instrument panel PONTIAC GRAND AM 2003 Owner's Guide

L
LOW
COOLANT
If the LOW COOLANT light r-
-
comes on and stays on, it
means you’re low on
engine coolant.
See
Low Coolant Warning Light on page 3-30.
Adding Coolant
If you need more coolant, add the proper DEX-COOL@
coolant mixture
at the surge tank, but only when the
engine is cool.
If the surge tank is empty, a special fill
procedure is necessary. See Engine Overheating
on page
5-26 and “How to Add Coolant to the Coolant
Surge Tank under
Cooling System on page 5-29
for instructions. You can
be burned
if you spill coolant on hot
engine parts. Coolant contains ethylene glycol,
and it
will burn if the engine parts are hot
enough. Don’t spill coolant on a hot engine.
1
When replacing the pressure cap, make sure it is
hand-tight.
Engine Overheating
You will find a coolant temperature gage and a low
coolant warning light on your vehicle’s instrument panel.
See
Engine Coolant Temperature Gage on page 3-30
and Low Coolant Warning Light on page 3-30.
5-26

How to Check Power Steering Fluid
Turn the key off, let the engine compartment cool down,
wipe the cap and the top of the reservoir clean, then
unscrew the cap and wipe the dipstick with a clean rag.
Replace the cap and completely tighten it. Then
remove the cap again and look at the fluid level on the
dipstick.
The level should be at the
FULL COLD mark. If
necessary, add only enough fluid to bring the level up to
the mark.
What to Use
To determine what kind of fluid to use, see Part D:
Recommended Fluids and lubricants on page 6- 15.
Always use the proper fluid. Failure to use the proper
fluid can cause leaks and damage hoses and seals.
Windshield Washer Fluid
What to Use
When you need windshield washer fluid, be sure to read
the manufacturer's instructions before use. If you
will
be operating your vehicle in an area where the
temperature may fall below freezing, use a fluid that has
sufficient protection against freezing. See
Engine
Compartment Overview on page
5-12 for reservoir
location.
Adding Washer Fluid
.1. ,- 5 * -,
LOW
Your vehicle has a low
washer fluid telltale that
will come on in the
instrument panel cluster
when the washer fluid
is low.
See
low Washer Fluid Warning light on page 3-36 for
more information.
5-37

Vinyl
Use warm water and a clean cloth.
0 Rub with a clean, damp cloth to remove dirt. You
may have
to do this more than once.
Things like tar, asphalt and shoe polish will stain if
you don’t get them off quickly. Use a clean cloth
and vinyl/leather cleaner. See your dealer for
this product.
Leather
Use a soft cloth with lukewarm water and a mild soap or
saddle soap and wipe dry with a soft cloth. Then, let
the leather dry naturally.
Do not use heat to dry.
e
For stubborn stains, use a leather cleaner. See your
dealer for this product.
Never use oils, varnishes, solvent-based or abrasive
cleaners, furniture polish or shoe polish on leather.
Soiled or stained leather should be cleaned
immediately.
If dirt is allowed to work into the finish,
it can harm the leather.
Top of the Instrument Panel
Use only mild soap and water to clean the top surfaces
of the instrument panel. Sprays containing silicones
or waxes may cause annoying reflections in the
windshield and even make it difficult to see through the
windshield under certain conditions.
Interior Plastic Components
Use only a mild soap and water solution on a soft cloth
or sponge. Commercial cleaners may affect the
surface finish.
Glass Surfaces
Glass should be cleaned often. GM Glass Cleaner or a
liquid household glass cleaner will remove normal
tobacco smoke and dust films on interior glass. See
GM
Vehicle Care/Appearance Materials
on page 5-78.
Notice: Don’t use abrasive cleaners on glass,
because they may cause scratches. Avoid placing
decals on the inside rear window, since they
may have to be scraped
off later. If abrasive cleaners
are used on the inside of the rear window, an
electric defogger element may be damaged. Any
temporary license should not be attached across the
defogger grid.
5-74

Vehicle Identification
Vehicle Identification Number (VIN)
This is the legal identifier for your vehicle. It appears on
a plate in the front corner
of the instrument panel, on
the driver’s side. You can see
it if you look through the
windshield from outside your vehicle. The VIN also
appears on the Vehicle Certification and Service Parts
labels and the certificates of title and registration.
Engine Identification
The 8th character in your VIN is the engine code.
This code will help you identify your engine,
specifications and replacement parts.
Service Parts Identification Label
You’ll find this label on the bottom of your spare
tire cover. It’s very helpful
if you ever need to order
parts. On this label is:
your VIN,
the model designation,
paint information and
a list of all production options and special
equipment.
Be sure that this label is not removed from the vehicle.
5-80

Electrical System
Add-On Electrical Equipment
Notice: Don’t add anything electrical to your
vehicle unless you check with your dealer first.
Some electrical equipment can damage your vehicle
and the damage wouldn’t be covered by your
warranty. Some add-on electrical equipment can
keep other components from working as they
should.
Your vehicle has an air bag system. Before attempting
to add anything electrical to your vehicle, see
Servicing Your Air Bag-Equipped Vehicle on page 1-59.
Windshield Wiper Fuses
The windshield wiper motor is protected by a circuit
breaker and a fuse. If the motor overheats due to heavy
the overload is caused by some electrical problem, have
it fixed.
SXLY, ek., the vvipec vviii Sup urliii iikle I~IIU~WI cuuis. ii
Power Windows and Qther Power
Options
A circuit breaker in the fuse panel protects the power
windows. When the current load is
too heavy, the circuit
breaker opens and closes, protecting the circuit until
the problem is fixed.
Fuses and Circuit Breakers
The wiring circuits in your vehicle are protected from
short circuits by a combination
of fuses, circuit breakers
and fusible links. This greatly reduces the chance of
damage caused by electrical problems.
Look at the silver-colored band inside the fuse.
If the
band is broken or melted, replace the fuse. Be sure
to
replace a bad fuse with a new one of the identical
size and rating.
There are three fuse blocks in your vehicle: two
instrument panel fuse blocks and the engine
rmpsrtment !LE? h!r\Ck.
There are four spare fuses located in the driver’s side
instrument panel end cap for your use.
Instrument Panel Fuse Blocks
There are two fuse panels for your vehic!~. One Is
located on the driver’s side of the instrument panel
the other
is located on the passenger’s side. and
5-81

Instrument Panel Fuse Block
(Driver’s Side)
f
A) WIPER E) TRUNKREL RADIO AMP C) TURN LPS D) PWR MIRROR E) AIR BAG
G) PCMACC F) BFCBATT
H)
DRLOCK I) IPC/ BFC ACC J) STOP LPS
L) IPC / HVAC BATT
OIL
= H)n?I DR UNLOCK
El pq DR UNLOCK
Fuses Usage
WIPER Windshield Wiper Motor,
TRUNK REU Trunk Release
Relay/Motor,
RADIO AMP Audio AmplifiedRFA
TURN LPS Turn
Signal Lamps
Washer Pump Fuses
PWR MIRROR
AIR BAG
BFC BATT
PCM ACC
DR LOCK
I PC/BFC ACC
STOP LPS
HAZARD LPS
I PC/HVAC
BATT
Circuit Breakers
PWR SEAT
Relay
TRUNK REL
DR UNLOCK DR LOCK
DRIVER DR
UNLOCK Usage
Power Mirrors
Air Bags Body Computer (BFC)
Power Control Module (PCM)
Door Lock Motors
Cluster, Body Computer (BFC)
Stop Lamps Hazard Lamps HVAC Head, Cluster, Data Link
Connector
Usage Power Seats
Usage
Trunk Relay
Door Unlock Relay Door Lock Relay
Driver’s Door Unlock Relay
5-82

Instrument Panel Fuse Block
(Passenger’s Side)
SEE OTHER END CAI
FOR FUSE PULLER
& SPARE FUSES
A) INST LPS
C) CRUISE SW B) CRUISE SW LPS
D) HVAC BLOWER E) CRUISE F) FOG LPS G) INT LPS H) RADIO BATT I) SUNROOF
*SEE OWNERS MANUAL /
Fuse
INST LPS
CRUISE
sw LPS
CRUISE SW
HVAC
BLOWER
CRUISE FOG LPS
INT LPS RADIO
BATT
SUNROOF Usage
Interior Lamp Dimming
Steering Wheel Cruise Control
Switch Lamps
Steering Wheel Cruise
Control Switches
HVAC Blower Motor
Cruise Control Fog Lamps
Interior Courtesy Lamps
Radio, XMTM Satellite Radio/DAB
Power Sunroof
Circuit Breaker Usage
PWR WNDW Power Windows
Relay
FOG LPS
Usage
Fog Lamps
5-83

Customer Assistance Information
Customer Satisfaction Procedure
Your satisfaction and goodwill are important to
your dealer and to Pontiac. Normally, any concerns with
the sales transaction or the operation of your vehicle
will be resolved by your dealer’s sales or service
departments. Sometimes, however, despite the best intentions
of all concerned, misunderstandings can
occur.
If your concern has not been resolved to your
satisfaction, the following steps should be taken:
STEP ONE: Discuss your concern with a member of
dealership management. Normally, concerns can
be quickly resolved at that level.
If the matter has
already been reviewed with the sales, service or parts
manager, contact the owner of the dealership or
the general manager.
STEP TWO:
If after contacting a member of dealership
management, it appears your concern cannot be
resolved by the dealership without further help, contact
the Pontiac Customer Assistance Center by calling
1-800-762-2737. In Canada, contact GM of Canada
Customer Communication Centre in Oshawa by calling
1-800-263-3777 (English) or 1-800-263-7854 (French). We
encourage you to call the toll-free number in order
to give your inquiry prompt attention. Please have
the following information available to give the Customer
Assistance Representative:
Vehicle Identification Number (This is available from
the vehicle registration or title, or the plate at the
top left of the instrument panel and visible through
the windshield.)
Dealership name and location
Vehicle delivery date and present mileage
When contacting Pontiac, please remember that your
concern will likely be resolved at a dealer’s facility. That
is why we suggest you follow Step One first
if you
have a concern.
STEP THREE: Both General Motors and your dealer
are committed to making sure you are completely
satisfied with your new vehicle. However,
if you continue
to remain unsatisfied after following the procedure
outlined in Steps One and Two, you should file with the
GM/BBB Auto Line Program to enforce any additional
rights you may have. Canadian owners refer to
your Warranty and Owner Assistance Information
booklet for information on the Canadian Motor Vehicle
Arbitration Plan (CAMVAP).
7-2

Inspection Brake System
............................................. 6-14
Engine Cooling System
................................ 6-14
Exhaust System
.......................................... 6-13
Fuel System
............................................... 6-13
Part C
. Periodic Maintenance ....................... 6-13
Steering. Suspension and Front Drive Axle
Boot and Seal ......................................... 6-13
Throttle System
........................................... 6-1 4
Cluster
....................................................... 3-23
Overview
..................................................... 3-2
Instrument Panel Brightness
............................. 3-1 6
Instrument Panel Fuse Block (Passenger's Side)
....................................... 5-83
Instrument Panel Fuse Block (Driver's Side)
............................................. 5-82
Instrument Panel Fuse Blocks
........................... 5-81
Interior Lamps
................................................ 3-16
Instrument Panel
Interior Plastic Components
.............................. 5-74
J
Jump Starting ................................................. 5-43
K
Key Lock Cylinders Service .............................. 6-10
Key Removal
................................................. 2-32
Keyless Entry System
....................................... 2-3 Keys
............................................................... 2-2
Lamps Exterior
...................................................... 3-13
Interior
....................................................... 3-16
Lap Belt
........................................................ 1-28
Lap-Shoulder Belt
................................... 1.14, 1-24
LATCH System Child Restraints
........................................... 1-44
Securing a Child Restraint Designed for the
LATCH System
........................................ 1-46
Latches, Seatback
............................................ 1-5
Leather
......................................................... 5-74
Leaving Your Vehicle
....................................... 2-11
Leaving Your Vehicle With the Engine Running
(Automatic Transaxle Only)
........................... 2-31
Lift Seat, Power
............................................... 1-7
Light Air Bag Readiness
....................................... 3-25
Anti-Lock Brake System Warning
................... 3-28
brake
Sys'rem Vvarrliny 5-10
Change Engine Oil ...................................... 3-35
Enhanced Traction System Active
.................. 3-29
Enhanced Traction System Warning
............... 3-28
Low Coolant Warning
................................... 3-30
Low
Oil Level ............................................. 3-35
Low Washer Fluid Warning
........................... 3-36
*- .................................
Charging System ......................................... 3-26
7

Tires (cont.) Wheel Alignment and Tire Balance
................. 5-59
Wheel Replacement
..................................... 5-59
When It
Is Time for New Tires ...................... 5-56
To Use the Engine Coolant Heater
.................... 2-23
Top
of the Instrument Panel ............................. 5-74
Top Strap
...................................................... 1-42
Top Strap Anchor Location
............................... 1-43
Torque Lock
................................................... 2-31
Total Weight on Your Vehicle’s Tires
.................. 4-39
Towing Recreational Vehicle
..................................... 4-32
Towing a Trailer
.......................................... 4-37
Your Vehicle
............................................... 4-32
Traction Enhanced Traction System Active Light
........... 3-29
Enhanced Traction System Warning Light
........ 3-28
Enhanced Traction
System (ETS)
.................... 4-9
Trailer Brakes
................................................. 4-40
Transaxle Fluid, Automatic
........................................... 5-22
Fluid, Manual
.............................................. 5-22
Transaxle Operation, Manual
............................ 2-27
Transmission
Up-Shift Light
.............................................. 3-26
Transmission, Transaxle, Transfer Case Unit
Repair Manual
.............................................. 7-9
Transportation Options
...................................... 7-7
Trap-Resistant Trunk Kit
.. I .. .. jj jj I .. ~ ~ ~ ~ ~ I ~ I 2-1 4
Tr2.ns2x!E! Gperstls!?, ,*.ntc!X!tic ......................... L 9-24
Trip Odometer ................................................ 3-24
Trunk
............................................................ 2-12
Turn and Lane-Change Signals
.......................... 3-6
Turn SignaVMultifunction Lever
........................... 3-6
Turn Signals When Towing a Trailer
.................. 4-41
Trunk
Lamp
................................................... 3-17
U
Underbody Flushing Service ............................. 6-12
Understanding Radio Reception
........................ 3-70
Uniform Tire Quality Grading
............................ 5-57
United States
................................................... 7-4
Up-Shift Light
................................................. 3-26
Used Replacement Wheels
.............................. 5-60
Using Cleaner on Fabric
.................................. 5-73
v
Vehicle Control
.................................................
Damage Warnings ..................................
Loaang .................................................
Parking Your ..........................................
Service Soon Light .................................
Symbols ................................................
Number (VIN) ........................................
Service Parts Identification Label ..............
Vehicle Storage .........................................
Vehicle Identification
....... 4-6
......... iv
..... 4-33
..... 2-32
..... 3-36
......... iv
..... 5-80
..... 5-80
.=i = 5-43
13