spare wheel OPEL MERIVA 2009 User Guide

174 Self-help, vehicle careChanging wheels There may be a tyre repair kit instead of a
spare wheel 3178.
Make the following preparations and
observe the following information:
z Park the vehicle on a level, firm and non-
skid surface. The front wheels must be in
the straight-ahead position.
z Switch on the hazard warning flashers,
apply the hand brake, engage first gear
or reverse.
z Erect warning triangle as specified.
Warning triangle 3171.
z Remove the spare wheel 3 172.
z Never change more than one wheel at
once.
z Use the jack 3 only to change wheels. z
If the ground on which the vehicle is
standing is soft, a solid board (max. 1 cm
thick) should be placed under the jack 3.
z Block the wheel diagonally opposite the
wheel to be changed by placing wedge
blocks or equivalent in front and behind
the wheel. z
No people or animals may be in the
vehicle when it is jacked up.
z Never crawl under a jacked-up vehicle.
z Do not start the vehicle when it is raised
on the jack.
z Before screwing in the wheel bolts, clean
them and lightly coat the taper of each
wheel bolt with comm ercially available
grease.

177
Self-help, vehicle care
Picture no: 14763s.tif
The edge of the jack base must be
planted firmly and vertically in line with
the contact point.
Raise vehicle by turning crank handle.
If this is not the case, carefully lower the
vehicle immediately and reposition the
jack.
5. Unscrew the wheel bolts.
Picture no: 11647s.tif
If the wheel bolt s have retaining
washers 3, they must not be removed.
6. Change wheel. Notes on spare wheel 3172. Notes on temporary spare wheel
3 173.
7. Screw in the wheel bolts. Push the wheel bolt wrench 3 on as far as possible and
tighten the wheel bolts slightly.
8. Lower vehicle.
9. Push the wheel bolt wrench 3 on as far
as possible and tighten crosswise.
Tightening torque is 110 Nm. 10. Before refitting the wheel trim, clean the
wheel around the retaining clips. Valve
symbol 3 on back of wheel trim must
point towards valve on wheel.
Align and refit wheel trim or wheel bolt
caps 3.
Alloy wheels 3: put hub cap on and
engage, inserting pin on rear of hub
cap into relevant hole in wheel.
Alloy wheels with anti-theft lock 3: Put
hub cap on. Insert and tighten anti-
theft lock 3.
11. Stow removed wheel, tool kit and warning triangle in the luggage
compartment 3171.
12. Check the tyre pressure of the newly mounted wheel.
13. Have the wheel bolt tightening torque (110 Nm) checked.
14. Replace the faulty tyre on the wheel that was removed.

178 Self-help, vehicle careTyre repair kit
3
Minor damage to the tyre tread or sidewall
can be repaired with the tyre repair kit.
Do not remove the foreign body from the
tyre.
T y r e d a m a g e e x c e e d i n g 4 m m o r t ha t i s o n
the rim cannot be repaired with the tyre
repair kit.
Important 3181.
In the event of a flat tyre:
z Switch on the hazard warning flashers,
apply the hand brake, engage first gear
or reverse.
z Erect warning triangle as specified.
Warning triangle 3171.
Picture no: 17919S.tif
The tyre repair kit is in the stowage
compartment beneath the floor cover in
the luggage compartment.
1. Remove bag containing tyre repair kit
from compartment. Carefully remove
parts from bag.
2. Remove the compressor.
Picture no: 13639T.tif
3. Remove the electrical connection cable and air hose from the stowage
compartments on the underside of the
compressor.
9 Warning
Do not drive faster than 80 km/h.
Do not use the temporary spare wheel
for a lengthy period.
Steering and handling may be affected.

202 Service and maintenance⊕additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x1000)
1)
1)Depending on what occurs first.
1
30 2
60 3
90 4
120 5
150
⊕o
Remove brake drum, clean, carry out visual check every 4 years/60 000 km
Visually inspect steering system boots, track rods, final drive xxxxx
Check track rod end and supporting ball joint xxxxx
⊕
Change brake and clutch fluids (manual transmission automated) every 2 years
Loosen wheel mountings and tighten to 110 Nm
xx
Grease or apply oil to
bolt taper when fitting.
Check tyre condition and pressure (inclu ding spare wheel), correct if necessary.
If there is a tyre inflation system, check that the set is complete and the use-by date is
still valid. Replace sealant bottle every four years.
⊕
Annual service check if the annual distance travelled is greater than 20 000 km.
Visually check the first aid kit (that it is wher e it should be, that it is undamaged and that
the use by date is still valid), lashing eyes and warning triangle every 2 years
Check headlamp settings (including auxi liary headlamps), adjust if necessary xx
Lubricate door hinges, check arms, cylinder lo ck, door latch, bonnet catch, rear panel
hinge xx
Test run, final check (check steering and ig nition lock, instrument and warning lamps,
entire brake system, steering, air conditioni ng system, engine, bodywork and chassis,
reset service/interval display with TECH 2. xxxxx
⊕
Germany only: carry out emissions check, main inspection
First time after three years, then every 2 years
If used commercially to tran sport passengers, taxis, ambulances, hire cars etc annually

205
Service and maintenance
⊕ additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x 1000)
1)
1)Depending on what occurs first.
1
15 2
30 3
45 4
60 5
75
⊕o
Remove brake drum, clean, carry out visual check every 4 years/60 000 km
Visually inspect steering system boots, track rods, final drive xxxxx
Check track rod end and supporting ball joint xxxxx
⊕
Change brake and clutch fluids (manual transmission automated) every 2 years
Loosen wheel mountings and tighten to 110 Nm
xx
Grease or apply oil to
bolt taper when fitting.
Check tyre condition and pressure (inclu ding spare wheel), correct if necessary.
If there is a tyre inflation system, check that the set is complete and the use-by date is
still valid. Replace sealant bottle every four years.
⊕
Annual service check if the annual distance travelled is greater than 20 000 km.
Visually check the first aid kit (that it is wher e it should be, that it is undamaged and that
the use by date is still valid), lashing eyes and warning triangle every 2 years
Check headlamp settings (including auxi liary headlamps), adjust if necessary xx
Lubricate door hinges, check arms, cylinder lo ck, door latch, bonnet catch, rear panel
hinge xx
Test run, final check (check steering and ig nition lock, instrument and warning lamps,
entire brake system, steering, air conditioni ng system, engine, bodywork and chassis,
reset service/interval display with TECH 2. xxxxx

228 Technical DataTyres Restrictions
Not all tyres available on the market
currently meet the structural requirements.
We recommend that you consult an Opel
Partner concerning suitable tyre makes.
These tyres have undergone special tests
to establish their reliability, safety and
specific suitability for Opel vehicles.
Despite continuous market monitoring, we
are unable to assess these attributes for
other tyres, even if they have been granted
approval by the relevant authorities or in
some other form.
Further information 3153. Winter tyres
3
Tyres of size 205/50 R 16 are not suitable
for use as winter tyres except on vehicles
with the Z 16 LET engine.
Tyres of size 205/45 R 17 are not suitable
for use as winter tyres. If winter tyres are in use, the spare wheel
may still be fitted with a summer tyre. Use
of the spare wheel may alter vehicle
handling. Obtain a replacement for the
faulty tyre as soon as possible, and have
the wheel balanced and fitted to the
vehicle.
Further information 3
157.
Tyre chains
3
Tyre chains may be used on the front
wheels only.
We recommend the use of tyre chains with
a fine mesh that add no more than 10 mm
to the running surface and the insides of
the tyres (including chain lock).
Tyre chains are not permitted on tyre
sizes 205/50 R 16 and 205/45 R 17.
Further information 3157. Wheels Wheel bolt tightening torque: 110 Nm.
Spare wheel
3
Depending on model, the spare wheel is
designed as a temporary spare wheel 3.
When using the spare wheel, the driving
behaviour may be modified. Replace the
faulty tyre as soon as possible, balance the
wheel and refit to vehicle. Follow the notes
on this page and 3157, 3173.
On vehicles with alloy wheels 3 the spare
wheel may have a steel rim.
The spare wheel can be fitted with a
smaller tyre
1)and a smaller rim than the
wheels fitted on the vehicle.
Tyre pressure (overpressure) The specified tyre pressures are valid for
cold tyres. The increased tyre pressure
resulting from extensive driving must not
be reduced. The tyre pressures specified on
the following pages apply to both summer
and winter tyres.
The spare wheel must always be inflated to
the tyre pressure for a full load – see table
on following pages.
Further information 3153 to 3157. 1)Country-specific version: The spare wheel is
only to be used as a temporary spare wheel.

238 IndexRear seats.................................................. 51
Rear window washer system ...13, 101, 215
Refuelling................................................. 140Fuel filler cap ....................................... 141
Remote control Central locking system ......................... 28
Steering wheel ............................... 24, 111
Replacement keys .................................... 26
Reversing lamps...................................... 107 Bulb replacement................................ 191
Roof load .......................... 58, 135, 138, 226
Roof rack ...................................58, 138, 158
Roof racks ......................................... 58, 138
Running-in ............................................... 135 Brakes .................................................. 213SSafeguard against unauthorised use ..................15, 17, 27, 36
Safety accessories .................................. 171
Safety net .................................................. 56
Safety systems ........................................ 111
Saving energy ......................................... 136
Seat adjustment ............................. 2, 44, 51
Seat belts........................................... 62, 198
Seat height adjustment ........................ 3, 45
Seat occupancy recognition .................... 72
Seat position ................................... 2, 44, 45
Seats ...................................................... 2, 44 Extending the luggage
compartment .................................. 32, 53
heated ................................................... 46
Selector lever ........................................... 130
Self-diagnosis ..............................61, 72, 153 Self-help
Central locking ...................................... 31
Electric windows.................................... 40
Information display .............................. 92
Radio remote control ........................... 29
Self-help, care for your car .................... 165
Service interval display .......................... 208
Service intervals ...................................... 199 additional work ................................... 206
hard driving conditions ...................... 206
main inspection .................................. 199
Service work ............................................ 208
Side airbags .............................................. 69
Signal system ...................................... 11, 12
Spare wheel .................................... 172, 174
Speed............................................... 137, 138 Fuel consumption ....................... 137, 138
Speedometer ............................................ 87
Starting the engine.............15, 27, 130, 166 Self-help............................................... 166
Steam-jet cleaners.................................. 198
Steering column lock ................................ 15
Steering wheel adju stment ........................ 5
Steering wheel remote control ........ 24, 111
Stowage compartments .......................... 80
Sun roof ..................................................... 42 Fault....................................................... 43
Sun shade ................................................. 43
Sun visors .................................................. 81
System settings ......................................... 94
TTables ........................................................ 81
Tachometer............................................... 87 Tail lamps ............................................... 102
Bulb replacement ............................... 191
Tank Fuel gauge ............................................ 88
Technical data ....................................... 218
Telephone, see Mob ile telephone ......... 113
Temperature regulation ........................ 123
Tempomat, see cruise control ............... 148
Temporary spare wheel ................. 158, 173
The first 1000 km .................................... 135
Tightening torque .......................... 177, 228
Time........................................................... 92
Toll systems ............................................ 112
Tools ........................................................ 171
Towing equipment ................................. 158
Towing eye ..................................... 168, 170
Transmission ............................................. 14 Manual transmission .......................... 134
Transmission, Easytronic ....................... 129 Driving programmes .......................... 131
fault ..................................................... 133
Interruption of power supply ............. 134
Kickdown............................................. 132
Selector lever................................. 15, 130
Winter programme ............................. 132
Travel Assistant ............................ 22, 48, 49
Tread depth ............................................ 155
Trip computer ..................................... 23, 97
Trip odometer ........................................... 87
Triple information display ....................... 90
Turn signal lamps ............................. 11, 103
Turn signals Bulb replacement ....................... 190, 191
Twin Audio ........................................ 24, 112