engine PONTIAC VIBE 2009 Owners Manual

150,000 Miles (240 000 km)
❑Drain, ush, and rell the cooling
system (or every 5 years,
whichever occurs rst).
This service can be complex;
you should have your dealer/
retailer perform this service.
SeeEngine Coolant on page 9-18
for what to use. Inspect hoses.
Clean radiator, condenser,
pressure cap, and neck. Pressure
test cooling system and pressure
cap.An Emission Control Service.
Part B: Owner Checks
and Services
These owner checks and services
should be performed at the intervals
specied to help ensure vehicle
safety, dependability, and emission
control performance.
Be sure any necessary repairs are
completed at once. Whenever
any uids or lubricants are added to
the vehicle, make sure they are
the proper ones, as shown in Part D.
At Each Fuel Fill
It is important to perform these
underhood checks at each fuel fill.
Engine Oil Level Check
Notice:It is important to check
the engine oil regularly and keep it
at the proper level. Failure to keep
the engine oil at the proper level
can cause damage to the engine
not covered by the vehicle
warranty.Check the engine oil level and add
the proper oil if necessary. See
Engine Oil on page 9-9.
Engine Coolant Level Check
Check the engine coolant level
and add DEX-COOL®coolant
mixture if necessary. SeeEngine
Coolant on page 9-18.
Windshield Washer Fluid
Level Check
Check the windshield washer uid
level in the windshield washer
uid reservoir and add the proper
uid if necessary. SeeWindshield
Washer Fluid on page 9-24.
Hood Latch Operation Check
Pull the primary hood latch release
handle inside the vehicle. The
secondary latch should keep the
hood from opening all the way when
the primary latch is released. Make
sure the hood closes rmly.
SeeHood Release on page 9-5.
11-12 Service and Maintenance
2009 - Pontiac Vibe Owner Manual

Starter Switch Check
{CAUTION
When you are doing this
inspection, the vehicle could move
suddenly. If the vehicle moves,
you or others could be injured.
1. Before starting this check, be
sure there is enough room
around the vehicle.
2. Firmly apply both the parking
brake and the regular brake.
SeeParking Brake on page 8-12.
Do not use the accelerator
pedal, and be ready to turn off
the engine immediately if it starts.3. For automatic transmission
vehicles, try to start the engine in
each gear. The vehicle should
start only in P (Park) or
N (Neutral). If the vehicle starts
in any other position, contact
your dealer/retailer for service.
For manual transmission
vehicles, put the shift lever
in Neutral, push the clutch pedal
down halfway, and try to start
the engine. The vehicle should
start only when the clutch
pedal is pushed down all the
way to the oor. If the vehicle
starts when the clutch pedal
is not pushed all the way down,
contact your dealer/retailer
for service.
Automatic Transmission Shift
Lock Control System Check
{CAUTION
When you are doing this
inspection, the vehicle could move
suddenly. If the vehicle moves,
you or others could be injured.
1. Before starting this check, be
sure there is enough room
around the vehicle. It should be
parked on a level surface.
2. Firmly apply the parking brake.
SeeParking Brake on page 8-12.
Be ready to apply the regular
brake immediately if the vehicle
begins to move.
3. With the engine off, turn the
ignition to ON/RUN, but do
not start the engine. Without
applying the regular brake,
try to move the shift lever out
of P (Park) with normal effort.
If the shift lever moves out
of P (Park), contact your
dealer/retailer for service.
11-14 Service and Maintenance
2009 - Pontiac Vibe Owner Manual

Ignition Transmission Lock
Check
While parked, and with the parking
brake set, try to turn the ignition
to LOCK/OFF in each shift lever
position.
For automatic transmission
vehicles, the ignition should turn
to LOCK/OFF only when the shift
lever is in P (Park).
For manual transmission vehicles,
the ignition should turn to LOCK/
OFF only if you push the ignition
key in farther, while turning it
toward LOCK/OFF.
Contact your dealer/retailer if
service is required.
Parking Brake and Automatic
Transmission P (Park)
Mechanism Check
{CAUTION
When you are doing this check,
the vehicle could begin to move.
You or others could be injured
and property could be damaged.
Make sure there is room in front
of the vehicle in case it begins to
roll. Be ready to apply the regular
brake at once should the vehicle
begin to move.
Park on a fairly steep hill, with the
vehicle facing downhill. Keeping
your foot on the regular brake,
set the parking brake.
To check the parking brake’s
holding ability: With the engine
running and transmission in
N (Neutral), slowly remove foot
pressure from the regular
brake pedal. Do this until the
vehicle is held by the parking
brake only.
To check the P (Park)
mechanism’s holding ability:
With the engine running, shift to
P (Park). Then release the
parking brake followed by the
regular brake.
Contact your dealer/retailer if
service is required.
Underbody Flushing Service
At least every spring, use plain
water to ush any corrosive
materials from the underbody.
Take care to clean thoroughly
any areas where mud and other
debris can collect.
Service and Maintenance 11-15
2009 - Pontiac Vibe Owner Manual

Part C: Periodic
Maintenance Inspections
Listed in this part are inspections
and services which should be
performed at least twice a year,
for instance, each spring and fall.
You should let your dealer/retailer
do these jobs. Make sure any
necessary repairs are completed
at once.
Proper procedures to perform these
services can be found in a service
manual. SeeService Publications
Ordering Information on page 12-16.
Steering, Suspension
and Front Drive Axle
Boot and Seal Inspection
Inspect the front and rear
suspension and steering system for
damaged, loose, or missing parts
or signs of wear. Inspect power
steering cables for proper hook-up,
binding, cracks, chang, etc.
Clean and then inspect the drive
axle boot seals for damage,
tears, or leakage. Replace seals
if necessary.
Exhaust System
Inspection
Inspect the complete exhaust
system. Inspect the body near the
exhaust system. Look for broken,
damaged, missing, or out-of-position
parts as well as open seams, holes,
loose connections, or other
conditions which could cause a heat
build-up in the oor pan or could
let exhaust fumes into the vehicle.
SeeEngine Exhaust on page 8-16.
Fuel System Inspection
Inspect the complete fuel system for
damage or leaks.
11-16 Service and Maintenance
2009 - Pontiac Vibe Owner Manual

Engine Cooling System
Inspection
Inspect the hoses and have them
replaced if they are cracked, swollen
or deteriorated. Inspect all pipes,
ttings and clamps; replace as
needed. Clean the outside of the
radiator and air conditioning
condenser. To help ensure proper
operation, a pressure test of
the cooling system and pressure
cap is recommended at least once
a year.
Throttle System
Inspection
Inspect the throttle system for
interference or binding, and for
damaged or missing parts.
Replace parts as needed.
Replace any components that
have high effort or excessive wear.
Do not lubricate accelerator and
cruise control cables.
Brake System Inspection
Inspect the complete system.
Inspect brake lines and hoses for
proper hook-up, binding, leaks,
cracks, chang, etc. Inspect disc
brake pads for wear and rotors for
surface condition. Inspect other
brake parts, including calipers,
parking brake, etc. You may need
to have your brakes inspected more
often if your driving habits or
conditions result in frequent braking.
Service and Maintenance 11-17
2009 - Pontiac Vibe Owner Manual

Part D: Recommended Fluids and Lubricants
Fluids and lubricants identied below by name, part number, or specication can be obtained from your
dealer/retailer.
UsageFluid/Lubricant
Engine Oil Engine oil which meets GM Standard GM6094M and displays the
American Petroleum Institute Certied for Gasoline Engines starburst
symbol. To determine the proper viscosity for your vehicle’s engine,
see
Engine Oil on page 9-9 .
Engine Coolant 50/50 mixture of clean, drinkable water and use only DEX-COOL
®
Coolant. See
Engine Coolant on page 9-18 .
Hydraulic Brake/Clutch System Delco
®Supreme 11 Brake Fluid or equivalent DOT-3 brake uid.
Windshield Washer Solvent Optikleen
®Washer Solvent.
Manual Transmission GM Goodwrench
®Synthetic Manual Transmission Fluid
(GM Part No. U.S. 12346190, in Canada 10953477 — 1 quart) or
SAE 75W-90 GL-5 gear oil.
Automatic Transmission Use only T-IV Automatic Transmission Fluid (GM Part No. U.S. 88900925,
in Canada 22689186).
Key Lock Cylinders Multi-Purpose Lubricant, Superlube (GM Part No. U.S. 12346241,
in Canada 10953474).
Manual Transmission Shift Linkage Chassis Lubricant (GM Part No. U.S. 12377985, in Canada 88901242) or
lubricant meeting requirements of NLGI #2, Category LB or GC-LB.
11-18 Service and Maintenance
2009 - Pontiac Vibe Owner Manual

Reporting Safety Defects
to General Motors
In addition to notifying NHTSA
(or Transport Canada) in a
situation like this, please notify
General Motors.
Call 1-800-762-2737, or write:
Pontiac Customer Assistance Center
P.O. Box 33172
Detroit, MI 48232-5172
In Canada, call 1-800-263-3777
(English) or 1-800-263-7854
(French), or write:
General Motors of Canada Limited
Customer Communication Centre,
CA1-163-005
1908 Colonel Sam Drive
Oshawa, Ontario L1H 8P7
Service Publications
Ordering Information
Service Manuals
Service Manuals have the diagnosis
and repair information on engines,
transmission, axle suspension,
brakes, electrical, steering, body, etc.
Service Bulletins
Service Bulletins give additional
technical service information
needed to knowledgeably service
General Motors cars and trucks.
Each bulletin contains instructions
to assist in the diagnosis and service
of your vehicle.
Owner Information
Owner publications are written
specically for owners and intended
to provide basic operational
information about the vehicle.The owner manual includes the
Maintenance Schedule for all
models.
In-Portfolio: Includes a Portfolio,
Owner Manual, and Warranty
Booklet.
RETAIL SELL PRICE:
$35.00 (U.S.) plus processing fee
Without Portfolio: Owner
Manual only.
RETAIL SELL PRICE:
$25.00 (U.S.) plus processing fee
Current and Past Model
Order Forms
Technical Service Bulletins and
Manuals are available for current
and past model GM vehicles.
To request an order form, specify
year and model name of the vehicle.
12-16 Customer Information
2009 - Pontiac Vibe Owner Manual

ORDER TOLL FREE:
1-800-551-4123 Monday-Friday
8:00 AM - 6:00 PM Eastern Time
For Credit Card Orders Only
(VISA-MasterCard-Discover),
visit Helm, Inc. on the World Wide
Web at: helminc.com
Or you can write to:
Helm, Incorporated
P.O. Box 07130
Detroit, MI 48207
Prices are subject to change
without notice and without incurring
obligation. Allow ample time for
delivery.
Note to Canadian Customers:
All listed prices are quoted in
U.S. funds. Canadian residents
are to make checks payable in
U.S. funds.Vehicle Data
Recording and
Privacy
Your GM vehicle has a number of
sophisticated computers that record
information about the vehicle’s
performance and how it is driven.
For example, your vehicle uses
computer modules to monitor and
control engine and transmission
performance, to monitor the
conditions for airbag deployment
and deploy airbags in a crash and, if
so equipped, to provide antilock
braking to help the driver control
the vehicle. These modules may
store data to help your dealer/retailer
technician service your vehicle.
Some modules may also store data
about how you operate the vehicle,
such as rate of fuel consumption or
average speed. These modules
may also retain the owner’s personal
preferences, such as radio pre-sets,
seat positions, and temperature
settings.
Event Data Recorders
This vehicle has an Event Data
Recorder (EDR). The main purpose
of an EDR is to record, in certain
crash or near crash-like situations,
such as an airbag deployment
or hitting a road obstacle, data that
will assist in understanding how
a vehicle’s systems performed.
The EDR is designed to record data
related to vehicle dynamics and
safety systems for a short period
of time, typically 30 seconds or less.
The EDR in this vehicle is designed
to record such data as:
How various systems in your
vehicle were operating
Whether or not the driver and
passenger safety belts were
buckled/fastened
How far, if at all, the driver was
pressing the accelerator and/or
brake pedal
How fast the vehicle was
traveling
Customer Information 12-17
2009 - Pontiac Vibe Owner Manual

A
Accessories and
Modications...................... 9-3
Accessory Power Outlets........ 4-9
Adding Equipment to Your
Airbag-Equipped Vehicle....1-34
Additives, Fuel.....................8-37
Add-On Electrical
Equipment.......................9-35
Air Cleaner/Filter, Engine.......9-12
Air Conditioning..................... 7-1
Airbag
Passenger Status
Indicator.......................4-15
Readiness Light................4-14
System, Replacing Parts
After a Crash................1-35
Airbag System.....................1-21
Adding Equipment to
Your Airbag-Equipped
Vehicle........................1-34
Check.............................1-35
How Does an Airbag
Restrain?.....................1-26Airbag System (cont.)
Passenger Sensing
System........................1-28
Servicing Your
Airbag-Equipped
Vehicle........................1-33
What Makes an Airbag
Inate?........................1-26
What Will You See After
an Airbag Inates?........1-26
When Should an Airbag
Inate?........................1-24
Where Are the Airbags?.....1-23
All-Wheel-Drive (AWD)
System...........................8-22
All-Wheel-Drive Service
Light...............................4-24
Antenna, Fixed Mast............6-14
Antenna, XM™ Satellite
Radio Antenna System......6-14
Antilock Brake
System (ABS)..................8-20
Antilock Brake, System
Warning Light...................4-18Appearance Care
Chemical Paint Spotting.....9-90
Exterior Cleaning..............9-86
Finish Damage.................9-89
Interior Cleaning...............9-83
Sheet Metal Damage........9-89
Underbody Maintenance....9-90
Appointments, Scheduling
Service...........................12-8
Ashtray(s)...........................4-10
Audio System........................ 6-1
Audio Steering Wheel
Controls.......................6-13
Fixed Mast Antenna..........6-14
Radio Reception...............6-14
Setting the Clock................ 6-2
XM™ Satellite Radio
Antenna System............6-14
Audio System(s).................... 6-3
Automatic Headlamp System . . . 5-2
Automatic Transmission
Fluid...............................9-14
Operation....................8-6, 8-8
INDEX i-1
2009 - Pontiac Vibe Owner Manual

B
Battery...............................9-30
Run-Down Protection.......... 5-4
Brake
System Inspection...........11-17
Brake Fluid.........................9-27
Brakes...............................9-27
System Warning Light.......4-17
Braking...............................8-19
Break-In, New Vehicle............ 8-2
Bulb Replacement................9-31
Halogen Bulbs..................9-31
Headlamp Aiming..............9-30
Headlamps and Parking
Lamps .........................9-31
License Plate Lamps.........9-34
Replacement Bulbs...........9-35
Taillamps.........................9-33
Buying New Tires.................9-54
C
California Fuel.....................8-36
California Perchlorate
Materials Requirements....... 9-3
California Proposition
65 Warning........................ 9-3
Canadian Owners..................... iiCapacities and
Specications...................10-2
Carbon Monoxide.........8-16, 8-29
Care, Safety Belts................1-20
Cargo Cover......................... 3-4
Cargo Management System.... 3-6
Cargo Tie Downs................... 3-6
Cautions and Notices............... iii
CD, MP3 .............................. 6-9
Center Console Storage Area . . . 3-2
Chains, Tire........................9-60
Charging System Light..........4-16
Check
Engine Lamp...................4-20
Chemical Paint Spotting........9-90
Child Restraints
Child Restraint Systems.....1-41
Infants and Young
Children.......................1-38
Lower Anchors and Tethers
for Children..................1-44
Older Children..................1-36
Securing..................1-50, 1-53
Where to Put the
Restraint......................1-43
Cleaning
Exterior...........................9-86
Interior............................9-83
Underbody Maintenance....9-90Climate Control System.......... 7-1
Air Filter, Passenger
Compartment.................. 7-4
Outlet Adjustment............... 7-3
Clock, Setting........................ 6-2
Clutch, Hydraulic..................9-17
Collision Damage Repair.....12-11
Compact Spare Tire.............9-70
Content Theft-Deterrent.........2-10
Control of a Vehicle..............8-18
Coolant
Engine............................
9-18
Engine
Temperature Gage.........4-19
Cooling System...................9-18
Cruise Control....................... 4-4
Cruise Control Light..............4-23
Cupholders........................... 3-1
Customer Assistance
Information
Courtesy
Transportation.....12-4, 12-10
Customer Assistance
Offices.........................12-4
Customer Satisfaction
Procedure....................12-1
i-2 INDEX
2009 - Pontiac Vibe Owner Manual