engine Peugeot 208 2013 Manual PDF

196
Checks






Checking levels
Oil level


The check is carried out either when
the ignition is switched on using theoil level indicator in the instrument
panel, or using the dipstick.

Engine oil change

Refer to the ser vicing and warranty booklet for
details of the inter val for this operation.
In order to maintain the reliability of the engine
and emission control system, the use of
additives in the engine oil is prohibited.

Oil specifi cation

The oil must be the correct grade for your engine and conform to the manufacturer'srecommendations.
Th
e brake fluid level should be close
to the "MA X" mark. If it is not, check
the brake pad wear.
Brake fluid level

Changing the fl uid

Refer to the servicing and warranty booklet for
details of the interval for this operation.

Fluid specifi cation

The brake fluid must conform to themanufacturer's recommendations and meet the
DOT3 or DOT4 standard.



Take care when working under the bonnet, as certain areas of the engine may be extremely hot (risk of burns) and the cooling fan could star t at
any time (even with the ignition off).
If a level drops si
gnificantly, have the corresponding system checked by a PEUGEOT dealer or a qualified workshop. Check all of these levels regularly, in line with the ser vicing booklet and the requirements of the warranties. Top them up if necessary, unless other wise indicated.
It is normal to top up the oil levelbetween two ser vices (or oil changes). PEUGEOT recommends that you check the level, and top up if necessary, every3 000 miles (5 000 kms).

After topping up the oil, the check whenswitching on the ignition with the oil level
indicator in the instrument panel is not valid
durin
g the 30 minutes after topping up. It will onl
y be correct if the vehicle is on level ground and the engine has been off for more
than 30 minutes.

197
8
Checks
Coolant level
The coolant level should be close
to the "MAX" mark but should never exceed it.

In addition, as the cooling system is pressurised, wait at least one hour after switching off the engine before carrying out anywork.
To avoid any risk of scalding, unscrew the cap
by two turns to allow the pressure to drop.
When the pressure has dropped, remove the
cap and top up the level.
Changing the coolant
The coolant does not have to be changed.
Fluid specifi cation
The coolant must conform to the
manufacturer's recommendations.



Fluid specifi cation

For optimum cleaning and to avoid freezing,
this fluid must not be topped up or replaced
with plain water.
Screenwash fluid level
Top up the level when necessary.
When the engine is warm, the temperature o
f
the coolant is regulated by the fan.
The cooling fan may star t after switchingoff the engine: take care with ar ticles andclothing that might become caught by thefan blades.

198
Checks
Avoid prolonged contact of used oil or fluids with the skin. Most of these fluids are harmful to health or indeed very corrosive.
Do not discard used oil or fluids intosewers or onto the ground. Take used oil to a PEUGEOT dealer or a qualified workshop (France) or to an authorised waste disposal site.








Used products
To p p i ng up
This additive must be topped up by a
PEUGEOT dealer or a qualified workshop
without delay.
Diesel additive level
(Diesel engine with particle
emission filter)
A low additive level is indicated by illumination
of the ser vice warning lamp, accompanied by an audible warning and a message in the screen (if a display screen is fitted).

199
8
Checks






Checks
12 V battery
The battery does not require any maintenance.
However, check that the terminals are clean
and correctl
y tightened, particularly in summer and winter.
The presence of this label, in particular with
the Stop & Star t system, indicates the use of
a specific 12 V lead-acid battery with special
technology and specification. The involvement
of a PEUGEOT dealer or a qualified workshop is essential when replacing or disconnecting
the battery.
Particle emissions filter (Diesel)

The star t of saturation of the particle filter is indicated by the fixed
illumination of this warning lamp
accompanied by a warning message
in the screen (if a display screen isfitted).
On a new vehicle, the first particlefilter regeneration operations may beaccompanied by a "burnt" smell, which is perfectly normal.
Following prolonged operation of thevehicle at very low speed or at idle, you may, in exceptional circumstances, notice the emission of water vapour atthe exhaust on acceleration. This does
not affect the behaviour of the vehicle or the environment.
Unless other wise indicated, check these components in accordance with the ser vicin
g and warranty booklet and according to your engine.
Other wise, have them checked by a PEUGEOT dealer or a qualified workshop.
Air filter and passenger compartment filter

Refer to the ser vicing and warrantybooklet for details of the replacement
inter vals for these components.
Oil filter
Replace the oil filter each time theengine oil is changed.
Refer to the servicing and warrantybooklet for details of the replacement
interval for this component. Depending on the environment
(e.g. dustyatmosphere) and the use of the vehicle(e.g. city driving), replace them twice as oftenif necessary.y
A clogged passenger compartment filter may have an adverse effect on the per formance
of the air conditioning system and generateundesirable odours. When carr
ying out work on the battery, refer
to the "Practical information" section for
details of the precautions to be taken before
disconnecting the battery and following its
reconnection.
As soon as the traffic conditions permit,
regenerate the filter by driving at a speed of at
least 40 mph (60 km/h) until the warning lamp goes off.
If the warning lamp stays on, this indicates a
low additive level.

9
201
Technical data
.../S: model fitted with Stop & Star t.















Petrol engines and gearboxes
Engines1 litre VTi68 hp1.2 litre VTi 82 hp1.4 litre VTi 95 hp
Gearboxes

Manual(5-speed)
Manual (5-speed)

Electronic (5-speed)

Manual (5-speed)

Model codes: CC... CA...

ZMZ0


HMZ0 - HMX0
HMZ0/PS

8FP0 - 8FN0


Cubic capacity (cc) 999

1 1991 397
Bore x stroke
(mm)
71 x 84.1
75 x 90.577 x 75

Max power: EU standard (kW)
* 50
60

70

Max power engine speed
(rpm)
6 000 5 750 6 000
Max torque: EU standard
(Nm)95

118

136

Max torque en
gine speed (rpm) 3 000
2 750
4 000

Fuel Unleaded Unleaded Unleaded

Catalytic converter yes yes
yes

OIL CAPACITIES
(in litres)
Engine (with filter replacement) 3.13
3.13

4.25

*
The maximum power corresponds to the type approved value on a test bed, under conditions defined by European legislation (directive 1999/99/EC).

202
Technical data
Engines1.6 litre VTi120 hp1.6 litre THP 155 hp1.6 litre THP 200 hp
GearboxesManual (5-speed)
Automatic(4-speed)


Manual (6-speed)


Manual(6-speed)
Model codes: CC... CA...
5FS0

5FS9
5FV8

5FU8
Cubic capacity (cc) 1 598
1 598

1 598

1 598

Bore x stroke (mm)77 x 85.8

77 x 85.8

77 x 85.8

77 x 85.8

Max power: EU standard
(kW)
* 88
105 115147
Max power engine speed
(rpm)
6 000 6 000 6 000 5 250
Max torque: EU standard
(Nm) 160
152 240275

Max torque engine speed (rpm)
4 250
3 560

1 400

1 770

F
uel Unleaded UnleadedUnleadedUnleaded

Catalytic conver ter yes yes
yes
yes
OIL CAPACITIES (in litres)

Engine (with filter replacement) 4.25
4.25
4.25

4.25
* The maximum power corresponds to the type approved value on a test bed, under conditions defined by European legislation (directive 1999/99/EC).

Petrol engines and gearboxes

9
203
Technical data
*
The kerb weight is equal to the unladen weight + driver (75 kg).
**

The weight of the braked trailer can be increased, within the GTW limit, if the GVW of the towing vehicle is reduced by an equal amount; warning,
towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned must be reduced b
y 10 % for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (10 0 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient temperature is above 37 °C,
limit the towed load.















Petrol weights and towed loads (in kg)
Engines1 litre VTi68hp1.2 litre VTi82 hp
GearboxesManual (5-speed)

Manual(5-speed)


Electronic (5-speed)
Model codes: CC... CA....ZMZ0


HMZ0 - HMX0HMZ0/PS

Body3-door 5-door
3-door
5-door
3-door
5-door


- Unladen wei
ght 960
975 960975
- -


- Kerb weight
*1 035 1 050
1 035
1 050 -
-



- Gross vehicle weight (GV W)
1 485 1 527-


-
Gross train weight (GTW)

on a 12 % gradient 1 935 2 347 -



- Braked trailer (within GTW limit) on a 10 % or 12 % gradient450 820-



- Braked trailer ** (with load transfer within
the GTW limit)
760
1 15 0-


-
Unbraked trailer 450
520-



- Recommended nose weight 30
46
-

204
Technical data
Engine s 1.4 litre VTi 95 hp1.6 litre VTi 120 hp
Gearbox

Manual(5-speed)
Manual (5-speed)
Model codes: CC... CA...
8FP0 - 8FN0

5FS0
Body3-door 5-door
3-door

5-door


- Unladen wei
ght1 055 1 0701 080
1 090



- Kerb weight
*

1 130
1 145
1 155 1 165


- Gross vehicle wei
ght (GV W)
1 590
1 605


-
Gross train weight (GTW)
on a 12% gradient2 530
2 565



- Braked trailer
(within GTW limit)
on a 10% or 12% gradient 940
960



- Braked trailer **
(with load transfer within
the GTW limit) 1 15 0
1 15 0



-
Unbraked trailer
570
580



- Recommended nose wei
ght 46

46

* The kerb wei
ght is equal to the unladen weight + driver (75 kg).
**
The weight of the braked trailer can be increased, within the GTW limit, if the GV W of the towing vehicle is reduced by an equal amount; warning,
towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.
Petrol weights and towed loads (in kg)
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned must be reduced by 10 % for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (10 0 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient temperature is above 37 °C,
limit the towed load.

9
205
Technical data
* The kerb weight is equal to the unladen weight + driver (75 kg).
**
The weight of the braked trailer can be increased, within the GTW limit, if the GVW of the towing vehicle is reduced by an equal amount; warning,
towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.
Petrol weights and towed loads (in kg)

The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned must be reduced by 10 % for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (10 0 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient temperature is above 37 °C,
limit the towed load.
Engines1.6 litreVTi120 hp1.6 litre THP155 hp1.6 litre THP 200 hp
Gearboxes
Automatic(4-speed)
Manual
(6-speed)

Manual
(6-speed)
Model codes: CC... CA...
5FS9
5FV8

5FU8
Body
3-door
5-door

3-door
3-door



- Unladen wei
ght 1 1201 150
1 090
1 160



- Kerb wei
ght *

1 195
1 225 1 165 1 235


- Gross vehicle wei
ght (GV W)

1 605
1 632
1 640

1 650



- Gross train weight (GTW)
on a 12% gradient 2 5652 582
2 570
2 580



- Braked trailer
(within GTW limit)
on a 10% or 12% gradient960 950
930930


- Braked trailer
**
(with load transfer within the GTW limit)

1 150 1 150 1 150


- Unbraked trailer
5
80
580
580



- Recommended nose weight
46

4646

206
Technical data
* The maximum power corresponds to the type approved value on a test bed, under conditions defined by European legislation (directive 1999/99/EC).















Diesel engines and gearboxes
Engines 1.4 litre HDi68 hp1.4 litre e- HDi 68 hp1.6 litre e- HDi 92 hp
GearboxesManual (5-speed)Electronic(5-speed)


Manual (5-speed)

Model codes: CC... CA...
8HR0
8HP0/PS
9HP0/S
Cubic capacity (cc) 1 398

1 560

Bore x stroke
(mm)

73.7 x 8275 x 88.3

Max power: EU standard (kW)
* 50
68

Max power engine speed
(rpm)
4 000 4 000
Max torque: EU standard
(Nm) 160

230

Max torque en
gine speed (rpm)
1 750
2 000

Fuel Diesel
Diesel

Catalytic conver ter yes yes

P
article emission filter yes
yes

OIL CAPACITIES
(in litres)
Engine (with filter replacement) 3.75 3.75

...
/S: e-HDi model fitted with Stop & Start.