service PORSCHE BOXSTER 2006 2.G Repair Manual

Practical Tips, Emergency Service
269
Tail light, leftTail lightChanging bulbs1. Remove carpeting covering the tail light.
Unscrew the securing nuts to do this.
2. Press the mounting of the lamp bracket
upwards (arrow) and remove the bulb holder.
A - Turn signal light
B - Reversing light
C - Rear fog light, rear light
D - Tail light
E - Brake light, rear light3. Replace the defective bulb (bayonet fitting).
4. Reassemble in reverse order.
Check operation of the light.
License plate lightsChanging bulb 1. Unscrew both screws A and remove the lens.
2. Remove defective bulb from between the
contact springs and replace.
3. Reassemble in reverse order.
Check operation of the light.

270
Practical Tips, Emergency Service
Additional brake lightThe light-emitting diodes of the additional brake
light cannot be replaced individually.
fHave the defective brake light replaced in a
qualified specialist workshop.
We recommend a Porsche partner for this
work as they have trained workshop personnel
and the necessary parts and tools.
Luggage compartment/footwell
lightsChanging bulb
1. With a screwdriver (arrow), carefully press light
out of the cutout in the lining.
2. Remove defective bulb from between the
contact springs and replace.
3. Insert the light into the cut-out first from one
side then from the other. Check operation.

Practical Tips, Emergency Service
271
Interior lightChanging bulb 1. With a screwdriver (arrow), carefully press light
out of the cutout in the lining.
2. Undo bulb holder (bayonet mount).
Remove bulb and replace.
3. Reassemble in reverse order.
Check operation of the light.
Door guard/curb lightChanging bulb 1. With a screwdriver (arrow), carefully push out
the light.
2. Pull the bulb holder out of light housing.
Remove defective bulb and replace.
3. Install the bulb holder and insert the light.

272
Practical Tips, Emergency Service
Adjusting Headlights fPlease observe the chapter “REPLACING BUL-
BS” on Page 258.
Adjustment
The adjustment is made with the vehicle ready to
drive and the fuel tank completely filled.
The driver’s seat must be loaded by a person or a
165 lbs. (75 kg) weight and the tire pressures
must meet the prescribed values.
After being loaded, the car must be rolled a few
meters so that the suspension can settle.
For checking the headlight adjustment, the verti-
cal position of the cutoff of the lowbeam (see fig.)
has to be projected on a vertical screen (wall) in
distance of 24.6 ft. (7.5 m) from the front lens of
the headlamp.
The correct position of the cutoff is 2.0 in. (5 cm)
at 24.6 ft. or 7.5 m (0.4°) below a horizontal line,
x cm from ground to the center of the headlamp
lens. Lateral adjustment of the headlights should be
carried out at a specialist workshop with an optical
adjustment unit.
Distance
Visual aim shall be performed at not less than
24.6 ft. (7.5) m (this value is a rounded down con-
version from the 25-foot distance typical of field
aim using a screen). The 24.6 ft. (7.5 m) distance
is measured from the headlamp lens to the view-
ing screen.

Practical Tips, Emergency Service
273
Floor
The surface upon which the vehicle rests is flat
and approximately level.
Screen
The screen upon which headlamp beams are pro-
jected is perpendicular to the floor and the vehi-
cle’s longitudinal axis, flat, uniformly light in color,
unobstructed, and wide and high enough to ac-
commodate the vehicle beam patterns to be
aimed.
The screen should be wide enough to provide at
least 3.3 ft. (1 m) of space outboard of the vehi-
cle’s headlamp spacing.
Adjustment screws
fDetach side carpeting in luggage compart-
ment.
Therefore unscrew plastic nut A.
Open the cover of the appropriate adjustment
screw.
The setting is adjusted by turning the hexagon
socket screws right or left, as appropriate.
B - Headlight vertical adjustmentVertical adjustment (screw B)
fturn clockwise = beam moves down
turn counter-clockwise = beam moves up
Note
fDo not alter the lateral adjustment.

274
Practical Tips, Emergency Service
Towing Certain state statutes and local ordinances prohib-
it towing with a chain, rope or even a tow bar.
In addition, damage to your vehicle may result
from improper procedures.
Consult your authorized Porsche dealer for de-
tails. Vehicle towing Flat bed towing is the preferred type of towing to
be used on Porsche vehicles.
Under certain circumstances, wheel lifts may be
used when the vehicle will not roll.
The vehicle must be towed with all four
wheels off the ground, otherwise damage to
the vehicle may result. Towing hook The towing hook is contained in the tool box.
Caution!
Risk of damage to the vehicle.
fUse the towing hook only for an emergency to
remove the vehicle off the road. The towing
hook is to be used only to pull the vehicle onto
the flat bed, tractor or towing aparatus if the
vehicle will roll freely. Under no circumstances
is the vehicle to be secured using the towing
hook. fNever use the towing hook to tow this or any
other vehicle.
fBear in mind the limited ground clearence of
your car on uneven surfaces.
Front mounting
The towing hook is stored in the tool box in the
luggage compartment.
1. Press the lower edge of the appropriate
plastic cover into the bumper until the cover
disengages.
2. Pull cover out of the bumper and let it hang by
its thread.
3. Completely screw in the towing hook.Rear mounting
1. Remove license plate.
2. Unscrew the towing hook.
3. Insert plastic cover at the lower edge of the
opening.
4. Fold the cover up and press on its upper edge
to engage it in the bumper.
5. Completely screw in the towing hook.

Practical Tips, Emergency Service
275
Pulling vehicle onto flat bed 1. Position wooden ramps at the base of the flat
bed to reduce the angle of the pull.
2. Reel in the hoist cable and check the underside
of the vehicle for any interference.
Tieing down vehicle on flat bed 1. Carefully feed towing straps through the open-
ing in the rear wheels.
Make sure metal parts of straps do not dam-
age rim.
Make sure the strap is flat over the rim bead.
Make sure brake backing plate is not dam-
aged.
2. Secure straps to rear of flat bed.
3. Reel in hoist cable only far enough to tension
tie-down straps. 4. Carefully feed towing straps through the open-
ing in the front wheels.
Make sure metal parts of straps do not dam-
age rim.
Make sure the strap is flat over the rim bead.
Make sure brake backing plate is not dam-
aged.
5. Secure straps to front of flat bed.
6. Release tension on hoist cable, but do not dis-
connect.
Use hoist cable as a safety cable.

276
Practical Tips, Emergency Service

Index
293
Warning light ........................................ 86
Cooling system .....................................86
, 186
Cruise control ............................................... 82
Cupholder .................................................. 144
DDashboard ................................................... 72
Data bank .................................................. 278
Defrosting windows .............................130
, 133
Diagnostic socket .................................15, 247
Diagrams ................................................... 288
Dimensions ................................................ 287
Dipped beam .............................................. 261
Door ............................................................ 25
Guard lights ........................................ 271
Handles................................................ 25
Locks...........................................25, 212
Mirror heating ....................................... 33
Windows ....................... 25
, 28, 170
, 214
Driving hints ................................................. 12
Driving in winter .......................................... 168
Driving performance ................................... 285
Drop-center rim .......................................... 234
DVD Navigation........................................... 152
EElectrical system ........................................ 246
Emergency flasher ...................................... 137
Emergency operation
Central locking................................19
, 22
Convertible top ................................... 173
Lids ................................................... 248
Tank cap ............................................ 197Emergency program, Tiptronic .....................168
Emergency service......................................220
Emergency starting with jump leads .............256
Emergenzy operation....................................22
Emission control system ........... 7
, 90, 200
, 201
Engine
Checking the oil level ...........................111
Exhaust ..................................................8
Number ..............................................279
Oil consumption ....................................14
Oil level indicator.................................111
Oils ....................................................286
Speeds ................................................14
Starting ................................................74
Switching off.........................................74
Engine compartment
Blower .......................................... 77, 86
Lid ............................................ 151, 203
Lid warning light ..................................150
Environment ...................................................6
FFire extinguisher .........................................147
Flat tire ......................................................238
Floor mats ..................................................217
Fog lights .................................. 124
, 266
, 269
Footwell light ..............................................270
Front lid......................................................151
Fuel ................................................ 4
, 88, 196
Containers ..............................................8
Economy ............................................194
Evaporation ........................................202
Level gauge ..........................................88
Level warning light................................88Portable Containers ............................ 199
Recommendation ....................... 198
, 199
Tank.......................................... 196, 197
Function keys ............................................... 40
Fuses ........................................................ 247
GGarage door opener................................... 158
Garage lift ................................................. 237
Gearchanging ............................................ 161
Glove compartment .................................... 143
Gong .............................. 75
, 76, 94, 123
, 124
Ground clearance ........................................... 8
HHandbrake ................................................... 57
Hardtop ..................................................... 178
Headlights ......................................... 125
, 261
Adjusting ................................... 272, 273
Cleaning system ................. 126
, 202
, 286
Heated rear window...................... 33
, 181
, 182
Heating ............................................. 130, 133
High beam
Indicator light ....................................... 85
Lever......................................... 124, 125
Home mode............................................... 124
HomeLink .................................................. 158
Hoods ............................................... 148, 151
Horn ..................................................... 15, 21