engine oil Peugeot 207 CC 2011.5 - RHD (UK. Australia) User Guide

8
!
i
CHECKS
121
Avoid any prolonged contact of
used oil or fl uids with the skin.
Most of these fl uids are harmful to
health or indeed very corrosive.
Do not discard used oil or fl uids
into sewers or onto the ground.
Take used oil to a PEUGEOT dealer
or a qualifi ed workshop (France) or
an authorised waste disposal site.


Diesel additive level (Diesel with
particle emission filter)
The minimum level of this additive is in-
dicated by lighting of the service warning
lamp, accompanied by an audible signal
and a message on the multifunction
screen.

Used products

Unless otherwise indicated, check
these components in accordance with
the servicing booklet and in relation to
your engine.
Otherwise, have them checked by a
PEUGEOT dealer or a qualifi ed workshop.


Battery

The battery does not require
any maintenance.

However, check that the ter-
minals are clean and correctly
tightened, particularly in sum-
mer and winter.
When carrying out work on the battery,
refer to the "Practical information" sec-
tion for details of the precautions to be
taken before disconnecting the battery
and following its reconnection.


Air filter and passenger compartment filter

Refer to the servicing booklet
for details of the replacement
intervals for these compo-
nents.
Depending on the environ-
ment (dusty atmosphere...) and the use
of the vehicle (city driving...), replace
them twice as often if necessary
.
A clogged passenger compartment fi lter
may have an adverse effect on the per-
formance of the air conditioning system
and generate undesirable odours.


Particle emission filter (Diesel)

Illumination of the service warning lamp togeth-
er with a related message indicates the start of
saturation of the particle emissions fi lter.


Oil filter

Replace the oil fi lter each time
the engine oil is changed.
Refer to the servicing booklet
for details of the replacement
interval for this component. As soon as the driving conditions
permit, regenerate the fi lter by driv-
ing at a speed of at least 35 mph
(60 km/h) until the service warning
lamp goes off.
Maintenance of the particle emis-
sion fi lter must be carried out by
a PEUGEOT dealer or a qualifi ed
workshop.
Following prolonged operation of
the vehicle at very low speed or at
idle, you may, exceptionally, notice
the emission of water vapour at the
exhaust on acceleration. This does
not have any adverse effect on the
performance of the vehicle or on
the environment.
Topping up
This additive must be topped up by a
PEUGEOT dealer or a qualifi ed work-
shop without delay.

8
!
CHECKS
122
Only use products recommended
by PEUGEOT or products of equiv-
alent quality and specifi cations.
In order to optimise the operation
of units as important as the braking
system, PEUGEOT selects and of-
fers very specifi c products.
To avoid damaging the electrical
units, the use of a high pressure
washer in the engine compartment
is strictly prohibited
.


Automatic gearbox

The gearbox does not re-
quire any maintenance (no oil
change).
Refer to the servicing booklet
for details of the checking in-
tervals for this component.


Brake disc and drum wear

For any information relating
to checking of the brake disc
and/or drum wear, contact a
PEUGEOT dealer or a quali-
fi ed workshop.


Manual gearbox

The gearbox does not re-
quire any maintenance (no oil
change).
Refer to the servicing booklet
for details of the level checking
intervals for this component.


Brake pads

Brake wear depends on the
style of driving, particularly in
the case of vehicles used in
town, over short distances. It
may be necessary to have the
condition of the brakes checked, even
between vehicle services.
Unless there is a leak on the circuit, a
drop in the brake fl uid level indicates
that the brake pads are worn.


Parking brake

If the parking brake travel is
too long or if you notice a loss
of effectiveness of this sys-
tem, the parking brake must
be adjusted, even between
two services.
This system must be checked by a PEUGEOT
dealer or a qualifi ed workshop.

9
!
PRACTICAL INFORMATION
126

)
Visit a PEUGEOT dealer or
a qualifi ed workshop as soon
as possible.
You must inform the techni-
cian that you have used this
kit. After inspection, the tech-
nician will inform you whether
the tyre can be repaired or
must be replaced.


2. Infl ation


)
Turn the selector A
to the
"air" position.

)
Uncoil the black pipe H
fully.

)
Connect the black pipe to
the valve of the wheel.
)
Connect the compressor’s electric
plug to the vehicle’s 12 V socket.

)
Start the vehicle again and leave the
engine running.
)

Adjust the pressure using the compres-
sor (to infl ate: switch B
in position "I"
;
to defl ate: switch B
in position "O"
and
press button C
), in accordance with the
vehicle’s tyre pressure label (located on
the left hand door aperture).
A loss of pressure indicates that the
puncture has not been fully plugged;
contact a PEUGEOT dealer or qual-
ifi ed workshop for assistance.

)
Remove and stow the kit.

)
Drive at reduced speed (50 mph
[80 km/h] max) limiting the distance
travelled to approximately 120 miles
(200 km).

9
!
PRACTICAL INFORMATION
127

Beware of discharges of fl uid.
The expiry date of the fl uid is indi-
cated on the cartridge.
The sealant cartridge is designed
for single use; even if only partly
used, it must be replaced.
After use, do not discard the car-
tridge into the environment, take
it to an authorised waste disposal
site or a PEUGEOT dealer.
Do not forget to obtain a new sealant
cartridge, available from PEUGEOT
dealers or from a qualifi ed workshop.



Removing the cartridge




)
Stow the black pipe.

)
Detach the angled base from the
white pipe.

)
Support the compressor vertically.

)

Unscrew the cartridge from the bottom.

Checking tyre pressures/inflating accessories


You can also use the compressor, with-
out injecting any product, to:


- check or adjust the pressure of your
tyres,

- infl ate other accessories (balls, bi-
cycle tyres...).


)
Turn the selector A
to the
"Air" position.

)
Uncoil the black pipe H
fully.

)
Connect the black pipe to
the valve of the wheel or accessory.
If necessary, fi t one of the adaptors
supplied with the kit fi rst.
)
Connect the compressor’s electri-
cal connector to the vehicle’s 12 V
socket.

)

Start the vehicle and let the engine run.


)
Adjust the pressure using the com-
pressor (to infl ate: switch B
in po-
sition "I"
; to defl ate: switch B
in
position "O"
and press button C
),
according to the vehicle’s tyre pres-
sure label or the accessory’s pres-
sure label.

)
Remove the kit then stow it.

9PRACTICAL INFORMATION
139


Fuse N°



Rating



Functions




F1



20 A

Engine control unit and fan assembly control
relay supply, timing and canister electrovalves
(1.6 litre16V THP), air fl ow sensor (Diesel),
injection pump (Diesel), water in diesel sensor
(Diesel), EGR electrovalves, air heating (Diesel).


F2



15 A

Horn.


F3



10 A

Front wash-wipe.


F4



20 A

Headlamp wash.


F5



15 A

Fuel pump (petrol), Turbo electrovalves
(1.6 litre 16V THP).


F6



10 A

Vehicle speed sensor, automatic gearbox.


F7



10 A

Electric power steering, directional headlamps,
directional headlamps control relay, switching and
protection unit (Diesel).


F8



20 A

Starter control.


F9



10 A

ABS/ESP control unit, brake pedal switch.


F10



30 A

Engine control unit actuators (petrol: ignition coils,
electrovalves, oxygen sensors, injectors, heaters,
electronic thermostat) (Diesel: electrovalves,
heaters).


F11



40 A

Air conditioning blower.


F12



30 A

Windscreen wipers Low/High speed.


F13



40 A

Built-in systems interface supply (ignition positive).


Engine compartment fuses

The fuse box is placed in the engine
compartment, near the battery (left-
hand side).

Access to the fuses


)
Unclip the cover.

)
Replace the fuse (refer to the cor-
responding paragraph).

)
When you have fi nished, close the
cover carefully to ensure the sealing
of the fuse box.

Fuse table

10
148
TECHNICAL DATA


ENGINES AND GEARBOXES



PETROL ENGINES


1.6 litre VTi 120 hp



1.6 litre THP 156 hp



GEARBOXES

Manual
(5-speed)
Automatic
(4-speed)
Manual
(6-speed)
Cubic capacity (cc)
1 598
1 598
Bore x stroke (mm)
77 x 85.8
77 x 85.8
Max power: EU standard (kW)
88
115
Max power engine speed (rpm)
5 750
5 800
Max torque: EU standard (Nm)
160
240
Max torque engine speed (rpm)
4 250
1 400
Fuel
Unleaded
Unleaded
Catalytic converter
Yes
Yes

OIL CAPACITIES (in litres)





Engine (with fi lter replacement)
4.25
4.25
4.25

10
150
TECHNICAL DATA


ENGINES AND GEARBOXES



DIESEL ENGINE


1.6 litre HDi 112 hp



GEARBOX

Manual (6-speed)
Cubic capacity (cc)
1 560
Bore x stroke (mm)
75 x 88.3
Max power: EU standard (kW)
80
Max power engine speed (rpm)
4 000
Max torque: EU standard (Nm)
240
Max torque engine speed (rpm)
1 750
Fuel

Diesel
Catalytic converter
Yes
Particle emission fi lter
Yes

OIL CAPACITIES (in litres)





Engine (with fi lter replacement)
3.75

214
VISUAL SEARCH
TECHNICAL DATA - MAINTENANCE

Running out of Diesel ............... 117
Checking levels .................120-121


- oil

- brake fl uid

- coolant


screenwash/headlamp wash fl uid
Changing bulbs..................132-135


- front

- rear Petrol engines....................148-149
Diesel engine .....................150-151
Dimensions ............................... 152
Identifi cation markings .............. 153
Opening the bonnet .................. 117
Under-bonnet layout, petrol ...... 118
Under-bonnet layout, Diesel ..... 119 Checking components .......121-122


- air fi lter

- passenger compartment fi lter

- oil fi lter

- brake pads/discs
Engine compartment
fuses ................................139-140
Battery ...............................141-142

Load shedding/economy mode ..... 143

215
ALPHABETICAL INDEX
Accessories ....................................147Accessory socket, 12 V ....................59Access to rear seats.........................52Adjusting headlamps ........................83Adjusting the steering wheel............54Airbag, knee...................................103Airbags...........................................101Airbags, front ..................................101Airbags, lateral ...............................103Air conditioning.................................18Air conditioning, digital ...............46,50Air conditioning, manual.............46,47Air distribution adjustment..........47,50Air filter...........................................r121Air flow..............................................18Air flow adjustment .....................47,50Air intake....................................47,50Air recirculation ...........................47,50Air vents ...........................................45Alarm ................................................69Anti-swirl net...............................61,62Anti-theft...........................................66Assistance call ..........................93,156Audible warning................................94Audio streaming (Bluetooth) ...........201Automatic illumination
of headlamps.................................82Automatic operation
of hazard warning lamps...............94Auxiliary sockets.......59, 176, 196,198
Capacity, fuel tank............................77CD MP3..................................175, 195Central locking..................................74Changing a bulb ..................... 132, 134Changing a fuse.............................136Changing a wheel...........................128Changing a wiper blade .................143Changing the date ..................180, 203Changing the remote control battery...............................67Changing the time............33,180, 203Checking levels......................118–120Checking the engine oil level...........30Checking tyre pressures (using the kit)...............................123Checks............................118, 119, 121Children..........................88,89, 91, 92Child seats, conventional .....86, 88, 89Closing the boot...............................76Closing the retractable roof................f4Connectors, audio ....59,176,196,198
Control for retractable roof.................f4Control for the four windows............71Control panel ..................................158Coolant level ...................................120Coolant temperature indicator..........r31Courtesy mirror.................................r57Cruise control.................................112Cup holder........................................r58
Battery, remote control ...............67, 68Bluetooth (hands-free)....177,178, 199Bluetooth (telephone) .............177, 178Bonnet ............................................117Bonnet stay ....................................117Boot..................................................76Boot luggage carrier.......................r146Brake discs .....................................121Brake lamps ...................................134
Brake pads .....................................121Braking assistance system...............96
A
C
Battery ....................................121,141
Battery, charging ............................141
B
Date (setting)..................180,202,203Daytime running lamps.....................80Deactivating
the passenger airbag ..................101Deadlocking ......................................65Defrosting...................................47,49Demisting..........................................47Dials and gauges..............................20Diesel additive level........................120Dimensions .....................................152Dipped beam ............................80,132Dipstick.............................................30Directional lighting, static..................83Direction indicators...........93,132,134Doors ................................................73Doors emergency control .................75Door trays .........................................58
D
EBA
(Emergency braking assistance).......96
Eco-driving.......................................18
E

216
ALPHABETICAL INDEX
Jack ................................................128JACK socket ...................................196
Keeping children safe .......................91Key in ignition warning.....................67Key with remote control ........65,66,68
Eco-driving (advice)..........................18Economical driving..........................18Economy mode..............................143Electric window controls...................71Electronic engine immobiliser.....66,68Emergency braking system ..............96Emergency call .........................93,156Emergency warning lamps ...............94Energy economy mode ..................143Engine, Diesel..................78,117,119Engine, petrol...........................78,118Engine compartment..............118,119Engine compartment fusebox.........136Engine oil level indicator..................r30Engines...................................148,150Environment ...............................18,68ESP/ASR..........................................97
Hands-free kit.................177, 178, 199Hazard warning lamps......................94Headlamps, directional .............83, 132Headlamp wash................................84Head restraints, front........................52Heating .......................................18, 47Height and reach adjustment,
steering wheel ...............................54Horn..................................................94Labels, identification.......................153Lamps, rear....................................r134Lamps, warningand indicator......................r21,23,24Level, brake fluid ............................120Level, headlamp wash....................120Lighting.............................................80Lighting, guide-me home............80,82Lighting, interior................................r85Lighting bulbs (replacement)..........132Lighting control stalk.........................80Lighting dimmer................................r32Lighting on reminder.........................80Loading .....................................18,146Load reduction mode......................143
G.P.S..............................................163Gearbox, automatic................107, 121Gearbox, manual............105,106, 121Gear lever.........................................r18Gear lever, automatic gearbox.......107Gear lever, manual gearbox ........... 105Gear shift indicator.........................r106Glove box.........................................59Guidance........................................ 163Guide-me-home................................80
Interior lamp.....................................85ISOFIX child seats......................90–92ISOFIX mountings............................90
H
J
K
L
Filling with fuel ............................77–79Fitting a wheel................................128Fittings, boot.....................................60Flashing indicators...................93,132Foglamps, rear.........................r80,134Front foglamps.........................80,132Front seats.......................................52Fuel.............................................18,78Fuel consumption.............................18Fuel filler flap ..............................77,79Fuel gauge .......................................77Fuel tank.....................................77,79Fusebox, dashboard...................................136Fuses..............................................136
F
G
Indicators, direction..........................93Inflating accessories(using the kit)...............................123Inflating tyres....................................18Inputs for audio system...176,196, 198Instrument panel lighting..................32Instrument panels.............................20Instrument panel screen...........20, 106Interior fittings.............................58, 59
I