air condition OPEL CORSA 2009 Owner's Manual

233
Opel Service, maintenance
⊕ Additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x1000)
1)
1)Depending on what occurs first.
1
30 2
60 3
90 4
120 5
150
⊕
Replace timing belt and tension pulley
Z 16 LEL, Z 16 LER, Z 17 DTR every 10 years/150000 km
Change engine oil and replace filter xxxxx
⊕o
Drain water from fuel filter, diesel (if the air humidity is high or the fuel of lower quality)xxxxx
Replace fuel filter and drain water, diesel (grade EN590)
Z 13 DTJ, Z 17 DTH xx
Replace fuel filter, petrol (g rade EN228), outer Z 16 LEL, Z 16 LER every 4 years/60000 km
Check handbrake, adjust if necessary (unl aden wheels); carry out a visual check of
wheel suspension and suspension front and re ar, brake lines, brake pressure hose, fuel
lines and exhaust system xx
Check external bodywork / underseal, note any damage in the Service and Warranty
Booklet. xxxxx
⊕o
Carry out a visual check on the front and rear wheel brakes
2)
2)If the loss is too great or there are leaks, carry
out remedial work in agreement with the customer.
xx
Annual service check if the annual distance travelled is greater than 20000 km.
Carry out a visual check of the engine, tran smission (AT, MT), check air conditioning
compressor for leaks
2)
xxxxx
Back to overview

234 Opel Service, maintenance⊕Additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x1000)
1)
1)Depending on what occurs first.
1
30 2
60 3
90 4
120 5
150
⊕o
Remove brake drum, clean, carry out visual check every 4 years/60 000 km
Visually inspect steering system boots, track rods, final drive xxxxx
Check track rod end and supporting ball joint xxxxx
⊕
Change brake and clutch fluids (manual transmission automated) every 2 years
Loosen wheel mounting and tighten to 110 Nm
xx
Grease or apply oil to
bolt taper when fitting.
Check tyre condition and pressure (inclu ding spare wheel), correct if necessary.
If there is a tyre inflation system, check that the set is complete and the use-by date is
still valid. Replace sealant bottle every four years.
⊕
Annual service check if the annual distance travelled is greater than 20000 km.
Visually check the first aid kit (that it is wher e it should be, that it is undamaged and that
the use by date is still valid), lashing eyes and warning triangle every 2 years
Check headlamp settings (including auxi liary headlamps), adjust if necessary x x
⊕o
Lubricate door hinges, check arms, cylinder lo ck, door latch, bonnet catch, rear panel
hinge xx
OPC: check function of central locking system
clean door lock from outside and grease xxxxx
Test run, final check (check steering and ig nition lock, instrument and warning lamps,
entire brake system, steering, air conditioni ng system, engine, bodywork and chassis,
reset service/interval display with TECH 2. xxxxx
⊕
Germany only: carry out emissions check, main inspection
First time after three years, then every 2 years
If used commercially to transport passengers, taxis, ambulances, hire cars etc. annually
Back to overview

235
Opel Service, maintenance
International service schedule⊕ Additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x1000)
1)
1)Depending on what occurs first.
1
15 2
30 3
45 4
60 5
75
Carry out a visual check of all warning lamps, lighting and signalling devices,
check steering and ignition locks xxxxx
Remote control: replace batterie s (check spare key) every 2 years
Check windscreen wipers, windscreen washer and headlamp washer systems, adjust if
necessary. xxxxx
Check coolant and antifreeze levels
2), top up if necessary, note antifreeze temperature
in Service and Warranty Booklet (validation fields).
2)If the loss is too great or there are leaks, carry out remedial work in agreement with the customer.
xxxxx
Check water-carrying hoses for leaks and make sure that they are secure. xxxxx
Check break fluid level
2), top up if necessary. xxx
Check that the battery terminals and lugs are secure xxxxx
Vehicle system check using TECH 2 xxxxx
Replace pollen filter or active charcoal filter xx
⊕o
If the air is particularly polluted, full of du st or sand or pollen, if the air conditioning
system smells Discussion between customer/Opel Partner
Replace air cleaner element every 4 years/60000 km
⊕
Replace spark plugs every 4 years/60000 km
Make a visual check of the ribbed belt x x
⊕
Replace ribbed belt
Z 13 DTJ, Z 13 DTH, Z 17 DTR every 10 years/150000 km
⊕
Check valve clearance,
adjust if necessary
Z16 LEL, Z 16 LER, Z 17 DTR every 10 years/150000 km
Back to overview

236 Opel Service, maintenance⊕Additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x1000)
1)
1)Depending on what occurs first.
1
15 2
30 3
45 4
60 5
75
⊕
Replace timing belt and tension pulley
Z 16 LEL, Z 16 LER, Z 17 DTR every 10 years/150000 km
Change engine oil and replace filter xxxxx
⊕o
Drain water from fuel filter, diesel (if the air humidity is high or the fuel of lower quality)xxxxx
Replace fuel filter and drain water, diesel (grade EN590)
Z 13 DTJ, Z 17 DTH xx
Replace fuel filter, petrol (g rade EN228), outer Z 16 LEL, Z 16 LER every 4 years/60000 km
Check handbrake, adjust if necessary (unl aden wheels); carry out a visual check of
wheel suspension and suspension front and re ar, brake lines, brake pressure hose, fuel
lines and exhaust system xx
Check external bodywork / underseal, note any damage in the Service and Warranty
Booklet. xxxxx
⊕o
Carry out a visual check on the front and rear wheel brakes
2)
2)If the loss is too great or there are leaks, carry
out remedial work in agreement with the customer.
xx
Annual service check if the annual distance travelled is greater than 20000 km.
Carry out a visual check of the engine, tran smission (AT, MT), check air conditioning
compressor for leaks
2)
xxxxx
Back to overview

237
Opel Service, maintenance
⊕ Additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x1000)
1)
1)Depending on what occurs first.
1
15 2
30 3
45 4
60 5
75
⊕o
Remove brake drum, clean, carry out visual check every 4 years/60000 km
Visually inspect steering system boots, track rods, final drive xxxxx
Check track rod end and supporting ball joint xxxxx
⊕
Change brake and clutch fluids (manual transmission automated) every 2 years
Loosen wheel mountings and tighten to 110 Nm
xx
Grease or apply oil to
bolt taper when fitting.
Check tyre condition and pressure (inclu ding spare wheel), correct if necessary.
If there is a tyre inflation system, check that the set is complete and the use-by date is
still valid. Replace sealant bottle every four years.
⊕
Annual service check if the annual distance travelled is greater than 20000 km.
Visually check the first aid kit (that it is wher e it should be, that it is undamaged and that
the use by date is still valid), lashing eyes and warning triangle every 2 years
Check headlamp settings (including auxi liary headlamps), adjust if necessary x x
⊕o
Lubricate door hinges, check arms, cylinder lo ck, door latch, bonnet catch, rear panel
hinge xx
OPC: check function of central locking system
clean door lock from outside and grease xxxxx
Test run, final check (check steering and ig nition lock, instrument and warning lamps,
entire brake system, steering, air conditioni ng system, engine, bodywork and chassis,
reset service/interval display with TECH 2. xxxxx
Back to overview

260 Technical DataTable 1, unladen weight
1), passenger car 5-door
1)According to EC Directive, including assumed weights for driver (68 kg), luggage (7 kg) and all fluids (tank 90 % full). ModelEngine Manual transmission Easytronic Automatic transmission
Corsa [kg]
Z 10 XEP 1145––
Z 12 XEP 11601160–
Z 14 XEP 1163–1188
Z 16 LEL 1280––
Z 13 DTJ 1235––
Z 13 DTH 12651265–
Z 17 DTR 1320––
Corsa with air
conditioning system
or climate control
system [kg] Z 10 XEP
1165––
Z 12 XEP 11801180–
Z 14 XEP 1183–1208
Z 16 LEL 1295––
Z 13 DTJ 1255––
Z 13 DTH 12851285–
Z 17 DTR 1340––
Corsa ECO [kg]
Z 13 DTJ 1210––
Corsa ECO with air
conditioning system [kg] Z 13 DTJ
1219––
Back to overview

261
Technical Data
Table 1, unladen weight
1), passenger car 3-door
1)According to EC Directive, including assumed weights for driver (68 kg), luggage (7 kg) and all fluids (tank 90 % full). ModelEngine Manual transmission Easytronic Automatic transmission
Corsa [kg]
Z 10 XEP 1100––
Z 12 XEP 11301130–
Z 14 XEP 1140–1165
Z 16 LEL 1255––
Z 13 DTJ 1205––
Z 13 DTH 12351235–
Z 17 DTR 1278––
Corsa with air
conditioning system
or climate control
system [kg] Z 10 XEP
1120––
Z 12 XEP 11501150–
Z 14 XEP 1160–1185
Z 16 LEL 1270––
Z 13 DTJ 1225––
Z 13 DTH 12551255–
Z 17 DTR 1298––
Corsa OPC [kg]
Z 16 LER 1278––
Corsa OPC with air
conditioning system [kg] Z 16 LER
1298––
Corsa ECO [kg]
Z 13 DTJ 1163––
Corsa ECO with air
conditioning system [kg] Z 13 DTJ
1175––
Back to overview

262 Technical DataTable 1, unladen weight
1), delivery vehicle
1)According to EC Directive, including assumed weights for driver (68 kg), luggage (7 kg) and all fluids (tank 90 % full). ModelEngineManual transmission Easytronic Automatic transmission
Corsa delivery vehicle [kg] Z 10 XEP 1125––
Z 12 XEP 11401140–
Z 13 DTJ 1215––
Z 13 DTH 12451245–
Corsa delivery vehicle with
air conditioning system or
climate control system [kg]Z 10 XEP
1145––
Z 12 XEP 11601160–
Z 13 DTJ 1235––
Z 13 DTH 12651265–
Back to overview

270 IndexIndex
AABS (Anti-lock Brake System) ............... 166
Accessories ....................................... 63, 196
Accessory socket ..................................... 80
Adaptive Forward Lighting (AFL) .. 23, 112Bulb replacement .............................. 216
Driving abroad ................................... 117
Adaptive Forward Lighting = AFL ................................ 23, 112
Air conditioning system ................ 120, 126
Air intake ................................................ 135
Air recirculation system ......................... 126
Air vents ................................................. 122
Airbag systems which can be deactivated .......................... 19, 75, 88
Airbags ..................................................... 69
Alarm system ........................................... 37
Alternator ................................................. 87
Antenna ......................................... 118, 228
Antifreeze ............................................... 244 Antifreeze protection .................... 244, 248
Anti-theft alarm system .......................... 37
Anti-theft locking system ........................ 33
Towing equipment ............................ 186
Anti-theft protection ............................... 17
Aquaplaning .......................................... 170
Ashtray ..................................................... 81
Automatic Anti-dazzle interior mirror .................. 44
Automatic transmission .......................... 15 automatic mode ................................ 145
Driving programme ........................... 146
Fault ................................................... 148
Interruption of power supply ............ 148
Kickdown ............................................ 146
Selector lever ............................... 15, 145
Winter programme ............................ 146
Automatic wiping .................................. 106
Auxiliary heater ..................................... 134
Back to overview

272 IndexDDashboard, see Instrument panel ............ 6
Data .................................................. 26, 250
Date .......................................................... 96
Daytime running lights .......................... 108
Decommissioning .................................. 249
Deflation detection system ............. 22, 164
Deflation Detection System (DDS) ....... 164
Demisting and defrostingWindows ............................................. 125
With climate control system .............. 131
With the air conditioning system ...... 128
Diesel fuel filter ...................................... 244
Diesel fuel system .......................... 190, 244
Diesel particle filter ........... 46, 85, 150, 157
Dimensions ............................................. 268
Dipped beam ........................................... 11 Bulb replacement ............................... 213
Display ..........................................91, 92, 94
Display mode ......................................... 100
Door locks ......................................... 26, 230
Double load-bay floor ....................... 24, 82
Driving abroad Headlamps ......................................... 116
Driving hints ........................................... 149
EEasytronic ................................................. 15 Driving programmes ......................... 139
Fault .................................................... 142
Interruption of power supply ............ 143
Kickdown ............................................ 141
Selector lever ........................................ 15
Sport programme .............................. 140
Starting off ......................................... 138
Winter programme ............................ 140
Economical driving ................................ 151
Electric sun roof ....................................... 46
Electric windows ...................................... 45
Electrical system ....................208, 249, 267
Electro-hydraulic power assisted steering ............................ 87, 149
Electronic components .......................... 249
Electronic immobiliser ............................. 27
Electronic Stability Program ................. 151
Engine code ...........................251, 252, 253
Engine control indicator ........................ 156
Engine data ........................................... 253
Engine oil ........................................ 239, 242 Additives ............................................ 239
Top up ................................................ 239
Viscosity .............................................. 239
Engine oil consumption ................. 149, 242
Engine oil level ................................. 86, 242
Engine oil pressure .................................. 86
Engine speed ......................................... 150
Engine wash ........................................... 230
Environmental protection ..................... 228 ESP (Electronic Stability Program) ....... 151
Exhaust control indicator ..................... 156
Exhaust gases ........................................ 157
Exhaust system ...................................... 149
Exterior mirrors ........................ 5, 42, 43, 46
FFan ......................................................... 123
Filling station
Engine oil level ................................... 242
Fuel ............................................. 252, 253
Opening the bonnet .......................... 190
Tyre pressure ............................. 152, 264
Vehicle data ....................................... 250
Windscreen washer system .............. 248
First-aid kit (cushion) ............................ 196
Flat tyre .................................................. 204
Flex-Fix system ................................ 24, 174
Fog lamps .............................................. 110 Bulb replacement .............................. 220
Fog tail lamp ......................................... 110 Bulb replacement .............................. 221
Foot brake ............................................. 167
Front passenger airbag .......................... 69
Fuel ......................................... 153, 252, 253
Fuel consumption .......................... 151, 256
Fuel filler cap ......................................... 153
Fuel filter ................................................ 244
Fuel gauge ............................................... 90
Fuel level .................................................. 90
Fuel system, diesel ................................ 190
Fuses ...................................................... 208
Back to overview