Diesel Peugeot 508 2012 User Guide

9
217
Checks
The various caps and covers allow access for checking the levels of the various fluids,
for replacing cer tain components and for priming the fuel system.

*

According to engine.












Diesel engines
1.
Power steering reservoir.2.Screenwash and headlamp wash reservoir.3.Coolant reservoir.4.
Brake fluid reservoir.
5. Battery/Fuses.
6.Fusebox.
7. Air filter.8.Engine oil dipstick.9.
Engine oil filler cap.10.Priming pump * . 11.
Bleed screw *
. 2.0 litre HDi 163 hp
2.2 litre HDi 200 hp

220
!
Checks
Avoid prolonged contact of used oil or fluids with the skin. Most of these fluids are harmful to
health or indeed very corrosive.
Do not discard used oil or fluids intosewers or onto the ground. Take used oil to a PEUGEOT dealer or a qualified workshop (France) or toan authorised waste disposal site.








Used products
To p p i ng up
This additive must be topped up by a
PEUGEOT dealer or a qualified workshop
w
ithout delay.
Diesel additive level
(Diesel engine with particle
emission filter)
A low additive level is indicated by illumination
of the ser vice warning lamp, accompanied by an audible warning and a message in the
instrument panel screen.

9
221
i
Checks






Checks
12 V battery
The battery does not require any maintenance.
However, check that the terminals
are clean and correctly tightened,particularly in summer and winter.
When carrying out work on the battery, refer to
the "Practical information" section for details of
the precautions to be taken before disconnecting
the battery and following its reconnection. Refer to the servicin
g booklet for
details of the replacement inter vals
for these components.
Dependin
g on the environment (e.g. dusty atmosphere) and the use of the
vehicle (e.g. city driving), replace them twice as often if necessary(refer to the "Engines"
section).
A clogged passenger compar tment filter may have an adverse effect on the per formance
of the air conditioning system and generateundesirable odours.
Air filter and passenger compartment filter
Replace the oil filter each time the engine oil is changed.
Refer to the servicing booklet for
details of the replacement inter val
for this component.
Oil filter The presence of this label, in par ticular with
the Stop & Star t system, indicates the use of
a specific 12 V lead-acid battery with special
technology and specification, for which the
involvement of a PEUGEOT dealer or a qualified workshop is required when replacingor disconnecting the battery. Failure to obser ve this recommendation mayshor ten the life of the battery.
Particle emission filter (Diesel)

The start of saturation of thepar ticle filter is indicated by
the temporary illumination of
this warning lamp accompanied by a message
in the multi-function screen.
As soon as the traffic conditions permit, regenerate the filter by driving at aspeed of at least 40 mph (60 km/h) until the warning lamp goes off.
If the warning lamp stays on,this indicates a low additive level.

On a new vehicle, the first particlefilter regeneration operations may beaccompanied by a "burning" smell,which is perfectly normal.
Following prolonged operation of thevehicle at very low speed or at idle, you may, in exceptional circumstances, notice the emission of water vapour atthe exhaust on acceleration. This does not affect the behaviour of the vehicle or the environment.
Unless other wise indicated, check these components in accordance with the ser vicing booklet and according to your engine.

Other wise, have them checked by a PEUGEOT dealer or a qualified workshop.

226
Technical data
Diesel engine1.6 litre HDi110 h p
Gearboxes
Manual(5-speed)


Electronic gear control (6-speed)

Model codes8D9HL0 - 8E9HL08D9HR8/PS - 8E9HR8/PS
Outline
Saloon
SWSaloonSW
Cubic capacit
y (cc)
1 560
1 560

Bore x stroke (mm)75 x 88.3

75 x 88,3

Max power: EU standard
(kW)
82
82
Max power en
gine speed (rpm) 3 600
3 600

Max torque: EU standard
(Nm) 240
270

Max torque engine speed (rpm) 1 750
1 750

F
uel Diesel

Catalytic conver ter
yes

Particle emission filter
yes
OIL CAPACITIES (in litres)

Engine (with filter replacement) 3.25

10
227
Technical data
ENGINES AND GEARBOXES
Diesel engines2.0 litre HDi 14 0 hp2.0 litre HDi163 hp
GearboxesManual (6-speed)


Automatic
(6-speed)Manual (6-speed)

Model codes8DRHR8 - 8ERHR8 8DRHF8 - 8ERHF88DRHHA - 8ERHHA 8DRHDA - 8ERHDA
8DRHH8 - 8ERHH8

OutlineSaloon
SWSaloon SWSaloon SW
Cubic capacit
y (cc) 1 997 1 997
Bore x stroke
(mm)
85 x 88 85 x 88
Max power: EU standard
(kW) 10 0103
10 0120

Max power en
gine speed (rpm)
4 000
3 750

Max torque: EU standard (Nm)
320340

Max torque engine speed (rpm) 2 000
2 000

Fuel

Diesel

Catalytic converter
yes

Particle emission filter yesno
OIL CAPACITIES (in litres)



En
gine (with filter replacement) 5.255

228
Technical data
ENGINES AND GEARBOXES
Dieselengine2.2 litre HDi204 hp
Gearbox
Automatic
(6-speed)
Model codes
8D4HLA - 8E4HLA
OutlineSaloon
SW
Cubic capacit
y (cc)

2 179

Bore x stroke (mm)
85 x 96
Max power: EU standard
(kW) 15 0
Max power en
gine speed (rpm) 3 500

Max torque: EU standard (Nm)
450

Max torque engine speed (rpm) 2 000

F
uel Diesel

Catalytic conver ter
yes

Particle emissions filter
yes
OIL
CAPACITIES (in litres)

Engine (with filter replacement) 5.25

10
229
Technical data
each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (10 0 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient temperature is above 37 °C,
limit the towed load.


*
The kerb wei
ght is equal to the unladen weight + driver (75 kg).

**
The weight of the braked trailer can be increased, within the GTW limit, if the GV W of the towing vehicle is reduced by an equal amount; warning,
towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.
WEIGHTS AND TOWED LOADS (in kg)
Diesel engines1.6 litre HDi 110 hp
Gearboxes

Manual(5-speed)


Electronic gear control (6-speed)
Model codes8D9HL0 - 8E9HL0

8D9HR8/PS - 8E9HR8/PS
OutlineSaloonSW
SaloonSW


- Unladen wei
ght 1 4051 425 1 410
1 430



- Kerb wei
ght *

1 480 1 500
1 485 1 505


- Gross vehicle wei
ght (GV W)
1 975
2 080
2 005
2 10 0



- Gross train wei
ght (GT W)
on a 12% gradient 3 175 3 18 0 3 205 3 200


- Braked trailer
(within GTW limit) on a 10% or 12% gradient
1 200
1 100

1 200

1 100



- Braked trailer
**
(with load transfer with theGTW limit)
1 475
1 400
1 475
1 400



-
Unbraked trailer
740

745740

750



- Recommended nose wei
ght
75

230
Technical data
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned must be reduced by 10 % for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (10 0 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the per formance of the vehicle to protect the engine; if the ambient temperature is above 37 °C,
limit the towed load.


* The kerb weight is equal to the unladen weight + driver (75 kg).
** The weight of the braked trailer can be increased, within the GTW limit, if the GV W of the towing vehicle is reduced by an equal amount; warning,
towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.
WEIGHTS AND TOWED LOADS (in kg)
Diesel engines2.0 litre HDi140 hp2.0 litre HDi163 hp
GearboxesManual (6-speed)


Automatic
(6-speed)

Manual (6-speed)

Model codes
8DRHR8 - 8ERHR8
8DRHF8 - 8ERHF8
8DRHHA - 8ERHHA 8DRHDA - 8ERHDA
8DRHH8 - 8ERHH8
OutlineSaloon
SW
Saloon SW
Saloon
SW


- Unladen wei
ght1 430
1 500
1 520
1 540
1 480
1 500



- Kerb weight *


1 505
1 575
1 595
1 615 1 555 1 575


- Gross vehicle wei
ght (GV W)
2 065
2 1402 105
2 18 0
2 075
2 140



- Gross train wei
ght (GT W)
on a 12% gradient 3 565 3 640 3 205 3 380 3 5753 640


- Braked trailer
(within GTW limit) on a 10% or 12% gradient
1 500

1 500

1 100

1 2001 500

1 500



- Braked trailer **
(with load transfer with the GTW limit)
1 775
1 775
1 375
1 475
1 775
1 790



- Unbraked trailer
750

750



- Recommended nose wei
ght
75

10
231
Technical data
* The kerb weight is equal to the unladen weight + driver (75 kg). **

The weight of the braked trailer can be increased, within the GTW limit, if the GVW of the towing vehicle is reduced by an equal amount; warning,
towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.

The
GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned must be reduced by 10 % for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (10 0 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient temperature is above 37 °C,
limit the towed load.

WEIGHTS AND TOWED LOADS (in kg)
Diesel engine2.2 litre HDi 204 hp
Gearbox

Automatic
(6-speed)
Model codes
8D4HLA - 8E4HLA
Outline
Saloon
SW


- Unladen wei
ght 1 540
1 660



- Kerb weight *1 615 1 735


- Gross vehicle wei
ght (GV W)
2 155
2 280



- Gross train weight (GT W)
on a 12% gradient 3 755 3 880


- Braked trailer
(within GTW limit) on a 10% or 12% gradient1 600
1 600



- Braked trailer
**
(with load transfer with theGTW limit)
1 875
1 875



- Unbraked trailer

750



- Recommended nose weight
75

324
Alphabetical index
Accessories ..................................................210Accessories socket, 12 volt............................74Adjusting headlamps .................................... 140Adjusting head restraints..........................64, 67Adjusting seat belt height..............................168Adjusting the steering wheel...........................73Airbags............................................................32Airbags, cur tain .....................................172, 173Airbags, front.........................................170, 173Airbags, lateral ......................................172, 173Air conditioning.......................20, 84, 85, 87, 90Air conditioning, digital ........................84,87,95Air conditioning, manual...........................84,85Air conditioning, quad-zone...............84,90,95Air filter..........................................................r221Air flow......................................................20, 83Air vents ..........................................................83Alarm ...............................................................50Anti-theft..........................................................98Armrest ............................................................74Armrest, rear...................................................r75Assistance call......................................162, 236Audible warning............................................162Audio streaming (Bluetooth)........280, 306,308Audio system (radio).....................................293Automatic illumination of headlamps ....133,137Automatic operation of hazard warninglamps ..........................................................161Automatic rain sensitive windscreen
wipers ................................................. 143, 145Auxiliary socket...............................76, 281,305
Bluetooth (hands-free)..........................263, 307Bluetooth (telephone)............................263, 307Boot...........................................................54-56
Boot (unlocking)..............................................43Brake discs....................................................222Brake lamps..........................................192, 193Brake pads....................................................222Brakes ...........................................................222
Capacity, fuel tank..........................................61CD.........................................................277, 300CD MP3 .........................................277, 301,302Central locking................................................44Changing a bulb.....................................187-195Changing a fuse....................................196-199Changing a wheel.................................180-186Changing a wiper blade........................146,204Changing the date.................................283, 316Changing the remote control battery ..............48Changing the time.................................283, 316Checking levels .....................................218-220Checking the engine oil level..........................37Checking tyre pressures(using the kit)..............................................179Checks..................................................214-222Children..................................149 -160, 169, 171Child seats............................................149-159Child seats, conventional ......................152,153Closing the boot..............................................54Closing the doors ............................................44Connectors, audio ..................76, 281,303,305Coolant level...........................................33, 219Coolant temperature indicator........................r33Courtesy lamps.............................................147Cruise control........................................123,126Cup holder.......................................................r74
Eco-driving.....................................................20Economy mode.............................................203Electronic engine immobiliser...................r49,98Electronic key............................................41- 48Electronic stability control (ESC)..................164Emergency boot release .................................57Emergency call.....................................162, 236Emergency warning lamps .....................80,161Energy economy mode.................................203Engine, Diesel..........63, 214, 216, 217,226-228Engine, petrol..................................63, 215, 223Engine compartment..............................215-217Engine compar tment fusebox.......................199Engine oil level indicator.........................r37,218Engines .........................................223,226-228Environment .......................20, 48, 84, 202, 220ESC/ASR....................................................... 164
A
C
E
Dashboard fusebox .......................................197Date (setting).........................................283, 316Daytime running lamps .........135,187, 189, 191Deactivating ESP..........................................166Deactivating the passenger airbag...............171Deadlocking....................................................45Defrosting........................................................95Diesel additive level......................................220Diesel preheat warning lamp..........................25Dimensions...................................................232Dipped beam ..................................132,187-189Dipstick....................................................37,218Directional lighting................................141, 142Direction indicators........136, 161, 187, 191-193Driving economically.......................................20Driving positions (storing)...............................66Dynamic emergency braking........................102
Dynamic stability control (DSC) ..............30, 166
Battery...................................................200, 221Battery, charging...........................................200Battery, remote control..............................47-49Blind................................................................58
B
D