power steering Peugeot 307 Break 2002.5 Owner's Manual

09-09-2002
PEUGEOT SERVICING25
A AND C SERVICE LEVELS AND THE INTERMEDIATE VISIT
Level
Operations Description of operation 1st Service
A C Intermediate
DRAIN/REFILL Engine oil Bleed fuel filter (diesel) Oil filter Fuel filter *(petrol)REPLACE Fuel filter element (diesel) Air filter element Spark plugs (petrol) Engine oil (check + topup) Manual gearbox oil (check + topup) Battery (check + topup) if cap is removableLevel Screen wash (check + topup) Coolant (check + topup) Brake fluid (check + topup) Power steering fluid (check + top up according to specification) Operation of lights and indicators Condition of glass, headlamp and light lenses and mirrors Horn Windscreen washer jets Condition of wiper blades Condition and tension of the ancillary drive belts Handbrake Condition of hydraulic circuits (hoses and covers)CHECK Condition of rubber boots and gaiters Brake pads Play in hubs, link rods, ball joints, flexible mountings Shock absorbers Rear drum brake lining wear. Condition and pressure of tyres (including spare wheel) Emission control check as per current legislation (petrol) Smoke opacity (diesel) Pollen filter (according to specification) Visual check of the whole vehicle
SERVICE* Courtesy vehicle
ROAD TEST
: All driving conditions: Arduous conditions * According to country.

09-09-2002
RECOMMENDATIONS FOR
APPROVED LUBRICANTS
The oils which appear in the table
opposite are suitable for most pur
poses.
The diagram opposite states the
optimum range of viscosity depend
ing on the temperatures at which the
oils are to be used.
It is also possible to use "superior
quality" synthetic oils.
In the absence of semisynthetic or
synthetic oils, oils of API SH/SJ qual
ity (for petrol engines), or CD/CF
quality (for diesel engines) may be
used by following the "Arduous
Conditions" servicing schedule,
which specifies shorter intervals.
Do not hesitate to ask for advice from
a PEUGEOT dealer to maintain dri
ving pleasure and to minimise the
maintenance cost of your vehicle.
For countries outside Europe, please
contact a local PEUGEOT dealer.
PEUGEOT SERVICING27
Manual
ONLY ONLY
Gearbox ESSO Gear Oil BV TOTAL TRANSMISSION BV 75W80 PR 9736.41 75W80
AutomaticONLY
GearboxATF 4HP20AL4PR 9736.22
Other approved products
Power steering FLUIDE DA PR 9730. A1
Brake fluid PEUGEOT DOT4
Coolant
ONLY PROCOR TM108/GLYSANTIN G33 or REVKOGEL 2000
Protection to minus 35C

1.4 LITRE PETROL ENGINE
1 Power steering reservoir.
2 Windscreen wash reservoir.
3 Coolant reservoir. 4
Brake fluid reservoir.
5 Battery.
6 Fuse box. 7
Air filter.
8 Dipstick.
9 Engine oil filler cap.
PRACTICAL INFORMATION 135
09-09-2002

09-09-2002
PRACTICAL INFORMATION
136
1
Power steering reservoir
2 Windscreen wash reservoir
3 Coolant reservoir. 4
Brake fluid reservoir.
5 Battery.
6 Fuse box. 7
Air filter.
8 Dipstick.
9 Engine oil filler cap.
1.6 LITRE 16V PETROL ENGINE

09-09-2002
PRACTICAL INFORMATION137
1
Power steering reservoir.
2 Windscreen wash reservoir.
3 Coolant reservoir. 4
Brake fluid reservoir.
5 Battery.
6 Fuse box. 7
Air filter.
8 Dipstick.
9 Engine oil filler cap.
2 LITRE 16V PETROL ENGINE

PRACTICAL INFORMATION
138
1
Power steering reservoir.
2 Windscreen wash reservoir.
3 Coolant reservoir. 4
Brake fluid reservoir.
5 Battery.
6 Fuse box.
7 Air filter. 8
Dipstick.
9 Engine oil filler cap.
10 Priming pump.
1.4 LITRE TURBO DIESEL HDI ENGINE
09-09-2002

PRACTICAL INFORMATION139
1
Power steering reservoir.
2 Windscreen wash reservoir.
3 Coolant reservoir. 4
Brake fluid reservoir.
5 Battery.
6 Fuse box.
7 Air filter. 8
Dipstick.
9 Engine oil filler cap.
10 Priming pump.
2 LITRE HDI TURBO DIESEL ENGINE (90 bhp/110 bhp)
09-09-2002

CHECKING THE LEVELS
Oil level Check the level regularly and top
up between changes. The maxi
mum consumption is 0.5 l per
600 miles.
Check the level with the vehicle
level, engine cold, using the oil
level gauge on the instrument
panel or the dipstick.
Dipstick
There are two marks on
the dipstick:
A= maximum
Never fill past this mark.
B = minimum
To maintain the reliability
of engines and emission
control systems, the use
of additives in engine oil
is prohibited.
Oil change
According to the information given in
"PEUGEOT SERVICING".
WARNING: avoid used oil from com
ing into prolonged contact with the
skin.Viscosity selection
In all cases, the oil selected must
meet the manufacturer's require
ments.
Brake fluid level:
The level must always be between the DANGER and MAXIMUM
marks in the reservoir.
If the level drops substantially, con tact a PEUGEOT dealer immedi
ately.
Fluid change:
must be carried out according to the manufacturer's servicing
schedule.
use fluids approved by the manu facturer, which fulfil DOT4 stan
dards.
WARNING: brake fluid is harmful to
health and very corrosive. Avoid all
contact with the skin.
Cooling system
Use the fluid approved by the manu
facturer.
When the engine is warm, the tem
perature of the coolant is controlled
by the engine fan. As this fan can
operate with the ignition key
removed and because the cooling
system is pressurised, wait for at
least one hour after the engine has
stopped before carrying out any
work. Slacken the cap to the first notch to
release the pressure to prevent any
risk of scalding. When the pressure
has dropped, remove the cap and
top up the level.
Note:
the coolant does not need to
be changed.
Used oil
Do not dispose of used oil, brake
fluid or coolant into drains or into the
ground
Power steering reservoir Open the reservoir, with the
engine at ambient temperature.
The level should always be
above the MIN. mark and close to
the MAX. mark.
Windscreen wash reservoir
For best quality cleaning and for your
safety, we recommend that you use
products approved by PEUGEOT
(reservoir capacity 3.5 litres).
PRACTICAL INFORMATION
140
09-09-2002

09-09-2002
Only use products
approved by Automobiles
PEUGEOT.
To ensure best perfor
mance from components
as important as the power steering
and the braking system,
PEUGEOT selects and offers quite
specific products.
CHECKS
Battery
At the start of winter, have your bat
tery checked by a PEUGEOT dealer.
Air filter and pollen filter
Have the filter elements replaced
regularly. If you drive in dusty con
ditions, change them twice as
often.
Brake pads
Brake pad wear depends on the style
of driving, in particular for vehicles
which are used in town, over short
distances. It may be necessary to
check the thickness of the pads,
even between services.
Parking brake
Where the parking brake travel is too
great or there is a reduction in the
performance of the system, the
handbrake should be adjusted, even
between services.
Have the system checked by a
PEUGEOT dealer. Manual gearbox
This does not need an oil change.
Check the level, according to the
manufacturer's servicing schedule.
Automatic gearbox
This does not need an oil change.
Have the level checked by a
PEUGEOT dealer, according to the
manufacturer's servicing schedule.
Oil filter
Change the filter regularly, in accor
dance with the servicing schedule.
RUNNING OUT OF FUEL
(DIESEL)
If you should run out of fuel, it is
necessary to reprime the circuit:
1.4 litre HDI engine
fill the fuel tank with at least five
litres of diesel,
operate the manual repriming pump, under the bonnet, until fuel
appears in the transparent pipe
under the bonnet,
operate the starter until the engine starts.
2 litre HDI engine
fill the fuel tank with at least five litres of diesel,
operate the manual repriming pump, under the bonnet, until
you feel resistance during the
manoeuvre,
operate the starter until the engine starts.
PRACTICAL INFORMATION 141

09-09-2002
Engine compartment fuses
Fuse box
To access the fuse box in the engine
compartment (beside the battery): unclip the cover.
Carefully close the cover and refit
the style cover when you have fin
ished.
PRACTICAL INFORMATION 153
The electrical system of
your vehicle is designed to
operate with standard or
optional equipment.
Before installing other electrical
equipment or accessories on your
vehicle, contact a PEUGEOT
dealer.
PEUGEOT will not accept respon
sibility for the cost incurred in
repairing your vehicle or for recti
fying the malfunctions resulting
from the installation of acces
sories not supplied and not rec
ommended by PEUGEOT and not
installed in accordance with its
instructions, in particular where
the equipment in question con
sumes more than 10 mil
liamperes.
* The maxifuses provide addi tional protection for the electrical
systems. All work must be car
ried out by a PEUGEOT dealer.
Fuse N° Rating Functions
1* 30 A Fan unit.
2* 30 A ESP/ABS pump motor.
3* 30 A ESP/ABS solenoid valves.
4* 60 A Builtin Systems Interface supply.
5* 70 A Builtin Systems Interface supply.
6* — Not used.
7* 30 A Ignition switch, power.
8* 70 A Power steering electropump unit.