oil filter Peugeot Expert VU 2016 Owner's Manual

10
Expert_en_Chap00b_vue-ensemble_ed01-2016
Maintenance - technical data
Dimensions 328-331
Identification markings 3 37
Running out of fuel
(priming pump)
3

27
Checking levels

2

78 -280
-

oil
-

b

rake fluid
-

p

ower steering fluid
-


coolant
-
s

creenwash, headlamp wash fluid
-

a

dditive (Diesel with particle filter)
Checking components
2

81-282
-


battery
-
a

ir / passenger compartment filter
-

o

il filter
-

p

article filter
-

b

rake pads / discs
Changing bulbs
3

03-315
-

front
-

rear
Platform cab
Changing rear lamp bulbs 3
15
Dimension 3 31 12V battery
32

1-325
op

ening the bonnet
2
76un
der the bonnet 2 77
Engines 332-336
AdBlue® 283-286 W eights

332-336
Load reduction, economy mode
2
70
Engine compartment fuses
3
16 - 317, 320
over view

13
Expert_en_Chap00c_eco-conduite_ed01-2016
Limit the causes of excess
consumption
Spread loads throughout the vehicle; place the
heaviest items in the bottom of the boot, as
close as possible to the rear seats.
Limit the loads carried in the vehicle and reduce
wind resistance (roof bars, roof rack, bicycle
carrier, trailer...). u
s
e a roof box in preference.
Remove roof bars and roof racks after use.
At the end of winter, remove snow tyres and refit
your summer tyres.
Observe the recommendations
on maintenance
Check the tyre pressures regularly, when cold,
referring to the label in the door aperture,
driver's side.
Carry out this check in particular:
-

b
efore a long journey,
-

a
t each change of season,
-

a
fter a long period out of use.
Don't forget the spare wheel and the tyres on
any trailer or caravan.
Have your vehicle serviced regularly (engine
oil, oil filter, air filter, passenger compartment
filter...) and observe the schedule of operations
recommended in the manufacturer's service
schedule.
With a BlueHDi Diesel engine, if the SCR
system is faulty your vehicle becomes polluting;
go to a PE
u

g
Eo
t dealer or a qualified
workshop without delay to have the emissions
of nitrogen oxides brought back to the legal
level. When refuelling, do not continue after the third
cut-off of the nozzle to avoid any over flow.
At the wheel of your new vehicle, it is only after
the first 1 800 miles (3 000 kilometres) that you
will see the fuel consumption settle down to a
consistent average.
.
Eco-driving

28
Warning / indicator lampStateCause Action / Observations
Rear foglamps fixed.
th

e rear foglamps are on.
tu
rn the ring on the stalk rear ward to switch off the
rear foglamps.
Service
on temporarily. A minor fault has occurred for which
there is no specific warning lamp. Identify the fault by means of the associated message,
for example:
-

l
ow engine oil level,
-

l
ow screenwash/headlamp wash fluid level,
-

d
ischarged remote control battery,
-

l
ow tyre pressures,
-

s
aturation of the particle filter (FAP) on Diesel
vehicles.
-


...
For more information on Checks and in particular the
particle filter, refer to the corresponding section.
For any other faults, contact a PE
u

g
Eo
t dealer or a
qualified workshop.
fixed. A major fault has occurred for which
there is no specific warning lamp. Identify the fault by reading the message and contact
a PE
u

g
Eo
t dealer or a qualified workshop.
+ fixed, associated with
flashing and then fixed
display of the service
spanner.
the

servicing interval has been
exceeded.
on

ly on BlueHDi Diesel versions.
Your vehicle must be serviced as soon as possible.
Instruments

280
Expert_en_Chap07_info-pratiques_ed01-2016
Changing the coolant
the coolant does not have to be replaced at
routine services.
Fluid specification
the coolant must conform to the
manufacturer's recommendations.
th
e check and top-up must be done
with the engine cold.
A low coolant level presents the risk of
serious damage to your engine.
If the ambient temperature is high, it
is recommended that the engine be
allowed to idle for 1 to 2 minutes after
the vehicle comes to a stop, to facilitate
its cooling.
Avoid prolonged contact of used oil or
fluids with the skin.
Most of these fluids are harmful to
health or indeed very corrosive.
Do not discard used oil or fluids into
sewers or onto the ground.
ta

ke used oil to a PE
u
g
Eo
t dealer or
a qualified workshop (France) or to an
authorised waste disposal site.
Used products
To p p i n g - u p
this additive must be topped-up by a
PEu gEo t dealer or a qualified workshop
without delay.
Diesel additive level (Diesel
engine with particle filter)
A low additive level is indicated by
illumination of this warning lamp,
accompanied by an audible warning
and a message in the instrument
panel screen.
Fluid specification
For optimum cleaning and to avoid freezing,
this fluid must not be topped up with or
replaced with plain water.
Screenwash and headlamp
wash fluid
In the case of vehicles fitted with
headlamp washers, the low fluid level
is indicated by an audible signal and
a message in the instrument panel
screen.
to

p up the reservoir when you next
stop the vehicle.
In wintry conditions, the use of an ethyl alcohol
or methanol base fluid is recommended.
Practical information

281
Expert_en_Chap07_info-pratiques_ed01-2016
Checks
12 V battery
the battery does not require any maintenance.
However, check regularly that the terminals
are correctly tightened (versions without quick
release terminals) and that the connections
are clean.Refer to the manufacturer's
service schedule for details of the
replacement intervals for these
components.
Air filter and passenger compartment filter
Replace the oil filter each time the
engine oil is changed.
Refer to the manufacturer's
service schedule for details of
the replacement interval for this
component.
Oil filterParticle filter (Diesel)
the start of saturation of the particle
filter is indicated by the temporary
illumination of this warning lamp
accompanied by a message in the
multifunction screen.
As soon as the traffic conditions permit,
regenerate the filter by driving at a
speed of at least 40 mph (60 km/h) until
the warning lamp goes off.
If the warning lamp stays on, this
indicates a low additive level.
For more information on Checking
levels , refer to the corresponding
section.
on a n

ew vehicle, the first particle
filter regeneration operations may be
accompanied by a "burning" smell,
which is per fectly normal.
Following prolonged operation of the
vehicle at very low speed or at idle,
you may, in exceptional circumstances,
notice the emission of water vapour at
the exhaust on acceleration.
t
h
is does
not affect the behaviour of the vehicle
or the environment.un
less otherwise indicated, check these components in accordance with the manufacturer's
service schedule and according to your engine.
ot

her wise, have them checked by a PE
u

g
Eo

t
dealer or a qualified workshop.
For more information and the precautions to
take before starting work on the 12 V batter y ,
refer to the corresponding section. Depending on the environment (e.g. dusty
atmosphere) and the use of the vehicle
(e.g.

city driving), replace them twice as often
if necessary .
A clogged passenger compartment filter may
have an adverse effect on the per formance
of the air conditioning system and generate
undesirable odours.
Versions equipped with Stop & Start are
fitted with a 12 V lead-acid battery of
specific technology and specification.
Its replacement should be carried
out only by a PE
u

g
Eo

t
dealer or a
qualified workshop.
7
Practical information

333
Expert_en_Chap09_caracteristiques-techniques_ed01-2016
EuRo 4 and 5 Diesel engines
* Increased payload.Engine
Engine
code Gearbox Engine oil capacity
with filter replacement (litres) LengthUnbraked trailer
weight (kg)
8-9 seats Trailer nose weight
(kg)
8-9 seats
1.6 litre HDi 909HF
(DV6Du) M
anual
(5-speed) -L1, L2, L3
--
L 2 *, L 3 * -
2 litre HDi 150AHX
(DW10F) Manual
(6-speed)
6 .1L1, L2, L3
-
L 2 *, L 3 * -
E A t
6

automatic (6-speed) L1, L2, L3
-
L 2 *, L 3 * -
9
technical data

334
Expert_en_Chap09_caracteristiques-techniques_ed01-2016
EngineEngine
code Gearbox Engine oil capacity
with filter replacement (litres) LengthUnbraked trailer
weight (kg)
8-9 seats Trailer nose
weight (kg)
8-9 seats
2 litre BlueHDi
150AHX
(DW10FD) Manual
(6-speed)
6 .1L1, L2, L3
--
L 2 *, L 3 * -
E A t
6

automatic (6-speed) L1, L2, L3
-
L 2 *, L 3 * -
* Increased payload.
technical data

335
Expert_en_Chap09_caracteristiques-techniques_ed01-2016
EuRo 6 Diesel engines
* Increased payload.Engine
Engine
code Gearbox Engine oil capacity
with filter replacement (litres) LengthUnbraked trailer
weight (kg)
8-9 seats Trailer nose weight
(kg)
8-9 seats
1.6 litre
BlueHDi 95 BHV
(DV6FD
u) M
anual
(5-speed) 5.6L1, L2, L3
75072
L 2 *, L 3 * 80
1.6 litre
BlueHDi 95 S&S BHS
(DV6FD
u) E
t
g
6

electronic (6-speed) 5.6L1, L2, L3
72
L 2 *, L 3 * 80
1.6 litre
BlueHDi 115 S&S BHX
(DV6FC
u
)
Manual
(6-speed) 5.6L1, L2, L3
72
L 2 *, L 3 * 80
9
technical data

336
Expert_en_Chap09_caracteristiques-techniques_ed01-2016
* Increased payload.Engine
Engine
code Gearbox Engine oil capacity
with filter replacement (litres) LengthUnbraked trailer

weight (kg)
8-9 seats Trailer nose weight

(kg)
8-9 seats
2 litre BlueHDi 150 S&SAHX
(DW10FD) Manual
(6-speed) 6 .1L1, L2, L3
75092
L 2 *, L 3 * 10 0
2 litre BlueHDi
180 S&SAHH
(DW10 FC) E A
t6
automatic (6-speed) 5 .1L1, L2, L3
80
L 2 *, L 3 * 88
technical data

508
Expert_en_Chap11_index-alpha_ed01-2016
HI
Headlamps, dipped beam ................29, 146, 304, 306, 308
Headlamps, halogen


............................304, 306
Headlamps, main beam
................... 2

9, 146, 304, 307, 308
Headlamps, Xenon


..............................304, 308
Headlamp wash


............................................ 15 8
Head restraints, front
............................103, 104
Head-up display


........................... 222, 223, 244
Heated bench seat
........................................ 10

5
Heating


............................. 12, 125, 126, 13 5 -13 8
Heating, additional
...............................

...95, 138
Heating, programmable


..........................95, 138
Hill start assist

............................................... 20

6
Horn ............................................................... 161
Hazard warning lamps


.......................... 160, 287
Hazard warning lamps, automatic operation


.................................... 160
Headlamp adjustment


................................... 155
Headlamp adjustment


................................... 155
Headlamp beam height


................................. 155
Headlamp dipping, automatic


....................... 15 4
Headlamps, automatic dipping
..............................

... 29, 153
Headlamps, automatic illumination


.................................. 146, 149, 15 0Identification, vehicle
....................................
3

37
Ignition
................

...................201, 203, 410, 466
Ignition on ...................................................... 203
Immobiliser, electronic


................52, 67, 71, 205
Indicator, AdBlue
® range ................................. 35
Indicator, coolant temperature ........................ 3
1
Indicator, engine oil level
................................ 34
Indicator lamps, operation


.............................. 17
Indicators, direction


...................................... 148
Inflating tyres


.................................................. 12
Inflating tyres and accessories (using the kit)
..............................

................290
ga

uge, fuel
.................................................... 265
ge

arbox, automatic


..............
12, 14-16, 21, 199,
204, 206, 209, 218, 219, 233, 237, 282, 321
ge

arbox, electronic


............
12, 14-16, 202, 206,
214, 218, 219, 282
ge

arbox, manual


..........
12, 14-16, 21, 206, 207,
218, 219, 233, 237, 282
gea

r lever
..............................

.........................
12
gea

r lever, automatic gearbox
.....................
20

9
ge

ar lever, electronic gearbox


.....................
282
ge

ar lever, manual gearbox


.........................
207
ge

ar shift indicator


.......................................
208
gl

ove box

......................................................
120
g.

P. S .


............................................................
366
gr

ip control

...................................................
16 4
gu

ide-me-home


............................................
150
G
Fatigue detection .................................. 250, 251
Filling the fuel tank ................................ 26
5, 267
Filter, air
...............

......................................... 281
Filter, oil


......................................................... 281
Filter, particle


........................................ 280, 281
Filter, passenger compartment


.....................281
Finisher


......................................................... 302
Fitting a wheel

...............................
................299
Fitting roof bars


............................................. 273
Fittings, interior


..................................... 120, 123
Fittings, rear
...............................

...................123
Fitting the mat


............................................... 11 9
Flap, fuel filler

...............................
.................265
Flap, removable


............................................ 10 6
Flashing indicators


........................................ 148
Foglamp, rear
......................... 1

47, 310, 313, 315
Foglamps


...................................................... 304
Foglamps, front


.....................147, 152, 304, 309
Foglamps, rear


.............................................. 147
Frequency (radio)


.................................. 3 9 5 , 4 51
Fuel .......................................................... 12, 267
Fuel consumption
...................................... 12

, 42
Fuel tank .......................................................... 20
Fusebox, engine compartment


.....................320
Fuses


............................................. 316, 317, 320
F
Alphabetical index