engine Peugeot Boxer Dag 2010 Owner's Manual
[x] Cancel search | Manufacturer: PEUGEOT, Model Year: 2010, Model line: Boxer Dag, Model: Peugeot Boxer Dag 2010Pages: 167, PDF Size: 4.33 MB
Page 11 of 167
4221
FAMILIARISATION
15
Familiarisation
Reversing camera
The camera comes on when you engage
reverse gear and remains active up to
approximately 9 mph (15 km/h). It is
deactivated above 11 mph (18 km/h).
77
Instrument panel
A. Speedometer.
B. Instrument panel screen.
C. Rev counter.
26 Warning lamps
With the ignition on, the orange and red
warning lamps come on.
With the engine running, these warning
lamps should switch off.
If warning lamps remain on, refer to the
chapter concerned.
27
MONITORING
Buttons
Brightness adjustment.
Screen
Press the button and place the screen in the
required position.
Back-lighting adjustment.
ON/OFF provides views of the rear
without engaging reverse gear.
Page 13 of 167
4321
FAMILIARISATION
17
Familiarisation
Cruise control
The state of the cruise control system is
given on the instrument panel by a warning
lamp located in the rev counter.
44 Hill start assist
This system, linked with the ESP, makes hill
starts easier and is activated in the following
conditions:
- the vehicle must be stationary, with the engine running,
- the gradient of the road must be steeper than 5 %.
38 Pneumatic suspension
This equipment allows you to alter the rear
height of the load floor to make loading or
unloading easier.
Press the up control switch; release to stop
the movement. Each press increases by one
level: +1 to +3.
Press the down control switch; release to
stop the movement. Each press decreases
by one level: -1 to -3.
Driving with the load floor too high or too
low may damage components under the
body.
79
Function deactivated.
Function selected.
DRIVING SAFELY
Page 25 of 167
Instruments and controls
28
Warning
lamp is indicates Solution - action
C o o l a n t
temperature o n w i t h t h e
n e e d l e i n t h e r e d
zone.
an abnormal increase.
P a r k a n d s w i t c h o f f t h e i g n i t i o n , a l l o w t h e s y s t e m
t o c o o l .
Visually check the level.
o n H i n t h e r e d
zone. a coolant temperature. R e f e r t o t h e " L e v e l s " s e c t i o n o f c h a p t e r 7 . C o n s u l
t a
P E U G E O T d e a l e r .
Engine oil
pressure o n w h i l e d r i v i n g . t h a t t h e p r e s s u r e i s t o o l o w .
P a r k a n d s w i t c h o f f t h e i g n i t i o n , a l l o w t h e l u b r i c
a t i o n
s y s t e m t o c o o l i n o r d e r t o c h e c k i t s l e v e l . R e f e r t o t h e
" L e v e l s " s e c t i o n o f c h a p t e r 7 .
c o n t i n u o u s l y o n ,
even though the
level is correct. a m a j o r f a u l t . C o n s u l t a P E U G E O T d e a l e r .
f l a s h i n g , f o r a
f e w s e c o n d s ,
w i t h a m e s s a g e
on the screen. t h a t a s e r v i c e w i l l s o o n b e d u e .
R e f e r t o t h e l i s t o f c h e c k s i n t h e s e r v i c i n g b o o k l
e t t h e n
carry out the PEUGEOT service.
Battery charge on.
a f a u l t i n t h e c h a r g i n g c i r c u i t . C h e c k t h e b a t t e r y t e r m i n a l s … R e f e r t o t h e " B a t t e r y
"
s e c t i o n o f c h a p t e r 8 .
c o n t i n u o u s l y o n ,
f i x e d o r f l a s h i n g
i n s p i t e o f t h e
checks. a c i r c u i t f a u l t , a n i g n i t i o n o r
i n j e c t i o n m a l f u n c t i o n .
C o n s u l t a P E U G E O T d e a l e r .
Door or bonnet
o p e n d e t e c t i o n on. t h a t a d o o r o r t h e b o n n e t i s n o t
c l o s e d c o r r e c t l y . C h e c k t h a t t h e c a b d o o r s , t h e r e a r a n d s i d e d o o r s
a n d
t h e b o n n e t a r e c l o s e d .
Page 32 of 167
Instruments and controls
3 5
2
READY TO SET OFF
SERVICE INDICATOR
F o r a f e w s e c o n d s a f t e r t h e i g n i t i o n i s
s w i t c h e d o n , t h e s p a n n e r s y m b o l i s i n g t h e
s e r v i c e i n d i c a t o r c o m e s o n : t h e s c r e e n
i n f o r m s y o u w h e n t h e n e x t s e r v i c e i s d u e ,
i n a c c o r d a n c e w i t h t h e m a n u f a c t u r e r ' s
s e r v i c i n g s c h e d u l e i n d i c a t e d i n t h e s e r v i c i n g
b o o k l e t . T h i s i n f o r m a t i o n i s d e t e r m i n e d i n
r e l a t i o n t o t h e d i s t a n c e t r a v e l l e d s i n c e t h e
previous service.
LIGHTING RHEOSTAT
T h e r h e o s t a t i s a c t i v e w h e n t h e l i g h t i n g i s o n .
A f t e r a f e w s e c o n d s , t h e d i s p l a y r e t u r n s t o
i t s u s u a l f u n c t i o n s .
U s e t h e s e c o n t r o l s t o a d j u s t t h e
b r i g h t n e s s o f t h e i n s t r u m e n t p a n e l .
There are 8 levels.
A long press returns you to the main menu.
R e f e r t o " M o d e " s e c t i o n o f c h a p t e r 4 .
Deterioration of the engine oil (100 and 120 bhp engines)
T h e " O i l L i f e " f u n c t i o n d e t e r m i n e s t h e
s e r v i c e i n t e r v a l , b e t w e e n 2 0 , 0 0 0 m i l e s
( 3 0 , 0 0 0 k m ) a n d 3 0 , 0 0 0 m i l e s ( 4 5 , 0 0 0 k m ) ,
d e p e n d i n g o n t h e w e a r o f t h e e n g i n e o i l .
T h e e n g i n e c o n t r o l u n i t t e s t s t h e d e g r e e o f
w e a r o f t h e e n g i n e o i l . R e f e r t o t h e l i s t o f c h e c k s i n t h e
s e r v i c i n g b o o k l e t w h i c h w a s g i v e n t o
y o u o n h a n d o v e r o f t h e v e h i c l e .
Reminder of servicing information
A t a n y t i m e , t o a c c e s s t h e s e r v i c e i n d i c a t o r ,
p r e s s b r i e f l y o n t h e M O D E b u t t o n .
U s e t h e u p / d o w n a r r o w s t o s e e t h e
s c h e d u l i n g a n d e n g i n e o i l w e a r i n f o r m a t i o n .
P r e s s i n g t h e M O D E b u t t o n a g a i n a l l o w s y o u
t o r e t u r n t o t h e v a r i o u s d i s p l a y m e n u s .
Menu... Choose...
Allows you
to...
12
Service Service
( M i l e s / k m
b e f o r e o i l
c h a n g e ) Display the
d i s t a n c e
remaining
b e f o r e t h e
n e x t o i l
change.
Oil Display the
oil level.
Resetting to zero
T h e s t o p p i n g o f t h e p e r m a n e n t f l a s h i n g o f
t h e i n d i c a t o r i s c a r r i e d o u t b y a n a u t h o r i s e d
r e p a i r e r w i t h a d i a g n o s t i c t o o l .
I n t h i s c a s e , y o u r v e h i c l e m u s t b e s e r v i c e d
a s s o o n a s p o s s i b l e ( w i t h i n a p p r o x i m a t e l y
6 0 0 m i l e s / 1 0 0 0 k m ) .
T h e f u n c t i o n m u s t b e r e s e t t o z e r o e v e r y
t i m e t h e e n g i n e o i l i s c h a n g e d .
Y o u a r e w a r n e d b y t h e f l a s h i n g o f
t h e e n g i n e o i l p r e s s u r e w a r n i n g
l a m p a n d a m e s s a g e o n t h e
instrument panel every time you
s t a r t t h e e n g i n e , i f y o u r v e h i c l e i s f i t t e d w i t h
t h i s f u n c t i o n .
Page 34 of 167
Starting and stopping
3 7
2
READY TO SET OFF
STARTING AND STOPPING
MAR p o s i t i o n : r u n n i n g .
C e r t a i n a c c e s s o r i e s c a n b e u s e d .
AVV p o s i t i o n : s t a r t e r .
T h e s t a r t e r i s o p e r a t e d .
STOP p o s i t i o n : s t e e r i n g l o c k .
T h e i g n i t i o n i s o f f .
Good practice when starting
Engine immobiliser warning lamp
I f t h i s c o m e s o n , u s e a n o t h e r k e y
a n d h a v e t h e f a u l t y k e y c h e c k e d
b y a P E U G E O T d e a l e r .
Diesel pre-heating warning lamp
Turn the key to the MAR position.
I n c o l d w e a t h e r , w a i t f o r t h i s
w a r n i n g l i g h t t o s w i t c h o f f t h e n
o p e r a t e t h e s t a r t e r ( AVV p o s i t i o n ) u n t i l t h e
engine starts.
I f t h e t e m p e r a t u r e i s h i g h e n o u g h , t h e
w a r n i n g l a m p c o m e s o n f o r l e s s t h a n o n e
s e c o n d , y o u c a n s t a r t w i t h o u t w a i t i n g . Door or bonnet open warning lamp
I f t h i s c o m e s o n , a d o o r o r t h e b o n n e t
i s n o t c l o s e d c o r r e c t l y , c h e c k !
Good practice when stopping
Minimise engine and gearbox wear
W h e n s w i t c h i n g o f f t h e i g n i t i o n , l e t t h e
e n g i n e t o i d l e f o r a f e w s e c o n d s t o a l l o w t h e
t u r b o c h a r g e r t o s l o w d o w n .
D o n o t p r e s s t h e a c c e l e r a t o r w h e n s w i t c h i n g
o f f t h e i g n i t i o n .
T h e r e i s n o n e e d t o e n g a g e a g e a r a f t e r
parking the vehicle.
In low temperatures
I n m o u n t a i n o u s a n d / o r c o l d a r e a s , i t i s
a d v i s a b l e t o u s e a " w i n t e r " t y p e f u e l s u i t e d
t o l o w o r m i n u s t e m p e r a t u r e s .
Page 39 of 167
41
3
EASE OF USE AND COMFORT
Steering wheel controls
AUTOMATIC ILLUMINATION OF HEADLAMPS
If your vehicle is fitted with this function, the
sidelamps and dipped beam headlamps are
switched on automatically if the light is poor.
In fog or snow, the sunshine sensor may
detect sufficient light. Therefore, the lamps
will not be switched on automatically. If
necessary, you must switch on the dipped
beam headlamps manually.
They are switched off when the light returns
to a sufficient level.
Activation
Turn the ring to this position.
The lamps are switched off
automatically when the ignition is
switched off.
Do not cover the sunshine sensor at
the top centre of the windscreen.
GUIDE ME HOME LIGHTING
Ignition off or key in the STOP position.
Within 2 minutes after switching off the
engine, position the ignition key in the STOP
position or remove it.
Pull the lighting stalk towards the steering
wheel. The indicator lamp comes on
on the instrument panel.
Each action on the lighting stalk,
pulled towards the steering
wheel, prolongs the guide me home
lighting by 30 seconds up to approximately
3 minutes. When this time has elapsed,
the lamps are switched off automatically.
Deactivate this control by keeping the stalk
pulled towards the steering wheel for more
than 2 seconds.
If your vehicle is fitted with this function:
when you leave your vehicle, the sidelamps
and dipped beam headlamps remain on for
the selected duration (when leaving a car
park for example).
To set the sensitivity of the sensor,
refer to "Mode" in chapter 4.
Page 45 of 167
47
3
EASE OF USE AND COMFORT
Ventilation
VENTILATION
DEMISTING AND DEFROSTING
Manual mode
Direct the control to this air
distribution setting.
For faster and more effective
demisting and defrosting of the
windscreen: Defrosting the rear screen and
mirrors
Only operates when the engine
is running. Pressing this button
activates the rapid demisting-
defrosting of the rear screen and
door mirrors.
This function switches off automatically to
prevent excessive energy consumption. It
stops when the engine is switched off but
resumes when the engine is started again.
Pressing this button switches the function off.
- increase the air flow setting,
Returning to the exterior air
intake position permits renewal
of the air in the passenger
compartment.
Windscreen and side windows
The ventilation outlets located at the base
of the windscreen and the side vents for the
side windows increase the effectiveness
of the demisting and defrosting. Do not
obstruct these air outlets.
The pollen filter continuously and effectively
filters dust.
Air recirculation (which can be activated by
the driver or the passenger) isolates the
passenger compartment from the exterior
atmosphere. However, this position should
only be used temporarily, normal use is to
drive with the control positioned with the
exterior air intake open.
- move the exterior air intake
control temporarily to air
recirculation.
Page 47 of 167
49
3
EASE OF USE AND COMFORT
Ventilation
WITH MANUAL ADJUSTMENT
If your vehicle is fitted with these controls,
they are located on the dashboard on the
centre console control panel.
Temperature adjustment
Control positioned:
- in the blue zone provides cool air,
Air flow
The force of the blown air, from
the vents, varies from 1 to the
strongest 4. Remember to adjust
this control in order to reach the
ambient air comfort level. To switch off the
blower, place the control in position 0.
Air conditioning
The air conditioning mode can only operate
with the engine running.
The air blower must be set to at
least 1.
Pressing the button triggers the
operation of the air conditioning,
the LED is on. Pressing the button again
switches the function off and the LED is
switched off.
Air distribution
The air supply distribution is directed by the
control turned towards:
the side vents and the central
vents,
the side vents, the central vents
and the footwells,
the footwells,
the windscreen, the footwells and
the side windows,
the windscreen and the side
windows.
- in the red zone provides
heating of the interior ambient
air.
Page 49 of 167
51
3
EASE OF USE AND COMFORT
Ventilation
MONO ZONE DIGITAL AIR CONDITIONING
If your vehicle is fitted with this system, the
controls are located in the middle of the
dashboard. The system can be identifid by
its control screen.
AUTO mode
Switching on FULL AUTO
mode: pressing the AUTO
control switches on the
system's functions, confirmed
by the display of FULL AUTO . This is the
normal operating mode for the digital air
conditioning system.
Using the moving ring surrounding the AUTO
control, set the comfort temperature to be
reached according to a setting between:
- H I ( H i g h t o ≈ 3 2 ) a n d ,
- L O ( L o w t o ≈ 1 6 ) .
T h e s y s t e m c o n t r o l s t h e d i s t r i b u t i o n , fl o w a n d
intake of air to ensure comfort equivalent to the s e t t i n g d i s p l a y e d a n d s u f fi c i e n t r e c i r c u l a t i o n o f
air in the passenger compartment.
No further adjustments are required.
Control screen for your digital air
conditioning system.
AUTO mode with personalisation
Switch on in AUTO mode, certain
settings can be modified: the
distribution, the air flow, the air
conditioning and the air intake/
recirculation.
The display changes from FULL AUTO to
AUTO .
To return to fully automatic operation, press
this button again. The display on the control
panel changes from AUTO to FULL AUTO .
If the system is not able to maintain
the setting selected following manual
adjustments, the setting flashes then AUTO
is cleared. Press the AUTO control to return
to the automatic settings.
Switching off the air conditioning
Pressing this control switches
off the air conditioning functions.
The snowflake is cleared from the
screen.
Complete switch-off
Pressing this control switches
the system off. The LED and the
screen switch off.
When the engine is running and the air
conditioning is on, this symbol and the
message FULL AUTO are displayed.
The other components are displayed
according to the settings selected by the user.
Page 51 of 167
53
3
EASE OF USE AND COMFORT
Ventilation
ADDITIONAL HEATING SYSTEMS
Supplementary heating
On the 2-3 seats version, this is located
under the seat on the driver's side with air
diffusion directed forwards.
REAR HEATING AND/OR AIR CONDITIONING
If your vehicle is fitted with an
additional air conditioning unit,
located in the rear of the vehicle:
the distribution rail located in
the roof and the individual diffusion vents
provide a perfect diffusion of cold air.
The warm air diffused at the floor, from the
front air conditioning unit, is distributed at
the feet of the rear passengers of rows 2
and 3.
A warm air diffusion vent, located on the rear
left wheelarch, may complete the assembly
for the feet of the rear passengers of row 3.
Additional heating
This is an additional passenger compartment
heating system which supplements the
standard equipment.
It can operate independently of the engine.
Depending on the level of finish of the
equipment, its start-up can be programmed.
Additional heater or programmable heating
This is an additional and separate system
which heats the Diesel engine hot coolant
loop to make starting easier.
It improves the demisting and defrosting
performance and that of the heated seats, if
fitted to the vehicle.
The passenger compartment heating is
brought up to temperature more rapidly.
This system must be programmed to start up
before you enter the vehicle. On the 5-9 seats version, it is
located at the rear. Depending
on the model version, the air
diffusion is either direct from the
rear or comes from the rail located under
each of the two rows of seats.
Press this control to activate/
deactivate the heating. The LED
is on if the heating is activated.
When rapid demisting and
defrosting is required, switch off
the control.