air filter PONTIAC FIREBIRD 1996 Owners Manual

Air Cleaner
3800 L36 (Code K) Engine
5.7L LT1 (Code P) Engine
Refer
to the Maintenance Schedule to determine when to
replace the air filter. . ‘1 ’ 8.1. - ’ (<,
See “Scheduled Maintenance Senkes” in the Index.
6-16
ProCarManuals.com

Operating the engine with the air cleaner off can
cause you or others to be burned. The air cleaner
not only cleans the air, it stops flame if the engine
backfires.
If it isn't there, and the engine
backfires, you could be burned. Don't drive with
it off, and be careful working on the engine with
the air cleaner off.
i
I NOTICE: I
LIftheeaner is off, a backfire can cause a I
Air Filter Replacement
To remove the air filter:
damaging engine fire. And, dirt can easily get
have the air cleaner in place when you're driving.
into
your engine, which will damage
it. Always
1. Remove the plastic pin by pulling it straight up.
ProCarManuals.com

4. Open the air cleaner and remove the filter.
If you have the 5.7L LT1 engine (with the WS6 option),
your air cleaner will be located near the front of the
engine compartment.
To remove the filter, remove the screws (located on the
rear edge
of the air cleaner), lift the air cleaner and
remove the filter.
ProCarManuals.com

Capacities (Approximate) (Continued)
Crankcase
Oil and Filter Change
3800 (WN K) ............ 4.5 quarts (4.3 L)**
5.7 L (VIN P) ............ 5.0 quarts (4.7 L)**
Fuel Tank .................. 15.5 gallons (58.7 L)
Five-Speed ................. 6.8 pints (3.2 L)*
Six-Speed .................. 8.0 pints (3.8 L)*
Rear Axle Lubricant ............ 3.5 pints (1 .TL)
Manual Transmission
+Not all air conditioning refrigerants are the same.
If the air conditioning system in your vehicle needs
refrigerant, be sure the proper refrigerant is used.
If you’re not sure, ask your Pontiac dealer.
*Recheck fluid level after filling. See “Automatic
Transmission
Fluid” or “Manual Transmission Fluid”
in the Index.
**Recheck the oil level after filling. See “Engine Oil” in
the Index.
Vehicle Dimensions
Wheelbase
Front Tread
Rea’ Tread
Length
Firebird / Formula
Trans
Am
Width
Height
101.1 inches (2 566 mm)
60.7 inches (1 542 mm)
60.7 inches (1 540 mm)
195.6 inches (4 968 mm)
197.0 inches ( 5 005 mm)
74.5 inches (1 893 mm)
52.10 inches (1 323, nun)
ProCarManuals.com

Replacement Parts Air Conditioning Refrigerants
Air Cleaner Filter Not all air conditioning refrigerants are the same.
VIN Engine Code P .................. A1163C refrigerant, be sure the proper refrigerant is used.
VIN Engine Code P (with WS6 Option) A1097C
Battery
............................... .75-60
Engine
Oil Filter
..... .;+ VIN Engine Code K .................. A1163C If the air conditioning system in your vehicle needs I . . '. .~ ,..I . ,. ,
If you're not sure, ask your Pontiac dealer. ...
. VIN Engine Code K ..................... PF47
VIN Engine Code
P .................... PF25
Fuel Filter
............................. GF578
PCV Valve
VIN Engine Code
K ................. CV892C
VIN Engine Code P ................. CV895C
Radiator Cap
........................... RC24
Spark Plug
VIN Engine Code K ....... -41-921 (0.060" Gap)
VIN Engine Code P ....... e41-943 (0.050" Gap)
Specification
................... 180°F (82°C)
Thermostat Temperature
I 6r't
ProCarManuals.com

Maintenance Schedule
Short Trip/City Definition
Follow the Short TripKity Maintenance Schedule if any
one
of these conditions is true for your vehicle:
0 Most trips are less than 5 to 10 miles (8 to 16 km).
This is particularly important when outside
temperatures are below freezing.
0 Most trips include extensive idling (such as frequent
driving in stop-and-go traffic).
$0 Most trips are through dusty areas.
You frequently tow a trailer or use a carrier on top of
0 If the vehicle is used for delivery service, police, taxi
One ofthe reasons you should follow this schedule if you
operate your vehicle under any of these conditions is that
these conditions cause engine oil to break down
soonel:
your vehicle.
or other commercial application.
Short Trip/City Intervals
~~
Every 3,000 Miles .(5 000 km): Engine Oil and Filter
Every 6,000 Miles (10 000 km): Chassis Lubrication
Change
(or 3 months, whichever occurs first).
(or
6 months, whichever occurs first).
- I
Short Trip/City Intervals
At 6,000 Miles (10 000 km) -- .Then
Every 12,000 Miles (20 000 km): Tire Rotation.
Every 6,000 Miles (10 000 km) of Trailering:
Rear Axle Fluid Change (Vehicles Towing Trailers).
At the First 6,000 Miles (10 000 Ism): Rear Axle Fluid
Change (Limited-Slip Differential).
Every 15,000 Miles (25 000 km): Air Cleaner Filter
Inspection, if driving in dusty conditions. Automatic
Transmission Service (severe conditions only).
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement, Fuel Tank, Cap and
Lines Inspection.
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection.
Every 100,000 Miles (166 000 km): Cooling System
Service
(or every 60 months, whichever occurs fust).
Spark Plug Wire Inspection. Spark Plug Replacement.
Automatic Transmission Service (normal conditions).
These intervals only summarize maintenance services.
Be
sure to follow the complete maintenance schedule on
the following pages.
7-4
ProCarManuals.com

Maintenance Schedule
Lung Trip/Highway Definition Long Trip/Highway Intervals
Follow this maintenance schedule only if none of the
conditions from the Short Trip/City Maintenance
Schedule is true.
Driving a vehicle with a fully warmed engine under
highway conditions causes engine oil to break
down slower.
Every 7,500 Miles (12 500 km): Engine Oil and Filter
Change (or every
12 months, whichever occurs fist).
Chassis Lubrication (or every
12 months, whichever
occurs first).
At the First 7,500 Miles (12 500 km): Rear Axle Fluid
Change (Limited-Slip Differential).
At 7,500 Miles (12 500 km) -- Then Every
15,000 Miles (25
000 km): Tire Rotation.
Every 15,000 Miles (25 000 km): Automatic
Transmission Service (severe conditions
only).
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement. Fuel Tank, Cap and Lines Inspection.
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection.
Every 100,000 Miles (166 000 km): Cooling System
Service (or every
60 months, whichever occurs first).
Spark Plug Wire Inspection: Spark Plug Replacement.
Automatic Transmission Service (normal conditions).
These intervals only summarize maintenance services.
Be sure to follow the complete maintendnce schedule on
the following pages.
7-5
ProCarManuals.com

I Short Trip/City Maintenance Schedule I
The services shown in this s'chedule up to 100,000 miles
(166 000 km) should be performed after 100,000 miles
(1.66 000 km) at the same intervals.
Footnotes
The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this' maintenance item will
not nullify
the emission warranty
or limit recall liability prior to the
completion
of the vehicle's useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
I 3,000 Miles (5 000 km)
17 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
I DATE ACTUAL MILEAGE SERVICED BY:
ProCarManuals.com

1 Short Trip/City Maintenance Schedule 1
12,000 Miles (20 000 km)
0 Change engine oil and filter (or every
,3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate the steering linkage (or every
6 months, whichever occurs first).
0 Change the rear axle gear lubricant if
vehicle is used to pull a trailer.
15,000 Miles (25 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Inspect air cleaner €ilter if you are driving
in dusty conditions. Replace filter if
necessary.
An Emission Control Service.
0 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32°C) or higher.
- In hilly or mountainous terrain.
ProCarManuals.com

I Short TripKity Maintenance Schedule I
27,000 Miles (45 000 km)
0 Change engine oil and filter (or every
3 months, wluchever occurs first).
An Emission Control Sewice.
I DATE I ACTUAL MILEAGE ISERVICED BY: I
30,000 Miles (50 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
Lubricate the steering linkage (or every
6 months, whichever occurs first).
17 Change the rear axle gear lubricant if
vehicle is used to pull a trailer.
0 Replace air cleaner filter.
An Emission Control Service.
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service.
(Continued)
7-11
ProCarManuals.com