steering OPEL MOVANO_B 2017 Manual user

162Driving and operating● the rear doors/tailgate are notclosed correctly
● the vehicle had a rear-end accident
● there are extreme temperature changes
Lane departure warning The lane departure warning system
uses a front camera to observe the
lane markings between which the
vehicle is driving. The system detects
lane changes and warns the driver in
the event of an unintended lane
change via visual and acoustic
signals.
Criteria for the detection of an
unintended lane change are:
● no operation of turn and lane- change signals
● no active steering
If the driver is performing these
actions, no warning will be issued.Activation
The lane departure warning system is activated by pressing ì in the roof
console; LED in the button
extinguishes to indicate that the
system is switched on.
When control indicator ì 3 94
illuminates in the instrument cluster,
the system is ready to operate. A
corresponding message also
appears in the Driver Information
Centre 3 98.
Control indicator ì extinguishes
when the system is not ready to warn the driver.
The system is only operable at
vehicle speeds above 60 km/h and if
lane markings are available and
detected.
If the turn and lane-change signals
are not operated when changing
lanes, i.e. an unintended lane change

166Driving and operatingTrailer hitch
General information
Only use towing equipment that has
been approved for your vehicle.
Entrust fitting of towing equipment at
a later date to a workshop. It may be
necessary to make changes that
affect the cooling system, heat
shields or other equipment.
Driving characteristics and towing tips
In the case of trailers with brakes,
attach the breakaway stopping cable.
Before attaching a trailer, lubricate
the coupling ball. However, do not do so if a stabiliser, which acts on thecoupling ball, is being used to reduce
snaking movements. For trailers with
low driving stability the use of a
stabiliser is recommended.
A maximum speed of 80 km/h must
not be exceeded, even in countries
where higher speeds are permitted.If the trailer starts snaking, drive more slowly, do not attempt to correct the
steering and brake sharply if
necessary.
When driving downhill, drive in the
same gear as if driving uphill and
drive at a similar speed.
Adjust tyre pressure to the value
specified for full load 3 239.
Trailer towing
Trailer loads The permissible trailer loads are
vehicle-dependent and engine-
dependent maximum values which
must not be exceeded. The actual
trailer load is the difference between
the actual gross weight of the trailer
and the actual coupling socket load
with the trailer coupled.
The permissible trailer loads are
specified in the vehicle documents. In
general, they are valid for gradients
up to max. 12%.
The permitted trailer load applies up to the specified incline and up to an
altitude of 1000 metres above sealevel. Since engine power decreases
as altitude increases due to the air
becoming thinner, therefore reducing
climbing ability, the permissible gross
train weight also decreases by 10%
for every 1000 metres of additional
altitude. The gross train weight does
not have to be reduced when driving
on roads with slight inclines (less than 8%, e.g. motorways).
The permissible gross train weight
must not be exceeded. This weight is
specified on the identification plate
3 218.
Vertical coupling load
The vertical coupling load is the load
exerted by the trailer on the coupling
ball. It can be varied by changing the
weight distribution when loading the
trailer.
The maximum permissible vertical
coupling load is specified on the
towing equipment identification plate
and in the vehicle documents. Always aim for the maximum load, especially in the case of heavy trailers. The
vertical coupling load should never
fall below 25 kg.

Driving and operating167In the case of trailer loads of
1200 kg or more, the vertical coupling
load should not be less than 50 kg.
Rear axle loadWhen the trailer is coupled and the
towing vehicle fully loaded (including all occupants), the permissible rear
axle load (see identification plate or
vehicle documents) must not be
exceeded.
Towing equipmentCaution
When operating without a trailer,
remove the coupling ball bar.
Towing equipment audible
warning
For vehicles fitted with towing
equipment, when connected to a
trailer the pitch of the audible warning
changes upon operation of the turn
signals.
The pitch of the audible warning will
change if a turn signal light on the
trailer or the towing vehicle fails.
Trailer stability assist
If the system detects snaking
movements, engine power is reduced
and the vehicle/trailer combination is
selectively braked until the snaking ceases. While the system is working,keep steering wheel as still as
possible.
Trailer stability assist (TSA) is a
function of the Electronic Stability
Program (ESP) 3 152.Auxiliary features
Power take-off
Activation
To activate the power take-off, with
the vehicle stationary and the engine
idling:
● Set the gearshift lever to neutral (vehicles with manual
transmission automated:
selector lever in position N).
● Depress the clutch pedal.

Vehicle care169Vehicle careGeneral Information...................170
Accessories and vehicle modifications .......................... 170
Vehicle storage ........................170
End-of-life vehicle recovery .....171
Vehicle checks ........................... 171
Performing work ......................171
Bonnet ..................................... 171
Engine oil ................................. 172
Engine coolant ......................... 173
Power steering fluid .................174
Washer fluid ............................ 175
Brakes ..................................... 175
Brake fluid ............................... 175
Vehicle battery ......................... 175
Diesel fuel filter ........................178
Diesel fuel system bleeding .....178
Wiper blade replacement ........179
Bulb replacement .......................179
Headlights ............................... 179
Adaptive forward lighting .........182
Fog lights ................................. 182
Front turn signal lights .............182
Tail lights ................................. 183
Side turn signal lights ..............184Centre high-mounted brake
light ......................................... 185
Number plate light ...................185
Interior lights ............................ 186
Instrument panel illumination ...187
Electrical system ........................187
Fuses ....................................... 187
Engine compartment fuse box . 188
Instrument panel fuse box .......189
Load compartment fuse box ....190
Vehicle tools .............................. 192
Tools ........................................ 192
Wheels and tyres .......................193
Tyres ....................................... 193
Winter tyres ............................. 193
Tyre designations ....................193
Tyre pressure .......................... 193
Tyre pressure monitoring system .................................... 194
Tread depth ............................. 196
Changing tyre and wheel size . 197 Wheel covers ........................... 197
Tyre chains .............................. 197
Tyre repair kit .......................... 198
Wheel changing .......................201
Spare wheel ............................ 203
Jump starting ............................. 206Towing....................................... 208
Towing the vehicle ...................208
Towing another vehicle ...........209
Appearance care .......................209
Exterior care ............................ 209
Interior care ............................. 211

174Vehicle careTop up with antifreeze. If no
antifreeze is available, use clean tap
water or distilled water. Install the cap tightly. Have the antifreeze
concentration checked and have the cause of the coolant loss remedied by
a workshop.
If a substantial amount of coolant is
required, it will be necessary to bleed any trapped air from the cooling
system. Seek the assistance of a
workshop.
Power steering fluidCaution
Extremely small amounts of
contamination can cause steering
system damage and cause it to not work properly. Do not allow
contaminates to contact the fluid
side of the reservoir cap or from
entering the reservoir.
The fluid level normally does not need
to be checked. If an unusual noise is
heard during steering or if the power
steering reacts conspicuously, seek
the assistance of a workshop.
Depending on vehicle, the power
steering fluid reservoir may be
located in the engine compartment
(Type A) or below the front wheel
arch, behind a trim panel (Type B).
Type A
If the fluid level in the reservoir falls
below the MINI mark, consult a
workshop.
Type B
If the fluid level in the reservoir falls
below the MIN mark, consult a
workshop.

198Vehicle careWheel covers on steel wheels maycome into contact with parts of the
chains. In such cases, remove the
wheel covers.
Tyre chains may only be used at
speeds up to 50 km/h and, when
travelling on roads that are free of
snow, they may only be used for brief
periods since they are subject to rapid wear on a hard road and may snap.
The use of tyre chains is not permitted on the temporary spare wheel.
Tyre repair kit Minor damage to the tyre tread can be
repaired with the tyre repair kit.
Do not remove foreign bodies from
the tyres.
Tyre damage exceeding four mm or
that is at the tyre's sidewall near the rim cannot be repaired with the tyrerepair kit.9 Warning
Do not drive faster than 80 km/h.
Do not use for a lengthy period.
Steering and handling may be
affected.
If the vehicle has a flat tyre:
Apply the parking brake and engage
neutral (manual transmission) or N
(manual transmission automated).
The tyre repair kit is located under the
front seat. Slide seat forwards fully
and fold backrest down to access kit.
1. Take the tyre repair kit out from under the front seat.
2. Remove the compressor.
3. Remove the power supply lead(s)
and air hose from the stowage
compartments on the underside
of the compressor.
4. Screw the compressor air hose to
the connection on the sealant
bottle.
5. Fit the sealant bottle into the retainer on the compressor.
Set the compressor near the tyre
in such a way that the sealant
bottle is upright.
6. Unscrew valve cap from defective
tyre.

208Vehicle carefar away from the discharged
vehicle battery as possible,
however at least 60 cm.
Route the leads so that they cannot
catch on rotating parts in the engine
compartment.
To start the engine: 1. Start the engine of the vehicle providing the jump start.
2. After five minutes, start the other engine. Start attempts should be
made for no longer than
15 seconds at an interval of
one minute.
3. Allow both engines to idle for approx. three minutes with the
leads connected.
4. Switch on electrical consumers (e.g. headlights, heated rear
window) of the vehicle receiving
the jump start.
5. Reverse above sequence exactly when removing leads.Towing
Towing the vehicle The towing eye is stowed with thevehicle tools 3 192.
Disengage the cover using a suitable
tool and remove.
Screw the towing eye clockwise into
the front towing point and tighten fully using the wheel wrench.
Attach a tow rope - or better still a tow
rod - to the towing eye, never to the
bumper or front suspension units.
Caution
Do not tow the vehicle from the
rear. The front towing eye must
only be used for towing and not
recovering a vehicle.
Switch on ignition to permit operation
of brake lights, horn and windscreen
wipers, and move the steering wheel
slightly to release the steering wheel
lock.
Switch off the air suspension system 3 135.
Transmission in neutral.
Caution
Vehicles with manual
transmission automated: If neutral cannot be selected, the vehiclemust only be towed with the drive
wheels raised off the ground.
The vehicle should always be
towed with the ignition switched
off.
Manual transmission automated
3 145.

249Loading information .....................78
Low fuel ....................................... 96
M
Malfunction indicator light ............93
Manual adjustment ......................35
Manual anti-dazzle ......................37
Manual door locks ........................22
Manual mode ............................. 147
Manual transmission............. 17, 145
Manual transmission automated ......................... 17, 145
Manual windows ..........................38
Messages ..................................... 99
Mirror adjustment ........................... 8
Mirrors .................................... 35, 37
Misted light covers .....................108
N New vehicle running-in ..............130
Number plate light .....................185
O Object detection systems ...........158
Odometer ..................................... 86
Oil ............................................... 172
Oil, engine .......................... 215, 219
Oil level ......................................... 87
Oil pressure .................................. 96
Outside temperature ....................82
Overcab storage ..........................72Overhead console .......................71
Overrun cut-off ........................... 131
P Parking ................................ 19, 134
Parking assist ............................ 158
Parking brake ............................ 150
Parking ticket holder .....................40
Particulate filter ........................... 137
Performing work ........................171
Pollen filter ................................. 126
Power door locks ..........................26
Power outlets ............................... 83
Power side step ............................ 27
Power sliding door ........................27
Power steering fluid ....................174
Power take-off ............................ 167
Power windows ............................ 38
Preheating ........................... 95, 130
Puncture ............................. 198, 201
R Radio Frequency Identification (RFID) ..................................... 244
Radio remote control ...................21
Rain sensor .................................. 81
Reading lights ............................ 110
Rear air conditioning system .....118
Rear bench seat storage ..............72
Rear courtesy light...................... 109
Rear doors ................................... 31Rear fog light ............................... 97
Rear fog lights ....................104, 108
Rear heating system .................. 116
Rear reading light .......................110
Rear reversing lens ......................38
Rear seats .................................... 49
Rear storage ................................. 72
Rear view camera ...................... 160
Rear windows .............................. 38
Recommended fluids and lubricants ........................ 215, 219
Refuelling ................................... 164 Registered trademarks ...............243
Remote control ............................. 21
Retractable parking brake ..........150
Reversing lights .........................108
Ride control systems ..........151, 154
Ride height ................................. 135
Roof .............................................. 40
Glass panel ............................... 40
Roof load ...................................... 78
Roof rack ..................................... 77
S
Safety belts ................................... 51
Safety net .................................... 76
Seat adjustment ....................... 7, 44
Seat belt ........................................ 8
Seat belt reminder .......................92
Seat belts ..................................... 51

250Seat heating................................. 48
Seat position ................................ 43
Selective catalytic reduction .......138
Selector lever ............................. 146
Service ............................... 126, 213
Service display ......................88, 93
Service information ....................213
Service vehicle soon .................... 93
Side airbag system ......................58
Sidelights .................................... 104
Side turn signal lights ................184
Side windows................................ 38
Sliding door .................................. 27
Spare wheel ............................... 203
Speed limiter......................... 85, 158
Speedometer ............................... 85
Starting and operating ................130
Starting off ................................... 18
Starting the engine .......18, 130, 146
Steering ...................................... 129
Steering column controls ..............80
Steering wheel adjustment ......9, 80
Steering wheel controls ...............80
Stop engine .................................. 94
Stop-start system............ 18, 96, 132
Storage ......................................... 70
Storage compartments .................70
Sun visors .................................... 40
Suspension height ......................135
Suspension seat ........................... 44Swivelling shelf............................. 71
Symbols ......................................... 4
T
Tachograph .......................... 97, 102
Tachometer ................................. 86
Tail lights ................................... 183
Technical data ............................ 219
Three-point seat belt .................... 52
Tools .......................................... 192
Top-Tether .................................... 60
Touchscreen ................................. 98
Tow bar....................................... 166
Towing ........................................ 166
Towing another vehicle .............209
Towing a trailer ........................... 166
Towing equipment .....................167
Towing eye ................................. 208
Towing the vehicle .....................208
Traction Control system ............. 151
Trailer coupling ........................... 166
Trailer stability assist .................167
Trailer towing ............................. 166
Transmission ............................... 17
Transmission display ...........88, 145
Tread depth ............................... 196
Trip computer ............................ 100
Trip odometer .............................. 86
Turbo engine warm-up ...............130
Turn and lane-change signals ...107Turn signal ................................... 92
Tyre chains ................................ 197
Tyre changing ............................. 201
Tyre designations ......................193
Tyre pressure ............................ 193
Tyre pressure monitoring system ............................... 95, 194
Tyre pressures ........................... 239
Tyre repair kit ............................. 198
Tyres .......................................... 193
Tyres and wheel size, changing. 197
U
Ultrasonic parking assist............. 158
Underseat storage .......................72
Upholstery .................................. 211
Upshift .......................................... 94
Using this manual ..........................3
V Vehicle battery ........................... 175
Vehicle checks............................ 171
Vehicle data ................................ 219
Vehicle data recording and privacy ..................................... 243
Vehicle dimensions .................... 229
Vehicle Identification Number ....217
Vehicle jack ................................ 192
Vehicle messages .......................99
Vehicle security ............................ 33
Vehicle specific data ......................3