light PONTIAC PONTIAC 1996 Repair Manual

Don't use any of these unless this manual says you can.
In many uses, these will damage your vehicle:
Alcohol
Laundry Soap
Bleach
If a ring forms after spot cleaning, clean the entire
area immediately or it will set.

Using Foam-Type Cleaner on Fabric
..
1. Vacuum and brush the area to remove any
loose dirt.
Reducing Agents 2. Always clean a whole trim panel or section. Mask
Cleaning the Inside of Your Pontiac
surrounding trim along stitch or welt lines.
3. Mix Multi-Purpose Powdered Cleaner following
4. Use suds only and apply with a clean sponge.
5. Don't saturate the material.
Use a vacuum cleaner often
to get
.rid of dust and loose the directions on the container label.
dirt. Wipe vinyl or leather with a clean, damp cloth.
Your Pontiac dealer has
two GM cleaners, a
solvent-type spot lifter and
a foam-type powdered
cleaner. They will clean normal spots and stains very
6. Don't rub it roughly. I , ,, ' . - ,;,: ~ .-.,<~, . ., ', 1 . ',-'.: ;,I>< ' y. +?;= :=
well. Do not use them on vinyl or leather.
Here are some cleaning tips:
to remove the suds.
Always read the'instructions on the cleaner label.' 8. Rinse the section with a clean, wet sponge.
~ - ; :i e,, '9 I ;i' I . -~ - . . -7 ..
7. As soon as you've cleaned the section, use a sponge ,< . .. .h
Clean up stains as soon as you can -- before they set. 9. Wipe off what's left with a slightly damp paper
Use a clean cloth or sponge, and change to a
clean area often.
A soft brush may be used if stains 10. Then dry it immediately with a blow dryer.
are stubborn. towel
or cloth.
11. Wipe with
a clean cloth.
Use solvent-type cleaners in a well-ventilated area
only. If you use them, don't saturate the stained area. ." , 7 I. ... : * -4..y> .
, ,.it. i , ' I: :.I ..' k.,
c57
ProCarManuals.com

Using Solvent-Qpe Cleaner on Fabric
First, see if you have to use solvent-type cleaner at all.
Some.spots
and stains will clean off better with just
water
and miId soap.
If you need to use a solvent:
Gently scrape excess soil from.the trim material with
a clean, dull knife or scraper. Use very little 'cleaner,
light pressure and clean cloths (preferably
cheesecloth). Cleaning should start at the outside of
the stain, "feathering" toward the center. Keep
changing,to
a ,. clean section of the cloth.
When you clean a stain from fabric, immediately
dry the area with a blow dryer to help prevent a
cleaning ring.
SpeciaI Cleaning Problem
Greasy ar Oily Stab
Stains caused by grease, oil, butter, margarine, shoe
polish, coffee with cream, chewing gum,-cosmetic
I
creams, vegetable oils, wax crayon, tar and asphalt can
be removed
as follows:
1. Carefully scrape off excess stain.'
2., Follow the solvent-type instructions described earlier.
3. Shoe polish, wax crayon, tar and asphalt will stain if
left on a vehicle's seat fabric. They should be removed
as soon as possible. Be careful, because the cleaner
will dissolve them and may cause ,them to spread.
Non-Greasy Stains
Stains caused by catsup, coffee (black), egg, fruit, fruit
juice,
milk, soft drinks, wine, vomit, urine and blood can
be removed as follows:
1. Carefully scrape off excess stain, then sponge the
2. If a stain remains, follow the foam-type instructions
described earlier.
3. If an odor lingers after cleaning vomit or urine,
treat
the area with a waterhaking soda solution:
1 teaspoon (5 ml) of baking soda to 1 cup (250 ml)
soiled
area with cool water. of lukewarm wate~:~,.'-~~"':~-r-'~!,: - .C \ . ...' E% 7:- 3-b: .-,3-. , . .' *'
4. Lf needed, clean lightly with solvent-type cleaner.
Combination. Stains
Stains caused by candy,'ice,cream, mayonnaise, chili
sauce and unknown stains can be removed as follows:
Carefully scrape off excess stain, then clean with
0 If a stain remains, clean it with solvent-type cleaner.
cool water and allow to dry.
6-58
ProCarManuals.com

Circuit Description
Breaker
c Power Windows
D Power Seats
Fuse
1
3
4
5
6
7
10
11
12
13
14
Description
CIGARETTE LIGHTER --' Instrument
Panel Cigarette Lighter
DRL MDL
HVAC
#2 -- €WAC Control Assembly
Solenoid
Box
HAZARD FLASHER
POWER ACCESSORY
#2 -- Sunroof Control Unit
LOCK CONTROL
-- Door
Lock Relay
I/P ELECTRONICS BATTERY
FEED -- Chime Module, Ele'ctronic ,
Brake Control Module (EBCM),
Theft-Deterrent Module, Radio,
Radio Amplifier, Trip Computer
STARTER RELAY
ANTI-THEFT -- Theft-Deterrent
Module
ABS -- Electronic Brake Control
Module
(EBCM), ABS Relay
HVAC
BLOWER MOTOR -- Blower
Motor Relay
-. . 2. , . ,I .. .- , 7.2: ' I- ...,.
ProCarManuals.com

Fuse
15
Description
HVAC #I -- Air Temperature Valve
Motor, Trip Computer, Daytime Running
Lamps (DRL) Module, HVAC Control
Assembly, Multifunction Lever Cruise
Control Switch
16 REAR DEFOG. -- HVAC Control
Assembly Rear Window
Defogger Switch
19 POWER ACCESSORY
#1 -- Antenna Relay, Power Mirror
Switch, Door Lock Switches, Door
Handle Switches
21 AIR BAG
-- Air Bag System
23 STOPLAMPS
-- TCCBrake Switch
, 24 CRUISE CONTROL
I 28 CTSY LAMPS -- Vanity Mirrors,
I/P Courtesy Lamps, UP Compartment
Lamp, Trunk Courtesy Lamp, Header Courtesy and Reading Lamp,
US Lighted
Rearview Mirror, Dome and Reading
Lamp, Quarter Courtesy Lamps
Fuse Description
29 WIPER -- Wiper Switch
30 TURN SIGNAL -- Turn Signal Flasher
32 POWER LOCKS -- Door Lock Relay
38 RADIO -- Radio, Steering Wheel
39 I/P ELECTRONICS IGNITION
37 ' AUXILIARY POWER
Radio Switches
FEED
-- Headlamp Switch, Cruise
Control Cut-Out Switch, Air Bag System, TCC/Brake Switch, Instrument
Cluster, Chime. Module, Second-Gear
Start Switch, Head-Up Display (HUD)
Switch, Daytime Running
Lamps (Dm) Module
ProCarManuals.com

Replacement Bulbs
Back-up ............................... 3057
Roof-Mountd ....................... 891T2
Exterior Lamps Bulb Number
Center High-Mounted Stoplamp
Shelf-Mounted
........................ 2355 . Fog
2-Door Models ................. H3 (GTP 880)
4-Door Models ......................... 88 1
2-Door Models
...................... 3 157NA
4-Door Models
......................... 889
2-Door Models .................... H4352 (U)
4-Door Models
........................ 9005
Front Parking/Turn Signal
Headlamp. High-Beam
Exterior Lamps Bulb Number
Headlamp. Low-B'eam
2-Door Models
............... ... H4351 (L)
4-Door Models ............... ....... 9006
Headlamp. Auxiliary ...................... 193
License Plate
............................ 194
Light Bar. Front ......................... 3057
Sidemarker. Front
Light Bar Panel. Rear
...................... 194
2-Door Models
.......................... 24
4-Door
Models ........................ 24NA
Sidemarker. Rear ......................... 194
Stop/Tail/Turn Signal
..................... 3057
ProCarManuals.com

At Least Twice a Year
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages are
working properly. Look for any other loose or damaged
safety belt system parts. If you see anything that might
keep a safety belt.system from doing its job, have it
repaired. Have any torn
or frayed safety belts replaced.
Also look for any opened or broken
air bag covers, and
have them repaired or replaced. (The air bag system
does not need regular maintenance.)
Automatic Transaxle Check
Check the transaxle fluid level; add if needed. See
“Automatic Transaxle” in the Index. A fluid
loss
may indicate a problem. Check the system and repair
if needed.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
specified in
Part D.
Body Lubrication Service
Lubricate all hinges and latches, including those for the
hood, rear compartment, glove box door, console door
and any folding seat hardware.
Part D tells you what to
use. More frequent lubrication may be required when
exposed to
a corrosive environment.
ProCarManuals.com

. Section 9 Index
Access Panel. ~mnk .... ...................... 2-39
Accessory Outlet
............................... 2-42
AirBag
....................................... 1-23
How Does it Restrain
.......................... 1-27
How it Works
................................ -1-25
Location
............................... 1.25. 1-26
Readiness Light
.......................... 1.25. 2.47
Servicing
................................... 1-29
What Makes it Inflate .......................... 1-27
What Will
You See After it Inflates ............... 1-28
When Should it Inflate
......................... 1-27
Aircleaner
.................................... 6-16
Airconditioning
................................ 3-2
Air Conditioning Refrigerants ..................... 6-75
Alignment and Balance, Tire
...................... 6-54
Aluminum Wheels, Cleaning
...................... 6-61
Antenna. Power
........... .. ....... 3-24
Antifreeze
................ ......... 6-20
Anti-Lock
Brake System Active Light
. . ........ 2-50, 4-8
Brakes
...................................... 4-6
Anti-Theft, Radio
.............................. 3- 19
Brake System Warning Light
.............. '2-49, 4-7
Appear~~~~Care ............................... 6-56 Appearance
Care Materials
....................... 6-63
Arbitration Program .............................. 8-8
Armrest. Storage ............................... 2-38
Ashtrays ...................................... 2-40
Audio Controls. Steering Wheel Touch Control
....... 3-21
Audio Equipment. Adding
........................ 3-22
Audio Systems
.................................. 3-5
Auto-Down Window ............................ 2-25
Automatic
Door Locks ............................. 2-4
Automatic Transaxle Check
........... .................... 7-37
Fluid
........................... ........ 6-17
Operation
.... i .............................. 2-14
Park Mechanism Check
......................... 7-39
Battery ...................................... 6-30
Jump Starting ................................. 5-2
Replacement. Remote Lock Control
............... 2-6
Saver
...................................... 2.36
Warnings
................................ 5.2. 5.4
BBB Auto Line ................................. 8-8
Better Business Bureau Mediation
................... 8-8
9-1
I ....... 1 ... I ..-- .~ ............. - ProCarManuals.com

Brake
Adjustment .................................. 6-2 9
Fluid
......................................... 6-26
Master Cylinder
............................... 6-26
Paikhg ..................................... 2-18
Pedal Travel
................................. 6-29
'Replacing System Parts
........................ 6-30
System Warning Light
......................... 2-48
Trailer
...................................... 4-34
Transaxle Shift Interlock Check
.................. 7-38
Transaxle Shift Interlock
....................... 2-22
. Wear ..............................,........ 6-29
Braking
........................................ 4-5
Break-In. New Vehicle .......................... 2-10
Brightness Control
.............................. 2-34
Bulb Replacement .............................. 6-3 1
Brakes,Anti
-Lock
............................... 4-6
Braking in Emergencies ..................... ..... 4-9
BTSI .......................................... 2-22
BTSICheck
................................... 7-38
Canadian Roadside Assistance
.................... 8-5
Capacities and Specifications ...................... 6-73
Carbon Monoxide
.................... 2.23.4.27. 4.33
Cassette Deck SerGice ........................... 7-36
Cassette Tape Player
........................ 3.7. 3.11
Cassette Tape
Player Care ........................ 3-23
CD Player Theft-Deterrent Feature
................. 3- 19
Center Passenger
Position ........................ 1-34
Cassette Tape Player Fxr~rs .......... .. ...... 3-9
Center High-Mounted Stoplamp .............. 6-44. 6-45 Certification Label
.............................. 4-29
Chains. Safety ................................. 4-34
Chains. Tire ................................... 6-56
Charging System Light
.......................... 2-47
Checking Your Restraint Systems
.................. 1-62
Chemical
Pahit Spotting ................. ' ......... 6-62 .
Child Restraints ................................ 1-44
Securing in a Rear Outside Seat Position
........... 1-46
Securing in the Center Rear Seat Position
.......... 1-48
Changing
a Flat Tire ............................. 5-23
Securing
in the Passenger Seat Positilon ...... 1-50. 1-53
Securing in the Right Front Seat Position
..... 1-50. 1-53
TopStrap
................................... l-45
Where to Put ................................ 1-44'
Cigarette Lighter
.................. ......... 2-41
Circuit Breakers and
Fuses ....................... 6-65
Cleaner. Air ................................... 6-16
Cleaning Aluminum Wheels
.......................... 6-61
. Fabric .......................... ......... 6-57
Glass
....................................... 6-59
InsideofYourPontiac
......................... 6-57
InstrumentPanel
............................. 6-59
Leather ...................................... 6-59
Outside
of Your Pontiac ......................... 6-60
Stains ...................................... 6-57
Tires
....................................... 6-62
Wheels
..................................... 6-61
Climate Control System
............................ 3-1
Special Problems ............................. 6-58
Vinyl ....................................... 6-59
Windshield and Wiper Blades ................... 6-60
9-2
ProCarManuals.com

Engine .................................... 6.8. 6.9
Coolant ..................................... 6-20
Coolant Heater ............................... 2-13
Coolant Level Check .......................... 7-36
Cmhzt Temperatere Gage ..................... 2-5 1
Coolant Temperature Light ..................... 2-50
Exhaust ..................................... 2-23
Identification ................................ 6#-64
Overheating ................................. 5-12
Specifications ................................ 6-74
Starting Your ................................ 2- 11
Adding
..................................... 6-11
Additives ................................ ; .. 6-14
Checking ................................... 6-11
LevelCheck ................................. 7-36
Used ....................................... 6-15
Whentochange .............................. 6-15
Ew~l 6-3 Exhaust, Engine ................................ 2-23
Fan Knob, Climate Control System .................. 3-1
Filter, Engine Oil ............................... 6- 15
First Gear, Automatic Transaxle ................... 2-17
Flashers, Hazard Warning ......................... 5-1
FlatTue, Changing ............................. 5-23 Fluids and Lubricants ............................. 7-41
Fog Lamp Bulb Replacement ................ 6-42, 6-43
Fog Lamps ..................................... 2-33
Running While Parked ......................... 2-24
........................................
Fabric Cleaning ............................... 6-57
FillingYourTank
................................ 6-4
Filter, Air ..................................... 6-16
Finishcare ..................................... 6-61
FinishDmage
................................. 6-62
Foreign Countries. Fuel ......................... 6-4
French Language Manual ........................... ii
Front Lamp
Bar Bulb Replacement ................. 6-38
Front Sidemarker Bulb Replacement ................ 6-40
Front Turn Signal Bulb Replacement ................ 6-40
FrontTowing ................................... 5-9
Fuel .......................................... 6-2
Filling Your Tank ............................... 6-4
Gage ....................................... 2-56
Canadian .................................... 6-3
In Foreign Countries ........................... 6-4
Fuses and Circuit Breakers ..................... 6-65
bages
Engine Coolant Temperature ................ 2-51
Fuel
....................................... 2-56
GAM ....................................... 4-29
Gear Positions, Automatic Transaxle ................ 2-14
Gross Axle Weight Rating ........................ 4-29
Gross Vehicle Weight Ratmg ...................... 4-29
Guide en Francpis .................. ............ ii
GVWR
......................... ....... 4-29
Hazard Warning Flashers .......................... 5-1
Headlamps ..................................... 2-32
Bulb Replacement ........................ 6-31 6-34
High/Low Beam Changer ...................... 2-27
Wiring ..................................... 6-65
GloveBox .................................... 2-38
Halogen Bulbs ................................ 6-31
HeadRestraints ................................. 1-5
Aiming ..................................... 6-35
OnReminder ................................. 2-32
9-4 --
ProCarManuals.com

Head-Up Display ............................. 2-58
Hearing Impaired. Customer Assistance
.............. 8-4
Heating
........................................ 3-3
High-Beam Headlamps
.......................... 2-27
Highway Hypnosis
.............................. 4-22
Hill and Mountain Roads
......................... 4-22
Hitches. Trailer
................................. 4-33
Hood Checking Things Under
......................... 6-6
Release
.................................... 6-7
Horn
.................. .................. 2-25
HUD .................. .................. 2-58
Hydroplaning
........... .................. 4-18
Ignition Positions
.............................. 2- 10
Inflation, Tire .................................. 6-49
Inside Daymight Rearview Mirror
.................. 2-37
Inspections Brakesystem
................................ 7- 40
Exhaust Systems
............................. 7-40
Front-Wheel-Drive Axle Boot
.................. 7-40
Front-Wheel-Drive Axle Seal
................... 7-40
Radiator and Heater Hose
...................... 7-40
Steering
.................................... 7-40
Suspension
.................................. 7-40
Throttle Linkage
.............................. 7-40
Instrumentpanel
............................... 2-43
Brightness Control
............................ 2-34
Cleaning
.................................... 6-59
Cluster
..................................... 2-44
FuseBlock
.................................. 6-65
Interior Lamps ................................. 2-34 Jack. Tire
..... ... ..... 5-23
Jump Starting
... ................ 5-2
Key Lock Cylinders Service ..................... 7-37
Key Reminder Warning
.......................... 2-11
Keys
.......................................... 2-1
Labels Certification
................................. 4-29
Service Parts Identification
..................... 6-64
Tire-Loading Information
...................... 4-28
Vehicle Identification Number
................... 6-64
Lamps
........................................ 2-32
Courtesy
..................................... 2-34
Dome
...................................... 2-36
Interior
..................................... 2-34
OnReminder
................................ 2-32
Sustained Interior Illumination
.................. 2-34
Latches. Seatback ................................ 1-5
Leaving Your Vehicle
............................. 2-4
Leaving Your Vehicle With the Engine Running
....... 2-21
Lighter
....................................... 2-41
Lights
Air Bag Readiness
....................... 1-25. 2.47
Anti-Lock Brake System Active
............. 2.50. 4.8
Anti-Lock Brake System Warning
............ 2.49. 4.7
Brake System Warning
......................... 2-48
Charging System
............................. 2-47
Engine Coolant Temperature
.................... 2-50
Interior
..................................... 2-34
Low Coolant Warning
......................... 2-51
LowFuel
................................... 2-57
9-5
. . ProCarManuals.com