Engine Peugeot 607 Dag 2002 Repair Manual
[x] Cancel search | Manufacturer: PEUGEOT, Model Year: 2002, Model line: 607 Dag, Model: Peugeot 607 Dag 2002Pages: 167, PDF Size: 2.61 MB
Page 159 of 167
PRACTICAL INFORMATION 153
Special features of the
automatic gearbox
When towing with four wheels on the
ground, the following rules must be
obeyed:
– lever in position
N,
– tow the vehicle at less than 30 mph (50 km/h) over a maximum
distance of 30 miles (50 km).
– do not add oil to the gearbox.
TOWING YOUR VEHICLE
Without lifting (4 wheels on the road)
You should always use a tow bar.
The towing eye is inside the spare wheel.
From the front:
Unclip the bottom of the cover, using the flat part of th e towing eye.
Screw in the towing eye until it locks.
From the rear: Unclip the top of the cover using the flat part of the to wing eye,
Screw in the towing eye until it locks.
Lifting (2 wheels only on the road )
It is preferable to raise the vehicle by the wheels.
Never use the radiator crossmember.
ParticularitŽs de la bo”te de vitesses automatique
When towing with the
engine switched off,
there is no braking assis
tance.
Page 160 of 167
PRACTICAL INFORMATION
154
T
OWING A TRAILER,
CARAVAN, BOAT ETC...
Only use original PEUGEOTtow
bars which have been tested and
approved from the design stage of
your vehicle.
The tow bar must be fitted by a
PEUGEOTdealer.
Driving advice
Distribution of loads: distribute the
load in the trailer so that the heaviest
loads are as close as possible to the
axle and the nose weight is close to
the maximum authorised without,
however, exceeding it.
Cooling: towing a trailer on a slope
increases the coolant temperature.
As the fan is electronically con
trolled, its cooling capacity is not
dependent on the engine speed.
On the contrary, use a high gear to
lower the engine speed, and reduce
your speed. In all cases, pay attention to the
coolant temperature.
Note:
in certain cases of particularly
arduous use (towing the maximum
load up a steep slope in high tem
peratures), the engine automatically
limits its power. In this case, cutting
off the air conditioning allows the
engine power to be recovered, and
therefore the towing speed to be sig
nificantly increased (approximately
12mph [20 km/h] more).
If the coolant temperature warning
light comes on, stop the vehicle and
switch off the engine as soon as pos
sible.
Tyres: check the tyre pressures of
the towing vehicle and of the trailer,
observing the recommended pres
sure.
Brakes: towing increases the brak
ing distance. Drive at a moderate
speed, change down early and brake
gradually.
Side wind: sensitivity to side wind is
increased. Drive smoothly and at a
moderate speed. Lighting
Manual adjustment
Adjust your headlamps so as not to
dazzle other road users (see section
on ''Manual adjustment of head
lamps''). Check the electrical sig
nalling of the trailer.
Automatic beam correction
For vehicles with Xenon bulbs, this
system automatically corrects the
height of the beam, whatever the
load of the vehicle. The driver is then
assured of having optimum lighting
and not causing a nuisance to other
road users.
In cases of malfunction, the driver is
alerted by means of the warning light
on the instrument panel.
In this situation the system adjusts
your headlamps to the low position.
Page 162 of 167
156TECHNICAL DATA
PETROL ENGINES
MODELS:
Model codes 9DRFNB 9D3FZB 9D3FZE 9DXFXB 9DXFXE
ENGINES
Capacity (cm 3
)
Bore x stroke (mm)
Number of valves
Max. power: EU standard (KW)
Max. power at engine speed (rpm)
Max. torque: EU standard (Nm)
Max. torque at engine speed (rpm)
Fuel
Catalytic converter
Electronic injection
GEARBOX
CAPACITIES (in litres)
Engine (with filter replacement)
Gearbox Final drive 2 litre 16V 2.2 litre 16V 24V V6 Injection
1997 2230 2946
85x88 86x96 87x82.6 16 16 24
100 116 152
6000 5650 6000
190 217 285
4100 3900 3750
Unleaded* Unleaded Unleaded Yes* Yes YesYe s Ye s Ye s
Manual Manual Automatic Manual Automatic
(5 speed) (5 speed) (4 speed) (5 speed) (4 speed)
4.25 4.25 4.751.9 1.85 8 1.85 8
* According to country.
Page 163 of 167
157
TECHNICAL DATA
Turbo diesel Turbo diesel 2 litre HDI 2.2 litre 16V HDI
1997 2179
85x88 85x96
81 6
80 79 98 4000 4000
250 314
1750 2000
Diesel Diesel
Yes* Yes
No Yes Yes Ye s Ye s
Manual Manual Automatic
(5 speed) (5 speed) (4 speed)
4.75 4.75
1.85 1.85 8
DIESEL ENGINES
MODELS:
Model codes 9DRHZB 9DRHSB 9D4HXB 9D4HXE
ENGINES
Capacity (cm 3
)
Bore x stroke (mm)
Number of valves
Max. power : EU standard (KW)80
Max. power at engine speed (rpm)
Max. torque: EU standard (Nm)
Max. torque at engine speed (rpm)
Fuel
Catalytic converter
Particulate emission filter (PEF)
Electronic Injection
GEARBOX
CAPACITIES (in litres)
Engine (with filter replacement)
Gearbox Final drive
* According to country.
Page 164 of 167
158
2 litre 16VManual 9DRFNB 22.9 (12.3)* 2.8 (6.6) 32.8 (8.6)* 205 g/km*
2.2 litre 16V Manual 9D3FZB 22.2 (12.7) 39.2 (7.2) 30.7 (9.2) 219 g/km
2.2 litre 16V Automatic 9D3FZE 21.1 (13.4) 39.8 (7.1) 30.1 (9.4) 225 g/km
24V V6 injection Manual 9DXFXB 0.3 (13.9) 38.2 (7.4)) 28.8 (9.8) 234 g/km
24V V6 injection Automatic 9DXFXE 19.6 (14.4) 36.2 (7.8) 27.7 (10.2) 245 g/km
2 litre turbo Manual9DRHZB 35.8 (7.9)* 60.1(4.7)* 47.9 (5.9)* 157 g/km*
diesel HDI 9DRHSB 35.7 (8.0)* 60.0 (4.8)* 47.8 (6.0)* 160 g/km*
2.2 litre 16V Manual 9D4HXB 31.7 (8.9) 51.4 (5.5) 2.2 (6..7) 178 g/km
turbo diesel HDI
2.2 litre 16V
Automatic 9D4HXE 28.8 (9.8) 48.7 (5.8) 39.2 (7.2) 93 g/kmturbo diesel HDI
Fuel consumption values correct at time of printing.
* According to country. Consumption As per directive 93/116 in MPG (litres/100km)
Engine Gearbox Model Urban Extra urban Mixed Emission codes driving driving driving by mass of CO2
TECHNICAL DATA
Page 165 of 167
159
TECHNICAL DATA
Engines2 litre 2.2 litre 2.2 litre 24V 24V
16V 16V 16V V6 injection V6 injection
Gearbox Manual Manual Auto. Manual Auto.
Model codes: 9DRFNB 9D3FZB 9D3FZE 9DXFXB 9DXFXE
• Kerb weight 1436 1455 1475 1560 1580
• Gross vehicle weight (GVW) – 2 035 2 055 2140 2160
• Gross train weight (GTW)* –
3 635 (1) 3 835 (2) 3 555 (1) 3 855 (2) 3 940 (1) 3 940 (2) 3 660 (1) 3960 (2)
• Braked trailer weight (within GTW limit) – – – – –
• Recommended nose weight – – – – –
Engines2 litre 2.2 litre 2.2 litre
HDI 16V HDI 16V HDI
Gearbox Manual Manual Auto.
Model codes: 9DRHZB/HSB 9D4HXB 9D4HXE
• Kerb weight 1490 1 535 1 550
• Gross vehicle weight (GVW) – 2 115 2 130
• Gross train weight (GTW)* –
3 715 (1) 3 865 (2) 3 330 (1) 3630 (2)
• Braked trailer weight (within GTW limit) – – –
• Recommended nose weight – – –
* The speed of a towing vehicle is limited to 60 mph (100 km/h).
(1) 12 % gradient. (2) 8 % gradient.
Note : When the external temperature is higher than 45°C, restrict th e gross train weight. For vehicles with a 2.2 litre 16V
HDI engine with automatic gearbox, towing is not possible.
WEIGHTS AND TOWING LOADS (in kg)
Page 167 of 167
161
TECHNICAL DATA
THE IDENTIFICATION FEATURES OF YOUR 607
A. Manufacturer's plate.
B. Serial number on the bodywork.
C. Serial number on the fascia.
D. Tyres. Label Don the inside of the fuel filler flap indicates :
– the dimensions of the rims and tyres,
– the makes of tyre recommended by the manufacturer,
– the tyre pressures (checking of the tyre pressure must be carried out w hen the tyres are cold, at least once a
month).
E. Paint reference. The label on the right hand engine support in the engi ne compartment indicates the paint colour reference.