heating OPEL MERIVA 2009 User Guide

123
Climate control
Picture no: 16496s.tif
Automatic mode
Basic setting for maximum comfort:
zPress AUTO button.
z Open all air vents.
z Switch on AC compressor 3125.
z Preset temperature to 22 C with turn
knob.
The temperature can be set higher or lower
as desired. Switching off the air conditioning
compressor (
ECO appears in display) can
have a detrimental effect on comfort and
safety 3125.
All air vents are actuated automatically in
automatic mode. The air vents should
therefore always be open 3115. Temperature preset
The left rotary knob can be used to set the
temperature to values of between 16 C
and 28 C.
For the sake of comfort, only change the
pre-selected temperature in small steps.
If the temperature setting is less
than 16 C,
LO appears in the air
conditioning display: the climate control
system runs constantly at maximum
cooling power, and the temperature is not
regulated.
If the temperature setting is
above 28 C, HI appears in the air
conditioning display: the climate control
system runs constantly at maximum
heating power, and the temperature is not
regulated.
The temperature settings remain stored
when the ignition is turned off.

127
Climate control
Auxiliary heater Depending on outside temperature and
engine temperature, the passenger
compartment of vehicles with Quickheat 3
electric auxiliary heating is warmed up
more quickly.
Diesel-engined vehicles have a fuel-
powered auxiliary heater 3.
Picture no: 14147s.tif
Air intake The air intakes in front of the windscreen on
the far right and left sides of the engine
compartment must be kept clear to allow
air intake. Remove any leaves, dirt or snow. Air outletDo not cover the air outlets when storing
items in the luggage compartment storage
compartments.
Pollen filter The pollen filter cleans dust, soot, pollen
and spores from the air entering from
outside. The active carbon layer 3
eliminates most odours and noxious
environmental gases from the air.

128 Climate controlRegular operationFor consistently good operation, the air
cooling system 3 must be switched on for
several minutes once per month regardless
of the weather and the time of year.
Operation not possible with the cooling
system switched on and when the outside
temperature is low.
Service For optimal cooling performance, we
recommend that the climate control
system be checked annually, starting three
years after initial vehicle registration.
z Functionality and pressure test,
z Heating functionality,
z Leakage check,
z Check of drive belts,
z Cleaning of condenser and evaporator
drainage,
z Performance check.

131
Driving and operation
Picture no: 14175s.tif
Selector lever in A/M
Switch between Automatic and Manual
mode.
In manual mode, gears can be selected
manually by moving the selector lever
to
+or
-. The currect gear is indicated in
the transmission display.
If the engine speed is too low the manual
transmission automated will automatically
shift to a lower gear even in Manual mode.
This prevents the engine from stalling. Selector lever in + or -
If a higher gear is selected when the
running speed is too low, or a lower gear
when the speed is too high, the gear
selection will not take place. This prevents
the engine from running at too low or too
high revs.
Gears can be skipped by jogging the
selector lever repeatedly
at short intervals.
When the vehicle is in automatic mode, the
manual transmission automated shifts to
manual mode by moving the selector lever
to position
+ or
-. The correct gear is
indicated on the transmission display.
Selector lever in R
Reverse gear. Engage only when vehicle is
stationary.
Press button on selector lever, select R. The
transmission display shows "R".
If R is selected when the vehicle is in motion,
"R" flashes in the transmission display and
no gear is engaged. Stopping the vehicle
In Automatic or Manual mode, when the
vehicle has stopped first gear (with Winter
mode engaged, second gear) is engaged
automatically and the
clutch released. In R
reverse remains engaged.
If a warning signal sounds when the
driver’s door is opened (foot brake not
depressed), move the selector lever to N
and apply the hand brake.
When stopping on gradients, engage the
hand brake or depress the brake pedal. To
prevent overheating of the clutch, do not
increase engine speed to ensure smooth
idling when in gear.
Switch off engine if stopping for a lengthy
period, e.g. in traffic jams or at level
crossings.
Electronically controlled driving
programmes in automatic mode
z Following a cold start, the operating
temperature program automatically
increases the engine revolutions to bring
the catalytic converter to the required
temperature.
z The adaptive program automatically
selects the gear according to the driving
conditions, e.g. increased load and
gradients.
+
Shift to a higher gear.
-
Shift to a lower gear.

139
Driving and operation
Fuels, refuellingFuel consumption
The fuel consumption is determined under
specified driving conditions 3224.
Special equipment increases the weight of
the vehicle. As a result, they can increase
fuel consumption and reduce the specified
maximum speed.
For the first few thousand kilometres,
friction between the engine and
transmission components is higher. This
increases fuel consumption. Fuel for petrol engines
Only use unleaded fuel that complies
with DIN EN 228.
Fuels with ethanol content greater than 5 %
may only be used if the vehicle has been
specifically developed and approved for
these fuels.
Use fuel with the recommended octane
rating (value in bold
3220). Use of fuel
with too low an octane rating can reduce
engine power and torque and will slightly
increase fuel consumption. Fuel for diesel engines
Only use diesel fuel that complies
with DIN EN 590. The fuel must have low
sulphur content (maximum 50 ppm).
Do not use marine diesel oils, heating oils
or entirely or partially plant-based diesel
fuels, such as rape seed oil or bio diesel,
Aquazole and similar diesel-water
emulsions. Diesel fuels must not be diluted
with fuels for petrol engines.
The flow and filterability of diesel fuel are
temperature-dependent. When
temperatures are low, re
fuel with diesel fuel
with guaranteed winter properties.
Caution
Use of fuel with too low an octane rating
could lead to uncontrolled combustion
and engine damage.

142 Driving and operation
Picture no: 6448u.tif
Catalytic converter, exhaust
gassesCatalytic converter
The catalytic converter reduces the
amount of harmful substances in the
exhaust gas, such as carbon monoxide
(CO), hydrocarbons, (CH) and nitrous
oxide (NO
x). Fuel grades other than those listed on
pages 139, 220 (e. g. LRP = Lead
Replacement Petrol or leaded fuel) could
damage the catalytic converter or
electronic components.
z
In the event of misfiring, uneven engine
running, a clear reduction in engine
performance or other unusual problems,
have the cause of the fault rectified by a
workshop as soon as possible. In an
emergency, driving can be continued for
a short period, keeping vehicle speed
and engine speed low.
This does not apply when the Electronic
Stability Program (ESP®
Plus
3) kicks in
3 146.
z If unburnt fuel enters the catalytic
converter of a petrol engine, this may
result in overheating and irreparable
damage to the catalytic converter.
You should therefore avoid
unnecessarily long use of the starter
when starting off, running the tank dry
and starting the engine by pushing or
towing.
Picture no: 17875s.tif
Controlling exhaust emission
Design measures, primarily in the fuel
injection system and ignition system zones
in combination with the catalytic converter,
the amount of hazardous substances in the
exhaust emissions, such as carbon
monoxide (CO), hydrocarbons (CH) and
nitrogen oxides (NO
x), are reduced to a
minimum.
Caution
Damage to the catalytic converter or the
vehicle may result if the following points
are not observed.

185
Self-help, vehicle care
Picture no: 14214s.tif
The following fuses are Maxi fuses.
Bulb replacement Switch off the ignition and switch off the
relevant switch or close the doors.
Only hold a new bulb at the base! Do not
touch the bulb glass with your bare hands.
Replace the bulb, checking that the data
on the base matches that of the defective
bulb.
To replace a bulb, pull off the relay box on
the left side. On the right side, pull off the
air hose to the air filter.
Picture no: 16085s.tif
Halogen headlamp systemHeadlamp system has separate bulbs for
dipped beam 1 (bottom bulbs) and main
beam 2 (top bulbs).
No. Circuit
1 Interior fan
2 Power steering
3 ABS
4 Easytronic diesel preheating
system
5 Heated rear window
6 Engine cooling
7 Starter
8 Engine cooling

198 Self-help, vehicle careWindows and windscreen wiper blades
Use a soft lint-free cloth or chamois leather
together with window cleaner and insect
remover.
When cleaning the rear window, make sure
the heating element inside the window is
not damaged.
For mechanical removal of ice, use a sharp-
edged ice scraper. Pre ss the scraper firmly
against the glass so that no dirt can get
under it and scratch the glass.
Clean smearing wiper blades with a soft
cloth and window cleaner. Locks
The locks are lubricated with a high-quality
locking cylinder grease
in the factory. Only
use de-icer in urgent cases, since it has a
de-greasing effect and affects the
operation of the locks. Have the locks re-
greased in a workshop after using de-icer.
Engine compartment
Look after areas in the engine
compartment that are painted in the same
colour as the vehicle like any other
paintwork.
It is advisable to wash the engine
compartment before and after winter and
preserve it with wax. Cover alternator and
brake fluid reservoir with plastic sheets
before washing the engine.
When washing the engine with a steam-jet
cleaner, do not direct the steam jet at
components of the Anti-lock Braking
System 3, the automatic air conditioning
system 3 or the belt drive and its
components.
After an engine wash, have all engine room
components preserved thoroughly by a
workshop using protective wax.
Do not use high-pressure jet cleaners. Underbody
Some areas of the vehicle underbody have
a PVC undercoating while other critical
areas have a durable protective wax
coating.
After the underbody is washed, check the
underbody and have more protective wax
applied if necessary.
Bitumen/rubber materials could damage
the PVC coating. Have underbody work
carried out by a workshop.
Before and after winter, wash the
underbody and have the protective wax
coating checked.
Towing equipment
Do not clean the coupling ball bar with a
steam-jet or high-pressure jet cleaner.

236 IndexExterior lighting switch-off delay........... 107
Exterior mirrors..........................4, 36, 38, 41FFan ........................................................... 114
Fault........................................................... 41
Filling station Engine oil level .................................... 210
Fuel .............................................. 220, 221
Opening the bonnet ........................... 165
Tyre pressure ............................... 138, 228
Vehicle data ................................ 218, 219
Windscreen washer system ................ 215
First-aid kit .............................................. 171
Flat tyre ................................................... 178
FlexSpace .................................................. 52
Fog lamps ............................................... 103 Bulb replacement................................ 191
Fog tail lamp ........................................... 104 Bulb replacement................................ 191
Foot brake ....................................... 151, 153
Front passenger airbag ........................... 67
Fuel ......................................... 139, 220, 221
Fuel consumption ........................... 137, 224
Fuel filter.................................................. 212
Fuel gauge ................................................ 88
Fuel system, diesel .................................. 165
Fuses ........................................................ 181GGears ................................................. 14, 134
Generator, see Alternator ........................ 85
Glasses compartment .............................. 81
Glove compartment ................................. 80 Glove compartment lighting ................. 109
Bulb replacement ............................... 195
Graphical information display ................ 90
Gross vehicle weight............................... 226
Gross vehicle weight rating ................... 226
HHalogen headlamp system ................... 185 Bulb replacement ............................... 185
Driving abroad.................................... 110
Hand brake ....................................... 16, 153
Hazard warning lamps .................... 12, 104
Head restraints ............................. 21, 46, 47
Headlamp flash ........................................ 11
Headlamp range adjustment................ 104
Headlamp switch ............................. 11, 102
Headlamp washer system13, 100, 101, 215
Headlamps ............................................... 11 Daytime running lights ....................... 102
Driving abroad.................................... 110
Fog lamps ........................................... 103
Reversing lamps.................................. 104
Warning device ................................... 100
Headlights Changing bulbs .................................. 185
Heated exterior mirrors................ 13, 38, 41
Heated rear window .................... 13, 38, 41
Heated seats............................................. 46
Heating ........................................... 114, 117 Seats ...................................................... 46
With climate control system .............. 123
With the air conditioning system....... 114 Height adjustment
Seat belts .............................................. 63
Steering wheel .........................................5
High-pressure cleaners .......................... 198
Hill Start Assist ........................................ 153
Horn........................................................... 12
IIdentification plate ......................... 218, 219
Idling ....................................................... 134
Ignition switch..................................... 16, 27
Ignition system ............................... 209, 216
Immobiliser ............................................... 27
Information display .................................. 90
Infotainment system .............................. 111
Instrument display ................................... 87
Instrument illumin ation .......................... 108
Bulb replacement ............................... 196
Instrument pane l ...................................... 15
Instruments ................................... 15, 82, 87
Interior mirror.................................. 4, 38, 39
Interruption of po wer supply ................... 99
Easytronic............................................ 134
Electric sun roof .................................... 43
Electric windows ................................... 41
Electronic Stability Program .............. 147
ISOFIX ....................................................... 79JJack ................................................. 171, 176
Jump leads.............................................. 166

237
Index
KKeyextending .............................................. 26
ignition lock ..................................... 16, 27
Locking doors............................28, 30, 36
Starting .................................................. 27
Starting the engine ............................... 16
Keys ........................................................... 26LLanguage selection .................................. 95
Lashing eyes ............................................. 57
Leather trim ............................................ 197
Light switch ............................................... 11
Lighting ............................................. 11, 102 Driving abroad .................................... 110
Loading .....................................58, 162, 226
Loading the vehicle .................................. 58
Locking doors ...........................2, 28, 30, 36
Locking from the inside ............................ 30
Lubricants ............................................... 210
Luggage compartment Bulb replacement................................ 195
Cover...................................................... 55
Extension ......................................... 32, 53
Lighting ............................................... 109
Loading .................................58, 162, 226
Luggage compartment cover ................. 55
Lumbar support ........................................ 45
MMain beam ................................................ 11 Bulb replacement ....................... 187, 188
Control indicator ................................... 84
Maintenance Air conditioning system...................... 128
Antifreeze protection ......................... 212
Brake fluid ........................................... 214
Brakes .................................................. 213
Catalytic converter ............................. 145
Engine oil ............................................. 210
Fuel consumption ............................... 138
Tyre pressure............................... 154, 228
Tyres .................................................... 155
Manual transmission ........................ 14, 134
Mirrors ................................................... 4, 38
Misted windows ......................118, 121, 124
Mobile telephone.................................... 113
Muffler, see Exhaust system .................. 144NNumber plate lamps Bulb replacement ............................... 193
Number plate lighting............................ 193
Number plates ........................................ 217OOctane numbers ............................. 220, 221
Odometer .................................................. 87
Oil ............................................................ 207 Additives ............................................. 207
Top up ................................................. 207
Viscosity............................................... 207 Oil consumption ..................... 210, 220, 221
Oil level.................................................... 210
Oil pressure ............................................... 84
Opel Service ............................................ 199
Operating temperature ......................... 136
Outside temperature gauge ................... 91
Overrun ........................................... 136, 138
PPaintwork damage................................. 197
Park pilot ................................................. 150
Parking lamps........................................... 11
Bulb replacement ............................... 189
Pedals...................................................... 136
Performance ........................................... 222
Pollen filter .............................................. 127
Power assisted steering, see electronic power steering ................ 86
Power steering, see electronic power steering ........................................ 86
Preheating ................................................ 86
Pushing, towing .............................. 142, 166QQuickheat ............................................... 127RRadio ................................................. 24, 111
Radio equipment (CB) ........................... 113
Radio reception ...................................... 111
Radio remote control ............................... 28
Reading lamps ....................................... 109
Rear lamp cluster ................................... 102 Bulb replacement ............................... 191