key PONTIAC GRAND PRIX 2008 Workshop Manual

Fuse Usage
RAP Retained Accessory Power
SUN ROOF Sunroof
CRUISE SW Cruise Switch
PK LP Parking Lamps
RR DEFOG Rear Window Defogger
DR LK/TRUNK Door Lock/Trunk
ONSTAR/ALDL Onstar
®/Diagnostic Link
CANISTER Fuel Tank Solenoid Canister
PK LAMPS Parking Lamps
RADIO/AMP Radio Amplier
RFA/MODRemote Function Activator (Remote
Keyless Entry)
DISPLAYSInstrument Panel Displays/Head-Up
Display (HUD), Driver Information
Center (DIC)
Fuse Usage
INT LIGHT Interior Lamps
HVAC Climate Controls
CHMSL/BKUPCenter High Mounted Stop
Lamp/Back-Up Lamps
PWR WDO Power Windows
SPRING
COIL 2Steering Wheel Control Switches
PWR SEAT Power Seat
TURN/HAZTurn Signals/Hazard Warning
Lamps
PWR MIRS Power Mirrors
HTD SEAT Heated Seat
To reinstall the end panel, position the lower section
with the edge of the instrument panel, and press the
sides of the panel until it snaps into place.
5-123

Maintenance Footnotes
†The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to
the completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the
maintenance be recorded.
(a)Visually inspect brake lines and hoses for proper
hook-up, binding, leaks, cracks, chafing, etc. Inspect
disc brake pads for wear and rotors for surface
condition. Inspect other brake parts, including calipers,
parking brake, etc.
(b)Visually inspect front and rear suspension and
steering system for damaged, loose, or missing parts or
signs of wear. Inspect power steering lines and hoses
for proper hook-up, binding, leaks, cracks, chafing, etc.
(c)Visually inspect hoses and have them replaced if they
are cracked, swollen, or deteriorated. Inspect all pipes,
fittings, and clamps; replace with genuine parts as
needed. To help ensure proper operation, a pressure
test of the cooling system and pressure cap and cleaning
the outside of the radiator and air conditioning condenser
is recommended at least once a year.(d)Inspect wiper blades for wear, cracking, or
contamination. Clean the windshield and wiper blades,
if contaminated. Replace wiper blades that are worn or
damaged. See Windshield Wiper Blade Replacement
on page 5-61andWindshield and Wiper Blades on
page 5-116for more information.
(e)Make sure the safety belt reminder light and safety
belt assemblies are working properly. Look for any
other loose or damaged safety belt system parts. If you
see anything that might keep a safety belt system
from doing its job, have it repaired. Have any torn or
frayed safety belts replaced. Also see Checking
the Restraint Systems on page 1-66.
(f)Lubricate all key lock cylinders. Lubricate all hinges
and latches, including those for the body doors,
hood, secondary latch, pivots, spring anchor, release
pawl, rear compartment, glove box door, console
door, and any folding seat hardware. More frequent
lubrication may be required when exposed to a corrosive
environment. Applying silicone grease on weatherstrips
with a clean cloth will make them last longer, seal
better, and not stick or squeak.
(g)If you drive regularly under dusty conditions,
the filter may require replacement more often.
6-7

Automatic Transmission Shift Lock
Control System Check
{CAUTION:
When you are doing this inspection, the
vehicle could move suddenly. If the vehicle
moves, you or others could be injured.
1. Before you start, be sure you have enough room
around the vehicle. It should be parked on a
level surface.
2. Firmly apply the parking brake. SeeParking Brake
on page 2-33.
Be ready to apply the regular brake immediately
if the vehicle begins to move.3. With the engine off, turn the ignition to ON/RUN,
but do not start the engine. Without applying the
regular brake, try to move the shift lever out
of PARK (P) with normal effort. If the shift lever
moves out of PARK (P), contact your dealer/retailer
for service.Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition to LOCK/OFF in each shift lever position.
The ignition should turn to LOCK/OFF only
when the shift lever is in PARK (P).
The ignition key should come out only in
LOCK/OFF.
Contact your dealer/retailer if service is required.
6-10

Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name,
part number, or specication can be obtained from
your dealer/retailer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets GM
Standard GM6094M and displays
the American Petroleum Institute
Certied for Gasoline Engines
starburst symbol. To determine
the proper viscosity for your
vehicle’s engine, seeEngine Oil
on page 5-15.
Engine Coolant50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
Coolant. SeeEngine Coolant
on page 5-24.
Hydraulic Brake
SystemDelco
®Supreme 11 Brake Fluid
or equivalent DOT-3 brake uid.
Windshield
WasherOptikleen
®Washer Solvent.
Usage Fluid/Lubricant
Power Steering
SystemGM Power Steering Fluid
(GM Part No. U.S. 89021184,
in Canada 89021186).
Automatic
TransmissionDEXRON
®-VI Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241,
in Canada 10953474).
Hood Latch
Assembly,
Secondary
Latch,
Pivots, Spring
Anchor, and
Release PawlLubriplate Lubricant Aerosol
(GM Part No. U.S. 12346293,
in Canada 992723) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Hood and Door
HingesMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241,
in Canada 10953474).
Weatherstrip
ConditioningWeatherstrip Lubricant
(GM Part No. U.S. 3634770,
in Canada 10953518) or
Dielectric Silicone Grease
(GM Part No. U.S. 12345579,
in Canada 992887).
6-12

Important:EDR data is recorded by your vehicle
only if a non-trivial crash situation occurs; no data is
recorded by the EDR under normal driving conditions
and no personal data (e.g., name, gender, age,
and crash location) is recorded. However, other parties,
such as law enforcement, could combine the EDR data
with the type of personally identifying data routinely
acquired during a crash investigation.
To read data recorded by an EDR, special equipment
is required, and access to the vehicle or the EDR
is needed. In addition to the vehicle manufacturer,
other parties, such as law enforcement, that have the
special equipment, can read the information if they
have access to the vehicle or the EDR.
GM will not access this data or share it with others
except: with the consent of the vehicle owner or,
if the vehicle is leased, with the consent of the lessee;
in response to an official request of police or similar
government office; as part of GM’s defense of litigation
through the discovery process; or, as required by
law. Data that GM collects or receives may also be
used for GM research needs or may be made available
to others for research purposes, where a need is
shown and the data is not tied to a specic vehicle
or vehicle owner.OnStar®
If your vehicle has OnStar and you subscribe to the
OnStar services, please refer to the OnStar Terms
and Conditions for information on data collection and
use. See alsoOnStar
®System on page 2-40in
this manual for more information.
Navigation System
If your vehicle has a navigation system, use of the
system may result in the storage of destinations,
addresses, telephone numbers, and other trip
information. Refer to the navigation system operating
manual for information on stored data and for
deletion instructions.
Radio Frequency
Identication (RFID)
RFID technology is used in some vehicles for functions
such as tire pressure monitoring and ignition system
security, as well as in connection with conveniences
such as key fobs for remote door locking/unlocking and
starting, and in-vehicle transmitters for garage door
openers. RFID technology in GM vehicles does not
use or record personal information or link with any other
GM system containing personal information.
7-17

E
EDR .............................................................7-16
Electrical System
Add-On Equipment.....................................5-120
Fuses and Circuit Breakers.........................5-121
Headlamp Wiring.......................................5-120
Instrument Panel Fuse Block.......................5-122
Power Windows and Other Power Options....5-121
Underhood Fuse Block...............................5-124
Windshield Wiper Fuses.............................5-121
Electronic Immobilizer
PASS-Key
®III .............................................2-20
Engine
Air Cleaner/Filter.........................................5-20
Check and Service Engine Soon Light............3-50
Coolant......................................................5-24
Coolant Heater............................................2-26
Coolant Temperature Gage...........................3-49
Coolant Temperature Warning Light................3-48
Drive Belt Routing.......................................6-14
Engine Compartment Overview......................5-12
Exhaust.....................................................2-36
Oil .............................................................5-15Engine (cont.)
Oil Life System...........................................5-18
Overheated Protection Operating Mode...........5-29
Overheating................................................5-27
Starting......................................................2-25
Enhanced Traction System (ETS)........................ 4-7
Warning Light.............................................3-48
Entry Lighting.................................................3-20
Event Data Recorders.....................................7-16
Extender, Safety Belt.......................................1-28
Exterior Lamps...............................................3-16
Exterior Lighting Battery Saver..........................3-19
F
Filter
Engine Air Cleaner......................................5-20
Finish Damage.............................................5-117
Flashers, Hazard Warning.................................. 3-6
Flash-to-Pass................................................... 3-9
Flat Tire........................................................5-85
Flat Tire, Changing.........................................5-96
Flat Tire, Storing...........................................5-107
5

Headlamps (cont.)
High/Low Beam Changer................................ 3-9
On Reminder..............................................3-17
Headlamps and Sidemarker Lamps...................5-54
Head-Up Display (HUD)...................................3-23
Heated Seats................................................... 1-4
Heater...........................................................3-28
Heater...........................................................3-32
Highbeam On Light.........................................3-54
Highway Hypnosis...........................................4-16
Hill and Mountain Roads..................................4-16
Hood
Checking Things Under................................5-10
Release.....................................................5-11
Horn ............................................................... 3-6
How to Wear Safety Belts Properly...................1-15
I
Ignition Positions.............................................2-23
Infants and Young Children, Restraints...............1-32
Ination - Tire Pressure...................................5-69
Inator Kit, Tire...............................................5-86
Instrument Panel
Overview..................................................... 3-4
Instrument Panel (I/P)
Brightness..................................................3-19
Cluster.......................................................3-39
Interior Lamps................................................3-19
J
Jump Starting.................................................5-46
K
Keyless Entry System....................................... 2-3
Keys............................................................... 2-2
L
Labeling, Tire Sidewall.....................................5-63
Lamps
Courtesy....................................................3-19
Dome ........................................................3-20
Exterior Lighting Battery Saver......................3-19
Front Reading.............................................3-21
Overhead Console Reading..........................3-21
Rear Assist Handle Reading..........................3-21
Lap-Shoulder Belt...........................................1-22
LATCH System
Child Restraints...........................................1-39
License Plate Lamps.......................................5-60
Light
Airbag Readiness........................................3-42
Anti-lock Brake System (ABS) Warning...........3-47
Brake System Warning.................................3-45
Cruise Control.............................................3-53
7

P
Paint, Damage..............................................5-117
Park Brake....................................................2-33
Park (P)
Shifting Into................................................2-34
Shifting Out of............................................2-35
Parking
Over Things That Burn.................................2-36
Passenger Airbag Status Indicator.....................3-43
Passenger Compartment Air Filter.....................3-36
Passenger Sensing System..............................1-60
Passing.........................................................4-12
PASS-KEY
®III Electronic Immobilizer................2-20
PASS-KEY®III Operation.................................2-21
Perchlorate Materials Requirements, California...... 5-4
Power
Door Locks.................................................2-11
Electrical System.......................................5-121
Lumbar Controls........................................... 1-4
Retained Accessory (RAP)............................2-24
Seat ............................................................ 1-3
Steering Fluid.............................................5-39
Windows....................................................2-17
Pressure Cap.................................................5-27
Privacy..........................................................7-16
Event Data Recorders..................................7-16
Navigation System.......................................7-17Privacy (cont.)
OnStar.......................................................7-17
Radio Frequency Identication.......................7-17
Programmable Automatic Door Locks.................2-12
R
Radio Frequency Identication (RFID),
Privacy......................................................7-17
Radio(s)........................................................3-95
Radios
Reception.................................................3-116
Setting the Clock.........................................3-95
Theft-Deterrent..........................................3-115
Rear Assist Handle Reading Lamps...................3-21
Rear Door Security Locks................................2-12
Rearview Mirror with OnStar
®...........................2-38
Rearview Mirrors.............................................2-38
Reclining Seatbacks.......................................... 1-5
Recommended Fluids and Lubricants.................6-12
Recreational Vehicle Towing.............................4-27
Remote Keyless Entry (RKE) System.................. 2-3
Remote Keyless Entry (RKE) System,
Operation..................................................... 2-4
Remote Vehicle Start........................................ 2-7
Removing the Flat Tire and Installing
the Spare Tire...........................................5-100
10

Service, Scheduling Appointments....................... 7-9
Servicing Your Airbag-Equipped Vehicle..............1-64
Setting the Clock............................................3-95
Sheet Metal Damage.....................................5-117
Shifting Into Park (P).......................................2-34
Shifting Out of Park (P)...................................2-35
Signals, Turn and Lane-Change.......................... 3-8
Spare Tire
Compact...................................................5-109
Installing...................................................5-100
Removing...................................................5-98
Storing.....................................................5-107
Specications, Capacities...............................5-128
Speedometer..................................................3-40
Split Folding Rear Seat..................................... 1-9
Stabilitrak
®Plus System.................................... 4-8
Start Vehicle, Remote....................................... 2-7
Starting the Engine.........................................2-25
Steering........................................................4-10
Steering Wheel Controls, Audio.......................3-115
Steering Wheel, Tilt Wheel................................. 3-7
Storage Areas
Center Console Storage Area........................2-44
Convenience Net.........................................2-44
Cupholder(s)...............................................2-43
Glove Box..................................................2-43
Sunglasses Storage Compartment..................2-44Stuck in Sand, Mud, Ice, or Snow.....................4-21
Sun Visors.....................................................2-18
Sunroof.........................................................2-44
T
Tachometer....................................................3-40
Taillamps
Turn Signal, and Stoplamps..........................5-58
TCS Warning Light..........................................3-47
Theft-Deterrent, Radio....................................3-115
Theft-Deterrent Systems...................................2-18
Content Theft-Deterrent................................2-18
PASS-Key
®III Electronic Immobilizer..............2-20
PASS-Key®III Operation..............................2-21
Tilt Wheel........................................................ 3-7
Time, Setting..................................................3-95
Tire
Pressure Light.............................................3-49
Tires.............................................................5-62
Aluminum Wheels, Cleaning........................5-116
Buying New Tires........................................5-78
Chains.......................................................5-84
Changing a Flat Tire....................................5-96
Cleaning...................................................5-117
Compact Spare Tire...................................5-109
12