oil PONTIAC FIREBIRD 1994 Owner's Manual

Service and Appearance Care
Don’t use any of these unless this manual
says you can. In many uses, these will
damage your vehicle:
0 Alcohol
Laundry Soap
0 Bleach
0 Reducing Agents
Cleaning the Inside of Your
Pontiac
Use a vacuum cleaner often to get rid of
dust and loose dirt. Wipe vinyl or leather
with a clean, damp cloth.
Your Pontiac dealer has two
GM cleaners,
a solvent-type spot lifter and a foam-type
powdered cleaner. They will clean normal
spots and stains very well. Do not use
them on vinyl or leather.
Here are some cleaning tips:
Always read the instructions on the
Clean up stains as soon as you can -
Use a clean cloth or sponge, and
cleaner
label.
before they set.
change to a clean area often. A soft
brush may be used
if stains are
stubborn.
D Use solvent-type cleaners in a
well-ventilated area only. If you use
them, don’t saturate
the stained area.
clean the entire area immediately or it
will set.
If a ring forms after spot cleaning,
Using Foam-Type Cleaner on Fabric
Vacuum and brush the area to remove
any loose dirt.
Always clean a whole trim panel or
section. Mask surrounding trim along stitch or welt lines.
Mix Multi-Purpose Powdered Cleaner
following the directions on the
container label.
Use suds only and apply with a clean
sponge.
Don’t saturate the material.
Don’t rub it roughly.
As soon as you’ve cleaned the section,
use a sponge to remove the suds.
Rinse the section with a clean, wet
sponge.
Wipe off what’s left with a slightly
damp paper towel or cloth.
Then dry it immediately with a blow
dryer or a heat lamp.
NOTICE:
Be careful with a hair dryer or heat
lamp.
You could scorch the fabric.
0 Wipe with a clean cloth.
Using Solvent-Type Cleaner on Fabric
First, see if you have to use solvent-type
cleaner at all. Some spots and stains will
clean
off better with just water and mild
soap.
If you need to use a solvent:
Gently scrape excess soil from the
trim material with a clean, dull knife
or scraper. Use very little cleaner, light
pressure and clean cloths (preferably cheesecloth). Cleaning should start at
the outside of the stain, “feathering”
toward the center. Keep changing to
a
clean section of the cloth.
. . .222
ProCarManuals.com

When you clean a stain from fabric,
immediately dry the area with an air
hose, hair dryer, or heat lamp to help
prevent a cleaning ring. (See
the
previous NOTICE.)
Special Cleaning Problems
Greasy or oily stains:
Such as grease,
oil, butter, margarine, shoe polish, coffee
with cream, chewing gum, cosmetic
creams, vegetable oils, wax crayon, tar
and asphalt.
0 Carefully scrape off excess stain.
0 Follow the solvent-type instructions
Shoe polish, wax crayon, tar and described earlier.
asphalt will stain if left on a vehicle
seat fabric. They should be removed
as soon as possible. Be careful,
because the cleaner will dissolve them
and may cause
them to spread
Non-greasy stains: Such as catsup,
coffee (black), egg, fruit, fruit juice, milk,
soft drinks, wine, vomit, urine and blood.
Carefully scrape off excess stain, then
sponge
the soiled area with cool water.
If a stain remains, follow the foam-type
instructions described earlier. If an
odor lingers after cleaning
vomit or urine, treat the area with
a waterhaking soda solution:
1 teaspoon (5 ml) of baking soda to
1 cup
(250 ml) of lukewarm water.
If needed, clean lightly with
solvent-type cleaner.
Combination stains: Such as candy,
ice cream, mayonnaise, chili sauce and
lnknown stains.
Carefully scrape off excess stain, then
clean with cool water and allow to
dry-
@ If a stain remains, clean it with
solvent-type cleaner.
Cleaning Vinyl
Use warm water and a clean cloth.
Rub with a clean, damp cloth to
remove dirt. You may have to do it
more than once.
Things like tar, asphalt and shoe
polish will stain if you don’t get them
off quickly. Use a clean cloth and a
solvent-type vinyl cleaner.
Cleaning Leather
Use a soft cloth with lukewarn water and
a mild soap or saddle soap.
For stubborn stains, use a mild
solution of
10% isopropyl alcohol
(rubbing alcohol) and
90% water.
solvent-based or abrasive cleaners,
furntiure polish or shoe polish on
leather.
immediately. If dirt is allowed,to work
into finish, it can harm the leather.
Cleaning the Top of the Instrument
Panel
Use only mild soap and water to Clean
the top surfaces of the instrument.pane1.
Sprays containing silicones or waxes
may cause annoying reflections in the
windshield and even make it difficult to
see through the windshield under certain
conditions.
Never use oils, varnishes,
Soiled leather should be cleaned
223. . .
ProCarManuals.com

Service and Appearance Care
Sheet Metal Damage
If your vehicle is damaged and requires
sheet metal repair or replacement, make
sure the body repair shop applies
anti-corrosion material to the parts
repaired or replaced to restore corrosion
protection.
Foreign Material
Calc'ium chloride and other salts, ice
melting agents, road oil and tar, tree sap,
bird droppings, chemicals from industrial chimneys, and other foreign matter can
damage your vehicle's finish
if they
remain on painted surfaces. Use cleaners
that are marked safe for painted surfaces
to remove foreign matter.
Finish Damage
Any stone chips, fractures or deep
scratches in the finish should be repaired
right away. Bare metal will corrode
quickly and may develop into a major
repair expense.
Minor chips and scratches can be repaired
with touch-up materials available from
your dealer or other service outlets.
Larger areas of finish damage can be corrected
in your dealer's body and paint
shop.
Underbody Maintenance
Chemicals used for ice and snow removal
and dust control can collect on the
underbody. If these are not removed,
accelerated corrosion (rust) can occur on
the underbody parts such as fuel lines,
frame, floor pan, and exhaust system even
though they have corrosion protection.
At least every spring, flush these
materials from the underbody with plain
water. Clean any areas where mud and
other debris cah collect. Dirt packed in
closed areas
of the frame should be
loosened before being flushed. Your
dealer or an underbody vehicle washing
system can do this for you.
Chemical Paint Spotting
Some weather and atmospheric conditions
:an create a chemical fallout. Airborne
?ollutants can fall upon and attack painted
curfaces on your vehicle. This damage
:an take two forms: blotchy,
inglet-shaped discolorations, and small
irregular dark spots etched into the paint
surface.
Although no defect in the paint job causes
this, Pontiac will repair, at no charge to
the owner, the surfaces of new vehicles
jamaged by this fallout condition within
12 months or 12,000 miles (20
000 km)
of purchase, whichever comes first.
. . ,226
ProCarManuals.com

Appearance Care and Maintenance Materials
PART NUMBER USAGE DESCRIPTION
SIZE
1051516
16
02. (0.473 L) 10501 73
Also old waxes, polishes
Tar
and Road Oil Remover
16 02. (0.473 L)
10501 72 Windshield washing system and gas line
Washer
Solvent and Gas Liner De-lcer
32
02. (0.946 L)
Windshield cleaner
Bon-Ami Powder"
12
02. (0.340 kg)
105001
1 Exterior cleaner and polish
Magic Mirror Cleaner-Polish
16
02. (0.473 L)
1050201 Spot and stain removal
on cloth and fabric Spot Lifter*
8 02. (0.237 L) 1051 398 Exterior wash
Wash-Wax (Concentrated)
16
02. (0.473
L)
1052870 Vinyl, cloth, door trims, seats, carpet, tires, mats Multi-Purpo\
se Powdered Cleaner
6
Ib. (2.72 kg)
1050429 Glass cleaning and
spot cleaning on vinyls Glass
Cleaner
24 02. (0.680 L)
1050427 Spot and stain removal
on cloth and fabric Fabric
Cleaner*
16 02. (0.473 L)
1050244 Spot and stain removal
on leather
and vinyl
VinyVLeather Cleaner*
32 02. (0.946 L)
105021 4 Cleans white and black tires White Sidewall Tire Cleaner 16
02. (0.473
L)
10501 74 Removes
rust and corrosion on chrome and steel
Cleaner and Polish
*Not recommended for pigskin suede leather.
See your General Motors Dealer for these products. See the Index under "Recommended Fluids and Lubricants" for other produc\
ts.
ProCarManuals.com

C B
G H J
Underhood Electrical Center
Fuses
1 - Electronic Brake Control Module
(5 Amp.)
2
- Fog Lamps (20 Amp.)
3 - HeadIight Doors Module (15
4 - Headlight Doors Module (1 5
5 - Anti-Lock Brake System (5 Amp.)
6 - Coolant Fan Relays; EVAP Canister Purge Solenoid; Exhaust
Gas Recirculation; Low Coolant
Relay; Reverse Lockout Solenoid
(10 Amp.)
Amp.)
Amp.)
7 - Air
Injection Pump Assembly;
8 - Not Used
9 - Fuel Injectors (7.5 Amp.)
10 - Fuel Injectors (7.5 Amp.)
11 - VIN Engine Code S: Camshaft
Air
Pump Relay
(20 Amp.)
Position Sensor; Crankshaft Position Sensor; Electronic
Ignition Module
(10 Amp.)
VIN Engine Code P: Ignition
Coil; Ignition Coil Driver
(10 Amp.)
12 - Air Conditioning Compressor
Relay; Cruise Control Switches
and Module
(20 Amp.)
Relays
B - Air Conditioning Compressor
C - Anti-Lock Brake System
D - Primary Coolant Fan (Driver Side)
E - Air Pump
F - Secondary Coolant Fan
(Passenger Side)
G - Traction Control System
H - Fog Lamps
J - Not Used
231 . ..
ProCarManuals.com

Service and Appearance Care
Replacement Parts
Air Cleaner Filter .............................................. A1 163C
Battery
........................................................ 75-60
Engine Oil Filter
VINEngineCodeS
............................................. PF47
FuelFilter
...................................................... GF578
PCV Valve VIN Engine
Code P
............................................. PF25
VIN Engine Code
S .......................................... CV789C
VIN Engine Code P
.......................................... CV895C
VIN Engine Code
S .............................. oR43TSK (0.045" Gap)
VIN Engine Code P
............................. oR45LTSP (0.050" Gap)
Thermostat Temperature Specification
.......................... 180°F (82°C)
Radiatorcap
................................................... RC24
Spark Plug
Wheel Nuts
Wheel Nut Torque ....... ........ ......... 100 lb. ft. (140 Nom)
.. .234
ProCarManuals.com

Service and Appearance Care
Crankcase
VIN Engine Code S .................................... 4.0 qt. (3.8 L)**
Without Filter Change
................................ 4.0 qt. (3.8 L)**
With Filter Change ................................... 5.0 qt. (4.7 L)**
Fuel Tank ........................................... 15.5 gal. (58.7 L)
Five-Speed
........................................... 5.9 pt. (2.8 L)*
Six-Speed
............................................ 8.0 pt. (3.8 L)*
Rear Axle Lubricant
...................................... 3.5 pt. (1.7L)
VIN Engine Code
P
Manual
Transmission
Vehicle Dimensions
Tread Wheelbase
........................................... 101.1 I‘ (2 566 mm)
Front
.............................................. .60.7“ ( 1 542 mm)
Rear
.............................................. .60.6” (1 540 mm)
Length
............................................... 193.2“ (4 908 mm)
Firebird and Formula
................................. 195.6” (4 968 mm)
Trans Am .......................................... 197.0” (5 005 mm)
Width
............................................... 74.5” (1 893 mm)
Coupe
........................................... 52.0” (1 322 mm)
Convertible ....................................... .52.7” ( 1 340 mm)
Coupe
........................................... .51.7” (1 312 mm)
Convertible
....................................... .52.4“ (1 331 mm)
Height
Firebird and Formula
Trans Am
*Recheck fluid level after filling. See “ManualTransmission Fluid” in the Index.
**Recheck oil level after filling. See “Engine Oil” in the Index.
. . -236
ProCarManuals.com

I IMPORTANT
I
KEEP THE ENGINE OIL
AT THE PROPER
LEVEL AND CHANGE AS
RECOMMENDED
This part covers the
maintenance required for your
Pontiac. Your vehicle needs
these services
to retain its
safety, dependability and
emission control performance.
Part 7
Maintenance Schedule
Section
Introduction: A Word about Maintenance ... . . 240
A.
B.
C.
D.
E.
..
Your Vehicle and the Environment ...... .......... 240
How This Part
Is Organized .......... ....... . . 240
Scheduled Maintenance Services .... ................. 242
Using
Your Maintenance Schedules ....................... 241
Selecting the Right Schedule
................ ..... 241
Schedule1
............................... . . 242
Schedule11
................................. . . 244
Explanation
of Scheduled Maintenance Services .......... 246
Owner Checksand Services ................................ 248
AtEachFuelFill
....................................... 248
At Least Once
a Month .................................. 248
At Least Twice a Year
................... ......... 248
At Least Once
a Year ............... .., . . 249
Recommended Fluids and Lubricants ... ................ 253
Maintenance Record ...................................... 255
Periodic Maintenance Inspections .... ... ..... 251
I-
I- -
Have you purchased the GM Protection Plan? The Plan
supplements
your new car warranties.
See
your GM dealer for details.
239. ..
ProCarManuals.com

Maintenance Schedule
C L Section A: Scheduled Maintenance Services
Schedule I
Follow Schedule I if your vehicle is
MAINLY driven under one or more of
the following conditions:
When most trips are less than
4 miles
(6 km).
When most trips are less than
10 miles
(16 km) and outside temperatures
remain below freezing.
When most trips include extended
idling and/or frequent low-speed
operation, as in stop-and-go traffic.
When towing a trailer.
When operating in dusty areas.
Schedule
I should also be followed if the
vehicle is used for delivery service. police,
taxi or other commercial aqdications.
* An Emission Control Service.
t The U.S. Environmental Protection Agency
or the California Air Resources Board has
determined that the failure to perform this
maintenance item will not nullify the emission
warranty
or limit recall liability prior to the
completion ‘of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be performed at the
indicated intervals and the maintenance be
recorded in “Section
E: Maintenance Record.”
ITEM NO.
-
1
3
-
4
6
-
7
9
11
WHAT TO SERVICE
See “Explanation of Scheduled
Maintenance Services” following
Schedules
I and II.
~
Engine Oil & Oil Filter Change*
Chassis Lubrication
Tire and Wheel Rotation
& Inspection
Engine Accessory Drive Belt Inspection*
Cooling System Service*
Transmission Service
Spark Plug Replacement
(3.4L L32 (Code
S) Engine)*
Spark Plug Replacement
(5.7L LTl (Code P) Engine)*
Spark Plug Wire Inspection*?’
Air Cleaner Filter Replacement*
Fuel Tank, Cap
& Lines Inspeclion*t
Rear Axle Fluid Change (For Vehicles
Towing Trailers or for Vehicles with
Limited-Slip Differentials)
WHEN TO PERFORM
Miles (kilometers) or Months
(whichever occursfirst).
Every 3,000 miles (5 000 km) or 3 months.
Every other oil change.
At
6,000 miles (10 000 km) and every
15,000 miles (25 000 km) or as necessary.
Every
30,000 miles (50 000 km) or 24 months.
See “Explanation of Scheduled Maintenance
Services” following Schedules I and
II.
Every 30,000 miles (50 000 km).
Every 100,000 miles (166 000 km).
Every 30,000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” following Schedules I and 11.
Every 30,000 miles
(50 000 km).
~ ~~ ~~~
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
. . .242
ProCarManuals.com

Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.)
Schedule lI
Follow Schedule II ONLY if none of
the driving. conditions specified in
Schedule
I apply.
* An Emission Control Service.
t The US. Environmental Protection Agency
or the California Air Resources Board has
determined that the failure to pedorm this
maintenance item will not nullify the emission
warranty or limit recall liability prior to the
completion
of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be performed at the
indicated intervals and the maintenance be
recorded in “Section
E: Maintenance Record.”
WHAT TO SERVICE WHEN TO PERFORM
“Explanation of Scheduled Miles (kilometers) or Months ITEM NO. Maintenance Services” following (whichever occursfirst).
Schedules
I and I?.
Engine Oil Change* Every 7,500 miles (12 500 km) or 12 months.
Oil Filter Change* At
first and every other oil change. 1
2 Chassis Lubrication Every 7,500 miles (12 500 km) or 12 months. ~~~
3 I Tire and Wheel Rotation & Inspection I
At 7,500 miles (12 500 km) and then every
15,000 miles (25
000 km) or as necessarv.
4 I Engine Accessory Drive Belt Inspection* ~ Every 30,000 miles (50 000 km) or 24 months.
5 I Cooling System Service* !
6 I Transmission Service I
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
Spark Plug Replacement
(3.4L L32 (Code
S) Engine)* Every 30,000 miles (50 000 km).
7
I
Spark Plug Replacement
(5.7L LTl (Code P) Ennine)* I Every 100,000 miles (166 000 km). \- I I, I
8 Spark Plug Wire Inspection*? Every 30,000 miles (50 000 km).
9 Air Cleaner Filter Replacement* I I
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and II.
10 Fuel Tank, Cap & Lines Inspection”? Every 30,000 miles (50 000 km).
, , Rear Axle Fluid Change (For Vehicles See “Explanation
of Scheduled Maintenance
with Limited-Slip Differentials) Services” following Schedules I and
11.
. . .244
ProCarManuals.com