manual transmission OPEL COMBO 2010 Owner's Manual

150 Self-help, vehicle careNo. Circuit
38
Left tail lamp, left parking lamp
39
Right tail lamp, right parking lamp
40
Brake lamps
41
Fog lamps
42
Fog tail lamp
43
Main beam (left)
44
Main beam (right)
45
Ventilation fan
46
Engine control unit
47
Heated rear window
48
Starter
49
EPS
50
ABS
51
Petrol engine: manual transmission
automated
Diesel engine: engine control unit
Picture no: 11744s.tif Picture no:
No. Circuit
52
Radiator fan
No. Circuit
53
Cooling fan, air conditioning
system
54
Manual transmission automated

167 Opel Service, maintenance
⊕Additional work.
o Intervals are shorter under extreme operating conditions and when such is necessary due to conditions specific to the country.
Service work after year
1)
km (x 1000)
1)
1)Whichever occurs first.
1
302
603
904
1205
150
Visually inspect steering bellows, track rods and axle drive xxxxx
Check track-rod ends and suspension ball joints xxxxx
⊕
Change brake and clutch fluid (manual transmission automated) every 2 years
Undo wheel mounting and tighten to 110 Nm torque
xx During assembly, lightly lubricate wheel bolt tapers with grease or oil
Check tyre condition; check and correct tyre pressures (including the spare wheel)
With tyre inflation system, check the set to make sure that it is complete and not out
of date. Replace sealant bottle every 4 years
⊕
Annual service check when the annual mileage is more than 20,000 km
Visually inspect the first-aid kit (present and stowed in the right place, intact and not
out of date), lashing eyes and warning triangleevery 2 years
Check and correct headlamp aiming (including auxiliary headlamps) x x
⊕o
Lubricate door hinges, door brakes, lock cylinders, strikers, bonnet closure and
tailgate hinges.xx
Road test, final inspection (check steering column lock, ignition switch, instruments
and control indicators, entire brake system, steering, air conditioning system, engine,
body and chassis), reset service interval display using TECH 2xxxxx
⊕
For Germany only: carry out emissions inspection (AU), general inspection (HU) First after 3 years and then every
2 years thereafter
With commercial passenger transport, taxis, ambulances, hired vehicles, etc. annually
⊕
Carry out gas system test (GAP) and note it in the Service and Warranty Booklet First after 3 years and then every
2 years thereafter
With commercial passenger transport, taxis, ambulances, hired vehicles, etc. annually

170 Opel Service, maintenance⊕Additional work.
o Intervals are shorter under extreme operating conditions and when such is necessary due to conditions specific to the country.
Service work after year
1)
km (x 1000)
1)
1)Whichever occurs first.
1
152
303
454
605
75
Visually inspect steering bellows, track rods and axle drive x x x x x
Check track-rod ends and suspension ball joints x x x x x
⊕
Change brake and clutch fluid (manual transmission automated) every 2 years
Undo wheel mounting and tighten to 110 Nm torque
xx During assembly, lightly lubricate wheel bolt tapers with grease or oil
Check tyre condition; check and correct tyre pressures (including the spare wheel)
With tyre inflation system, check the set to make sure that it is complete and not
out of date. Replace sealant bottle every 4 years
⊕
Annual service check when the annual mileage is more than 20,000 km
Visually inspect the first-aid kit (present and stowed in the right place, intact and
not out of date), lashing eyes and warning triangleevery 2 years
Check and correct headlamp aiming (including auxiliary headlamps) x x
⊕o
Lubricate door hinges, door brakes, lock cylinders, strikers, bonnet closure and
tailgate hinges.xx
Road test, final inspection (check steering column lock, ignition switch, instruments
and control indicators, entire brake system, steering, air conditioning system, engine,
body and chassis), reset service interval display using TECH 2xxxxx
⊕
Carry out gas system test (GAP) and note it in the Service and Warranty Booklet First after 3 years and then every
2 years thereafter
With commercial passenger transport, taxis, ambulances, hired vehicles, etc. annually

181
Opel Service, maintenance
Laying the vehicle up for a long
period of time If the vehicle is to be laid up for several
months, the following work should be
undertaken to prevent damage.
zWash and wax the vehicle 3161.
zHave the wax in the engine
compartment and underbody checked.
zClean and preserve rubber seals.
zChange engine oil.
zCheck anti-freeze and corrosion
protection 3177.
zCheck the coolant level; top up
anti-freeze if necessary 3178.
zDrain the windscreen washer system.
zIncrease tyre pressure to the value
specified for full load 3121, 3191. zPark the vehicle in dry and
well-ventilated place. With manual
transmission select first or reverse gear;
with manual transmission automated 3
move the selector lever to the centre
position before switching the ignition off.
Use chocks or the like to prevent the
vehicle from rolling.
zDo not apply hand brake.
zDisconnect the clamp from the negative
terminal of the vehicle battery.
Putting the vehicle back into
servicePerform the following work before
recommissioning the vehicle:
zConnect the clamp to the negative
terminal of the vehicle battery.
zCheck tyre pressure 3121, 3191.
zTop up the windscreen washer system
3180.
zCheck engine oil level 3175.
zCheck coolant level 3178.
zFit the number plate if necessary.

185 Technical data
Performance EngineZ 14 XEP Z 16 YNG Z 13 DTJ Z 17 DTH
Maximum speed
1) [km/h]
5-speed manual transmission
Manual transmission automated
1)The maximum speed is achievable with a maximum of half payload. Optional equipment may reduce the specified maximum speed of the vehicle.
164
–165
–152
2)
152
2)
2)Specific version with electronic speed limitation at 125 km/h.
170
–

187 Technical data
Fuel consumption, CO
2 emissions
(up to tyre width of 185 mm)

Fuel consumption, CO
2 emissions
(up to tyre width of 205 mm)

Engine
Z 14 XEP Z 13 DTJ Z 17 DTH
Manual/manual transmission automated
urban [l/100 km]
extra-urban [l/100 km]
altogether [l/100 km]
CO
2 [g/km] 7.9/–
5.2/–
6.2/–
148/– 6.1/ 5.9
4.5/ 4.5
5.1/ 5.0
134/135 6.6/–
4.4/–
5.2/–
140/–
Engine
Z 14 XEP Z 13 DTJ Z 17 DTH
Manual/manual transmission automated
urban [l/100 km]
extra-urban [l/100 km]
altogether [l/100 km]
CO2 [g/km] 8.1/–
5.4/–
6.4/–
153/– 6.3/ 6.1
4.7/ 4.7
5.3/ 5.2
139/140 6.8/–
4.6/–
5.4/–
146/–

188 Technical dataFuel consumption
(H gas)
1)
1)These values relate to the use of test gas G20 (H gas) in compliance with calculation method
1999/100/EC
.
Engine Z 16 YNG
Manual transmission
urban [m
3/100 km]
extra-urban [m
3/100 km]
altogether [m3/100 km] 10.1
5.9
7.5
Fuel consumption
(H gas)
1)
Engine
Z 16 YNG
Manual transmission
urban [kg/100 km]
extra-urban [kg/100 km]
altogether [kg/100 km] 6.6
3.9
4.9 CO
2 emissions
2)(natural gas operation, g/km according to 80/1268/EEC)
2)Emission reduction as per Euro4.Engine Z 16 YNG
CO
2 altogether [g/km] 133

190 Technical dataWeights
(kg)
, Table 1, kerb weight
1)
1)According to EC Directive 70/156/EC, including assumed weights for driver (68 kg), luggage (7 kg) and all fluids (tank 90 % full). Combo van EngineManual transmission Manual transmission automated
without/with air
conditioning
[kg]Z 14 XEP 1190/1350 –
Z 16 YNG 1322/1352 –
Z 13 DTJ 1285/1420 1285/1420
Z 17 DTH 1320/1455 –Weights
(kg)
, Table 1, kerb weight
Combo EngineManual transmission manual transmission automated
without/with air
conditioning
[kg]Z 14 XEP 1235/1265 –
Z 16 YNG 1367/1397 –
Z 13 DTJ 1325/1355 1325/1355
Z 17 DTH 1365/1395 –Weights
, Table 2, heavy accessories
Accessories Folding
sun roofTowing
equipmentAnti-lock braking
system (ABS)Sliding door (front
passenger’s side) Rear vent
windowsLoad
compartment grilleSplit load
compartment grille
Weight [kg] 18 18 7 23 9 8 10

201
Index
KKey
Extending ............................................. 20
Ignition lock .......................................... 16
Locking doors ...........................20, 23, 24
Remove ................................................. 17
Starting ........................................... 16, 21
Starting the engine .............................. 16
Keys ...................................................... 2, 20LLanguage selection ................................. 80
Lashing eyes ............................................ 44
Leaf doors ...................................... 3, 22, 29
Light switch ................................................ 6
Lighting ................................................ 6, 84
Driving abroad ..................................... 89
Load compartment
Loading ................................................ 47
Load compartment grille ........................ 46
Loading ............................................ 47, 126
Loading the vehicle ................................. 47
Locking doors ..............................20, 23, 24
Locking from the inside ..................... 22, 25
Locking the doors .......................... 2, 22, 24
Locks ....................................................... 162
Lubricants .............................................. 175Luggage compartment .......................... 28
Bulb replacement .............................. 158
Cover .................................................... 44
Extension .............................................. 42
Lashing eyes ........................................ 44
Lighting ................................................ 88
Loading ................................ 47, 126, 189
Locking ................................................. 28
Luggage compartment cover ................ 44
MMain beam ........................................... 7, 85
Bulb replacement .............................. 152
Control indicator .................................. 68
Maintenance
Air conditioning system ....................... 99
Antifreeze protection ........................ 177
Brake fluid .......................................... 179
Brakes ................................................. 178
Catalytic converter ............................ 118
Engine oil ............................................ 175
Fuel consumption .............................. 109
Tyre pressure ...................................... 121
Tyres ........................................... 122, 123
Manual transmission ............................. 105
Manual transmission, see Transmission 15
Mirrors ............................................ 6, 34, 35
Misted windows ................................. 96, 98
Mobile telephone ..................................... 91
Muffler, see Exhaust system ................. 116
NNatural gas .............................. 74, 110, 113
Number plate lamps
Bulb replacement .............................. 158
Number plate lighting .......................... 158OOctane numbers .................................... 184
Odometer ................................................. 71
Oil ........................................................... 172
Additives ............................................ 172
Topping up ........................................ 172
Viscosity ............................................. 172
Oil consumption ............................ 175, 184
Oil level ................................................... 175
Oil pressure .............................................. 67
Opel Service ........................................... 164
Operating temperature ........................ 107
Outside temperature gauge .................. 76
Overrun .......................................... 107, 109

203
Index
Signal system ........................................... 13
Sliding doors ............................................ 27
Spare fuses ............................................. 145
Spare keys ................................................ 20
Spare wheel .................................... 134, 137
Speed .............................................. 108, 109
Fuel consumption ...................... 108, 109
Speedometer ............................................ 71
Starter switch ........................................... 16
Starting the engine ....................16, 21, 129
Self-help .............................................. 129
Steam jet cleaner ................................... 163
Steering column lock ......................... 16, 17
Steering wheel adjustment ....................... 6
Steering wheel remote control .......... 19, 90
Stowage compartments .............. 39, 63, 64
Sun visors .................................................. 65
System settings ........................................ 79TTachometer .............................................. 71
Tail lamps ................................................. 84
Bulb replacement ............................... 157
Tailgate ................................................ 2, 28
Technical data ....................................... 182
Telephone, see Mobile telephone .......... 91
Temperature regulation .......................... 94
Temporary spare wheel ................ 125, 135
The first 1000 km ................................... 106Tightening torque .......................... 141, 191
Time .......................................................... 77
Tools ....................................................... 136
Towing .................................................... 131
Towing equipment ................................ 126
Towing eye ..................................... 131, 133
Transmission, Easytronic
Driving programmes ......................... 102
Fault .................................................... 104
Interruption of power supply ............ 105
Kickdown ............................................ 103
Selector lever ........................................ 15
Winter programme ............................ 103
Transmission, manual ..................... 15, 105
Tread depth ........................................... 123
Trip odometer .......................................... 72
Triple information display ....................... 76
Turn signal lamps ................................ 7, 85
Turn signals
Bulb replacement ..............154, 156, 157
Tyre chains ............................................. 125
Tyre condition ........................................ 122
Tyre pressure ................................. 121, 191
Tyre repair kit ........................................ 142
UUnderbody wash ................................... 163
Units of measure ..................................... 81
Unleaded fuel ................................ 114, 184
VValve cap key ........................................ 121
Vehicle care ........................................... 160
Vehicle decommissioning ..................... 181
Vehicle identification number .............. 183
Vehicle keys, see Keys ............................ 20
Vehicle recommissioning ...................... 181
Vehicle tools .......................................... 136
Ventilation ............................................... 92
VIN,
see Vehicle Identification Number ..... 182