check engine Peugeot 301 2015 Owner's Guide

164
301_en_Chap10_verifications_ed01-2014
To avoid damaging the electrical units,
never use a high pressure jet wash in
the engine compartment.
Diesel engine
1. Screenwash fluid reservoir.
2. Coolant header tank.
3.
A

i r f i l t e r.
4.
B

rake fluid reservoir.
5.


Battery.
6.


Fusebox.
7.
E

ngine oil dipstick.
8.
E

ngine oil filler cap.
9.
P

riming pump.
Checks

165
301_en_Chap10_verifications_ed01-2014
Checking levels
Oil level
The check of the oil level is carried
out with the dipstick, located under
the bonnet. For the position of the dipstick,
refer to the under-bonnet view on a previous
page.
Checking with dipstick
Refer to the under-bonnet view for the location
of the dipstick on your vehicle.
F

T
ake the dipstick by its coloured grip and
pull it out completely.
F

W
ith the end of the dipstick with a clean
and non-fluffy cloth.
F

R
efit the dipstick and push it fully down,
then pull it out again for a visual check of
the oil level:
the level must be between the two marks
A
and B . If you find that the oil level is above the A mark
or below the B mark, do not star t the engine.
Take care when working under the bonnet, as certain areas of the engine may be extremely hot (risk of burns) and the cooling fan could start at
any time (even with the ignition off).
Check all of these levels regularly, in line with the manufacturer's service schedule. Top them up if necessary, unless other wise indicated.
If a level drops significantly, have the corresponding system checked by a PEUGEOT dealer or a qualified workshop.
It is normal to top up the oil level
between two services (or oil changes).
PEUGEOT recommends that you check
the level, and top up if necessary, every
3 000 miles (5 000 km).
To ensure the accuracy of the reading, your
vehicle must be on a level sur face, with the
engine off for at least 30 minutes.
-

I
f the level is above
the MAX mark (risk of
engine damage), contact
a PEUGEOT dealer or a
qualified workshop.
-

I
f the level is below the
MIN mark, you must top-
up the engine oil.
10
Checks

166
301_en_Chap10_verifications_ed01-2014
Topping-up the engine oil
Oil grade
The oil must be the correct grade for your
engine and conform to the manufacturer's
recommendations.
Refer to the under-bonnet view for the location
of the oil filler cap on your vehicle.
F
U
nscrew the filler cap for access to the
filler orifice.
F

P
our in the oil in small quantities, avoiding
spills onto the engine (risk of fire).
F

W
ait a few minutes before checking the
level again using the dipstick.
F

T
op-up again if necessary.
F

A
fter checking and topping up, carefully
refit the oil filler cap and the dipstick to its
housing.
Engine oil change
Refer to the manufacturer's service schedule
for details of the interval for this operation.
In order to maintain the reliability of the engine
and emissions control system, never use
additives in the engine oil.
Checks

167
301_en_Chap10_verifications_ed01-2014
Coolant level
The coolant level should be close
to the "MA X" mark but should never
exceed it.
In addition, as the cooling system is
pressurised, wait at least one hour after
switching off the engine before carrying out any
work.
To avoid any risk of scalding, unscrew the cap
by two turns to allow the pressure to drop.
When the pressure has dropped, remove the
cap and top up the level.Changing the coolant
The coolant does not have to be replaced at
routine services.
Fluid specification
The coolant must conform to the
manufacturer's recommendations.
When the engine is warm, the temperature of
the coolant is regulated by the fan.
The cooling fan may star t after switching
off the engine: take care with ar ticles and
clothing that might be caught by the fan
blades.
The brake fluid level should be close
to the "MA X" mark. If it is not, check
the brake pad wear.
Brake fluid level
Changing the fluid
Refer to the manufacturer's service schedule
for details of the interval for this operation.
Fluid specification
The brake fluid must conform to the
manufacturer's recommendations.
10
Checks

168
301_en_Chap10_verifications_ed01-2014
Fluid specification
For optimum cleaning and to avoid freezing,
this fluid must not be topped up or replaced
with plain water.
In wintry conditions, it is recommended that you
use an ethyl alcohol or methanol based fluid.
Screenwash fluid level
Top up the level when necessary.Avoid prolonged contact of used oil or
fluids with the skin.
Most of these fluids are harmful to
health or indeed very corrosive.
Do not discard used oil or fluids into
sewers or onto the ground.
Take used oil to a PEUGEOT dealer or
a qualified workshop (France) or to an
authorised waste disposal site.
Used products
To p p i n g u p
This additive must be topped up by a
PEUGEOT dealer or a qualified workshop
without delay.
Diesel additive level (Diesel
engine with particle filter)
A low additive level is indicated by illumination
of the service warning lamp, accompanied
by an audible warning and a message in the
screen (if a display screen is fitted).
Checks

169
301_en_Chap10_verifications_ed01-2014
Checks
12 V battery
The battery does not require any maintenance.
However, check that the terminals are clean
and correctly tightened, particularly in summer
and winter.
Particle filter (Diesel)
The start of saturation of the
particle filter is indicated by
the fixed illumination of this warning lamp
accompanied by a warning message in the
screen (if a display screen is fitted).
As soon as the traffic conditions permit,
regenerate the filter by driving at a speed of at
least 40 mph (60 km/h) until the warning lamp
goes off.
If the warning lamp stays on, this indicates a
low additive level.
On a new vehicle, the first particle
filter regeneration operations may be
accompanied by a "burnt" smell, which
is perfectly normal.
Following prolonged operation of the
vehicle at very low speed or at idle,
you may, in exceptional circumstances,
notice the emission of water vapour at
the exhaust on acceleration. This does
not affect the behaviour of the vehicle
or the environment.
Unless otherwise indicated, check these components in accordance with the manufacturer's service schedule and according to your engine.
Other wise, have them checked by a PEUGEOT dealer or a qualified workshop.
Air filter and passenger compartment filter
Refer to the manufacturer's
service schedule for details of the
replacement intervals for these
components.
Oil filter
Replace the oil filter each time the
engine oil is changed.
Refer to the manufacturer's
service schedule for details of
the replacement interval for this
component.
When carrying out work on the battery, refer
to the "Practical information" section for
details of the precautions to be taken before
disconnecting the battery and following its
reconnection.
Depending on the environment (e.g. dusty
atmosphere) and the use of the vehicle (e.g.
city driving), replace them twice as often if
necessary
.
A clogged passenger compartment filter may
have an adverse effect on the per formance
of the air conditioning system and generate
undesirable odours.
10
Checks

223
301_en_Chap12b_RDE1_ed01-2014
FREqUENTLY ASKED q UESTIONS
qUESTION ANSWER SOLUTION
The CD is ejected
automatically or is not
played by the player
.The CD is inserted upside down, is unplayable, does not contain any
audio data or contains an audio format which the player cannot play.
The CD is protected by an anti-pirating protection system which is not
recognised by the audio equipment. -

Check that the CD is inserted in the player the
right way up.
-


Check the condition of the CD: the CD cannot
be played if it is too damaged.
-


Check the content in the case of a recorded
CD: consult the advice in the "Audio" section.
-


The audio system's CD player does not play
DVDs.
-


Due to their quality level, certain writeable
CDs will not be played by the audio system.
The CD player sound is
poor

. The CD used is scratched or of poor quality.
Insert good quality CDs and store them in suitable
conditions.
The audio settings (bass, treble, ambiance) are unsuitable. Set the treble or bass level to 0, without selecting
an ambiance.
In "Random all" play,
not all of the tracks are
played. In "Random all" play, the system can only take into account up to
999
tracks.
With the engine off, the
audio system switches
off after a few minutes
of use. When the engine is switched off, the audio system operating time
depends on the battery charge.
The switch-off is normal: the audio system switches to economy mode
and switches off to prevent discharging the vehicle's battery. Start the vehicle's engine to increase the battery
charge.
The message "the audio
system is overheated"
appears on the display. In order to protect the installation if the surrounding temperature is t\
oo
high, the audio system switches to an automatic thermal protection mode \
leading to a reduction of the volume or stopping of the playing of the C\
D. Switch the audio system off for a few minutes to
allow the system to cool.

228
301_en_Chap13_recherche-visuelle_ed01-2014
Maintenance - Technical data
Petrol weights 172
Diesel weights 1 74
Changing bulbs
1

36-141
-

front
-

rear Running out of fuel, Diesel

1

21
Opening the bonnet
1

62
Under the bonnet, petrol

1

63
Under the bonnet, Diesel

1

64
Petrol engines

1

71
Diesel engines
1

73 Bat ter y


147-149
Load reduction, economy mode
1
49, 150
Engine compartment
fuses
14
2-143, 146
Checking levels
16

5 -168
-

oil
-

b

rake fluid
-


coolant
-

s

creenwash fluid
-

a

dditive (Diesel with particle filter)
Checking components
1

69-170
-


battery
- a
ir / passenger compartment filter
-
o
il filter
-

p

article filter (Diesel)
-

b

rake pads / discs
Identification markings
1

76
Dimensions


175
Visual search

229
301_en_Chap14_index-alpha_ed01-2014
ABS and EBFD systems .................................94
A ccessories .................................................. 157
Accessory socket, 12V
...................................57
Adjusting headlamps


...................................... 86
Adjusting head restraints


................................41
Adjusting the steering wheel


..........................45
Advice on care and maintenance


........................157, 163, 16 4
Advice on driving


............................................ 60
Airbags


...................................................... 19, 9 9
Airbags, front ........................................... 99, 102
Airbags, lateral


...................................... 101, 102
Air conditioning


......................................... 48, 50
Air filter
.......................................................... 169
Air flow

..............................
................................8
Air vents


.......................................................... 46
Alarm


............................................................... 34
Anti-lock braking system (ABS)
......................94
Anti-theft


......................................................... 61
Armrest, front
............................................ 55, 57
Ashtray


............................................................ 55
Audible warning


.............................................. 90
Audio streaming (Bluetooth)
................. 19

0, 192
Audio system (radio)
.............................17 7, 2 0 9
Automatic operation of hazard warning lamps


.............................................. 90
Auxiliary socket


.......................57, 186, 189, 217 Battery, remote control .............................
3
2, 33
Bluetooth (hands-free) .................................. 19
1
Bonnet


...........................................................162
Boot


.................................................................37
Boot (unlocking)
.............................................. 3

0
Brake discs
.................................................... 17

0
Brake lamps
...............................

...................140
Brake pads


....................................................170
Braking assistance system

.............................94
B

raking system warning lamp
.........................16
C

apacity, fuel tank
..............................
..........118
CD


.........................................................18 4, 213
CD MP3
.................................................185, 18 6
Central locking


................................................31
Changing a bulb


.....................................13 6 -141
Changing a fuse


.....................................142-146
Changing a wheel


..................................128 -13 4
Changing a wiper blade


..........................8 8 , 151
Changing the date


...........................................23
Changing the remote control battery
........................................................... 32
C

hanging the time

...........................................23
Checking levels
..................................... 16

5 -168
Checking tyre pressures (using the kit)
..............................

................12 2
Checks
...............

....................................162-170
Child lock
...............................

........................117
Child seats, ISOFIX

...............................11

2 -11 6
Children
...............................

.....98, 10 0, 103 -117
Battery


............................................ 147-149, 16 9
Battery, charging


........................................... 149
A
D
C
B
Child seats .............................. ..............103 -116
Child seats, conventional .......................109 -110
Cigarette lighter ............................................... 57
Cleaning (advice)
.......................... 1

57, 163, 16 4
Clock


............................................................... 23
Closing the boot
........................................ 31, 37
Closing the doors


...................................... 31, 3 6
Connectors, audio
................... 5

7, 186, 189, 217
Coolant level


................................................. 167
Courtesy lamps
............................................... 89
Cruise control
.................................................. 77
C

up holder
...............................
........................55
Date (setting)
...............................

....................23
Daytime running lamps


...........................8 5, 13 8
Deactivating the passenger airbag ..................................10 0
Demisting, front


............................................... 53
Demisting, rear
................................................ 54
D

ials and gauges

............................................ 10
Diesel engine pre-heat warning lamp


................................................ 13
Dimensions


................................................... 175
Dipped beam
...............................

............81, 13 8
Dipstick
................

.......................................... 165
Direction indicators


.........................90, 137, 140
Doors


............................................................... 36
Door pockets
................................................... 55
D

riving economically ........................................ 8
.
Alphabetical index

232
301_en_Chap14_index-alpha_ed01-2014
Replacing the oil filter ...................................16 9
Replacing the passenger compartment filter


...................................... 169
Replacing wiper blades ...........................8 8 , 151
Resetting the service indicator


........................................................ 21
Resetting the trip recorder


..............................22
Rev counter


..................................................... 10
Reversing lamps


........................................... 140
Roof bars
....................................................... 16

0
Routine checks


..................................... 16 9, 170
Running out of fuel (Diesel)

..........................12

1
Safety for children
....................98, 10 0, 103 -117
Screen C, monochrome (Audio system / Bluetooth) ...................................................... 26
Screen menu map


.........................201, 202, 220
Screen, monochrome


...........................201, 220
Screen, multifunction (with audio equipment)


............................................ 26, 180
Screenwash fluid level
..................................168
Screenwash, front


........................................... 87
Screen-wash reservoir


.................................168
Seat adjustment
...............................

...............40
Seat belts
......................................... 9

6, 98, 109
Seats, rear


....................................................... 42
Serial number, vehicle
.................................. 17

6
Service indicator


............................................. 20
Servicing
...............................

............................8
Setting the clock
............................................. 23
S
Towing another vehicle .................................15 3
Three flashes (direction indicators) ................90
Traction control (ASR)


....................................95
Traffic information (TA)


.................................182
Tr a i l e r


............................................................ 15 4
Trip computer


............................................ 24-25
Trip distance recorder


..................................... 22
Tyre pressures


.............................................. 176
Ty r e s


.................................................................. 8
Tyre under-inflation detection


........................................... 16, 91, 93
Table of weights

.................................... 17

2 , 174
Tables of engines


.................................. 171, 173
Tables of fuses

.............................................. 142
Ta n k , f u e l


....................................................... 11 9
Technical data


........................................ 171-174
Telephone


..................................................... 193
Temporary tyre repair kit ...............................12 2
Third brake lamp


........................................... 141
To o l s


...................................................... 128, 129
Total distance recorder


................................... 22
To w b a r


........................................................... 15 4
Towed loads


.......................................... 172 , 174Under floor storage


......................................... 59
Under-inflation (detection)
.................. 16

, 91- 93
Unlocking
..............................

..........................30
Unlocking the boot
.......................................... 30
Vanity mirror
.................................................... 56
V

entilation
..............................
.............46-48, 50
T
U
V
Shields for very cold conditions ................... 15 6
Sidelamps ....................................... 81, 138, 140
Side repeater
..............................

..................13 9
Snow chains
.................................................. 13

5
Spare wheel
...............................

...........128, 129
Speed limiter


................................................... 75
Speedometer


.................................................. 10
Stability control (ESP)
..................................... 95
Start
...............................

................................148
Starting the engine


................................... 61- 63
Steering mounted controls, audio


........................................................... 179
Storage


...................................................... 55-57
Sun visor


......................................................... 56
Switching off the engine
........................... 61

- 63
Synchronising the remote control


...................32
Systems, ASR and ESP

..................................95
Alphabetical index