battery Ram 1500 2020 Repair Manual

SERVICING AND MAINTENANCE 489
5.7L Engine With Stop/Start
1 — Air Cleaner Filter6 — Power Distribution Center
2 — Engine Oil Fill 7 — Washer Fluid Reservoir
3 — Engine Oil Dipstick 8 — Engine Coolant Reservoir
4 — Brake Fluid Reservoir 9 — Engine Coolant Pressure Cap
5 — Battery
7
2020_DT_1500_OM_US.book Page 489

SERVICING AND MAINTENANCE 491
Maintenance-Free Battery
Your vehicle is equipped with a maintenance-free battery.
You will never have to add water, nor is periodic mainte-
nance required.
Pressure Washing
WARNING!
• Battery fluid is a corrosive acid solution and can burn or even blind you. Do not allow battery fluid to contact
your eyes, skin, or clothing. Do not lean over a battery
when attaching clamps. If acid splashes in eyes or on
skin, flush the area immediately with large amounts of
water. Refer to “Jump Starting Procedure” in “In Case
Of Emergency” for further information.
• Battery gas is flammable and explosive. Keep flame or sparks away from the battery. Do not use a booster
battery or any other booster source with an output
greater than 12 Volts. Do not allow cable clamps to
touch each other.
• Battery posts, terminals, and related accessories contain lead and lead compounds. Wash hands after handling.
CAUTION!
• It is essential when replacing the cables on the battery that the positive cable is attached to the positive post
and the negative cable is attached to the negative post.
Battery posts are marked positive (+) and negative (-)
and are identified on the battery case. Cable clamps
should be tight on the terminal posts and free of corro -
sion.
• If a “fast charger” is used while the battery is in the vehicle, disconnect both vehicle battery cables before
connecting the charger to the battery. Do not use a “fast
charger” to provide starting voltage.
CAUTION!
Cleaning the engine compartment with a high pressure
washer is not recommended. Precautions have been
taken to safeguard all parts and connections however,
the pressures generated by these machines is such that
complete protection against water ingress cannot be
guaranteed.
7
2020_DT_1500_OM_US.book Page 491

SERVICING AND MAINTENANCE 539
Sustained high temperature can cause the material of the
tire to degenerate and reduce tire life, and excessive
temperature can lead to sudden tire failure. The grade C
corresponds to a level of performance, which all
passenger vehicle tires must meet under the Federal
Motor Vehicle Safety Standard No. 109. Grades B and A
represent higher levels of performance on the laboratory
test wheel, than the minimum required by law.
STORING THE VEHICLE
If you are storing your vehicle for more than 21 days, we
recommend that you take the following steps to minimize
the drain on your vehicle's battery:
• Disconnect the negative cable from battery.
• Any time you store your vehicle or keep it out of service(i.e., vacation) for two weeks or more, run the air condi -
tioning system at idle for about five minutes in the fresh air and high blower setting. This will ensure adequate system
lubrication to minimize the possibility of compressor
damage when the system is started again.
BODYWORK
Protection From Atmospheric Agents
Vehicle body care requirements vary according to
geographic locations and usage. Chemicals that make roads
passable in snow and ice and those that are sprayed on trees
and road surfaces during other seasons are highly corrosive
to the metal in your vehicle. Outside parking, which exposes
your vehicle to airborne contaminants, road surfaces on
which the vehicle is operated, extreme hot or cold weather
and other extreme conditions will have an adverse effect on
paint, metal trim, and underbody protection.
The following maintenance recommendations will enable
you to obtain maximum benefit from the corrosion resistance
built into your vehicle.
WARNING!
The temperature grade for this tire is established for a
tire that is properly inflated and not overloaded.
Excessive speed, under-inflation, or excessive loading,
either separately or in combination, can cause heat
buildup and possible tire failure.
7
2020_DT_1500_OM_US.book Page 539

658
Audio Systems (Radio) .......................................................... 557
Auto Down Power Windows .................................................. 95Auto Unlock, Doors ................................................................ 308
Automatic Door Locks ............................................................. 41
Automatic Headlights .............................................................. 70
Automatic High Beams ............................................................ 68
Automatic Tailgate Release ................................................... 107
Automatic Temperature Control (ATC) ................................ 91
Automatic Transmission ................................................ 304, 514 Adding Fluid ....................................................................... 514Fluid And Filter Change .................................................... 514
Fluid Change........................................................................ 514
Fluid Level Check ....................................................... 513, 514
Fluid Type .................................................................... 513, 556
Special Additives................................................................. 514
Automatic Transmission Limp Home Mode ...................... 308
Auxiliary Driving Systems .................................................... 211
Axle Fluid......................................................................... 515, 556
Axle Lubrication...................................................................... 515 B
Back-Up .................................................................................... 396
Back-Up Camera ..................................................................... 396
Battery............................................................................... 181, 491 Charging System Light....................................................... 181
Keyless Key Fob Replacement ............................................ 21
Battery Saver Feature ............................................................... 73 Belts, Seat ..................................................................................286
Blind Spot Monitoring ............................................................ 211
Body Builders Guide ................................................................14
Body Mechanism Lubrication ...............................................502
B-Pillar Location ......................................................................521
Brake Assist System ................................................................200
Brake Control System .............................................................199
Brake Fluid .......................................................................512, 556
Brake System....................................................................512, 546 Fluid Check ..........................................................................512
Master Cylinder ...................................................................512Parking ..................................................................................297
Warning Light......................................................................179
Brake/Transmission Interlock ..............................................304
Bulb Replacement ...................................................................436
Bulbs, Light ......................................................................289, 436 C
Camera...................................................................................... 396
Camera, Rear....................................................................396, 398
Camper .....................................................................................146
Capacities, Fuel........................................................................553
Caps, Filler Oil (Engine) ..................................................................487, 493
Radiator (Coolant Pressure)...............................................509
Car Washes ..............................................................................540
Carbon Monoxide Warning ...........................................286, 552
2020_DT_1500_OM_US.book Page 658

663
K
Key Fob Panic Alarm ........................................................................... 20
Programming Additional Key Fobs ............................. 24, 31
Key Fob Battery Service (Remote Keyless Entry)................. 21
Key Fob Programming (Remote Keyless Entry) .................. 24
Keyless Enter-N-Go .......................................................... 37, 291 Lock The Vehicle’s Doors................................... 566, 586, 610
Passive Entry.......................................................................... 37
Passive Entry Programming ...................................... 586, 610
Keys............................................................................................. 18 Replacement........................................................................... 32 L
Lane Change And Turn Signals .............................................. 71 Lane Change Assist .................................................................. 71
LaneSense ................................................................................. 391
Lap/Shoulder Belts ................................................................ 237
Latches ...................................................................................... 289 Hood ..................................................................................... 105
Lead Free Gasoline ................................................................. 548
Leaks, Fluid.............................................................................. 289
Life Of Tires ............................................................................. 529
Light Bulbs ....................................................................... 289, 436
Lights ........................................................................................ 289 Air Bag .................................................................. 179, 246, 287
Brake Assist Warning ......................................................... 204 Brake Warning .....................................................................179
Bulb Replacement................................................................436
Cargo .......................................................................................72
Center Mounted Stop..........................................................443
Courtesy/Reading ................................................................73
Cruise ............................................................................193, 194 Daytime Running ..................................................................67
Electronic Stability Program(ESP) Indicator ...................181
Engine Temperature Warning ...........................................181
Exterior............................................................................66, 289Fog .........................................................................................441
Hazard Warning Flasher ....................................................431
Headlights ........................................................................66, 70High Beam ..............................................................................68
High Beam/Low Beam Select .............................................68
Hill Descent Control Indicator .......................................... 205Illuminated Entry ..................................................................75
Interior ....................................................................................73
Lights On Reminder..............................................................71
Low Fuel ...............................................................................185
Malfunction Indicator (Check Engine).............................183Park........................................................................................192Passing ....................................................................................69
Seat Belt Reminder ..............................................................179
Security Alarm .....................................................................180
Service ...................................................................................436
11
2020_DT_1500_OM_US.book Page 663

664
Traction Control .................................................................. 204
Turn Signals ........................................... 71, 193, 289, 438, 441
Warning Instrument Cluster Descriptions .............. 181, 193
Limited-Slip Differential ................................................ 332, 515
Load Shed Battery Saver Mode............................................. 176
Load Shed Battery Saver On ................................................. 176
Load Shed Electrical Load Reduction .................................. 176
Load Shed Intelligent Battery Sensor ................................... 176
Loading Vehicle ...................................................................... 405 Tires....................................................................................... 521
Locks Automatic Door..................................................................... 41
Child Protection .................................................................... 42
Power Door ............................................................................ 36
Low Tire Pressure System ..................................................... 227
Lubrication, Body ................................................................... 502
Lug Nuts................................................................................... 547
Lug Nuts/Bolts ....................................................................... 546 M
Maintenance..................................................................... 100, 105
Maintenance Free Battery ...................................................... 491
Maintenance Schedule ........................................................... 482
Malfunction Indicator Light (Check Engine) ...................... 183
Manual Service ................................................................................... 656
Media Hub ............................................................................... 623 Memory Seat ..............................................................................47
Methanol...................................................................................550
Mirrors ........................................................................................59
Electric Powered ....................................................................61
Heated .....................................................................................65
Memory...................................................................................47
Outside....................................................................................61
Rearview ................................................................... 59, 60, 431 Trailer Towing .......................................................................64
Modifications/Alterations Vehicle.....................................................................................15
Monitor, Tire Pressure System ..............................................227
Mopar Parts..............................................................................655
MP3 Control ............................................................................. 623
Multi-Function Control Lever .................................................68 N
New Vehicle Break-In Period ................................................297 O
Occupant Restraints ................................................................234
Octane Rating, Gasoline (Fuel)......................................548, 549
Off-Pavement Driving (Off-Road) ........................................429
Off-Road Driving (Off-Pavement) ........................................429
Oil Filter, Change .................................................................... 494
Oil Filter, Selection ..................................................................494
Oil Pressure Light ...................................................................181
Oil, Engine ........................................................................492, 554
2020_DT_1500_OM_US.book Page 664

INSTALLATION OF RADIO TRANSMITTING
EQUIPMENT
Special design considerations are incorporated into this
vehicle’s electronic system to provide immunity to radio
frequency signals. Mobile two-way radios and telephone
equipment must be installed properly by trained person-
nel. The following must be observed during installation.
The positive power connection should be made
directly to the battery and fused as close to the battery as
possible. The negative power connection should be made
to body sheet metal adjacent to the negative battery
connection. This connection should not be fused.
Antennas for two-way radios should be mounted on
the roof or the rear area of the vehicle. Care should be
used in mounting antennas with magnet bases. Magnets
may affect the accuracy or operation of the compass on
vehicles so equipped.
The antenna cable should be as short as practical and
routed away from the vehicle wiring when possible. Use
only fully shielded coaxial cable.
Carefully match the antenna and cable to the radio to
ensure a low Standing Wave Ratio (SWR). Mobile radio equipment with output power greater than
normal may require special precautions.
All installations should be checked for possible

interference between the communications equipment
and the vehicle’s electronic systems.
Operating, servicing and maintain -
ing a passenger vehicle or off-highway
motor vehicle can expose you to chemicals
including engine exhaust, carbon monox -
ide, phthalates, and lead, which are known
to the State of California to cause cancer and
birth defects or other reproductive harm.
To minimize exposure, avoid breathing
exhaust, do not idle the engine except as
necessary, service your vehicle in a
well-ventilated area and wear gloves or
wash your hands frequently when servicing
your vehicle. For more information go to
www.P65Warnings.ca.gov/passenger-vehicle .
WARNING: