warning light PORSCHE BOXSTER 2005 2.G Repair Manual

206
Practical Tips, Emergency Service
Tire pressures
Warning!
Incorrect tire pressure causes increased tire
wear and adversely affects road handling.
fAlways use an accurate tire pressure gauge
when checking inflation pressures.
fDo not exceed the maximum tire pressure list-
ed on the tire sidewall.
Please observe the chapter “VEHICLE IDENTI-
FICATION NUMBER” on Page 258.
fCold tire inflation pressure means: all tires
must be cold, ambient temperature maximum
(68°F, (20°C)
, when adjusting the inflation pres-
sure.
Avoid sunlight striking the tires before measur-
ing cold pressures, since the pressures would
rise from temperature influence.
fValve caps protect the valve from dust and dirt,
and thus from leakage.
Always screw caps tightly down.
Replace missing caps immediately.
fUse only plastic valve caps.
fDo not use commercially available sealant or
tire inflating bottles. Only use Porsche approved tire sealant.The tire pressure must match the prescribed val-
ue.
You can find information on tire pressure:
– on Page 5 of this Owner’s Manual
– and in the left door aperture.
These values are for cold tires (68°F (20 °C)).
fCheck the tire pressure at least every
2 weeks. Always check when tires are cold.
When tires are warm, the tire pressure is
increased.
fNever let air out of hot tires.
This could cause the tire pressure to fall below
the prescribed value.
Insufficient tire filling pressure can cause tires to
overheat and thus be damaged – even invisibly.
Hidden tire damage is not eliminated by subse-
quently correcting the tire pressure.Overloading
Danger!
Risk of personal injury, loss of control and
damage to vehicle parts.
fDo not overload your vehicle. Be careful about
the roof load.
fIf loading the vehicle also correct the tire pres-
sure. Tire pressure for loaded vehicle can be
found on the tire pressure plate and in the
chapter technical data.
fNever exceed the specified axle load.
Overloading can shorten the service life of the
tires and car, as well as lead to dangerous ve-
hicle reactions and long braking distances.
Damage due to overloading is not covered by the vehicle warranty.
fPlease observe the chapter “LOADING INFOR-
MATION” on Page 216.
fPlease observe the chapter “TIRE PRESSURE
FOR COLD TIRES” on Page 264.

Practical Tips, Emergency Service
221
A- Filler bottle
B- Filler hose
C- Plug of the filler hose
D-Valve turner
E-Valve insert
F- Tire valveInserting sealant
1. Leave the object that caused the puncture in
the tire.
2. Remove sealant and the enclosed sticker from
the luggage compartment.
3. Adhere the sticker in the driver's field of vision.
4. Shake filler bottle A.5. Screw filler hose B onto the filler bottle.
The filler bottle is now open.
6. Unscrew valve cap from tire valve F.
7. Remove valve insert E from the tire valve with
valve turner D.
Keep the valve insert in a clean and dry place.
8. Remove plug C of the filler hose B.
9. Push filler hose onto the tire valve.
10.Hold filler bottle higher than the level of the tire
valve and press it together forcefully until the
bottle is completely emptied into the tire.
11.Pull filler hose off the tire valve.
12.Twist the valve insert firmly into the tire valve
using the valve turner.
13.Connect the compressor to the cigarette light-
er and inflate the tire to the prescribed tire
pressure.
Please observe the chapter “TIRE PRESSURE
FOR COLD TIRES” on Page 264.
14.Screw valve cap onto the tire valve.
15.Check the tire pressure after driving for around
10 minutes.
If the tire pressure is less than 22 psi (1.5 bar),
do not continue driving.
If a value of more than 22 psi (1.5 bar) is indi-
cated, correct the pressure to the prescribed
value.16.Please consult your authorized Porsche
dealer.
Care Instructions
After drying, any sealant that emerges can be
peeled off like a film.
Warning!
Risk of accident.
fHave the tire replaced by an authorized
Porsche dealer immediately.
fAvoid hard acceleration and high cornering
speeds.
fDo not exceed maximum speed of 50 mph
(80 km/h).
fPlease always observe the safety and oper-
ating instructions, which can be found in the
separate operating instructions for the sealant and on the compressor.

224
Practical Tips, Emergency Service
Changing a wheel
Warning!
Risk of injury. The car may slip off the jack.
fMake sure that no one is in the vehicle when
jacking up and changing a wheel.
fAlways place the car on stable supports if work
has to be carried out under the car.
Risk of damage to the brake discs of the
Porsche Ceramic Composite Brake (PCCB).
fAlways screw in both assembly aids when changing a wheel.
Note
The tools required for changing a wheel (e.g. jack,
wheel bolt wrench, assembly aids) are not sup-
plied with the car. They are available at your
authorized Porsche dealer.
1. Fully apply the handbrake, engage 1st gear or
select position P and withdraw the ignition key.
2. Secure the car against rolling away, e.g. by
means of wedges under the wheels on the op-
posite side.
This is particularly important on slopes.
Screw in assembly aid for vehicles without
Porsche Ceramic Composite Brake3. Slightly slacken the wheel bolts of the wheel to
be changed.
4. Raise the car until the wheel lifts off the
ground.
Please observe the chapter “LIFTING THE VE-
HICLE WITH A LIFTING PLATFORM OR GARAGE
LIFT” on Page 218.
Screw in two assembly aids for vehicles with
Porsche Ceramic Composite Brake5. Remove 1 or 2 wheel bolts (see respective
illustration). Screw in assembly aids instead of
the wheel bolts.
Remove the remaining wheel bolts.

226
Practical Tips, Emergency Service
Electrical System In order to avoid damage and faults in electrical or
electronic systems, electrical accessories should
be installed at your authorized Porsche dealer.
fOnly use accessories authorized by Porsche.
Warning!
Risk of short circuit and fire.
Replacing fuses or relays with the engine
running or the ignition on could cause elec-
trical shock.
fDisconnected the battery during all work on
the electrical system.
Please observe the chapter “BATTERY” on Page 229.
Relays Defective relays should be changed only by an
authorized workshop.
Alarm system, central locking The status of the central locking and alarm system
is not changed by disconnecting the battery.
When the battery is disconnected, the alarm sys-
tem ceases to function. Overload protection If the central locking system is operated more
than ten times within a minute, further operation is
blocked for 30 seconds.
Load switch-off after 2 hours or 7 daysIf the ignition key is removed, loads which are
switched on or are in standby mode (such as the
luggage compartment light, interior light and
radio) are automatically switched off after approx.
2hours.
If the vehicle is not started or unlocked with the
remote control within 7days, the remote control
standby function is switched off (to save the
vehicle battery).
1. In this case, unlock the driver's door with the
key at the door lock.
Leave the door closed in order to prevent the
alarm system from being triggered.
2. Press button 1 on the remote control.
The remote control is now activated again.

232
Practical Tips, Emergency Service
Putting vehicle into operationAfter the battery is connected or after an exhaus-
tively discharged battery is charged, the multi-
functional PSM light lights up on the instrument
panel and a message appears on the on-board
computer to indicate a fault.
This fault can be remedied with a few simple
steps:
1. Start the engine.
2. With the vehicle stationary, perform a few
steering movements to the left and right and
then drive a short distance in a straight line
until the multifunctinal PSM light goes out and
the message on the on-board computer
disappears.
3. If the warnings do not disappear, then:
Drive carefully to the nearest qualified
specialist workshop.
Have the fault remedied.
4. After the warnings disappear, stop the vehicle
in a suitable place.
5. Perform adaptation of the power windows:
Please observe the chapter “STORING END
POSITION OF THE WINDOWS” on Page 29.Ignition key/ignition lock
fDo not insert the ignition key into the ignition
lock if the vehicle battery is discharged.
The ignition key can no longer be removed.
The key cannot be removed until the vehicle elec-
trical system is supplied with power again.
fPlease observe the chapter “EMERGENCY UN-
LOCKING OF THE FRONT LUGGAGE COMPART-
MENT LID” on Page 228.
6. Please observe the chapter “JUMP LEAD
STARTING” on Page 236.

238
Practical Tips, Emergency Service
Replacing bulbs
Warning!
Risk of short circuit.
fAlways switch off the relevant load when
changing bulbs.
Risk of injury. The Bi-Xenon headlights are
under high voltage when installed.
fExercise extreme caution when working in the
area of the Bi-Xenon headlights.
Risk of damage. Bulbs of a higher wattage
can damage the lamp housing.
fOnly use the bulbs specified in the bulb chart.
fBulbs must be clean and free from grease.
fNever touch bulbs with your bare hands. Use a
cloth or soft paper when replacing bulbs.
fAlways carry spare bulbs with you.
In certain countries, the carrying of spare
bulbs is mandatory.
Caution!
Risk of damage to headlights due to exces-
sive temperatures and abrasion.
fAttach no coverings (e.g. films, “stone
guards”) in the area of the headlights.
fUse soapy water only to clean light lenses and
plastic headlight lenses.
In no case may chemical cleaners or other vol-
atile cleaning fluids be used.
fTo prevent scratches, do not rub with a dry or merely moist cloth, tissue or insect sponges.

240
Practical Tips, Emergency Service
Warning!
Risk of short circuit.
fAlways switch off the relevant load when
changing bulbs.
Risk of injury. The Bi-Xenon headlights are
under high voltage when installed.
fExercise extreme caution when working in the
area of the Bi-Xenon headlights.
Risk of damage. Bulbs of a higher wattage
can damage the lamp housing.
fOnly use the bulbs specified in the bulb chart.
fBulbs must be clean and free from grease.
fNever touch bulbs with your bare hands. Use a
cloth or soft paper when replacing bulbs.
fAlways carry spare bulbs with you.
In certain countries, the carrying of spare
bulbs is mandatory.
Caution!
Risk of damage to headlights due to exces-
sive temperatures and abrasion.
fAttach no coverings (e.g. films, “stone
guards”) in the area of the headlights.
fUse soapy water only to clean light lenses and
plastic headlight lenses.
In no case may chemical cleaners or other vol-
atile cleaning fluids be used.
fTo prevent scratches, do not rub with a dry or merely moist cloth, tissue or insect sponges.

272
Index
IndexAABS (antilock brake system) .......................... 55
Air conditioning ...................................114
, 117
Air distribution ....................................114, 117
Air filter ...................................................... 190
Airbag system .............................................. 49
Disposal ............................................... 50
Switching passenger’s airbag on and off . 48
Air-conditioning compressor ................116, 119
Alarm system ............................................. 141
Alcantara ................................................... 199
Antenna .............................................141, 194
Antilock brake system................................... 55
Warning light ........................................ 56
Ashtray ...................................................... 122
Assembly aids for wheel changes................. 224
Assistant ...................................................... 64
Audio operation .......................................... 139
Auto-button air conditioning ......................... 117
Automatic
Anti-glare mirrors .................................. 30
Car washes ........................................ 192
Door locking ......................................... 24
Headlight beam adjustment.................. 109
Speed control ....................................... 76
Automatic air conditioning system ................ 117
Average consumption............................87, 100
Average speed .....................................87, 100
BBackrest
Adjustment ........................................... 34
Release ................................................ 34
Battery....................................................... 229
Care .................................................. 230
Charge state....................................... 230
Putting vehicle into operation ............... 232
Remote control ................................... 235
Removing ........................................... 233
Warning light......................................... 84
Winter driving...................................... 231
Before driving off ....................................12
, 13
Blower adjustment..............................114, 117
Brake light..........................................249, 250
Brakes
Brake pad warning light ......................... 85
Fluid ...........................................175, 266
Fluid warning light ............................... 175
Pads ..............................................14, 54
Test stand ............................................ 60
Break in hints................................................ 14
Bulbs
Chart ................................................. 239
Replacing ........................................... 239
CCabriolet .................................................... 154
Canholder .................................................. 128
Capacities, overview ................................... 266Car care ..................................................... 168
Car telephone ............................................. 141
Car washes ................................................ 192
Catalytic converters ....................................183
Cautions............................................ 168
, 202
Central locking....................................... 19, 21
Emergency operation ..................... 19, 22
Central vents .............................................. 120
Central warning light..................................... 85
Changing wheels ......................................... 224
Check engine
Warning light......................................... 84
Checking pressure ...................................... 223
Chield retraint system.................................... 45
Child restraint system
Switching passenger’s airbag on and off . 48
Chime ........................................................ 108
CHRONO stopwatch ......................................92
Circulating-air button .......................... 114, 117
Clock .................................................. 83, 100
Clutch ........................................................ 146
Clutch pedal ................................................. 51
Combination filter ........................................190
Comfort seat ................................................ 34
Coming Home mode ................................... 108
Compact disc
holder ................................................ 127
Player ................................................ 140
Storage .............................................. 136
Convertible top ........................................... 154
Care................................................... 193
Coolant ....................................... 80
, 170
, 266

Index
273
Level.................................................. 170
Temperature gauge.............................. 80
Warning light ........................................ 80
Cooling system .....................................80
, 170
Cruise control ............................................... 76
Cupholder .................................................. 128
DDashboard ................................................... 65
Data bank .................................................. 258
Defrosting windows .............................114
, 117
Diagnostic socket .................................15, 227
Diagrams ................................................... 268
Dimensions ................................................ 267
Dipped beam .............................................. 241
Door ............................................................ 25
Guard lights ........................................ 251
Handles................................................ 25
Locks...........................................25, 194
Mirror heating ....................................... 33
Windows ....................... 25
, 28, 154
, 196
Driving hints ................................................. 12
Driving in winter .......................................... 152
Driving performance ................................... 265
Drop-center rim .......................................... 215
DVD Navigation........................................... 136
EElectrical system ........................................ 226
Emergency flasher ...................................... 121
Emergency operation
Central locking................................19
, 22
Convertible top ................................... 157Lids ...................................................228
Tank cap ............................................179
Emergency program, Tiptronic .....................152
Emergency service......................................202
Emergency starting with jump leads .............236
Emergenzy operation....................................22
Emission control system ........... 7
, 84, 182
, 183
Engine
Checking the oil level .............................97
Exhaust ..................................................8
Number ..............................................259
Oil consumption ....................................14
Oil level indicator...................................97
Oils ....................................................266
Speeds ................................................14
Starting ................................................67
Switching off.........................................67
Engine compartment
Blower .......................................... 70, 80
Lid ............................................ 135, 185
Lid warning light ..................................134
Environment ...................................................6
FFire extinguisher .........................................131
Flat tire ......................................................219
Floor mats ..................................................199
Fog lights .................................. 108
, 246
, 249
Footwell light ..............................................250
Front lid......................................................135
Fuel ................................................ 4
, 82, 178
Containers ..............................................8
Economy ............................................177
Evaporation ........................................184Level gauge ......................................... 82
Level warning light................................ 82
Portable Containers ............................ 181
Recommendation ....................... 180
, 181
Tank.......................................... 178, 179
Function keys ............................................... 40
Fuses ........................................................ 227
GGarage door opener................................... 142
Garage lift ................................................. 218
Gearchanging ............................................ 145
Glove compartment .................................... 127
Gong .............................. 68
, 69, 88, 107
, 108
Ground clearance ........................................... 8
HHandbrake ................................................... 51
Hardtop ..................................................... 162
Headlights ......................................... 109
, 241
Adjusting ................................... 252, 253
Cleaning system ................. 110
, 184
, 266
Heated rear window...................... 33
, 165
, 166
Heating ............................................. 114, 117
High beam
Indicator light ....................................... 79
Lever......................................... 108, 109
Home mode............................................... 108
HomeLink .................................................. 142
Hoods ............................................... 132, 135
Horn ..................................................... 15, 21

274IIdentifikation number................................... 258
Ignition lock............................. 67
, 69, 70, 147
Immobilizer .................................................. 17
Instrument
Illumination ........................................... 76
Lights ................................................ 108
Panel ................................................... 73
Interior lights .............................................. 251
Interior mirror ............................................... 30
JJump lead starting ...................................... 236KKeylock...................................................... 147
Keys ............................................................ 17
with remote control ............................... 18LLATCH System.............................................. 47
Leather care............................................... 198
License plate light....................................... 108
Lids ...................................................132
, 135
Emergency unlocking.......................... 228
Light
Flasher................................ 79
, 108
, 109
Low beam ..................................108, 109
Switch................................................ 109
Light alloy wheels ....................................... 198
Inscription .......................................... 215
Load switch-off ........................................... 226Loading information .................................... 216
Locking ................................................. 20
, 23
Luggage
Net ........................................... 130, 187
Luggage compartment ............... 136
, 137
, 250
Lid warning light.................................. 134
Lids ................................................... 134
MMaintenance ............................................... 168
Make-up mirror ............................................. 41
Maximum permitted engine speeds ....... 14
, 146
Mirrors ......................................................... 31
Anti-glare .............................................. 30
Multi-Functional steering wheel
Function keys........................................ 40
NNavigation .................................................. 138
Notes on
Car care ............................................. 191
Maintenance ....................................... 168
Number plate light ............................. 108
, 249
OOctane rating..................................... 180
, 181
Off delay .................................................... 108
Oil ............................................................. 266
Checking level ...................................... 97
Consumption ........................................ 14
Level checks ...................................... 173
Level indicator ...................................... 97On-board computer .................................. 8
, 86
Basic settings .......................................99
Language versions................................99
On-board literature ..........................................2
Orientation light ..........................................125
Outside temperatur indicator..........................83
PPaint
Care...................................................191
Data ...................................................259
ParkAssistant................................................64
Parking
Aids .....................................................64
Assistant ..............................................65
Brake ...................................................51
Light ..................................................108
Particle filter ...............................................190
Plastic parts ...............................................197
Platform lift.................................................218
Porsche Active Suspension Management (PASM) .
61
Porsche Ceramic Composite Brake (PCCB) .......8
Porsche Communication Management ..... 8
, 138
Porsche Stability Management (PSM) ..............58
Information light ....................................60
Power measurements ..................................168
Power steering fluid level .................... 189, 266
Power windows .............................. 25
, 28, 154
Practical tips ..............................................202