air condition PONTIAC FIREBIRD 1996 Owner's Manual

Maintenance Schedule
Lung Trip/Highway Definition Long Trip/Highway Intervals
Follow this maintenance schedule only if none of the
conditions from the Short Trip/City Maintenance
Schedule is true.
Driving a vehicle with a fully warmed engine under
highway conditions causes engine oil to break
down slower.
Every 7,500 Miles (12 500 km): Engine Oil and Filter
Change (or every
12 months, whichever occurs fist).
Chassis Lubrication (or every
12 months, whichever
occurs first).
At the First 7,500 Miles (12 500 km): Rear Axle Fluid
Change (Limited-Slip Differential).
At 7,500 Miles (12 500 km) -- Then Every
15,000 Miles (25
000 km): Tire Rotation.
Every 15,000 Miles (25 000 km): Automatic
Transmission Service (severe conditions
only).
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement. Fuel Tank, Cap and Lines Inspection.
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection.
Every 100,000 Miles (166 000 km): Cooling System
Service (or every
60 months, whichever occurs first).
Spark Plug Wire Inspection: Spark Plug Replacement.
Automatic Transmission Service (normal conditions).
These intervals only summarize maintenance services.
Be sure to follow the complete maintendnce schedule on
the following pages.
7-5
ProCarManuals.com

1 Short Trip/City Maintenance Schedule 1
12,000 Miles (20 000 km)
0 Change engine oil and filter (or every
,3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate the steering linkage (or every
6 months, whichever occurs first).
0 Change the rear axle gear lubricant if
vehicle is used to pull a trailer.
15,000 Miles (25 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Inspect air cleaner €ilter if you are driving
in dusty conditions. Replace filter if
necessary.
An Emission Control Service.
0 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32°C) or higher.
- In hilly or mountainous terrain.
ProCarManuals.com

1 Short Trip/City Maintenance Schedule I
45,000 Miles (75 000 km)
Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Change automatic transmission fluid and
filter if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32 "C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
If you do not use your vehicle under any of
these conditions, change the fluid and filter at
100,000 miles (1 66 000 km).
Manual transmission fluid doesn't require change.
0 Inspect air cleaner filter if you are driving
in dusty conditions. Replace filter
if
delivery service.
necessary. An Emission Control Service.
DATE
SERVICED BY: ACTUAL MILEAGE
7-15
ProCarManuals.com

Short Trip/City Maintenance Schedule
60,000 Miles (100 000 km)
Cl Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
I7 Lubricate the steering linkage (or every
6 months, whichever occurs first).
0 Change the rear axle gear lubricant if
vehicle is used to pull a trailer.
0 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90' F
(32 O C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trader towing.
- Uses such as found in taxi, police or
delivery service.
Ifyou do n ot use your vehicle under any of
these conditions, chartge the fluid and filter at
100,000 miles (I 66 000 lzm).
Manual transmission fluid doesn't require change.
17 Inspect engine accessory drive belt.
0 Replace air cleaner filter.
An Emission Control Service.
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service.
DATE ACTUAL MILEAGE
SERVICED BY:
7-18
ProCarManuals.com

)City Maintenance Schedule I
75,000 Miles (125 000 km)
Change engine oil and filter (or every
3 months, whichever occurs first).
'An Emission Control Service.
[7 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, change the fluid and filter at
100,000 miles (166 000 km):
Manual transmission fluid doesn't require change.
0 Inspect air cleaner filter if you are driving
in dusty conditions. Replace filter if
necessary. An Emission Control Service.
DATE SERVICED BY: ACTUAL MILEAGE
ProCarManuals.com

1 Short TripKity Maintenance Schedule I
90,000 Miles (150 000 km)
Change engine oil and filter (or every
3 months, whichever occurs first). I
0 Lubricate the steering linkage (or every
6 months, .whichever occurs first).
0 Change the rear axle gear lubricant if
vehicle is used to pull
a trailer.
0 Change automatic transmission fluid ,and
filter
if the vehicle is mainly 'driven under
one or more of these
conditions: ~
An Emission Control Service.
- In heavy city traffic where the outside
temperature regularly reaches
90 "F
(32°C) or higher. t i.*. .:?- i! ' '. .. . r .I . It : -:. - .
- In hill! 1 or mountain0 us terrain.
- When doing frequent trailer towing.
- Uses such 'as found in taxi, police or
delivery service.
lf you do not use your vehicle under any of
these conditions, change the fluid andJiEter at
lOO,OOO miles (166 000 km).
Manual transmission fluid doesn't require change.
"0 Replace air cleaner filter.
An Emission Control Service.
7-24
ProCarManuals.com

1 Long Trip/Highwag Maintenance Schedule 1
If you do not use your vehicle under any of
these conditions, change the fluid and filter at
100,000 miles (1 66 000 km).
Manual transmission fluid doesd t.require change.
0 Replace air cleaner filter. -8 .. z
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service. ?
An Emission Control Service.
DATE SERVICED BY: ACTUAL MILEAGE
37,500 Miles (62 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
’ 0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information.
During
tire rotation, check brake calipers for freedom
of movement. Refer to the appropriate
GM service manual for proper caliper
service procedures.
An Emission Control Service.
DATE SERVICED BY: ACTUAL MILEAGE
7-31
ProCarManuals.com

Long Trip/Highway Maintenance Schedule
60,000 Miles (100 000 km) (Continued)
If you do not use your vehicle under any of
these conditions, change the fluid and filter at
100,000 miles (166 000 km).
Manual transmission fluid doesn’t require change.
0 Inspect engine accessory drive belt.
0 Replace air cleaner filter.
An Emission Control Service.
Inspect fuel tank, cap and lines for damage
or
leaks. Inspect fuel cap gasket for any
damage. Replace
parts as needed.
An Emission Control Service. ?
I 67,500 Miles (112 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information,. During
tire rotation, check brake calipers for fieedom
of movement. Refer
to the appropriate
GM service manual for proper caliper
An Emission Control Service.
I service procedures.
DATE SERVICED BY: ACTUAL MILEAGE DATE SERVICED BY: ACTUAL MILEAGE
-
7-34
ProCarManuals.com

I Long Trip/Highway Maintenance Schedule
- Uses such as found in taxi, police or
If you do not use your vehicle under any of these
conditions, change the fluid and filter at
100,000
miles (1 66 000 km).
Manual transmission fluid doesn’t require change.
delivery service.
Replace air cleaner filter.
17 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Em,ission Control Service.
An Emission Control Service.
97,500 Miles (162 500 km)
IJ Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information.
During
tire rotation, check brake calipers for freedom of movement. Refer to the appropriate
GM service manual for proper caliper
service procedures.
DATE SERVICED BY: ACTUAL MILEAGE
DATE
SERVICED BY: ACTUAL MILEAGE
7-37
ProCarManuals.com

Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall). You should let your GM dealer’s
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a Pontiac Service Manual. See “Service and
Owner Publications’’ in the Index.
Steering and Suspension Inspection
inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect
the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body near
the exhaust system. Look for broken, damaged, missing or
0~t~€-pii60n parts as well as open seams, holes, loose
connections or other conditions which could cause a heat
build-up in
the floor pan or could let exhaust fumes into
the vehicle. See “Engine Exhaust” in the Index.
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen
or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed.
Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding, and
for damage or missing parts. Replace parts as needed.
Replace any cables that have high effort
or excessive wear.
Do not lubricate accelerator and cruise control cables.
Rear Axle Service
Check the gear lubricabt level in the rear axle and add if I
needed. See “Rear Axle” in the Index. A fluid loss may
indicate a problem. Check
the axle and repair it if needed.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition.
Also inspect drum brake linings
for wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc. The
parking brake is self-adjusting and no manual
adjustment
is required. You may need to have your
‘brakes inspected more often
if your driving habits or
conditions result in frequent braking.
7-43
ProCarManuals.com