battery OPEL COMBO 2010 User Guide

130 Self-help, vehicle care
Picture no: 15286a.tif
zNever expose the battery to naked
flames or sparks.
zA flat battery can freeze even at
temperatures around 0 C. Thaw out a
frozen battery before connecting jump
leads.
zDo not allow battery fluid to come into
contact with eyes, skin, fabrics or
painted surfaces. The fluid contains
sulphuric acid which can cause injuries
and damage in the event of direct
contact.
zWear eye protection and protective
clothing when handling a battery. zUse a booster battery with the same
voltage (12 volts). Its capacity (Ah) must
not be much less than that of the
discharged battery.
zUse jump leads with insulated terminals
and a cross section of at least 16 mm
2
(25 mm
2 for diesel engines).
zDo not disconnect the discharged
battery from the vehicle.
zSwitch off all unnecessary electrical
consumers.
zDo not lean over the battery during jump
starting.
zDo not allow the terminals of one lead to
touch those of the other lead.
zDo not touch the vehicles while jump
starting.
zApply the hand brake and engage
neutral gear.
Picture no: 16492s.tif
Lead connection order:
1. Connect the red lead to the positive
terminal 1 of the booster battery.
2. Connect the other red lead to the
positive terminal 2 of the discharged
battery.
3. Connect the black lead to the negative
terminal 3 of the booster battery.
4. Connect the other end of the black
lead4 to a vehicle grounding point,
such as the engine block or a screw
connection in the engine suspension.
Connect the lead as far away from
the discharged battery as possible.

143
Self-help, vehicle care
Picture no: 15319t.tif
4. Screw the compressor air hose to the
connection on the sealant bottle.
5. Fit the sealant bottle in the retainer on
the compressor.
Set the compressor near the tyre in such
a way that the sealant bottle is upright.
6. Remove the valve cap from the defective
tyre.
Picture no: 15795t.tif
7. Screw the filler hose to the tyre valve.
8. The switch on the compressor must be
set to §.
9. Plug the compressor connector into the
accessory socket or the cigarette lighter
socket. Accessory socket 361.
10. Switch on ignition.
To prevent battery discharge, we
recommend that you leave the engine
running.
Picture no: 15796t.tif
11. Set the rocker switch on the compressor
to I. The tyre is filled with sealant.
12. While the sealant bottle drains (approx.
30 seconds) the pressure indicator on
the compressor briefly points to 6 bar.
Pressure then sinks again.
13. All of the sealant is pumped into the
tyre. Afterwards, the tyre is filled with
air.
14. The prescribed tyre pressure should be
reached within 10 minutes. Tyre
pressure 3121, 3191. Switch off the
compressor when the correct pressure
is obtained.

164 Opel Service, maintenanceOpel Service,
maintenance
Scheduled maintenanceThe service intervals apply to normal
operating conditions. For extreme
operating conditions, 3171.
Service interval display 3173.
European service intervals
Every 30,000 km or annually, whichever
occurs first.
International service intervals
Every 15,000 km or annually, whichever
occurs first.
Confirmations
Service is confirmed in the boxes provided
for such purposes in the Service and
Warranty Booklet. The workshop confirms
the date and mileage of service through a
stamp and signature.
Make sure that the Service and Warranty
Booklet has been correctly filled in as proof
of uninterrupted service is essential to the
granting of warranty or goodwill claims
and is a benefit when selling the vehicle.
Service planThe European service plan applies to the
following countries: Andorra, Austria,
Belgium, Cyprus, Czech Republic,
Denmark, Estonia, Finland, France,
Germany, Greece, Greenland, Hungary,
Iceland, Ireland, Italy, Latvia, Lithuania,
Luxembourg, Malta, the Netherlands,
Norway, Poland, Portugal, Slovakia,
Slovenia, Spain, Sweden, Switzerland,
Great Britain.
The International service plan applies to all
other countries. Scheduled maintenance ..................... 164
Service plan .......................................... 164
Additional service work ....................... 171
Recommended fluids and lubricants . 171
Inspection system ................................ 173
Genuine Opel Parts and Accessories . 174
Performing work .................................. 174
Engine oil .............................................. 175
Diesel fuel filter .................................... 177
Coolant ................................................. 177
Brakes ................................................... 178
Brake fluid ............................................ 179
Windscreen wiper replacement .......... 179
Windscreen washer system ................. 180
Battery .................................................. 180
Protecting electronic components ..... 180
Laying the vehicle up for a long
period of time .................................... 181
Putting the vehicle back into service . 181

165 Opel Service, maintenance
European service plan⊕Additional work.
o Intervals are shorter under extreme operating conditions and when such is necessary due to conditions specific to the country.
Service work after year
1)
km (x 1000)
1)
1)Whichever occurs first.
1
302
603
904
1205
150
Visually inspect control, lighting and signal devices as well as airbags;
check steering column lock and ignition switchxxxxx
Remote control: replace batteries (don’t forget the spare key) every 2 years
Check and correct windscreen wipers, windscreen washer system and headlamp
washer systemxxxxx
Check and correct coolant level and frost protection (pale orange)
2)
Note freeze protection temperature in the Service and Warranty Booklet
(confirmation box)
2)If loss is great/leaks are present, carry out follow-up work with customer consent.
xxxxx
Check water hoses for leaks and check to make sure they are firmly seated x x x x x
Check and correct brake fluid level
2) xxx
Check battery clamps to make sure they are firmly seated and check the battery eye x x x x x
Vehicle System Check with TECH 2 x x x x x
Replace pollen filter or active charcoal filter x x
⊕o
if the air is heavily polluted or there are high levels of airborne dust, sand or pollen,
the air-conditioning system will produce an odourVerbal arrangement between the
customer and Opel Partner
Replace the air filter element every 4 years/60,000 km
⊕
Replace spark plugsevery 4 years/60,000 km
Z 16 YNGevery 2 years/30,000 km
Visually inspect the ribbed V-belt every 2 years/60,000 km
⊕
Replace ribbed V-belt
Y 13 DTJ, Z 13 DTJ, Y 13 DT, Z 13 DT, Z 17 DTH every 10 years/150,000 km
⊕
Check valve play and adjust
Z16 XEP, Z 17 DTHevery 10 years/150,000 km

168 Opel Service, maintenanceInternational service plan⊕Additional work.
o Intervals are shorter under extreme operating conditions and when such is necessary due to conditions specific to the country.
Service work after year
1)
km (x 1000)
1)
1)Whichever occurs first.
1
152
303
454
605
75
Visually inspect control, lighting and signal devices as well as airbags;
check steering column lock and ignition switchxxxxx
Remote control: replace batteries (don’t forget the spare key) every 2 years
Check and correct windscreen wipers, windscreen washer system and headlamp
washer systemxxxxx
Check and correct coolant level and frost protection (pale orange)
2)
Note freeze protection temperature in the Service and Warranty Booklet
(confirmation box)
2)If loss is great/leaks are present, carry out follow-up work with customer consent.
xxxxx
Check water hoses for leaks and check to make sure they are firmly seated x x x x x
Check and correct brake fluid level
2) xxx
Check battery clamps to make sure they are firmly seated and check the battery eye x x x x x
Vehicle System Check with TECH 2 x x x x x
Replace pollen filter or active charcoal filter x x
⊕o
if the air is heavily polluted or there are high levels of airborne dust, sand or pollen,
the air-conditioning system will produce an odourVerbal arrangement between the
customer and Opel Partner
Replace the air filter element every 4 years/60,000 km
⊕
Replace spark plugsevery 4 years/60,000 km
Z 16 YNGevery 2 years/30,000 km
Visually inspect the ribbed V-belt every 2 years/60,000 km
⊕
Replace ribbed V-belt
Y 13 DTJ, Z 13 DTJ, Y 13 DT, Z 13 DT, Z 17 DTH every 10 years/150,000 km
⊕
Check valve play and adjust
Z16 XEP, Z 17 DTHevery 10 years/150,000 km

173
Opel Service, maintenance
Picture no: 14419s.tif
Inspection systemIn order to ensure economical and safe
vehicle operation and to maintain the
value of your vehicle, it is of vital
importance that all maintenance work is
carried out at the proper intervals as
specified.
Fixed service interval
When service is due, InSP appears in
the odometer display for approximately
10 seconds when the ignition is switched
on. Have the next service performed by a
workshop within one week or 500 km
(whichever occurs first). The service interval display takes account
of off-the-road periods during which the
battery is disconnected.
Flexible service interval 3
The length of the service intervals is based
on several parameters stemming from
usage. For this reason, various
engine-specific data is continually
gathered and is used to calculate the
remaining distance until the next service.
If the remaining distance is less than
1500 km, InSP is displayed with a
remaining distance of 1000 km when the
ignition is switched on and off. If less than
1000 km remains, InSP is displayed for
several seconds. Have the next service
performed by a workshop within one week
or 500 km (whichever occurs first).
Display of remaining distance:
1. Switch off ignition.
2. Briefly press the trip odometer reset
button. The odometer reading is shown.
3. Press and hold the reset button for about
2 seconds. InSP and the remaining
distance are displayed. Further information on maintenance and
the inspection system can be found in the
Service and Warranty Booklet, which is
located in the glove compartment.
Have maintenance work – and repair work
on the body and the equipment – carried
out professionally by a workshop. We
recommend using your Opel Partner, who
has excellent knowledge of Opel vehicles
and has the necessary special tools and
up-to-date service instructions from Opel.
It is particularly advisable to use an Opel
Partner during the warranty period in order
to prevent invalidation of the warranty.
Further information can be found in the
Service and Warranty Booklet.
Separate anti-corrosion service
Carry out according to the intervals
specified in the Service and Warranty
Booklet.

180 Opel Service, maintenance
Picture no: 11678s.tif
Windscreen washer system Reservoir for windscreen washer and rear
windscreen washer at driver’s side in
engine compartment.
Fill with clean water mixed with cleaner
and anti-freeze.
Make sure there is sufficient anti-freeze
protection.
When closing the reservoir, press the lid
firmly over the beaded edge all the way
round.
Picture no: 13488a.tif
Battery The vehicle battery is maintenance-free.
Batteries do not belong in household
waste. They must be disposed of at an
appropriate recycling collection point.
The retrofitting of electrical or electronic
accessories may subject the battery to
additional loading and cause it to become
discharged. Please seek advice concerning
the technical options, such as installing a
more powerful battery. Laying up the vehicle for more than
4 weeks can lead to battery discharge.
Disconnect the negative terminal of the
vehicle battery.
Ensure the ignition is switched off before
connecting or disconnecting the vehicle
battery.
Protecting electronic components In order to prevent faults in electronic
components in the electrical system, never
connect or disconnect battery with engine
running or ignition switched on. Never start
engine with battery disconnected, e.g.
when starting using jump leads.
To avoid damaging the vehicle, do not
make any modifications to the electrical
system, e. g. connecting additional
consumers or tampering with electronic
control units (chip tuning).
9 Warning
Electronic ignition systems generate very
high voltages. Do not touch the ignition
system; high voltage can be fatal.

181
Opel Service, maintenance
Laying the vehicle up for a long
period of time If the vehicle is to be laid up for several
months, the following work should be
undertaken to prevent damage.
zWash and wax the vehicle 3161.
zHave the wax in the engine
compartment and underbody checked.
zClean and preserve rubber seals.
zChange engine oil.
zCheck anti-freeze and corrosion
protection 3177.
zCheck the coolant level; top up
anti-freeze if necessary 3178.
zDrain the windscreen washer system.
zIncrease tyre pressure to the value
specified for full load 3121, 3191. zPark the vehicle in dry and
well-ventilated place. With manual
transmission select first or reverse gear;
with manual transmission automated 3
move the selector lever to the centre
position before switching the ignition off.
Use chocks or the like to prevent the
vehicle from rolling.
zDo not apply hand brake.
zDisconnect the clamp from the negative
terminal of the vehicle battery.
Putting the vehicle back into
servicePerform the following work before
recommissioning the vehicle:
zConnect the clamp to the negative
terminal of the vehicle battery.
zCheck tyre pressure 3121, 3191.
zTop up the windscreen washer system
3180.
zCheck engine oil level 3175.
zCheck coolant level 3178.
zFit the number plate if necessary.

198 IndexIndex
AABS (Anti-lock Braking System) ........... 119
Accessories ............................................. 133
Accessory socket ..................................... 61
Air intake .................................................. 99
Air recirculation system ........................... 97
Air vents ................................................... 93
Airbags ..................................................... 56
Alarm ........................................................ 33
Alternator ................................................. 69
Antenna ........................................... 90, 161
Anti-corrosion service ............................ 173
Antifreeze ............................................... 177
Antifreeze protection .................... 177, 180
Anti-knock quality of fuel
Octane number .................................. 184
Anti-theft alarm system .......................... 31
Anti-theft lock
Alloy wheels ....................................... 139
Anti-theft protection ............................... 17
Aquaplaning .......................................... 123
Ashtray ..................................................... 62
BBattery ........................................... 107, 180
Interruption of power supply ...... 37, 105
Before starting off ................................... 15
Belt tensioners ......................................... 49
Bleeding, diesel fuel system ................. 128
Bonnet .................................................... 128
Boot, see Luggage
compartment ............................. 28, 29, 42
Brake assist ............................................ 120
Brake lamps ........................................... 157
Brake system ......................................... 118
Brakes
ABS ..................................................... 119
Brake assist ........................................ 120
Brake lamps ....................................... 157
Brake servo unit ................................. 106
Hand brake ........................................ 120
Bulb replacement .................................. 151
Bulbs ....................................................... 151

199
Index
CCapacities .............................................. 195
Car Pass .................................................... 20
Caravan/trailer towing .................. 106, 125
Care ........................................................ 160
Catalytic converter ............... 114, 118, 129
Central locking system ...................... 23, 24
Centre console lighting ........................... 88
Changeover inhibitor ............................. 114
Changing the remote control battery .... 24
Changing tyre/wheel type ..................... 121
Changing wheels ................................... 137
Child restraint system .............................. 53
Child safety locks ..................................... 27
Cigarette lighter ....................................... 61
Clock ......................................................... 72
Clutch operation ............................ 105, 107
CO
2 emissions ........................................ 186
Coin holder ............................................... 65
Cold start ................................................ 107
Contrast .................................................... 81
Control indicator
ABS (Anti-lock Braking System) ........ 119
Airbag ................................................... 59
Engine electronics .............................. 116
Exhaust ............................................... 115
Immobiliser ........................................... 21
Control indicators .............................. 12, 66
Belt tensioners ...................................... 50
EPS (Electric Power Steering) .............. 70
Coolant ................................................... 177Coolant level .......................................... 178
Coolant temperature display ................. 73
Coolant thermometer .............................. 73
Correcting time ........................................ 80
Coupling socket load ............................ 126
Courtesy lamp ......................................... 88
Courtesy lamps
Bulb replacement ...................... 158, 159
DDashboard, see Instrument panel ........... 9
Data .................................................. 20, 182
Date .......................................................... 77
Daytime running lights ............................ 84
Decommissioning .................................. 181
Demisting and defrosting
Windows ............................................... 96
With the air conditioning system ........ 98
Diesel fuel filter ...................................... 177
Diesel fuel system .................................. 128
Diesel particle filter ............37, 68, 107, 116
Dimensions ............................................. 196
Dipped beam ............................................. 7
Bulb replacement ...................... 151, 155
Display .............................................. 76, 100
Display instruments ................................. 71
Display mode ........................................... 82
Door locks ........................................ 20, 162
Driving abroad .............................. 110, 164
Headlamps ........................................... 89
Driving hints ........................................... 106
EEasytronic ................................................ 15
Driving programmes ......................... 102
Fault ................................................... 104
Interruption of power supply ............ 105
Kickdown ............................................ 103
Selector lever ....................................... 15
Winter programme ............................ 103
Economical driving ................................ 108
Electric power steering .................... 70, 106
Towing ................................................ 131
Electric windows ...................................... 36
Electrical system .................... 145, 180, 195
Electronic components .......................... 180
Electronic immobiliser ............................. 21
Ellipsoidal headlamp system ................ 155
Engine code ........................................... 184
Engine control indicator ....................... 116
Engine oil ....................................... 172, 175
Additives ............................................ 172
Topping up ........................................ 172
Viscosity ............................................. 172
Engine oil consumption ........ 106, 175, 184
Engine oil level ....................................... 175
Engine speed ......................................... 107
Engine wash ................................... 162, 163
Environmental protection ..................... 160
EPS .................................................... 70, 106
Exhaust control indicator ..................... 115
Exhaust gases ........................................ 116
Exhaust system ...................................... 106
Exterior mirrors ........................ 5, 34, 35, 37