oil level PORSCHE 911 GT3 2004 5.G User Guide

Maintenance,CarCare

Caution 112
Coolant Level 113
Engine Oil 114
Engine OilLevel 115
Engine OilRecommendation 117
Brake FluidLevel 119
Fuel Economy 120
Fuel Recommendations 122
Portable FuelContainers 123
Emission ControlSystem 124
Fuel Evaporation Control 126
Washer Fluid 126
Power Steering 127
Air Filter 128
Particle Filter 128
Manual Transmission Oil 128
Wiper Blades 129
Car Care Instructions 130
Maintenance, CarCare

Exercise ExtremeCautionwhen
Working onyour Vehicle

/!\
Warning!
Ignoring thefollowing instructions may
cause serious personal injury.

~ The engine compartment ofany motor vehicle
is apotentially hazardous area.Ifyou arenot
fully familiar withproper repairprocedures, do
not attempt theadjustments describedonthe
following pages.
This caution appliestothe entire vehicle.
~ Only work onyour vehicle outdoors orinawell
ventilated area.
~ Ensure thatthere arenoopen flames inthe
area ofyour vehicle atany time when fuel
fumes mightbepresent. Beespecially cau-
tious ofsuch devices suchashot water heat-
ers which igniteaflame intermittently.
~ Before working onany part inthe engine com-
partment, turntheengine offand letitcool
down sufficiently. Hotengine compartment
components canburn skinoncontact.
~ Bealert andcautious aroundengineatall
times whiletheengine isrunning.
If work hastobe performed withtheengine
running, alwayssetthe parking brake,and
make suretheshift lever isinneutral position.

1
Maintenance, CarCare ~
Inparticular, bevery careful toensure that
items ofclothing (ties,shirt, sleeves etc.),
jewelry, longhair,hand orfingers cannotget
caught inthe engine-compartment blower,fan,
belts orother moving parts.
The radiator andradiator fansareinthe front
of the car.
The engine-compartment blowerismounted
on the engine compartment lid.
The fans canstart orcontinue runningasa
function oftemperature, evenwiththeengine
switched off.
Carry outwork inthese areasonlywiththeen-
gine off,theignition switched off,and exercise
extreme caution.
~ Your Porsche isequipped withanelectronic ig-
nition system. Whentheignition ison, high
voltage ispresent inall wires connected with
the ignition system; therefore, exerciseex-
treme caution whenworking onany part ofthe
engine whiletheignition ison orthe engine is
running.
~ Always support yourcarwith safety stands ifit
is necessary towork under thecar.
~ When working underthecarwithout safety
stands butwith thewheels onthe ground,
make surethecarison level ground, the
wheels areblocked, andthat theengine
cannot bestarted.
Remove theignition key. ~
Donot smoke orallow anopen flame around
the battery orfuel.
Keep afire extinguisher inclose reach.
~ Incomplete orimproper servicingmaycause
problems inthe operation ofthe car. Ifin doubt
about anyservicing, haveitdone byyour
authorized Porschedealer.
Improper maintenance duringthewarranty
period mayaffect yourPorsche warranty cov-
erage.
~ Supplies offluids, e.g.engine oil,brake fluidor
coolant, arehazardous toyour health.
Keep these fluidsoutofchildren's reachand
dispose ofthem inaccordance withtheappro-
priate regulations.
~ Some countries requireadditional toolsand
special sparepartstobe carried.
Please makeenquiries beforedriving abroad.

Power measurements

Power measurements ondynamometers arenot
approved byPorsche.

Engine-compartment blower,
radiator fan

The radiator andradiator fansareinthe front of
the car.
The engine-compartment blowerismounted on
the engine compartment lid.

A
Warning!
Risk ofinjury.
After theengine isswitched off,theengine-
compartment andcoolant temperatures are
monitored forapprox. 20minutes.
During thisperiod, anddepending ontem-
perature, theengine-compartment blower
and radiator fansmaycontinue torun or
start torun.

t>
Carry outwork inthese areasonlywiththeen-
gine off,the ignition switched off,and exercise
extreme caution.

1
Maintenance, CarCare
Engine
Oil

Engine oilconsumption

It is normal foryour engine toconsume oil.
The rate ofoil consumption dependsonthe quality
and viscosity ofoil, the speed atwhich theengine
is operated, theclimate, roadconditions aswell
as the amount ofdilution andoxidation ofthe
lubricant.
If the vehicle isused forrepeated shorttrips, and
consumes anormal amount ofoil, the engine oil
measurement maynotshow anydrop inthe oil
level atall, even after600miles (1000 km)or
more. Thisisbecause theoilisgradually becom-
ing diluted withfuelormoisture, makingitappear
that theoillevel hasnotchanged.
The diluting ingredients evaporateoutwhen the
vehicle isdriven athigh speeds, ason anexpress-
way, making itthen appear thatoilisexcessively
consumed afterdriving athigh speeds.
If the conditions youdrive yourvehicle inare
dusty, humid, orhot, thefrequency ofthe oil
change intervals shouldbegreater. If
the vehicle isdriven atahigh rateofspeed,
climatic conditions arewarm, andtheload ishigh,
the oilshould bechecked morefrequently, as
driving conditions willdetermine therate ofoil
consumption.
- The engine inyour vehicle depends onoilto
lubricate andcool allofits moving parts.
Therefore, theengine oilshould bechecked
regularly andkept atthe required level.
- Make ita habit tohave theengine oillevel
checked withevery fuelfilling.
- The oilpressure warninglightisnot anoillevel
indicator.
The oilpressure warninglightindicates serious
engine damage maybeoccuring whenlit,ifen-
gine rpmisabove idlespeed.

Engine Oillevel

c>
Please observe thechapter "EXERCISE EX-
TREME CAUTION WHENWORKING ONYOUR
VEHICLE" onPage 112.

c>
Regularly checktheoillevel using theon-board
computer eachtimethevehicle isrefuelled.
Please observe thechapter "ON-BOARD COM-
PUTER (BC)"onPage 67.
A

Warning!
Risk ofburning fromhotparts inengine com-
partment. Riskofinjury byrotating parts.
The engine compartment bloweronthe en-
gine compartment lidcan start upeven with
engine off.

c>
Exercise extremcaution whenworking onthe
engine compartment.

I>
Top ofengine oilonly withtheengine off.

Engine oilishazardous toyour health and
may befatal
if
swallowed.

I>
Keep engine oilout ofchildren's reach.

Used engine oilcontains chemicals thathave
caused cancerinlaboratory animals.

I>
Always protect yourskinbywashing thorough-
ly with soap andwater.
The oildipstick andoilfiller areinthe engine com-
partment.

I>I>I>

Maintenance,CarCare
1

Preconditions forcorrect
oillevel

measurement withtheoildipstick

Vehicle mustbelevel.
- Engine mustberunning andatoperating
temperature (engine coolant temperature ofatleast
176T /

80°C).
- The engine mustidleforatleast 20seconds
(under 1,000rpm).
- The airconditioning mustbeoff.

1
Maintenance, CarCare
Checking
the
oillevel
andtopping off
engine oil

1. Apply handbrake andputthe gearshift leverin
neutral.
2. Unscrew capAof the oilfiller opening.
Withdraw dipstickBand wipe itwith aclean,
lint-free cloth.
3. Push dipstick fullyhome, withdraw againand
read offthe oillevel.
Push dipstick inas far asthe stop.
The

oillevel
must inno case fallbelow the
minimum orexceed themaximum
oillevel

on the dipstick.

The difference betvv'eenthetwo marks isapproxi-
mately 1.0liter/l.l quarts.
4. Add engine oilquarter-liter atatime, ifneces-
sary.
5. Check oillevel withthedipstick again.
6. Carefully closecapofthe oilfiller opening.

Brake Fluidlevel

I>
Please observe thechapter "EXERCISE EX-
TREME CAUTION WHENWORKING ONYOUR
VEHICLE" onPage 112.

I>
Use only new(unused) OriginalPorsche
brake fluid.
A

Warning!
Brake fluidishazardous toyour health, and
may befatal ifswallowed.
Brake fluidalsoattacks paintwork.

I>
Keep brake fluidoutofchildren's reach.

I>
Take carewhile topping offbrake fluidnotto
soil theluggage compartment oritems oflug-
gage .
Checking thebrake fluidlevel
The reservoir forthe hydraulic brakingsystems is
in the luggage compartment.

I>
Check thebrake·fluid levelregularly atthe
transparent reservoir.
The fluid level should always liebetween the"MIN"
and "MAX" marks.
A slight decrease inthe fluid level duetowear and
automatic readjustment ofthe disc brakes isnor-

mal.
If, however, thefluid level fallsmarkedly orbelow
the "MIN" mark, thebraking systemmayhave
developed aleak.

I>
Have thebraking systemchecked immediately
at an authorized Porschedealer. Changing
thebrake fluid
Brake fluidabsorbs moisture fromtheairover
time. Thisaccumulation ofwater lowers theboil-
ing point and,under certain operating conditions,
can affect thebraking action.
Therefore havethebrake fluidchanged inaccor-
dance withthechange intervals statedinthe
brochure "Maintenance".
• Warning lightUSA

G
Warning lightCanada
The brake-fluid warninglightsinthe instrument
panel andon-board computer indicate:
- brake-fluid leveltoolow,
- inconjunction withlarge pedal travel,
a braking-circuit failure.

If the warning lightsshould lightupwhile
driVing:

I>
Stop immediately inasuitable place.

I>
Donot continue driving.
Please havethefault remedied atyour nearest
authorized Porschedealer.
Maintenance, CarCare

19

Storing yourPorsche

If you intend tostore yourPorsche foraprolonged
period, pleaseconsult yourauthorized Porsche
dealer. Thestaff willbeglad toadvise youonthe
most suitable andnecessary methods.
r> Clean yourvehicle thoroughly insideandout-
side.
Clean theengine compartment.
The under carriage andchassis components
should befree ofdirt and saltdeposits.
r> Fillupthe fuel tank.
r> Change theoiland oilfilter, andrunthe engine
for several minutes.
r>

Increase thetire pressure to58 psi (4bar).
It is not recommended tolift the vehicle, dueto
the possibility ofcorrosion onshock absorber
piston shafts.
The vehicle shouldbemoved slightly, approxi-
mately everyfourweeks, toprevent flatspot
on the tires.

Climate control

The airconditioning systemshouldbeingood
working condition andfully charged.

WindshieldjHeadlight washer

r> Check andcorrect antifreeze/cleaning solu-
tion level asnecessary.

Electrical system

r> Remove thebattery fromthevehicle andstore
it in acool dryplace, notonacement floor.

When thebattery isdisconnected, the
alarm system isdeactivated.

r> Recharge thebattery every3months. Ifthe
battery remains inthe vehicle withthecables
connected, itis necessary tocheck, remove
and recharge thebattery every2-3weeks.

Do not fast charge thebattery.

r> Please observe thechapter "SATTERY" on
Page 155.
Vehicle
interior

The interior mustbedry, especially inthe area of
the floor carpets. Theuseofdrying agents (Silica-
Gel) isrecommended invehicles withleather inte-
rior and inareas withhighhumidity. Therecom-
mended amountis3fabric bagsof1.1 Ibs.
(500 grams) eachplaced onthe floor carpets.
Windows, doorsandlidsmust beclosed. Theair
flaps should beopened.
Maintenance, CarCare

Exercise ExtremeCautionwhen
Working onyour Vehicle

A
Warning!
Ignoring thefollowing instructions may
cause serious personal injury.

I>
The engine compartment ofany motor vehicle
is apotentially hazardous area.Ifyou arenot
fully familiar withproper repairprocedures, do
not attempt theadjustments describedonthe
following pages.
This caution appliestothe entire vehicle.

I>
Only work onyour vehicle outdoors orinawell
ventilated area.

I>
Ensure thatthere arenoopen flames inthe
area ofyour vehicle atany time when fuel
fumes mightbepresent. Beespecially cau-
tious ofsuch devices suchashot water heat-
ers which igniteaflame intermittently.

I>
Before working onany part inthe engine com-
partment, turntheengine offand letitcool
down sufficiently. Hotengine compartment
components canburn skinoncontact.

I>
Bealert andcautious aroundengineatall
times whiletheengine isrunning.
If work hastobe performed withtheengine
running, alwayssetthe parking brake,and
make suretheshift lever isin neutral position.

140
PracticalTips,Emergency Service
I>

Inparticular, bevery careful toensure that
items ofclothing (ties,shirt, sleeves etc.),jew-
elry, long hair,hand orfingers cannotget
caught inthe engine-compartment blower,fan,
belts orother moving parts.
The radiator andradiator fansareinthe front
of the car.
The fans canstart orcontinue runningasa
function oftemperature, evenwiththeengine
switched off.
Carry outwork inthese areasonlywith theen-
gine off,theignition switched off,and exercise
extreme caution.

I>
Your Porsche isequipped withanelectronic ig-
nition system. Whentheignition ison, high volt-
age ispresent inall wires connected withthe
ignition system; therefore, exerciseextreme
caution whenworking onany part ofthe engine
while theignition ison orthe engine isrunning.

I>
Always support yourcarwith safety stands ifit
is necessary towork under thecar.

I>
When working underthecarwithout safety
stands butwith thewheels onthe ground,
make surethecar ison level ground, the
wheels areblocked, andthat theengine
cannot bestarted.
Remove theignition key.
I>

Donot smoke orallow anopen flame around
the battery orfuel.
Keep afire extinguisher inclose reach.

I>
Incomplete orimproper servicingmaycause
problems inthe operation ofthe car. Ifin doubt
about anyservicing, haveitdone byyour au-
thorized Porschedealer.
Improper maintenance duringthewarranty pe-
riod may affect yourPorsche warranty cover·
age.

I>
Supplies offluids, e.g.engine oil,brake fluidor
coolant, arehazardous toyour health.
Keep these fluidsoutofchildren's reachand
dispose ofthem inaccordance withtheappro-
priate regulations.

I>
Some countries requireadditional toolsand
special sparepartstobe carried.
Please makeenquiries beforedriving abroad.

CapacitiesUse only fluids andfuels authorized byPorsche. Yourauthorized Porschedealerwillgladly advise you.

Your Porsche hasbeen designed sothat itis not necessary tomix anyadditives withoilsorfuels.
Engine
CoolantManual transmission
and differential
Fuel tank
Fuel quality
Power steering
Brake fluid
Windshield washer
Oil
change quantity withoutoilfilter approx. 9.3quarts/S.75 liters
Oil change quantity withoilfilter approx. 9.6quarts/9.0 liters
Reference indicationisthe level onthe oildipstick.
Please observe thechapter "ENGINE Oil"onPage 114.
approx. 7.39U.S.gallons/28 liters
3.5 quarts/3.3 literstransmission oilSAE 75W-90, Mobilube PTX
approx. 16.6U.S.gallons/63 liters
Your engine isdesigned toprovide optimum performance andfuel economy using

unleaded premiumfuelwith anoctane ratingof98 RON (93CLC orAKI).

Porsche therefore recommends theuse ofthese fuelsinyour vehicle.
Porsche alsorecognizes thatthese fuelsmaynotalways beavailable. Beassured thatyour vehicle
will operate properly onunleaded premiumfuelswithoctane numbers ofatleast
95RON (90CLC orAKI),

since theengine's "Electronic Oktane
™
knock control" willadapt theignition timing,ifnecessary.
approx. 1.35quarts/1.27 literhydraulic fluidPentosin CHF11S®
0.67 quarts/0.63 liters;useonly Original Porsche brakefluid.
approx. 3.19quarts/3 literswithout headlight washer
approx. 6.06quarts/5.7 literswithheadlight washer
TechnicalData

Temperaturgauge 54,56
Warning light 54,56
Cruise contro!. 58,86,87
Curb light 172
D
Dashboard 48
Defrosting windows 29,90, 91
Diagnostic socket 17,153
Diagrams 187
Dimensions 186
Door 21
Guard 172
Handles 21
Locks 21,132
Windows 21,26,27,133
Door mirror 28
Heating 29
Driving hints 14
Driving performance 182
E
Electrical system 152
Emergency flasher 81
Emergency operation
Central locking 23
Lids 154
Tank flap 121
Emergency service 140
Emergency startingwithjumper cables160,161
Emission controlsystem 7,66, 124, 125
Engine Checking oillevel 71,115 Dipstick
116
Exhaust 10
Number 180
Oil consumption 16,114
Oillevel 116
Oil level gauge 71
Oil pressure gauge 54,56,65
Oil pressure warninglight.. 54,56,65
Oils 114,185
Speeds 16,182
Starting 52
Stopping 53
Engine compartment
Blower 53,62
Lid 98,99
Lid warning light.. 54,56,98
Light 172

F

Fog lights 82,169, 171
F ootbrake 41
Footweillights 47
Fresh airintake 93
Front hood 99
Fuel 4,63, 121
Containers 10
Economy 120
Evaporation control 126
Level gauge 54,56,63
Level warning light 63
Recommendation 122,123
Tank 122
Warning light... 54,56
Fuses 153
G

Garage lift 148
Gearshifting 109
Glove compartment. 96
Gong 18,51, 69, 79
Ground clearance 9,186
H
Headlights 82,83,164
Adjusting 175,176
Cleaning system 84,126, 185
Heated rearwindow 29
Heating 88
High beam
Indicator light... 54,56,61
Lever 82
Hoods 98,99
Horn 17,22, 23

I

Identification number 100,180
Ignition lock 50
Immobilizer 19
Indicator lights 54
Infrared passenger compartment monitoring..24
Instrument panel 48
Instruments 54
Lights 59,82
Interior light 46,173
Interior mirror 28
Intermittent operationswitch 84
Index