coolant Peugeot Expert 2019 Owner's Manual

9
Instrument panel
Speedometer
Analogue speedometer (mph or km/h).
Indicators with LCD text or
matrix instrument panel
1.Fuel gauge.
2. Engine coolant temperature gauge.
Display screen
When travelling abroad, it may be
necessary to change the units of distance:
the display of road speed must be in the
official units (miles or km) for the country.
The change of units is done via the screen
configuration menu, with the vehicle
stationary.
With LCD instrument panel
With LCD text instrument panel With matrix instrument panel
1.
Cruise control or speed limiter settings.
2. Gear efficiency indicator.
Gear with an automatic or electronic
gearbox.
3. Digital speedometer (mph or km/h) with
LCD and LCD text instrument panel.
Display area with matrix instrument
panel: alert or function status message,
trip computer, digital speedometer (mph
or km/h), etc.
4. Ser vice indicator, then total distance
recorder (miles or km), trip distance
recorder (miles or km).
Display zone with LCD text instrument
panel: alert or function status message,
trip computer, etc.
5. Engine coolant temperature gauge.
6. Engine oil level indicator.
7. Fuel gauge.
1
Instruments

12
+Brakes
Fixed, associated with
the ABS warning lamp. The electronic brake force distribution
(EBFD) system has a fault. Carry out (1) and then (2).
Parking brake Fixed. The parking brake is applied or not
properly released.
or Maximum
engine coolant
temperature
Fixed (warning
lamp or LED), and
needle in the red
zone (depending on
ve r s i o n). The temperature of the cooling
system is too high.
Carry out (1), then wait until the engine has cooled
down before topping up the coolant, if necessary. If
the problem persists, carry out (2).
Warning


/ indicator lamp
State Cause Actions

/ Observations
Battery charge Fixed. The battery charging circuit has a
fault (dirty or loose terminals, slack or
cut alternator belt, etc.). Clean and retighten the terminals. If the warning lamp
does not go off when the engine is started, carry
out


(2).
Seat belts
not fastened/
unfastened Fixed or flashing,
accompanied by an
increasing audible
signal. A seat belt has not been fastened or
has been unfastened (depending on
ve r s i o n).
Door open Fixed, associated with
a message identifying
the access.
An audible signal
supplements the alert
if the speed is higher
than 6 mph (10
km/h).A door, the boot, the tailgate or
the tailgate screen is still open
(depending on version).
Close the access.
If your vehicle is equipped with a right-hand hinged
door, its opening will not
be indicated by this warning
lamp.
Instruments

24
The distance indicated (in miles or
kilometres) is calculated according to the
distance covered and the time elapsed
since the last ser vice.
The alert may be triggered close to a due
date.
Engine coolant temperature
With the engine running, when the needle or
bar graph (depending on version) is:
-
i
n zone A , the temperature of the engine
coolant is correct,
-

i
n zone B , the temperature of the engine
coolant is too high; the maximum
temperature and central STOP warning
lamps come on, accompanied by an audible
signal and a warning message.
You must stop the vehicle as soon as it is
safe to do so.
Checking
After driving for a few minutes, the temperature
and pressure in the cooling system increase.
To top up the level:
F

w
ait at least one hour for the engine to cool,
F

u
nscrew the cap by two turns to allow the
pressure to drop,
F

w
hen the pressure has dropped, remove the
cap,
F

t
op up the level to the "MA X" mark.
For more information on Checking levels ,
refer to the corresponding section.
Be aware of the risk of scalding when
topping up the coolant. Do not fill above
the maximum level (indicated on the
reservoir).
Wait a few minutes before switching off the
engine.
Contact a PEUGEOT dealer or a qualified
workshop.
The level read will only be correct if
the vehicle is on level ground and the
engine has been stopped for more than
30

minutes.
Oil level correct
This is indicated by a message in the
instrument panel.
Oil level incorrect
This is indicated by a message in the
instrument panel.
If the low oil level is confirmed by a check using
the dipstick, the level must be topped up to
avoid damage to the engine.
Engine oil level indicator
On versions fitted with an electric oil level
indicator, the state of the engine oil level is
displayed in the instrument panel for a few
seconds when the ignition is switched on, at
the same time as the ser vicing information.
Instruments

139
In case of towing
Driving with a trailer places greater
demands on the towing vehicle and
requires extra care from the driver.Respect the maximum towable weights.
At altitude:
reduce the maximum load
by 10% per 1,000 metres of altitude; the
density of the air decreases with altitude
and the performance of the engine
reduces.
New vehicle: do not pull a trailer before
having driven at least 620 miles (1,000
kilometres).
If the outside temperature is high, let the
engine idle for 1 to 2 minutes after the
vehicle comes to a stop, to help it to cool.
Before setting off
Nose weight
F Distribute the load in the trailer so that the heaviest items are as close as possible to
the axle and the nose weight (at the point
where it joins your vehicle) approaches the
maximum permitted without exceeding it.
Ty r e s
F Check the tyre pressures of the towing vehicle and of the trailer, observing the
recommended pressures.
Lighting
F Check the electrical signalling on the trailer and the headlamp beam height of your
vehicle.
If a genuine PEUGEOT towing device
is used, the rear parking sensors will be
deactivated automatically to avoid the
audible signal.
When driving
Cooling
Towing a trailer uphill increases the
temperature of the coolant. The maximum
towable load depends on the gradient and the
exterior temperature. The cooling capacity of
the fan does not increase with engine speed.
F

T
o reduce the heating up, reduce the
vehicle speed and the engine speed.
In all cases, keep a check on the coolant
temperature.
If you are obliged to drive on a flooded road:
F

c

heck that the depth of water does not
exceed 15

cm, taking account of waves that
might be generated by other users,
F

d

eactivate the Stop & Start function,
F

d

rive as slowly as possible without stalling.
In all cases, do not exceed 6 mph (10

km/h),
F

d

o not stop and do not switch off the engine.
On leaving the flooded road, as soon as safety
conditions allow, make several light brake
applications to dry the brake discs and pads.
If in doubt about the state of your vehicle,
contact a PEUGEOT dealer or a qualified
workshop.
6
Driving

191
When the engine is hot, handle the
exterior safety catch and the bonnet
stay with care (risk of burns), using the
protected area.
When the bonnet is open, take care not to
damage the safety catch.
Do not open the bonnet under very windy
conditions.
The cooling fan may star t after
switching off the engine: take care
with articles and clothing that might be
caught by the fan blades.
Opening
F Open the door.
F
P
ull towards you the release lever ( 1),
located at the bottom of the door frame.
F

L
ift the safety catch ( 2), then raise the
bonnet. F

U
nclip the stay (
3) from its housing and
place it in the support slot to hold the bonnet
open.
Closing
F Take the stay out of the support slot.
F C lip the stay in its housing.
F

L
ower the bonnet and release it near the
end of its travel.
F

P
ull on the bonnet to check that it is fully
latched.
Because of the presence of electrical
equipment under the bonnet, it is
recommended that exposure to water
(rain, washing, etc.) be limited.
Engine
Diesel
The diesel circuit is under very high
pressure.
All work on this circuit must be carried out
only by a PEUGEOT dealer or a qualified
workshop.
This engine is an example only. The location of
the dipstick and engine oil filler cap, as well as
the priming pump may vary. 1.
Screenwash and headlamp wash
reservoir.
2. Engine coolant reservoir.
3. Engine oil filler cap.
4. Engine oil dipstick.
5. Priming pump.
6. Brake fluid filler cap.
7. Battery.
8. Remote earth point ("-" terminal).
9. Fusebox.
10. Power steering fluid reservoir.
11. A i r f i l t e r.
Checking levels
Check all of the following levels regularly in
accordance with the manufacturer's service
schedule. Top them up if required, unless
otherwise indicated.
If a level drops significantly, have the
corresponding system checked by a PEUGEOT
dealer or a qualified workshop.
7
Practical information

193
During the 30 minutes after topping up the
oil, the check per formed with the oil level
indicator in the instrument panel when the
ignition is switched on is not valid.
Brake fluid
The level of this fluid should be
close to the "MAX" mark. If not,
check the brake pad wear.
To know how often the brake fluid should be
replaced, refer to the manufacturer's servicing
schedule. If topping up, clean the cap before
replacing it. Use only DOT4 brake fluid
from a sealed canister.
F

A

dd more oil if necessary.
F

A

fter checking the level, carefully refit the oil
filler cap and the dipstick in its tube.
Power steering fluid
The level of this fluid should be
close to the " MAX" mark. With the
engine cold and the vehicle standing
on level ground, check this by
reading the level on the filler neck.
Engine coolant
Check the engine coolant level
regularly.
It is normal to top up this fluid
between two services.
The check and top-up must only be done with
the engine cold.
A low level presents a risk of serious damage
to the engine.
The level of this fluid should be close to the
" MAX " mark but should never exceed it.
If the level is close to or below the " MIN” mark,
it is essential to top up. Once the pressure has dropped, remove the
cap and top up to the required level.
Screen and headlamp
washer fluid
Top up the reser voir when you next
stop the vehicle.
Fluid specification
The fluid must be topped up with a ready-to-
use mixture.
In winter (temperatures below zero), a liquid
containing an agent to prevent freezing must
be used which is appropriate for the prevailing
conditions, in order to protect the elements of
the system (pump, tank, ducts, jets, etc.).
When the engine is hot, the temperature of this
fluid is regulated by the fan.
In addition, as the cooling system is
pressurised, wait at least one hour after
switching off the engine before carrying out any
work.
To avoid the risk of scalding if you need to top
up in an emergency, wrap a cloth around the
cap and unscrew the cap by two turns to allow
the pressure to drop. Filling with pure water is prohibited
under all circumstances (risk of freezing,
limestone deposits, etc.).
Diesel fuel additive (Diesel
with particle filter)
or
The minimum level in the particle
filter additive tank is indicated by
fixed illumination of this warning
lamp, accompanied by an audible
warning and a message warning that
the level of additive is too low.
7
Practical information

234
G
H
Gauge, fuel............................................. 185 -187
Gearbox, automatic .......145 -15 0, 15 3 -15 4, 19 5
Gearbox, electronic


...............145, 15 0 -152, 19 5
Gearbox, manual


...........14 5 -14 6 , 15 3 -15 4, 19 5
Gear lever, automatic gearbox


..............147-15 0
Gear lever, electronic gearbox


.....................195
Gear lever, manual gearbox


..................145 -14 6
Gear shift indicator ~ Gear efficiency indicator


..................................... 14 6
Glove box
........................................................ 76
Hazard warning lamps


..........................108, 200
Hazard warning lamps, automatic operation
.................................... 10

8
Headlamp adjustment


...................................102
Headlamp adjustment


...................................102
Headlamp beam height
................................. 10

2
Headlamps, automatic dipping


.......20, 101, 174
Headlamps, automatic illumination


................99
Headlamps, dipped beam


..........20, 97, 211-213
Headlamps, halogen


..............................211-212
Headlamps, main beam


.......20, 22, 97, 211-213
Headlamps, Xenon


....................................... 213
EBFD
................

.............................................
11 0
Eco-driving (advice)


..........................................
7
Economy mode
............................................. 18

9
Electric windows


.............................................
53
Electronic brake force distribution (EBFD)
.............................. 10

9 -110
Emergency braking assistance (EBA)


...
109 -110
Emergency call


.....................................
108 -109
Emergency warning lamps


...................
108, 200
Emissions control system, SCR

.............
26, 19 6
Energy economy mode
................................. 18

9
Engine compartment
.................................... 19

1
Engine, Diesel


...........
13, 18, 185, 191, 200, 225
Engines
.........................................................
224
Engine self-diagnosis ..................................... 16
E
nvironment
.......................................... 7, 40, 94
ESC (electronic stability control)

.................. 10

9
E
F
Fatigue detection .......................................... 175
Filling the AdBlue® tank ........................ 19 4, 198
Filling the fuel tank ................................. 185 -187
Filter, air


........................................................ 19 4
Filter, Diesel fuel


........................................... 191
Filter, oil
................

......................................... 19 4
Filter, particle


........................................ 193, 195
Filter, passenger compartment


...............8 6, 19 4
Finisher


......................................................... 210
Fitting a wheel

....................................... 208 -210
Fitting roof bars


............................................. 189
Fittings, interior
.................................... 7

5 -76, 81
Fittings, rear


.................................................... 81
Fitting the mat


................................................. 75
Flap, fuel filler


......................................... 185 -187
Flap, removable
..............................

..........60-62
Flashing indicators


.......................................... 98
Floor cab

....................................................... 216
Fluid, brake


................................................... 193
D
Date (setting) ................................................... 30
Daytime running lamps ..............97, 99, 211-213
Deactivating the passenger airbag


.......11 8 , 12 2
Deactivation of DSC (ESC)
...........................111
Deadlocking


............................................... 37- 3 8
Defrosting


............................................ 60, 90 -91
Demisting


.................................................. 90 -91
Demisting, rear


................................................ 91
Demisting, rear screen


...................................91
Dimensions
..............................

.....................228
Dipstick
................

.............................. 24 -25, 192
Direction indicators


..................98, 211-214, 216
Display, head-up
...............................

.....15 8 -159
Door pockets
...............................

..............75 -76
Doors, rear
................................................ 49-50
Doors, side-hinged
......... 3

7-38, 49 - 50, 214 -215
Driver’s attention warning


.............................175
Driving


.................................................... 13 8 -13 9
Driving abroad ................................................. 97
Driving aids camera (warnings)


....................157
Driving aids (recommendations)


...................15 6
Driving economically ......................................... 7
Dynamic stability control (DSC)


.......17, 1 0 9 -11 3
Cruise control


..................
159, 161-162, 16 4 -167
Cruise control, adaptive .........
16 2 , 167, 170 -171
Cruise control by speed limit recognition
...............................
............
161-162
Cruise control, dynamic with Stop function

........................................
161-162
Cup holder .......................................................
75 Fluid, engine coolant

.....................................
193
Fluid, power steering
.................................... 19
3
Foglamp, rear

..................................
19, 214, 216
Foglamps, front

.........................
97-98, 100, 214
Foglamps, rear
........................................... 9
7- 9 8
Fuel ............................................................ 7, 1 8 5
Fuel consumption

........................................
7, 2 9
Fuel tank ........................................................ 185
Fusebox, engine compartment

.....................
219
Fuses
...................................................... 21
7-219
Alphabetical index

235
IIgnition .................................................... 142-143
Ignition on ...................................................... 143
Immobiliser, electronic


..................................140
Indicator, AdBlue
® range ................................. 25
Indicator, coolant temperature ........................ 24
Indicator, engine oil level
.......................... 24-25
Indicator lamps, operation
.............................. 97
I

ndicators, direction

........................................ 98
Inflating tyres


................................................ 19 6
Inflating tyres and accessories (using the kit)


...................................... 202-205
Infrared camera


............................................ 157
Instrument panel


....................................... 9, 15 8
Intelligent Traction Control


............................ 11 0
ISOFIX


........................................... 13 0, 132-13 6
JJack .........................................................78, 206
Jump starting ................................................ 220
LLabels .................................................... 5, 63 - 64
Labels, identification ..................................... 231
Lane Departure Warning System (LDWS)


................................... 174 -175
Level, AdBlue
® .............................................. 19 4
Level, brake fluid ........................................... 193
Level, Diesel additive


............................ 193, 195
Level, engine coolant


.............................. 24, 193
Level, engine oil
................................ 24 -25, 192
Level, headlamp wash


.......................... 105, 193
Level, power steering fluid
............................ 193
Levels and checks

..............................
...191-193
Level, screenwash fluid

........................ 1

05, 193
Lighting


............................................................ 97
Lighting, cornering


........................................ 10 0
Lighting dimmer


.............................................. 27
Lighting, directional


....................................... 10 0
Lighting, guide-me home


................................ 99
Lighting, interior
...............................

.......95, 102
Lighting, mood


.............................................. 102
Lighting, welcome


................................... 9 9 -10 0
Loading


................................................... 8 0, 189
Loading area fittings


....................................... 79
Load reduction mode


.................................... 189
Load restraint
...............................

...................79
Locating your vehicle


...................................... 32
Locking
...............................

...........31, 33, 36 -37
Locking from the inside
............................. 41- 4 3
Locking the doors
...................................... 4

1- 42
Low fuel level

......................................... 18

5 -187
Lumbar


...................................................... 55, 58
Key


........................................... 31, 33 -36, 38 -39
Key, electronic


......................................... 31, 14 3
K
Maintenance, routine ............................15 8, 19 4
Manoeuvring aids (recommendations) .........15 6
Map reading lamps
......................................... 95
M

arkings, identification

.................................231
Massage function
........................................... 58
Mat


.................................................. 75, 141, 158
Memorising a speed

..................................... 15

9
Mirror, rear view
.............................................. 60
Mirrors, door ........................ 59 - 60, 91, 176, 178
Misfuel prevention


......................................... 187
Moduwork .................................................. 60-62
Mountings, ISOFIX


........................12 9, 132-13 6M
NNet, cargo.................................................. 60-62
Net, high load retaining ...................................81
Net, luggage retaining ..................................... 78
Number plate lamps


...................................... 216
Headlamp wash
..............................

..............
104
Head restraints, front

......................................
56
Head-up display
..................................... 15

8 -159
Heated bench seat


..........................................
57
Heating
........................................... 8

6 - 87, 92-94
Heating, additional


...............................
51, 9 2- 9 4
Heating, programmable


.......................
51, 9 2- 9 4
Hill start assist

........................................
14 4 -145
Horn ............................................................... 109Keyless Entry and Starting

........
3

1- 3 8, 141, 143
Key with remote control

.....................
3

6 - 3 7, 1 4 0
Kit, puncture repair
............................... 20

3-205
Kit, temporary puncture repair
.............. 20

2-205
O
Obstacle detection
........................................ 178
Oil change ..................................................... 19
2
Oil consumption


............................................ 192
OIl, engine
...............................

......................192
On-board tools


...................................... 201-202
Opening the bonnet


...............................19 0 -191
Opening the boot


................................ 31- 32, 50
Opening the doors


.........................31- 32, 43 - 4 4
Opening to 180°

........................................ 49

-50
.
Alphabetical index

237
Table of weights ............................................2 25
Table position .................................................. 55
Table, retractable sliding


...........................83-85
Tables, aircraft


................................................ 76
Tables of fuses
....................................... 217-219
Table top, working
........................................... 63
Tailgate rear screen


........................................ 50
Ta n k , f u e l


................................................ 185 -187
Technical data


............................................... 225
Temperature, coolant


................................12, 24
Textured Paint


............................................... 19 9
Third brake lamp


........................................... 215
Time (setting)


.................................................. 30
Tool box
................

................................. 201-202
To o l s


..................................................... 202, 206
Topping-up AdBlue
®...................................... 198
Total distance recorder ................................... 27
To w b a r
...............................

............................ 188
Towed loads


.......................................... 224-225
Towing another vehicle


......................... 222-223
Towing eye

.................................................... 222
Traction control (ASR)


..................... 17, 1 0 9 -11 3
Tr a i l e r
...............

............................................. 188
Trajectory control systems

..................... 10

9 -110
Triangle, warning ........................................... 200
Trip computer


............................................ 28-29
Trip distance recorder
..................................... 2

7
Ty r e s


.............................................................. 19 6
Tyre under-inflation detection
....................... 1

8, 154-155, 205, 210
T
V
U
W
Ventilation ............................... 86 - 87, 90, 92, 94
Visiopark 1 .................................................... 18 0
Under-inflation (detection)


............................
15 4
Unlocking

.......................................
31-32, 34-36
Unlocking from the inside .........................
41- 4 3
Unlocking, selective

..................................
33-36
Unlocking the doors
................................... 4
1- 42
Unlocking, total

.........................................
33-36
Updating the date
............................................ 3
0
Updating the time
...............................
.............
30
USB

.................................................................
77
Warning and indicator lamps
..................... 1

0 -11
Warning lamp, airbag
...................................... 18
W

arning lamp, braking system

..................11 -12
Warning lamp, Diesel engine pre-heater


.......18
Warning lamp, driver''s seat belt not fastened
...............................

..........115
Warning lamp, low fuel level
...........................19
Warning lamp, parking brake


..........................12
Warning lamps


................................................ 11
Warning lamp, seat belts


........................12 , 115
Warning lamp, Service ....................................13
Warnings and indicators


............................1 0 -11
Washer jets, heated


........................................ 91
Washing


........................................................ 15 8
Weights
...............

.................................. 224-225
Welcome lighting ............................................. 32
Wheel, spare
................. 1

55, 196, 206 -207, 210
Windows, rear


................................................. 82
Windscreen, heated


........................................ 91Wiper blades (changing)


.......................
105 -10 6
Wiper, rear ..................................................... 104
Wipers

.............................................
20, 103 -104
Wipers, automatic rain sensitive

...........
103 -104
.
Alphabetical index