maintenance Peugeot 508 2012 Owner's Manual

.
21
Limit the causes of excess
consumption
Spread loads throughout the vehicle; placethe heaviest items in the bottom of the boot,as close as possible to the rear seats.Limit the loads carried in the vehicle and reduce wind resistance (roof bars, roof rack, bicycle carrier, trailer...). Use a roof box inpreference.Remove roof bars and roof racks after use.

At the end of winter, remove snow tyres and refit your summer tyres.
Observe the recommendations
on maintenance
Check the tyre pressures regularly, when cold, referring to the label in the door aper ture, driver's side.Carry out this check in par ticular:- before a long journey,- at each change of season,- after a long period out of use. Don't forget the spare wheel and the tyres onany trailer or caravan.
Have your vehicle ser viced regularly (engine oil, oil filter, air filter...) and obser ve the schedule of operations recommended by the
manufacturer.


When refuelling, do not continue after the3 rdcut-off of the nozzle to avoid any over flow.

At the wheel of your new vehicle, it is only after the first 1 800 miles (3 000 kilometres) that you will see the fuel consumption settledown to a consistent average.

84
i
Comfort
In order for these systems to be fully effective, follow the operation and maintenance guidelines below: )If the interior temperature remains very high after the vehicle has been parked in the sunfor a considerable time, first ventilate the passenger compar tment for a few minutes. Place the air flow control at a sufficient level to provide an adequate renewal of air in the passenger compartment.)To obtain an even air distribution, take care not to obstruct the exterior air intake grilles located at the base of the windscreen, the nozzles, the vents and the air outlets, as wellas the air extractor located in the boot. )Use in preference the intake of exterior air as prolonged use of the air recirculation maycause misting of the windows and side windows.)Do not cover the sunshine sensor, located on the dashboard; this is used for regulation of the automatic air conditioning system.)Operate the air conditioning system for 5 to 10 minutes, once or twice a month to keep itin good working order. )Ensure that the passenger compar tment filter is in good condition and have the filter elements replaced regularly (refer to the "Checks" section). We recommend the use of a combined passenger compar tment filter. Thanks to its second special active filter, it contributes to the purification of the air breathed by theoccupants and the cleanliness of the passenger compar tment (reduction of allergic symptoms, bad odours and greasy deposits).)The air conditioning uses power from the engine while operating. This results in anincrease in the vehicle's fuel consumption. When towing at or near maximum capacity or on steep slopes in high ambient temperatures, switching off the air conditioning saves engine power and so improvestowing capacity. Condensation created by the air conditioning results in a discharge of water under thevehicle when stationary, which is per fectly normal.)To ensure correct operation of the air conditioning system, you are also advised to have it checked regularly.)If the system does not produce cold air, do not use it and contact a PEUGEOT dealer or a qualified workshop.
Recommendations for ventilation and air conditioning


The air conditioning system does not contain chlorine and does not present any danger to the ozone layer.

110
i!
Driving
Displays in the instrument
panel
When you move the lever in the gate to select aposition, the corresponding indicator comes on
in the instrument panel.
P. Park R. ReverseN.
Neutral D.
Drive (Automatic driving) S.Sport
programme7
. Snow
programme 1 to 6.
Gear engaged during manual operation-. Invalid value during manual operation
)
With your foot on the brake, select
pos
ition Por N.) Start the engine.
If this procedure is not followed, an audible
signal is heard, accompanied by a message in
the instrument panel screen.
) With the engine running, press the brake
pedal.
) Release the parking brake, unless it is
programmed to automatic mode. ) Select position R , D
or M , )
Gradually release the brake pedal.
The vehicle moves off immediately.


Moving off


When the engine is running at idle, with the brakes released, if position R , D
or M
is selected, the vehicle moves evenwithout the accelerator being pressed. When the engine is running, never leave children in the vehicle without supervision.
When carrying out maintenance with the engine running, apply the parkingbrake and select position P
.
P
If position Nis engaged inadver tently while driving, allow the engine to return to idle then engage position Dto accelerate.

4
119
i
!
!
Driving
The system is reactivated automatically at every new star t using the key.


Reactivation

Press the "ECO OFF"switch again.
The s
ystem is active again; this is confirmed
by the switch warning lamp going off and a message in the screen.
Operating fault
In the event of a fault with the system, the
"ECO OFF"
switch warning lamp flashes thencomes on continuously.
Have it checked by a PEUGEOT dealer or aqualified workshop.
In the event of a fault in STOP mode, the
vehicle ma
y stall. It is then necessary to switch
off the ignition and star t the engine again using
the key.

Before doing anything under the bonnet,deactivate the Stop & Start system toavoid any risk of injury resulting fromautomatic operation of STA R T m o d e .
This system requires a 12 V battery with a
special specification and technology (reference
numbers available from PEUGEOT dealers).
Fitting a battery not listed byPEUGEOT introduces the risk of malfunction of
the system.
To c h a rge the battery, use a 12 V charger andobser ve the polarity.


Maintenance


The Stop & Star t system makes use of advanced technology. For any work onthe system go to a qualified workshopwith the skills and equipment required,which a PEUGEOT dealer is able toprovide.

8
211
i
!i
Practical information
The fitting of electrical equipmentor accessories which are notrecommended by PEUGEOT may result in a failure of your vehicle's electronic system and excessive electricalconsumption.Please note this precaution. You areadvised to contact a PEUGEOTrepresentative to be shown the rangeof recommended equipment andaccessories.



Installation of radio communication transmitters

Before installing any after-market radio communication transmitter, you can contact a PEUGEOT dealer for the specification of transmitters which canbe fitted (frequency, maximum power, aerial position, specific installation
requirements), in line with the VehicleElectromagnetic Compatibility Directive(2004/10 4/EC).


Depending on the legislation in force in the country, it may be compulsoryto have a high visibility safety vest, warning triangle and spare bulbs and fuses available in the vehicle. You can also obtain products
for cleaning and
maintenance (exterior and interior) and topping up fluids (screenwash, ...), as well as refills(cartridge for temporary tyre repair kit...) fromPEUGEOT dealers.



"Multimedia":

audio systems, portable navigation system,
Ta k a r a / S o ny por table video screen, Bluetoothsystem, speakers, DVD player, Wi-Fi, speed camera aler t, video suppor t, microwave unit...

9
221
i
Checks






Checks
12 V battery
The battery does not require any maintenance.
However, check that the terminals
are clean and correctly tightened,particularly in summer and winter.
When carrying out work on the battery, refer to
the "Practical information" section for details of
the precautions to be taken before disconnecting
the battery and following its reconnection. Refer to the servicin
g booklet for
details of the replacement inter vals
for these components.
Dependin
g on the environment (e.g. dusty atmosphere) and the use of the
vehicle (e.g. city driving), replace them twice as often if necessary(refer to the "Engines"
section).
A clogged passenger compar tment filter may have an adverse effect on the per formance
of the air conditioning system and generateundesirable odours.
Air filter and passenger compartment filter
Replace the oil filter each time the engine oil is changed.
Refer to the servicing booklet for
details of the replacement inter val
for this component.
Oil filter The presence of this label, in par ticular with
the Stop & Star t system, indicates the use of
a specific 12 V lead-acid battery with special
technology and specification, for which the
involvement of a PEUGEOT dealer or a qualified workshop is required when replacingor disconnecting the battery. Failure to obser ve this recommendation mayshor ten the life of the battery.
Particle emission filter (Diesel)

The start of saturation of thepar ticle filter is indicated by
the temporary illumination of
this warning lamp accompanied by a message
in the multi-function screen.
As soon as the traffic conditions permit, regenerate the filter by driving at aspeed of at least 40 mph (60 km/h) until the warning lamp goes off.
If the warning lamp stays on,this indicates a low additive level.

On a new vehicle, the first particlefilter regeneration operations may beaccompanied by a "burning" smell,which is perfectly normal.
Following prolonged operation of thevehicle at very low speed or at idle, you may, in exceptional circumstances, notice the emission of water vapour atthe exhaust on acceleration. This does not affect the behaviour of the vehicle or the environment.
Unless other wise indicated, check these components in accordance with the ser vicing booklet and according to your engine.

Other wise, have them checked by a PEUGEOT dealer or a qualified workshop.

222
!
Checks
Manual gearbox
The gearbox does not require anymaintenance (no oil change).
Refer to the servicing booklet for
the details of the level checking
interval for this component.
6-speed electronic gearbox
s
ystem
The gearbox does not require anymaintenance (no oil change).
Refer to the servicing booklet for
details of the checking interval for
this component.
Automatic gearbox
The gearbox does not require anymaintenance (no oil change).
Refer to the ser vicing booklet for
details of the level checkin
g interval
for this component. Brake wear depends on the st
yle
of driving, par ticularly in the case
of vehicles used in town, over shor t
distances. It ma
y be necessary to
have the condition of the brakes checked,even between vehicle services.
Unless there is a leak in the circuit, a drop in
the brake fluid level indicates that the brake pads are worn.
















Brake pads

For information on checking brake
disc wear, contact a PEUGEOT
dealer or a qualified workshop.


Brake disc wear














Electric parkin
g brake
This system does not require any routine servicing. However, in the
event of a problem, have the systemchecked by a PEUGEOT dealer or a qualified workshop.
For more information, see "Driving - Electric parking brake - § Operating faults".
















Only use products recommended by PEUGEOT or products of equivalentquality and specification. In order to optimise the operationof units as impor tant as the braking system, PEUGEOT selects and offersvery specific products.
To a v o i d d a m aging the electrical units,the use of a high pressure washer in the engine compar tment is strictly
prohibited.
Manual parking brake

If a loss of effectiveness of this system is noticed, the parking brake
must be checked, even between
tw
o services.
Checking this system must be done by aPEUGEOT dealer or a qualified workshop.

.
325
Alphabetical index
G.P.S.............................................................245Gearbox, automatic..............................109, 222Gearbox, electronic gear control ..........................................113, 117, 222Gearbox, manual ...................107,108, 117, 222Gear lever, automatic gearbox .....................109Gear lever, electronic gear control gearbox...........................................113Gear lever, manual gearbox.........................107Gear shift indicator........................................108Guidance.......................................................245Guide-me-home....................................13 6, 137
Halogen headlamps..............................187,188Hands-free kit........................................263,307Hazard warning lamps............................80,161
Identification plates .......................................233Indicator lamps, status ..............................23-32Indicators, direction......................................161Inflating accessories (using the kit) ..............................................179Inflating tyres..........................................20, 233
Inputs for audio system...................76, 281, 305Instrument panel.............................................22Instrument panel screen.........................23,108Intelligent Traction Control ............................165Interior fittings .................................................74Interior mood lighting....................................148ISOFIX child seats .................................156-158ISOFIX mountings.........................................156
Labels, identification .....................................233Lamps, warning and indicator...................r23-32Level, brake fluid ...........................................218Level, headlamp wash..........................144, 219Level, power steering fluid............................218Levels and checks.................................215-222Lighting, guide-me home......................136, 137Lighting, interior....................................r147,148Lighting bulbs (replacement) ...........................................187-195Lighting control stalk.............................132, 136Lighting on reminder.....................................r135Loading....................................................20,209Load reduction mode....................................202Load space cover............................................r79Locating your vehicle......................................46Long objects, transpor ting..............................76Low fuel level..................................................61Luggage retaining strap ............................77,78
Keeping children safe............149 -160, 169, 171Key.............................................................41-49Key, electronic.........................41, 42,44, 47, 97Keyless Entry and Star ting ...........41, 42,49,97Key with remote control..................................41
Main beam.............................132,187-189, 191Maintenance....................................................20Manual gearbox............................................107Map reading lamps.......................................147Markings, identification .................................233Massage function ...........................................68Mat ..................................................................75
G
H
K
I
L
M
Filling with fuel..........................................61, 63Fitting a wheel ...............................................185Fitting roof bars .............................................209Fittings, boot.............................................77,78Flashing indicators................................136,161Foglamps..............................13 4, 187, 19 0, 192
Foglamps, front.............................134,187, 190Foglamps, rear......................................r134, 192
Folding the rear seats .....................................69Front seats ................................................64-66Fuel............................................................20, 63Fuel consumption ............................................20Fuel filler cap...................................................61Fuel filler flap...................................................61Fuel gauge......................................................61Fuel tank..........................................................61Fuses.............................................................196
Head-up display ............................121,124, 126Headlamp adjustment...................................140Headlamps, directional .........................141,187Headlamp wash............................................144Headlamp wash reser voir.............................r219Head restraints, front......................................67Head restraints, rear.......................................r69Heated seats .............................................64, 67Heating.............................20, 85, 87, 90, 93, 96Height and reach adjustment, steering wheel..............................................73High load retaining net ....................................81Hill start assist...............................................120
F
Jack.......................................................180,181JACK socket....................................76, 281, 305JBL (audio system)....................................7,237
J

.
333
Visual search
Maintenance - Technical data
Identification markings 233 Dimensions 232


Running out of fuel, Diesel 214
Checking levels 218-220- oil - brake fluid - power steering fluid - coolant- screenwash/headlamp wash fluid Checking components 221-222 - air filter - passenger compar tment filter - oil filter - electric parking brake- brake pads/discs

Changing bulbs 187-195- front- rear

12V battery 200-202 Load reduction, economy mode 202, 203 Engine compar tment fuses 19 6, 19 9


Opening the bonnet 213
Under the bonnet, petrol 215
Under the bonnet, Diesel 216-217
Petrol engines 223
Diesel engines 226 -228
Petrol weights 224-225 Diesel weights 229 -231