manual transmission PONTIAC GTO 2004 User Guide

Jump Starting
If your battery has run down, you may want to use
another vehicle and some jumper cables to start your
vehicle. Be sure to follow the steps below to do it safely.
{CAUTION:
Batteries can hurt you. They can be dangerous
because:
They contain acid that can burn you.
They contain gas that can explode
or ignite.
They contain enough electricity to
burn you.
If you do not follow these steps exactly, some
or all of these things can hurt you.Notice:Ignoring these steps could result in costly
damage to your vehicle that would not be covered
by your warranty.
Trying to start your vehicle by pushing or pulling it
will not work, and it could damage your vehicle.
1. Check the other vehicle. It must have a 12-volt
battery with a negative ground system. Remove
any battery covers.
Notice:If the other vehicle’s system is not a 12-volt
system with a negative ground, both vehicles can
be damaged. Only use vehicles with 12-volt systems
with negative grounds to jump start your vehicle.
2. Get the vehicles close enough so the jumper cables
can reach, but be sure the vehicles aren’t touching
each other. If they are, it could cause a ground
connection you don’t want. You wouldn’t be able to
start your vehicle, and the bad grounding could
damage the electrical systems.
To avoid the possibility of the vehicles rolling, set
the parking brake firmly on both vehicles involved in
the jump start procedure. Put an automatic
transmission in PARK (P) or a manual transmission
in Neutral before setting the parking brake.
5-42

Changing a Flat Tire
If a tire goes flat, avoid further tire and wheel damage
by driving slowly to a level place. Turn on your
hazard warning flashers.
{CAUTION:
Changing a tire can be dangerous. The vehicle
can slip off the jack and roll over or fall on you
or other people. You and they could be badly
injured or even killed. Find a level place to
change your tire. To help prevent the vehicle
from moving:
1. Set the parking brake rmly.
2. Put an automatic transmission shift lever
in PARK (P), or shift a manual
transmission to FIRST (1) or
REVERSE (R).
3. Turn off the engine and do not restart
while the vehicle is raised.
4. Do not allow passengers to remain in the
vehicle.
CAUTION: (Continued)
CAUTION: (Continued)
Put the wheel blocks at the front and rear of
the tire farthest away from the one being
changed. That would be the tire on the other
side, at the opposite end of the vehicle.
The following steps will tell you how to use the jack and
change a tire.
5-71

Capacities and Specications
The following approximate capacities are given in English and metric conversions.
Please refer toRecommended Fluids and Lubricants on page 6-13for more information.
Capacities and Specications
ApplicationCapacities
English Metric
Air Conditioning Refrigerant R134a 1.8 lbs 0.8 kg
Automatic Transmission (Drain and Refill) 5.3 quarts 5.0 L
Cooling System 15.1 quarts 14.3 L
Engine Oil with Filter (Drain and Refill) 6.5 quarts 6.2 L
Fuel Tank 18.5 gallons 70.0 L
Manual Transmission 4.6 quarts 4.4 L
Rear Axle Fluid 1.7 quarts 1.6 L
Wheel Nut Torque 74–92 lb ft 100–125Y
All capacities are approximate. When adding, be sure to fill to the appropriate level, as recommended in this
manual. Recheck fluid level after filling
Engine Specications
Engine VIN Code Transmission Spark Plug Gap
LS1 V8 G Automatic/Manual 0.040 inches (1.0 mm)
5-92

Automatic Transmission Shift Lock
Control System Check
{CAUTION:
When you are doing this inspection, the
vehicle could move suddenly. If the vehicle
moves, you or others could be injured.
1. Before you start, be sure you have enough room
around the vehicle. It should be parked on a level
surface.
2. Firmly apply the parking brake. SeeParking Brake
on page 2-23if necessary.
Be ready to apply the regular brake immediately if
the vehicle begins to move.
3. With the engine off, turn the key to the ON position,
but do not start the engine. Without applying the
regular brake, try to move the shift lever out
of PARK (P) with normal effort. If the shift lever
moves out of PARK (P), contact your GM
Goodwrench dealer for service.
Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to LOCK in each shift lever position.
•With an automatic transmission, the key should turn
to LOCK only when the shift lever is in PARK (P).
The key should come out only in LOCK.
•With a manual transmission, the key should turn to
LOCK only when the shift lever is in reverse. The
key should come out only in LOCK.
Contact your GM Goodwrench dealer if service is
required.
6-11

Recommended Fluids and
Lubricants
Fluids and lubricants identified below by name, part
number or specification may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets GM
Standard GM6094M and displays
the American Petroleum Institute
Certified for Gasoline Engines
starburst symbol. To determine the
proper viscosity for your vehicle’s
engine, seeEngine Oil on
page 5-13.
Engine Coolant50/50 mixture of clean, drinkable
water and use only
DEX-COOL
®Coolant. SeeEngine
Coolant on page 5-25.
Hydraulic Brake
SystemHydraulic Brake Fluid. Use only
GM Part No. U.S. 88958860, in
Canada 88901244, Super DOT-4
brake fluid.
Usage Fluid/Lubricant
Windshield
Washer SolventGM Optikleen
®Washer Solvent.
Hydraulic
Clutch SystemHydraulic Clutch Fluid. Use only
GM Part No. U.S. 88958860, in
Canada 88901244, Super DOT-4
brake fluid.
Parking Brake
Cable GuidesChassis Lubricant
(GM Part No. U.S. 12377985, in
Canada 88901242) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Power Steering
SystemDEXRON
®-III Automatic
Transmission Fluid.
Manual
TransmissionDEXRON
®-III Automatic
Transmission Fluid.
Automatic
TransmissionDEXRON
®-III Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
6-13

Service Publications Ordering
Information
Service Manuals
Service Manuals have the diagnosis and repair
information on engines, transmission, axle, suspension,
brakes, electrical, steering, body, etc.
RETAIL SELL PRICE: $120.00
Transmission, Transaxle, Transfer
Case Unit Repair Manual
This manual provides information on unit repair service
procedures, adjustments, and specifications for GM
transmissions, transaxles, and transfer cases.
RETAIL SELL PRICE: $50.00
Service Bulletins
Service Bulletins give technical service information
needed to knowledgeably service General Motors cars
and trucks. Each bulletin contains instructions to
assist in the diagnosis and service of your vehicle.
In Canada, information pertaining to Product Service
Bulletins can be obtained by contacting your General
Motors dealer or by calling 1-800-GM-DRIVE
(1-800-463-7483).
Owner’s Information
Owner publications are written specifically for owners
and intended to provide basic operational information
about the vehicle. The owner’s manual will include
the Maintenance Schedule for all models.
In-Portfolio: Includes a Portfolio, Owner’s Manual, and
Warranty Booklet.
RETAIL SELL PRICE: $35.00
Without Portfolio: Owner’s Manual only.
RETAIL SELL PRICE: $25.00
7-11

E
Electrical System
Add-On Equipment......................................5-87
Fuses and Circuit Breakers...........................5-87
Emergency Trunk Release Handle.....................2-10
Emissions Inspection and Maintenance
Programs...................................................3-31
Engine
Air Cleaner/Filter.........................................5-18
Battery.......................................................5-41
Change Engine Oil Light...............................3-33
Check and Service Engine Soon Light............3-29
Coolant......................................................5-25
Coolant Temperature Gage...........................3-28
Drive Belt Routing.......................................6-16
Engine Compartment Overview......................5-12
Exhaust.....................................................2-27
Oil .............................................................5-13
Overheating................................................5-28
Starting......................................................2-17
Engine Compartment Fuse Block......................5-90
Engine Oil Additives........................................5-16
Entering Programming Mode............................2-33
Entry Lighting.................................................3-15
Event Data Recorders (EDR)............................. 7-9
EXIT OPTIONS MENU....................................2-37Exiting Programming Mode...............................2-37
Express-Down Window....................................2-12
Extender, Safety Belt.......................................1-25
Exterior Lamps...............................................3-12
F
Filter
Engine Air Cleaner......................................5-18
Finding a Station............................................3-43
Finish Care....................................................5-82
Finish Damage...............................................5-84
Flash-to-Pass Feature....................................... 3-7
Flat Tire........................................................5-70
Flat Tire, Changing.........................................5-71
Fluid
Automatic Transmission................................5-19
Manual Transmission....................................5-23
Power Steering...........................................5-36
Windshield Washer......................................5-37
FM ...............................................................3-54
Fog Lamp Light..............................................3-33
Fog Lamps....................................................3-14
Front Reading Lamps......................................3-16
Front Storage Area.........................................2-31
5

Leaving Your Vehicle......................................... 2-7
Leaving Your Vehicle With the Engine
Running.....................................................2-25
Light
Air Bag Readiness.......................................3-26
Anti-Lock Brake System Warning...................3-28
Brake System Warning.................................3-27
Change Engine Oil......................................3-33
Charging System.........................................3-27
Daytime Running Lamps Indicator..................3-34
Fog Lamp..................................................3-33
Highbeam On.............................................3-33
Malfunction Indicator....................................3-29
Oil Pressure...............................................3-32
Safety Belt Reminder...................................3-25
Security.....................................................3-33
Service Vehicle Soon...................................3-34
Lighted Visor Vanity Mirrors..............................2-12
Loading Your Vehicle.......................................4-30
Locks
Door........................................................... 2-6
Leaving Your Vehicle..................................... 2-7
Loss of Control...............................................4-13
Lumbar
Manual Controls............................................ 1-2M
Maintenance Schedule
Additional Required Services........................... 6-6
At Each Fuel Fill........................................... 6-9
At Least Once a Month................................6-10
At Least Once a Year..................................6-10
Introduction.................................................. 6-2
Maintenance Footnotes.................................. 6-8
Maintenance Record....................................6-17
Maintenance Requirements............................. 6-2
Normal Maintenance Replacement Parts.........6-15
Owner Checks and Services........................... 6-9
Recommended Fluids and Lubricants.............6-13
Scheduled Maintenance................................. 6-4
Using Your................................................... 6-3
Your Vehicle and the Environment................... 6-2
Malfunction Indicator Light................................3-29
Manual Lumbar Controls.................................... 1-2
Manual Transmission.......................................2-17
Fluid..........................................................5-23
Operation...................................................2-21
Mexico, Central America and Caribbean Islands/
Countries (Except Puerto Rico and U.S. Virgin
Islands) – Customer Assistance....................... 7-4
8

Mirrors
Manual Rearview Mirror................................2-29
Outside Convex Mirror.................................2-30
Outside Power Mirrors..................................2-29
MyGMLink.com................................................ 7-3
N
Navigating the Menu.......................................2-33
New Vehicle Break-In......................................2-15
Normal Maintenance Replacement Parts............6-15
O
Odometer......................................................3-36
Off-Road Recovery..........................................4-11
Oil
Change Engine Oil Light...............................3-33
Engine.......................................................5-13
Pressure Light.............................................3-32
Older Children, Restraints................................1-26
One to Four Shift Light (Manual Transmission)....2-22
Online Owner Center........................................ 7-3
Operation......................................................3-19
Operation Tips................................................3-22
Options Menu.................................................3-49
O/SPEED (Overspeed)....................................3-38
O/Speed P2 (Overspeed Presets)......................3-38
Other Warning Devices...................................... 3-4Outlet Adjustment............................................3-22
Outside
Convex Mirror.............................................2-30
Power Mirrors.............................................2-29
Overseas – Customer Assistance........................ 7-4
Owner Checks and Services.............................. 6-9
Owner’s Information........................................7-11
P
Park (P)
Shifting Into................................................2-24
Shifting Out of............................................2-26
Parking
Brake........................................................2-23
Over Things That Burn.................................2-27
Your Vehicle/Key Removal............................2-26
Passing.........................................................4-12
Plan Ahead When Possible................................ 7-7
Playing a CD.................................................3-45
Playing the Radio...........................................3-43
Power
Accessory Outlets........................................3-17
Seat............................................................ 1-2
Steering Fluid.............................................5-36
Windows....................................................2-11
Power Steering................................................ 4-9
Pretensioners, Safety Belt................................1-25
9

Traction
Control System (TCS).................................... 4-8
Transmission
Fluid, Automatic...........................................5-19
Fluid, Manual..............................................5-23
Transmission Operation, Automatic....................2-18
Transmission Operation, Manual........................2-21
Transmission, Transaxle, Transfer Case Unit
Repair Manual............................................7-11
Transportation Options...................................... 7-7
Trip A/B .........................................................3-40
Trip Computer................................................3-36
TRIP COMPUTER A & B.................................2-34
Trip Computer Notes:......................................3-40
Trip Computer Warning Messages.....................3-41
Trip Distance..................................................3-37
TRIP TIME....................................................3-37
Trunk.............................................................. 2-8
Trunk Lamp...................................................3-16
Trunk Lock...................................................... 2-8
Turn and Lane-Change Signals.......................... 3-6
Turn Signal/Multifunction Lever........................... 3-5
TWO STAGE UNLOCK....................................2-36U
UNDERSPEED CHIME....................................2-34
Underspeed Chime.........................................3-38
Understanding Radio Reception........................3-54
Uniform Tire Quality Grading............................5-66
United States – Customer Assistance.................. 7-4
Used Replacement Wheels..............................5-69
Using Cleaner on Fabric..................................5-79
V
Vehicle
Control........................................................ 4-5
Damage Warnings........................................... iv
Loading......................................................4-30
Parking Your...............................................2-26
Service Soon Light......................................3-34
Symbols......................................................... iv
Vehicle Data Collection and Event Data
Recorders.................................................... 7-9
Vehicle Identification
Number (VIN).............................................5-86
Service Parts Identification Label...................5-86
Vehicle Personalization....................................2-32
Vehicle Storage..............................................5-41
Ventilation Adjustment......................................3-22
Visors...........................................................2-12
13