.Tyre chains 3 193.
Directional tyres Fit directional tyres such that they rollin the direction of travel. The rolling
direction is indicated by a symbol
(e.g. an arrow) on the sidewall.
The following applies to tyres fitted
opposing the rolling direction:
■ Driveability may be affected. Have the defective tyre renewed or
repaired as soon as possible.
■ Drive particularly carefully on wet and snow-covered road surfaces.

Vehicle care201
3. Connect the black lead to thenegative terminal of the booster
battery.
4. Connect the other end of the black
lead to a vehicle grounding point,
such as the engine block or an
engine mounting bolt. Connect as far away from the discharged
battery as possible, however at
least 60 cm.
Route the leads so that they cannot
catch on rotating parts in the engine
compartment.
To start the engine: 1. Start the engine of the vehicle providing the jump.
2. After 5 minutes, start the other engine. Start attempts should be
made for no longer than
15 seconds at an interval of
1 minute.
3. Allow both engines to idle for approx. 3 minutes with the leads
connected.4. Switch on electrical consumers (e.g. headlights, heated rear
window) of the vehicle receiving
the jump start.
5. Reverse above sequence exactly when removing leads.Towing
Towing the vehicle
Disengage the cover at the bottom
and remove downwards.
The towing eye is stowed with the
vehicle tools 3 187.

202Vehicle care
Screw in the towing eye as far as it will
go until it stops in a horizontal
position.
Attach a tow rope – or better still a tow
rod – to the towing eye.
The towing eye must only be used for towing and not recovering the vehicle.
Switch on ignition to release steering
wheel lock and to permit operation of
brake lights, horn and windscreen
wiper.
Open&Start system 3 22.
Transmission in neutral.
Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
When the engine is not running,
considerably more force is needed to
brake and steer.
To prevent the entry of exhaust gases from the towing vehicle, switch on the
air recirculation and close the
windows.
Vehicles with automatic transmission
must be towed facing forwards, not faster than 80 km/h nor further than
100 km. In all other cases and when
the transmission is defective, the front axle must be raised off the ground.
Seek the assistance of a workshop.
Manual transmission automated
3 142.
After towing, unscrew the towing eye
and refit the cover.
Towing another vehicle
Disengage cap at bottom and remove
downwards.

Vehicle care203
For other models unclip locking tabs
downward and pull off the cover
upwards.
The towing eye is stowed with the
vehicle tools 3 187.
Screw in the towing eye as far as it will
go until it stops in a horizontal
position.
The lashing eye at the rear
underneath the vehicle must never be used as a towing eye.
Attach a tow rope – or better still a tow
rod – to the towing eye.
The towing eye must only be used for towing and not recovering a vehicle.
Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
After towing, unscrew the towing eye and refit the cover.
Version with cover: install by inserting the bottom lugs of the cover in the
bumper, folding and then press the
lugs at the top into place.
Appearance care
Exterior care
Locks The locks are lubricated at the factoryusing a high quality lock cylinder
grease. Use de-icing agent only when
absolutely necessary, as this has a
degreasing effect and impairs lock function. After using a de-icing agent, have the locks regreased by a
workshop.
Washing
The paintwork of your vehicle is
exposed to environmental influences. Wash and wax your vehicle regularly.
When using automatic car washes,
select a programme that includes
waxing.
Bird droppings, dead insects, resin,
pollen and the like should be cleaned
off immediately, as they contain
aggressive constituents which can
cause paint damage.

Vehicle care205
Wheels and tyresDo not use high-pressure jet
cleaners.
Clean rims with a pH-neutral wheel
cleaner.
Rims are painted and can be treated
with the same agents as the body.
Paintwork damageRectify minor paintwork damage witha touch-up pen before rust forms.
Have more extensive damage or rust
areas repaired by a workshop.
Underbody Some areas of the vehicle underbody
have a PVC undercoating while other critical areas have a durable
protective wax coating.
After the underbody is washed, check
the underbody and have it waxed if
necessary.
Bitumen/rubber materials could
damage the PVC coating. Have
underbody work carried out by a
workshop.Before and after winter, wash the
underbody and have the protective
wax coating checked.
Engine compartment
Areas of the engine compartment that
are painted in the same colour as the vehicle must be looked after like any
other painted surface.
It is advisable to wash the engine
compartment before and after winter
and preserve it with wax. Protect the
alternator and brake fluid reservoir
with plastic sheets before washing
the engine.
When washing the engine with a
steam-jet cleaner, do not direct the
steam jet towards components of the
antilock brake system, air
conditioning system or the belt drive
and its components.
After an engine wash, have all engine
room components preserved
thoroughly by a workshop using
protective wax.
Do not use high-pressure jet
cleaners.TwinTop
Clean all seals with a damp soft lint- free cloth. Allow to dry completely. Treat all seals, e.g. on the roof and
windscreen frame, with the special
maintenance kit (available from your
Opel Service Partner) from time to
time. Good contact between the fine
rubber lips and the sealing surfaces
prevents leaks and reduces clamping
forces.
Intermediate roof position for cleaning
3 41.
Do not use high-pressure jet
cleaners.
Towing equipment
Do not clean the coupling ball bar with
a steam-jet or high-pressure jet
cleaner.
Interior care Interior and upholsteryOnly clean the vehicle interior,
including the instrument panel fascia
and panelling, with a dry cloth or
interior cleaner.

Technical data223
Heavy accessoriesAccessoriesSun roofTowing equipmentSplit rear seat backrestHeadlamp washer systemWeight [kg]23 (not on Saloon 4-door)
17 (Saloon 4-door)21 (not on TwinTop)
26 (TwinTop)20 (Station wagon)
9 (Saloon 3-door / 5-door)2 (Saloon 4-door / 5-door)Vehicle dimensionsSaloon 5-doorSaloon 3-doorSaloon 4-doorStation wagonVanTwinTopLength [mm]424942904587451545154476Width without exterior mirrors [mm]175317531753175317531759Width with two exterior mirrors [mm]203220322033203220322021Height (without antenna) [mm]146014351458150015001411Length of load compartment floor [mm]81981990510851825805Load compartment width [mm]944944102710881103734Height of load compartment opening [mm]614555–766775–Wheelbase [mm]261426142703270327032614Turning circle diameter [m]11.2011.2011.5011.5011.5011.20

232Technical dataTowing hitch installation dimensionsSaloon

239
Child restraint systems ................61
Cigarette lighter ........................... 91
Climate control ............................. 15
Climate control systems .............124
Clock ............................................ 89
Continuous damping control ......149
Control indicators.......................... 94
Control of the vehicle .................132
Controls ........................................ 86
Convex shape .............................. 32
Coolant and antifreeze ...............208
Cruise control ....................102, 149
Cupholders .................................. 67
Curtain airbag system .................. 59
Curve lighting.............................. 119
D
Danger, Warnings and Cautions ...3
Daytime running lights ...............119
Declaration of conformity ............235
Deflation detection system and tyre pressure monitoring system 99
Diesel fuel system bleeding .......165
Diesel particle filter ....................135
Door open .................................. 102
Doors ............................................ 28
Drain diesel fuel filter .................110
Driving characteristics and towing tips .............................. 154
Driving hints ................................ 132E
Easytronic ................................... 142
Electric adjustment ......................33
Electrical system......................... 181
Electronic climate control system 127
Electronic driving programmes . ........................................ 139, 143
Electronic Stability Program 99, 147
End-of-life vehicle recovery .......160
Engine compartment fuse box ...182
Engine coolant ........................... 162
Engine coolant temperature ........99
Engine cooling level ..................110
Engine data ............................... 216
Engine exhaust .......................... 135
Engine identification ...................212
Engine oil ................... 161, 208, 213
Engine oil pressure ....................100
Entry lighting .............................. 122
Event data recorders ..................235
Exit lighting ................................ 123
Exterior care .............................. 203
Exterior light ............................... 101
Exterior lighting ....................13, 117
Exterior mirrors ............................. 32
F
Fault ................................... 140, 144
First aid ......................................... 81First aid kit ................................... 81
Fixed air vents ........................... 130
Fog light ..................................... 102
Fog lights ................................... 171
Folding mirrors ............................. 33
Folding tray .................................. 80
Front airbag system .....................58
Front fog lights ........................... 120
Front seats.................................... 49
Front turn signal light ..................166
Front turn signal lights ...............171
Fuel............................................. 151
Fuel consumption - CO 2-
Emissions ............................... 153
Fuel for diesel engines ..............152
Fuel for petrol engines ...............151
Fuel gauge ................................... 94 Fuses ......................................... 181
G
Gauges ......................................... 93
General information ...................154
Glovebox ..................................... 67
Graphic-Info-Display, Colour- Info-Display ............................ 105
H Halogen headlights ....................166
Hand brake ......................... 146, 147
Hazard warning flashers ............119

241
Performing work ........................160
Pollen filter ................................. 131
Power outlets ............................... 90
Power windows ............................ 35
Preheating and diesel particle filter .......................................... 99
Puncture ..................................... 196
Q
Quickheat ................................... 130
R Radio Frequency Identification (RFID) ..................................... 236
Radio remote control ...................20
Reading lights ............................ 122
Rear fog light ............................. 102
Rear fog lights ........................... 120
Rear seats .................................... 53
Rear window wiper/washer .......... 88
Recommended fluids and lubricants ........................ 208, 213
Refuelling ................................... 152
Retractable hardtop .....................41
Reversing lights .........................121
Ride control systems ..................147
Roof .............................................. 39
Roof rack ..................................... 83
Run-flat tyres ............................. 189S
Safety net .................................... 78
Seat adjustment ....................... 7, 50
Seat belt ........................................ 8
Seat belt reminder .......................96
Seat belts ..................................... 54
Seat folding .................................. 52
Seat occupancy recognition ..60, 96
Seat position ................................ 49
Selector lever ..................... 137, 142
Service ............................... 131, 207
Service display ............................ 94
Service information ....................207
Service vehicle soon .................... 97
Side airbag system ......................59
Sidelights .................................... 117
Side turn signal lights ................178
Spare wheel ............................... 198
Speedometer ............................... 93
Sport mode .......................... 98, 148
Starting and operating ................132
Starting off ................................... 17
Starting the engine ............133, 142
Steering wheel adjustment ......9, 86
Steering wheel controls ...............86
Stop watch ................................. 116
Storage ......................................... 67
Storage compartments .................67
Sunglasses storage .....................68Sunroof ........................................ 39
Sunvisor lights ........................... 122
Sun visors .................................... 38
Symbols ......................................... 4
T
Tachometer ................................. 93
Tail lights ................................... 171
Three-point seat belt .................... 55
Tools .......................................... 187
Top-tether child restraint systems 65
Tow bar....................................... 154
Towing ................................ 154, 201
Towing another vehicle .............202
Towing equipment .....................155
Towing hitch installation dimensions ............................. 232
Towing the vehicle .....................201
Trailer coupling ........................... 154
Trailer stability assist .................158
Trailer towing ............................. 155
Transmission ............................... 16
Transmission display .........136, 142
Tread depth ............................... 192
Trip computer in Board-Info- Display ................................... 112
Trip computer in Graphic-Info- Display or Colour-Info-Display 113
Triple-Info-Display .....................102
Trip odometer .............................. 93