door lock OPEL FRONTERA 1998 Workshop Manual

12
43
860RW026
C01RX016
M
N 3
2
7
6
8
98 43
65 21
7
Potentiometer
ConnectionPosition
Detection
Block Automatic Heater / Air
Conditioner Control Unit
Controller
Sliding Contact
Full Heate PositionTerminal PlateFull Cool PositionDriver
Cool Side Heat Side
C01RX005
Full cool
Full cool0 0 0.5 1.0
50 100%
Aperture of air mix doorVoltage ratio VM/VDD
Full heat Full heat
VDD
VM +
–

8A–2LIGHTING SYSTEM
Vanity Mirror Illumination Bulb 8A–16. . . . . . . . . . . . .
Removal 8A–16. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8A–16. . . . . . . . . . . . . . . . . . . . . . . . . . .
Starter Switch 8A–17. . . . . . . . . . . . . . . . . . . . . . . . . . .
Removal 8A–17. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8A–17. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lighting Switch (Combination Switch) 8A–18. . . . . .
Removal 8A–18. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8A–18. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fog Light Switch 8A–19. . . . . . . . . . . . . . . . . . . . . . . .
Removal 8A–19. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8A–19. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Stoplight Switch (W/O Cruise Control) 8A–20. . . . . .
Removal 8A–20. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8A–20. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake Switch (W/Cruise Control) 8A–21. . . . . . . . . .
Removal 8A–21. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8A–21. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Turn Signal Switch (Combination Switch) 8A–21. . .
Removal and Installation 8A–21. . . . . . . . . . . . . . .
Hazard Warning Switch 8A–22. . . . . . . . . . . . . . . . . .
Removal 8A–22. . . . . . . . . . . . . . . . . . . . . . . . . . . . . Installation 8A–22. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tailgate Switch 8A–23. . . . . . . . . . . . . . . . . . . . . . . . . .
Removal 8A–23. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8A–23. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Switch 8A–23. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Removal 8A–23. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8A–23. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Defogger Switch 8A–24. . . . . . . . . . . . . . . . . . .
Removal 8A–24. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8A–24. . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat Heater Switch 8A–25. . . . . . . . . . . . . . . . . . . . . .
Removal 8A–25. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8A–25. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Key Remind Switch (Starter Switch) 8A–25. . . . . . .
Removal and Installation 8A–25. . . . . . . . . . . . . . .
Illumination Controller 8A–26. . . . . . . . . . . . . . . . . . . .
Removal 8A–26. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8A–26. . . . . . . . . . . . . . . . . . . . . . . . . . .
Power/Winter Switch 8A–27. . . . . . . . . . . . . . . . . . . . .
Removal 8A–27. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8A–27. . . . . . . . . . . . . . . . . . . . . . . . . . .
Main Data and Specifications 8A–28. . . . . . . . . . . . .
Service Precaution
WARNING: IF SO EQUIPPED WITH A
SUPPLEMENTAL RESTRAINT SYSTEM (SRS),
REFER TO THE SRS COMPONENT AND WIRING
LOCATION VIEW IN ORDER TO DETERMINE
WHETHER YOU ARE PERFORMING SERVICE ON OR
NEAR THE SRS COMPONENTS OR THE SRS
WIRING. WHEN YOU ARE PERFORMING SERVICE
ON OR NEAR THE SRS COMPONENTS OR THE SRS
WIRING, REFER TO THE SRS SERVICE
INFORMATION. FAILURE TO FOLLOW WARNINGS
COULD RESULT IN POSSIBLE AIR BAG
DEPLOYMENT, PERSONAL INJURY, OR
OTHERWISE UNNEEDED SRS SYSTEM REPAIRS.
CAUTION: Always use the correct fastener in the
proper location. When you replace a fastener, use
ONLY the exact part number for that application.
ISUZU will call out those fasteners that require a
replacement after removal. ISUZU will also call out
the fasteners that require thread lockers or thread
sealant. UNLESS OTHERWISE SPECIFIED, do not
use supplemental coatings (Paints, greases, or other
corrosion inhibitors) on threaded fasteners or
fastener joint interfaces. Generally, such coatings
adversely affect the fastener torque and the joint
clamping force, and may damage the fastener. When
you install fasteners, use the correct tightening
sequence and specifications. Following these
instructions can help you avoid damage to parts and
systems.

The chassis electrical system is a 12–volt system with a
negative ground polarity.
Wire size are appropriate to respective circuits, and
classified by color. (The classification of harnesses by
color is shown on the circuit diagram for ease of harness
identification.)
The wire size is determined by load capacity and the
length of wire required.
The vehicle harnesses are: body harness, chassis
harness, engine room harness, instrument harness,
transmission harness, engine ECGI harness, dome light
harness, door harness, rear body harness, tailgate
harness, SRS harness and battery cables.
The harnesses are protected either by tape or corrugated
tube, depending on harness location.
The circuit for each system consists of the power source,
wire, fuse, relay, switch, load parts and ground, all of
which are shown on the circuit diagram.
In this section, each electrical device is classified by
system.
For major parts shown on the circuit based on the circuit
diagram for each system, a summary, diagnosis of
troubles and inspection procedures are detailed.
Notes for Working on Electrical
Items
Disconnecting the Battery Cable
1. All switches should be in the “OFF” position.
2. Disconnect the battery ground cable (2).
3. Disconnect the battery positive cable (1).
CAUTION: It is important that the battery ground
cable be disconnected first. Disconnecting the
battery positive cable first can result in a short circuit.
Connecting the Battery Cable
Follow the disconnecting procedure in the reverse order.CAUTION: Clean the battery terminal and apply a
light coat of grease to prevent terminal corrosion.
Disconnecting the Connector
Some connectors have a tang lock to hold the connectors
together during vehicle operation.
Some tang locks are released by pulling them towards
you (1).
Other tang locks are released by pressing them forward
(2).
Determine which type of tang lock is on the connector
being handled.
Firmly grasp both sides (male and female) of the
connector (3).
Release the tang lock and carefully pull the two halves of
the connector apart.
Never pull on the wires to separate the connectors (4).
2
1
General Description
1
2
3
4

3.0
W
3.0
L/R 3.0
L/B
0.5
O/G
AUDIO
CIGARETTE
LIGHTERBLOWER
MOTORMAGNETIC
CLUTCHPOWER
WINDOW
RELAY
(2)STOPLIGHT AUDIO
(14)
DOME LIGHTRR DEFOGGER
FRT DOOR LOCK &
POWER WINDOW SW C-11 10A
AUDIO
(ACC)
MIRROR
0.5
BRC-20 10A
AIR CON
0.85
G/WC-14 15A
STOP
A/T CONT
1.25
R/WC-15 20A
AUDIO (B)
3.0
L/OC-17 25A
RR
DEFOG
FUSE BOX
1.25
O/BC-12 20A
CIGAR
3.0
LC-19 25A
BLOWER
3.0
B/L 3.0
W5.0
W 5.0
W
5.0
W
C/B-2 30A
P/W,P/S,
S/R
0.5
R/WC-16 10A
CLOCK (B)
ROOM
1.25
LG/WC-18 20A
DOOR
LOCK
HEATER &
A/C RELAY
B-36
2
B-364
D08RWB16

3.0
W
3.0
L/R 3.0
L/B
0.5
O/G
AUDIO CIGARETTE
LIGHTERBLOWER
MOTORMAGNETIC
CLUTCHPOWER
WINDOW
RELAY
(2)STOPLIGHT AUDIO
(14)
DOME LIGHT FRT DOOR LOCK &
POWER WINDOW SW RR DEFOGGER C-11 10A
AUDIO
(ACC)
MIRROR
0.5
BRC-20 10A
AIR CON
0.85
G/WC-14 15A
STOP
A/T CONT
1.25
R/WC-15 20A
AUDIO (B)
3.0
L/OC-17 25A
RR
DEFOG
FUSE BOX
1.25
O/BC-12 20A
CIGAR
3.0
LC-19 25A
BLOWER
3.0
B/L 3.0
W5.0
W 5.0
W
5.0
W
C/B-2 30A
P/W,P/S,
S/R
0.5
R/WC-16 10A
CLOCK (B)
ROOM
1.25
LG/WC-18 20A
DOOR
LOCK
HEATER &
A/C RELAY
B-36
2
B-364
D08RWB21

TAIL
RELAY
(4)
MAP
LIGHT
5.0
W
0.5
R/W
0.5
R/W
0.5
R/W
0.5
R/W C-16 10A
CLOCK(B), ROOMBATT. (+)
STARTER SW
(IG1)
3.0
B/Y
C-4 10A
ELEC. IGN
0.5
R/Y
LUGGAGE
ROOM
LIGHT
1
R-82R-6
16H-32
1
L-2
R-63
H-217
A
TAIL
GATE SW
0.5
B
1.25
B
BODY-RRR-3R-6
0.5
R/W
0.5
GR/W0.5
R/W
1D-18
10H-18
14H-46
4
B-62
B-6
ALARM & RELAY CONTROL UNIT
1
B-610
B-64H-15
D-18
2
FRT
COURTESY
LIGHT-LH
0.5
GR/R0.5
GR/W
0.85
G/R 0.5
GR/W
R-21
FRT DOOR
SW-LH
0.5
GR/W0.5
R/W0.5
R/W
0.5
R/W0.5
L/W 1 2
D-7
10H-22D-7
2H-22 2
H-18
FRT
COURTESY
LIGHT-RH
0.5
GR/W
D08RW781

TAIL
RELAY
(4)
MAP
LIGHT
5.0
W
0.5
R/W
0.5
R/W
0.5
R/W
0.5
R/W C-16 10A
CLOCK(B), ROOMBATT. (+)
STARTER SW
(IG1)
3.0
B/Y
C-4 10A
ELEC. IGN
0.5
R/Y
LUGGAGE
ROOM
LIGHT
1
R-82R-6
16H-32
1
L-2
R-63
H-217
A
TAIL
GATE SW
0.5
B
1.25
B
BODY-RRR-3R-6
0.5
R/W
0.5
GR/W0.5
R/W
1D-18
10H-18
5H-47
4
B-62
B-6
ALARM & RELAY CONTROL UNIT
1
B-610
B-64H-15
D-18
2
FRT
COURTESY
LIGHT-LH
0.5
GR/R0.5
GR/W
0.85
G/R 0.5
GR/W
K-21
FRT DOOR
SW-RH
0.5
GR/W0.5
R/W0.5
R/W
0.5
R/W0.5
L/W 1 2
D-7
10H-22D-7
2H-22 2
H-18
FRT
COURTESY
LIGHT-RH
0.5
GR/W
D08RW812

FRT DOOR LOCK
ACTUATOR-RHFRT DOOR LOCK
ACTUATOR-LHRR DOOR LOCK
ACTUATOR-LHRR DOOR LOCK
ACTUATOR-RHTAIL GATE
ACTUATOR
24 24 2463
24 63
42 28 15 13
35 3 9
8
10 78
5
1.25
LG 1.25
LG 1.25
LG 1.25
LG 5.0
W
1.25
LG/W
1.25
LG/W2.0
L/B
1.25
LG/B
1.25
LG1.25
LG/B1.25
LG1.25
LG/B 1.25
LG1.25
LG/B1.25
LG1.25
LG/B 1.25
LG1.25
LG/B1.25
LG1.25
LG/B
1.25
LG1.25
LG/B 1.25
LG1.25
LG/B 1.25
LG1.25
LG/B 1.25
LG/B1.25
LG/B 1.25
LG/B
D-9 D-9 D-19 D-19 D-21 D-21H-28H-28
D-26 D-26 H-34 H-34
15 13410
H-32
H-32H-47 H-47
G-4 G-4 H-38 H-38 H-32 H-32
H-19 H-19 H-23 H-23D-5
D-5 D-5D-5
H-23 LOCK UNLOCK BATT. (+)
C-18 20A
DOOR LOCK
FRT DOOR LOCK &
POWER WINDOW SW-RHFRT DOOR LOCK &
POWER WINDOW SW-RH
POWER WINDOW
RELAY (4)
D08RW759

3 3 7
1 2 4
7
1 32 142 142 1
1 2
1 0.5
B 0.5
B 0.5
L/Y 0.5
LG/L
0.5
LG/R
1.25
B0.5
LG/R 0.5
LG/L
0.5
L/Y1.25
B
1.25
BD-8D-81 D-5
D-8
H-23 D-17D-17 D-17 D-14 D-14
D-14
H-19
B-1 H-18 H-19 H-22 H-23 D-30 D-30
H-19
7
H-23
B-18
BODY-RH 1.25
B 1.25
B0.5
LG/R 0.3
LG/L0.5
LG/R 0.5
LG/L0.5
LG/R 0.3
LG/L
2.0
B
BODY-LH
DOOR LOCK
KEY SW-RH DOOR LOCK
KEY SW-LHLOCK UNLOCKLOCK UNLOCK
LOCK
UNLOCK
LOCK UNLOCK
FRT DOOR LOCK &
POWER WINDOW
SW-LH
FRT DOOR LOCK & POWER WINDOW SW-RH
D08RW760

FRT DOOR LOCK
ACTUATOR-RHFRT DOOR LOCK
ACTUATOR-LHRR DOOR LOCK
ACTUATOR-LHRR DOOR LOCK
ACTUATOR-RHTAIL GATE
ACTUATOR
24 24 2415 13
24 410
42 28 15 13
35 9
8
10 78
1.25
LG
1.25
LG/B1.25
LG/B1.25
LG 1.25
LG 1.25
LG 5.0
W
1.25
LG/W
1.25
LG/W2.0
L/B
1.25
LG/B1.25
LG1.25
LG/B1.25
LG1.25
LG/B
1.25
LG1.25
LG/B1.25
LG1.25
LG/B 1.25
LG1.25
LG/B1.25
LG1.25
LG/B
1.25
LG1.25
LG/B 1.25
LG1.25
LG/B 1.25
LG1.25
LG/B 1.25
LG/B 1.25
LG/B1.25
LG/B
D-9 D-9 D-19 D-19 D-21 D-21H-32 H-32
D-26 D-26 H-47 H-47
6363
H-28H-28H-34 H-34
G-4 G-4 H-38 H-38 H-32 H-32H-23H-19
H-19
6
5
1.25
LG
H-233H-23
13
H-22
H-23D-5
D-5 D-5D-5 LOCK UNLOCK BATT. (+)
C-18 20A
DOOR LOCK
FRT DOOR LOCK &
POWER WINDOW SW-RHFRT DOOR LOCK &
POWER WINDOW SW-RH
POWER WINDOW
RELAY (4)
D08RW761