boot Ram 2500 2011 Owner's manual (Gas and Diesel)

JOBNAME: 288987 2011 Maint-Wa PAGE: 8 SESS: 55 OUTPUT: Wed May 26 09:12:27 2010
/chrysler/chry-intl/warr-maint/288987-ram-gasdsl-en/warranty
5/100 POWERTRAIN WARRANTY
The following powertrain components are covered for5 years or 100,000
kilometres,whichever occurs first, measured from the vehicle’s original
warranty start date.
Vehicles placed in taxi, limousine, postal or ambulance service and all SRT
vehicles are excluded from the5-year or 100,000-kilometrePowertrain
Warranty, and are covered only under the3-year or 60,000-kilometreBasic
Warranty.
•Engine –Cylinder block and all internal parts; cylinder head assem-
blies; timing case, timing chain, timing belt, gears and sprockets;
vibration damper; oil pump; water pump and housing; intake and
exhaust manifolds; flywheel with starter ring gear; core plugs; valve
covers; oil pan; turbocharger housing and internal parts; turbocharger
wastegate actuator; supercharger; serpentine belt tensioner; seals and
gaskets for listed components only.
•Transmission –Transmission case and all internal parts; torque con-
verter; drive/flex plate; transmission range switch; transmission control
module; bell housing; oil pan; seals and gaskets for listed components
only.
Note: Manual transmission clutch parts are not covered at any time.•Rear-Wheel Drive (If equipped) –Rear axle housing and all internal
parts; axle shafts; axle shaft bearings; driveshaft assemblies; driveshaft
centre bearings; universal joints and yokes; seals and gaskets for listed
components only.
•4-Wheel Drive (4x4) (If equipped)–Transfer case and all internal parts;
transfer case control module and shift mode motor assembly; axle
housing and all internal parts; axle shafts; axle shaft bearings; drive-
shaft assemblies (front and rear); driveshaft centre bearings; universal
joints and yokes; disconnect housing assembly; seals and gaskets for
the listed components.
•All-Wheel Drive (AWD) (If equipped) –Power transfer unit and all
internal parts; driveshaft and axle shaft assemblies; constant velocity
joints and boots; axle housing and all internal parts; differential carrier
assembly and all internal parts; output ball bearing; output flange; end
cover; viscous converter clutch; overrunning clutch; vacuum motor;
torque tube; pinion spacer and shim; seals and gaskets for these parts
only.
8
5/100 POWERTRAIN WARRANTY

JOBNAME: 288987 2011 Maint-Wa PAGE: 3 SESS: 59 OUTPUT: Wed May 26 09:12:27 2010
/chrysler/chry-intl/warr-maint/288987-ram-gasdsl-en/01bintervals-gas
Perform Maintenance At
26,000 km or 12 Months
❏Change the engine oil and oil filter.Under no circumstances should the oil change
interval exceed 13,000 km or 6 months whichever occurs first.*
❏Rotate tires, rotate at the first sign of irregular wear even if it occurs prior to this
service.
❏Lubricate the front drive shaft fitting. (All 4x4 models except 1500)
❏Inspect the engine air filter if using your vehicle in dusty or off-road conditions;
replace if necessary.
❏Inspect the brake linings; replace if necessary.
❏Inspect the CV joints.
❏Inspect the exhaust system.
❏Inspect the front suspension components, tie rod ends and boot seals; replace if
necessary.
* Oil changes that are prompted by the oil change indicator system prior to this schedule maintenance interval can
be recorded in the oil change log section.
Perform Maintenance
At
12 Months or
26,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................

JOBNAME: 288987 2011 Maint-Wa PAGE: 4 SESS: 59 OUTPUT: Wed May 26 09:12:27 2010
/chrysler/chry-intl/warr-maint/288987-ram-gasdsl-en/01bintervals-gas
❏Change the engine oil and oil filter.Under no circum-
stances should the oil change interval exceed 13,000 km
or 6 months whichever occurs first.*
❏Rotate tires, rotate at the first sign of irregular wear even if
it occurs prior to this service.
❏Lubricate the front drive shaft fitting. (All 4x4 models ex-
cept 1500)
❏Inspect the engine air filter if using your vehicle in dusty
or off-road conditions; replace if necessary.
❏Inspect the brake linings; replace if necessary.
❏Inspect the CV joints.
❏Inspect the exhaust system.
❏Inspect the front suspension components, tie rod ends and
boot seals; replace if necessary.
* Oil changes that are prompted by the oil change indicator system prior to this
schedule maintenance interval can be recorded in the oil change log section.
Perform Maintenance At
26,000 km or 12 Months
Odometer Reading
Date
Repair Order No.
CHRYSLER
RETAILERSTAMP
Signature of authorized Chrysler Canada Retailer
................................................................................................

JOBNAME: 288987 2011 Maint-Wa PAGE: 7 SESS: 59 OUTPUT: Wed May 26 09:12:27 2010
/chrysler/chry-intl/warr-maint/288987-ram-gasdsl-en/01bintervals-gas
Perform Maintenance At
52,000 km or 24 Months
❏Change the engine oil and oil filter.Under no circumstances should the oil change
interval exceed 13,000 km or 6 months whichever occurs first.*
❏Rotate tires, rotate at the first sign of irregular wear even if it occurs prior to this
service.
❏Lubricate the front drive shaft fitting. (All 4x4 models except 1500)
❏Inspect the brake linings; replace if necessary.
❏Inspect the front suspension components, tie rod ends and boot seals; replace if
necessary.
❏Adjust the parking brake on vehicles equipped with four-wheel disc brakes.
❏Replace the engine air filter.
❏Inspect the transfer case fluid. (4x4)
❏Replace the spark plugs on 3.7L and 5.7L engines.
* Oil changes that are prompted by the oil change indicator system prior to this schedule maintenance interval can
be recorded in the oil change log section.
Perform Maintenance
At
24 Months or
52,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................

JOBNAME: 288987 2011 Maint-Wa PAGE: 8 SESS: 59 OUTPUT: Wed May 26 09:12:27 2010
/chrysler/chry-intl/warr-maint/288987-ram-gasdsl-en/01bintervals-gas
❏Change the engine oil and oil filter.Under no circum-
stances should the oil change interval exceed 13,000 km
or 6 months whichever occurs first.*
❏Rotate tires, rotate at the first sign of irregular wear even if
it occurs prior to this service.
❏Lubricate the front drive shaft fitting. (All 4x4 models ex-
cept 1500)
❏Inspect the brake linings; replace if necessary.
❏Inspect the front suspension components, tie rod ends and
boot seals; replace if necessary.
❏Adjust the parking brake on vehicles equipped with four-
wheel disc brakes.
❏Replace the engine air filter.
❏Inspect the transfer case fluid. (4x4)
❏Replace the spark plugs on 3.7L and 5.7L engines.
* Oil changes that are prompted by the oil change indicator system prior to this
schedule maintenance interval can be recorded in the oil change log section.
Perform Maintenance At
52,000 km or 24 Months
Odometer Reading
Date
Repair Order No.
CHRYSLER
RETAILERSTAMP
Signature of authorized Chrysler Canada Retailer
................................................................................................

JOBNAME: 288987 2011 Maint-Wa PAGE: 11 SESS: 59 OUTPUT: Wed May 26 09:12:27 2010
/chrysler/chry-intl/warr-maint/288987-ram-gasdsl-en/01bintervals-gas
Perform Maintenance At
78,000 km or 36 Months
❏Change the engine oil and oil filter.Under no circumstances should the oil change
interval exceed 13,000 km or 6 months whichever occurs first.*
❏Rotate tires, rotate at the first sign of irregular wear even if it occurs prior to this
service.
❏Lubricate the front drive shaft fitting. (All 4x4 models except 1500)
❏Inspect the engine air filter if using your vehicle in dusty or off-road conditions;
replace if necessary.
❏Inspect the brake linings; replace if necessary.
❏Inspect the front (4x4) and rear axle fluid; change if using your vehicle for any of
the following: police, fleet, off-road or frequent trailer towing.
❏Inspect the CV joints.
❏Inspect the exhaust system.
❏Inspect the front suspension components, tie rod ends and boot seals; replace if
necessary.
❏Replace the top row of spark plugs on 4.7L engines.**
* Oil changes that are prompted by the oil change indicator system prior to this schedule maintenance interval can
be recorded in the oil change log section.
** Vehicles built with the 4.7L engine are equipped with sixteen spark plugs, one set is located on the top of the
engine under the coils and the second set is located on the side of the engine. The spark plugs located under the
coils are a standard plug and must be change every 78,000 kilometres. The spark plugs located on the side of the
engine are a premium plug and must be changed every 156,000 kilometres.
Perform Maintenance
At
36 Months or
78,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................

JOBNAME: 288987 2011 Maint-Wa PAGE: 12 SESS: 59 OUTPUT: Wed May 26 09:12:27 2010
/chrysler/chry-intl/warr-maint/288987-ram-gasdsl-en/01bintervals-gas
❏Change the engine oil and oil filter.Under no circum-
stances should the oil change interval exceed 13,000 km
or 6 months whichever occurs first.*
❏Rotate tires, rotate at the first sign of irregular wear even if
it occurs prior to this service.
❏Lubricate the front drive shaft fitting. (All 4x4 models ex-
cept 1500)
❏Inspect the engine air filter if using your vehicle in dusty
or off-road conditions; replace if necessary.
❏Inspect the brake linings; replace if necessary.
❏Inspect the front (4x4) and rear axle fluid; change if using
your vehicle for any of the following: police, fleet, off-
road or frequent trailer towing.
❏Inspect the CV joints.
❏Inspect the exhaust system.
❏Inspect the front suspension components, tie rod ends and
boot seals; replace if necessary.
❏Replace the top row of spark plugs on 4.7L engines.**
* Oil changes that are prompted by the oil change indicator system prior to this
schedule maintenance interval can be recorded in the oil change log section.
** Vehicles built with the 4.7L engine are equipped with sixteen spark plugs, one
set is located on the top of the engine under the coils and the second set is
located on the side of the engine. The spark plugs located under the coils are a
standard plug and must be change every 78,000 kilometres. The spark plugs
located on the side of the engine are a premium plug and must be changed
every 156,000 kilometres.
Perform Maintenance At
78,000 km or 36 Months
Odometer Reading
Date
Repair Order No.
CHRYSLER
RETAILERSTAMP
Signature of authorized Chrysler Canada Retailer
................................................................................................

JOBNAME: 288987 2011 Maint-Wa PAGE: 15 SESS: 60 OUTPUT: Wed May 26 09:12:27 2010
/chrysler/chry-intl/warr-maint/288987-ram-gasdsl-en/01bintervals-gas
Perform Maintenance At
104,000 km or 48 Months
❏Change the engine oil and oil filter.Under no circumstances should the oil change
interval exceed 13,000 km or 6 months whichever occurs first.*
❏Rotate tires, rotate at the first sign of irregular wear even if it occurs prior to this
service.
❏Lubricate the front drive shaft fitting. (All 4x4 models except 1500)
❏Inspect the brake linings; replace if necessary.
❏Inspect the front suspension components, tie rod ends and boot seals; replace if
necessary.
❏Adjust the parking brake on vehicles equipped with four-wheel disc brakes.
❏Replace the engine air filter.
❏Replace the spark plugs on 3.7L and 5.7L engines.
❏Replace the ignition cables on 3.7L engines.
❏Change the automatic transmission fluid and filter if using your vehicle for any of
the following: police, fleet or frequent trailer towing.
❏Inspect the transfer case fluid (4x4); change if using your vehicle for any of the
following: police, fleet or frequent trailer towing.
* Oil changes that are prompted by the oil change indicator system prior to this schedule maintenance interval can
be recorded in the oil change log section.
Perform Maintenance
At
48 Months or
104,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................

JOBNAME: 288987 2011 Maint-Wa PAGE: 16 SESS: 60 OUTPUT: Wed May 26 09:12:27 2010
/chrysler/chry-intl/warr-maint/288987-ram-gasdsl-en/01bintervals-gas
❏Change the engine oil and oil filter.Under no circum-
stances should the oil change interval exceed 13,000 km
or 6 months whichever occurs first.*
❏Rotate tires, rotate at the first sign of irregular wear even if
it occurs prior to this service.
❏Lubricate the front drive shaft fitting. (All 4x4 models ex-
cept 1500)
❏Inspect the brake linings; replace if necessary.
❏Inspect the front suspension components, tie rod ends and
boot seals; replace if necessary.
❏Adjust the parking brake on vehicles equipped with four-
wheel disc brakes.
❏Replace the engine air filter.
❏Replace the spark plugs on 3.7L and 5.7L engines.
❏Replace the ignition cables on 3.7L engines.
❏Change the automatic transmission fluid and filter if using
your vehicle for any of the following: police, fleet or fre-
quent trailer towing.
❏Inspect the transfer case fluid (4x4); change if using your
vehicle for any of the following: police, fleet or frequent
trailer towing.
* Oil changes that are prompted by the oil change indicator system prior to this
schedule maintenance interval can be recorded in the oil change log section.
Perform Maintenance At
104,000 km or 48 Months
Odometer Reading
Date
Repair Order No.
CHRYSLER
RETAILERSTAMP
Signature of authorized Chrysler Canada Retailer
................................................................................................

JOBNAME: 288987 2011 Maint-Wa PAGE: 19 SESS: 59 OUTPUT: Wed May 26 09:12:27 2010
/chrysler/chry-intl/warr-maint/288987-ram-gasdsl-en/01bintervals-gas
Perform Maintenance At
130,000 km or 60 Months
❏Change the engine oil and oil filter.Under no circumstances should the oil change
interval exceed 13,000 km or 6 months whichever occurs first.*
❏Rotate tires, rotate at the first sign of irregular wear even if it occurs prior to this
service.
❏Lubricate the front drive shaft fitting. (All 4x4 models except 1500)
❏Inspect the engine air filter if using your vehicle in dusty or off-road conditions;
replace if necessary.
❏Inspect the brake linings; replace if necessary.
❏Inspect the front suspension components, tie rod ends and boot seals; replace if
necessary.
❏Flush and replace the engine coolant at 60 months if not done at 169,000 km.
* Oil changes that are prompted by the oil change indicator system prior to this schedule maintenance interval can
be recorded in the oil change log section.
Perform Maintenance
At
60 Months or
130,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................