ESP Ram 2500 2015 Repair Manual

•For tough stains, apply MOPAR® Total Clean, or a
mild soap solution to a clean, damp cloth and remove
stain. Use a fresh, damp towel to remove soap residue.
• For grease stains, apply MOPAR® Multi-Purpose
Cleaner to a clean, damp cloth and remove stain. Use
a fresh, damp towel to remove soap residue.
• Do not use any harsh solvents or any other form of
protectants on Stain Repel products.
Interior Care
Use MOPAR® Total Clean to clean fabric upholstery and
carpeting.
Use MOPAR® Total Clean to clean vinyl upholstery.
MOPAR® Total Clean is specifically recommended for
leather upholstery. Your leather upholstery can be best preserved by regular
cleaning with a damp soft cloth. Small particles of dirt
can act as an abrasive and damage the leather upholstery
and should be removed promptly with a damp cloth.
Stubborn soils can be removed easily with a soft cloth
and MOPAR® Total Clean. Care should be taken to avoid
soaking your leather upholstery with any liquid. Please
do not use polishes, oils, cleaning fluids, solvents, deter-
gents, or ammonia-based cleaners to clean your leather
upholstery. Application of a leather conditioner is not
required to maintain the original condition.
WARNING!
Do not use volatile solvents for cleaning purposes.
Many are potentially flammable, and if used in
closed areas they may cause respiratory harm.
790 MAINTAINING YOUR VEHICLE

Power Distribution Center
The Power Distribution Center is located in the engine
compartment near the battery. This center contains car-
tridge fuses, micro fuses, relays, and circuit breakers. A
description of each fuse and component may be stamped
on the inside cover, otherwise the cavity number of each
fuse is stamped on the inside cover that corresponds to
the following chart.
Cavity Cartridge Fuse Micro FuseDescription
F01 80 Amp Black Rad Fan Control Module – If equipped
F03 60 Amp Yellow Rad Fan – If Equipped
F05 40 Amp Green Compressor for Air Suspension – If Equipped
F06 40 Amp Green Antilock Brakes/Electronic Stability Control Pump
Power Distribution Center Location
7
MAINTAINING YOUR VEHICLE 795

8. Reach through the access hole of the wheel housesplash shield and lift the slide lock upward far enough
to disengage it from the lock post on the back of the
front lamp unit housing. 9. Remove the headlamp assembly. Grasp the outboard
edge of the lamp and pull it straight forward to
disengage the ball stud from the plastic grommet.
10. Disconnect the wiring harness connectors from the bulb socket.
11. Replace bulb(s) as necessary.
CAUTION!
• Do not contaminate the bulb glass by touching it
with your fingers or by allowing it to contact other
oily surfaces. Shortened bulb life will result.
• Always use the correct bulb size and type for
replacement. An incorrect bulb size or type may
overheat and cause damage to the lamp, the bulb
socket, or the lamp wiring.
Slide Lock
7
MAINTAINING YOUR VEHICLE 807

Customer Assistance For The Hearing Or Speech
Impaired (TDD/TTY)
To assist customers who have hearing difficulties, the
manufacturer has installed special TDD (Telecommuni-
cation Devices for the Deaf) equipment at its customer
center. Any hearing or speech impaired customer, who
has access to a TDD or a conventional teletypewriter
(TTY) in the United States, can communicate with the
manufacturer by dialing 1-800-380-CHRY.
Canadian residents with hearing difficulties that require
assistance can use the special needs relay service offered
by Bell Canada. For TTY teletypewriter users, dial 711
and for Voice callers, dial 1-800-855-0511 to connect with
a Bell Relay Service operator.
Service Contract
You may have purchased a service contract for a vehicle
to help protect you from the high cost of unexpected
repairs after the manufacturer’s New Vehicle LimitedWarranty expires. The manufacturer stands behind only
the manufacturer’s service contracts. If you purchased a
manufacturer’s service contract, you will receive Plan
Provisions and an Owner Identification Card in the mail
within three weeks of the vehicle delivery date. If you
have any questions about the service contract, call the
manufacturer’s Service Contract National Customer
Hotline at 1-800-521-9922 (Canadian residents, call (800)
465-2001 English / (800) 387-9983 French).
The manufacturer will not stand behind any service
contract that is not the manufacturer’s service contract. It
is not responsible for any service contract other than the
manufacturer’s service contract. If you purchased a ser-
vice contract that is not a manufacturer’s service contract,
and you require service after the manufacturer’s New
Vehicle Limited Warranty expires, please refer to the
contract documents, and contact the person listed in
those documents.
9
IF YOU NEED CONSUMER ASSISTANCE 835

Temperature Grades
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation of heat
and its ability to dissipate heat, when tested under
controlled conditions on a specified indoor laboratory
test wheel. Sustained high temperature can cause the
material of the tire to degenerate and reduce tire life, and
excessive temperature can lead to sudden tire failure. The
grade C corresponds to a level of performance, which all
passenger car tires must meet under the Federal Motor
Vehicle Safety Standard No. 109. Grades B and A repre-
sent higher levels of performance on the laboratory test
wheel, than the minimum required by law.
WARNING!
The temperature grade for this tire is established for
a tire that is properly inflated and not overloaded.
Excessive speed, under-inflation, or excessive load-
ing, either separately or in combination, can cause
heat buildup and possible tire failure.
840 IF YOU NEED CONSUMER ASSISTANCE

Adding Engine Coolant (Antifreeze)............773
Adding Fuel ............................ .636
Adjustable Pedals ........................ .183
Airbag.............................. .67, 68
Air Bag Advance Front Air Bag ....................68
Air bag Operation .......................70
Air Bag Warning Light ....................78
Enhanced Accident Response ................78
Event Data Recorder (EDR) .................81
FrontAirBag ........................67, 68
If A Deployment Occurs ...................76
Knee Impact Bolsters .....................71
Maintaining Your Air Bag System ............80
Side Air Bags ...........................72
Air bag Deployment ........................67
Air bag Light ..................... .78, 116, 285
Air bag Maintenance ........................80
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .755 Air Conditioner Maintenance
.................761
Air Conditioning ..................... .395, 400
Air Conditioning Controls ................395, 400
Air Conditioning, Operating Tips ...........414, 416
Air Conditioning Refrigerant ..........761, 762, 763
Air Conditioning System ..........395, 400, 413, 761
Air Pressure, Tires .....................602, 613
Air Suspension .......................... .510
Alarm Light ............................ .285
Alarm, Panic .............................28
Alarm (Security Alarm) ......................21
Alarm System (Security Alarm) ................21
Alterations/Modifications, Vehicle ...............7
Antifreeze (Engine Coolant) ...............772, 815
Disposal ............................. .775
Anti-Lock Brake System (ABS) ................576
Anti-Lock Warning Light .................285, 577
Appearance Care ........................ .786
Ashtray ............................... .229
842 INDEX

Break-In Recommendations................113
Compartment ......................... .744
Compartment Identification .........744, 745, 746
Coolant (Antifreeze) .....................817
Exhaust Gas Caution .................114,632
Flooded, Starting ...................... .445
Fuel Requirements ...................627, 815
Jump Starting ......................... .725
Oil .......................... .751, 815, 817
Oil Filler Cap ...................... .753, 754
Oil Selection ...................... .752, 815
Oil Synthetic ......................... .754
Overheating .......................... .679
Engine Oil Viscosity ....................753, 754
Engine Oil Viscosity Chart ...................753
Enhanced Accident Response Feature ............78
Entry System, Illuminated ....................24
Ethanol ............................... .629
Event Data Recorder ........................81 Exhaust Gas Caution
....................114,632
Exhaust System .......................114,768
Exterior Lighting ......................... .165
Exterior Lights ...........................117
Filters Air Cleaner .......................... .755
Engine Oil ........................ .754, 817
Engine Oil Disposal .....................754
Flashers Turn Signal .....................117, 175, 285
Flat Tire Stowage ..................... .698, 719
Flexible Fuel Vehicles Cruising Range ........................ .635
Engine Oil ........................... .634
Fuel Requirements ...................633, 634
Maintenance .......................... .636
Replacement Parts ...................... .635
Starting ............................. .635
10
INDEX 847

Airbag........................ .78, 116, 285
Alarm .............................. .285
Anti-Lock ............................ .285
Anti-Lock Warning ..................... .577
Automatic Headlights ....................166
Brake Assist Warning ....................585
Brake Warning ........................ .285
Bulb Replacement ...................... .805
Cap Top Clearance ......................811
Cargo .............................. .174
Center Mounted Stop ....................810
Check Engine (Malfunction Indicator) .........285
Courtesy/Reading ................172, 174, 209
Daytime Running ...................... .167
Electronic Stability Program (ESP) Indicator .....585
Exterior ..............................117
Fog ......................... .170, 285, 808
Four-Wheel Drive Indicator ................491
Hazard Warning Flasher ..................679 Headlights
........................... .165
High Beam ....................... .176, 285
High Beam Indicator .....................285
High Beam/Low Beam Select ...............176
Hill Descent Control Indicator ..............587
Illuminated Entry ........................24
Instrument Cluster ..................... .285
Interior ....................171, 172, 174, 209
Oil Pressure .......................... .285
Passing ............................. .176
Seat Belt Reminder ..................... .285
Security Alarm ........................ .285
Service .......................... .804, 805
Side Marker .......................... .814
Tire Pressure Monitoring (TPMS) .........285, 619
Traction Control ....................... .585
Transfer Case ......................... .491
T

urn Signal ..................117, 175, 806, 808
Warning (Instrument Cluster Description) ......28510
INDEX 851