tires Ram 2500 (Diesel) 2007 Service Manual

Miles 82,500 90,000 97,500 100,000 105,000
(Kilometers) (133 000) (145 000) (157 000) (160 000) (169 000)
[Months] [66] [72] [78] [84]
Change engine oil and engine oil filter. X X X X
Lubricate Front Drive Shaft Fitting (4X4). X X X X
Rotate tires. X X X X
Check spare tire for proper pressure and correct
stowage.XXX X
Lubricate outer tie rod ends. X X X X
Flush and replace engine coolant, if not replaced at
60 mos.X
Check transfer case fluid level (4X4). X
Change front and rear axle fluid (4X4). X X
Inspect drive belt, replace as required.* X X
Inspect fan hub. X
Inspect damper. X
Replace fuel filter element. X X
518 SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 112,500 120,000 127,500 135,000 142,500 150,000
(Kilometers) (181 000) (193 000) (205 000) (217 000) (229 000) (241 000)
[Months] [90] [96] [102] [108] [114] [120]
Change engine oil and engine oil filter. X X X X X X
Lubricate Front Drive Shaft Fitting (4X4). X X X X X X
Rotate tires. X X X X X X
Check spare tire for proper pressure and cor-
rect stowage.X X XXXX
Lubricate outer tie rod ends. X X X X X X
Flush and replace engine coolant at 120
months, if not replaced at 100,000 miles
(161 000 km).X
Inspect drive belt, replace as required.* X X X
Drain and refill transfer case fluid (4X4). X
Check transfer case fluid level (4X4).X
Change front and rear axle fluid (4X4). X X X
520 SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

DEPARTMENT OF TRANSPORTATION UNIFORM
TIRE QUALITY GRADES
The following describes the tire grading categories estab-
lished by the National highway Traffic Safety Adminis-
tration. The specific grade rating assigned by the tire’s
manufacturer in each category is shown on the sidewall
of the tires on your car.
All Passenger Car Tires Must Conform to Federal Safety
Requirements in Addition to These Grades.
Treadwear
The treadwear grade is a comparative rating based on the
wear rate of the tire when tested under controlled con-
ditions on a specified government test course. For ex-
ample, a tire graded 150 would wear one and a half (1
1/2) times as well on the government course as a tire
graded 100. The relative performance of tires depends
upon the actual conditions of their use, however, andmay depart significantly from the norm due to variations
in driving habits, service practices and differences in road
characteristics and climate.
Traction Grades
The traction grades, from highest to lowest, are AA, A, B,
and C. Those grades represent the tire’s ability to stop on
wet pavement as measured under controlled conditions
on specified government test surfaces of asphalt and
concrete. A tire marked C may have poor traction perfor-
mance.
WARNING!
The traction grade assigned to this tire is based on
straight-ahead braking traction tests, and does not
include acceleration, cornering, hydroplaning, or
peak traction characteristics.
530 IF YOU NEED CONSUMER ASSISTANCE

Temperature Grades
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation of heat
and its ability to dissipate heat when tested under
controlled conditions on a specified indoor laboratory
test wheel. Sustained high temperature can cause the
material of the tire to degenerate and reduce tire life, and
excessive temperature can lead to sudden tire failure. The
grade C corresponds to a level of performance which all
passenger car tires must meet under the Federal Motor
Vehicle Safety Standard No. 109. Grades B and A repre-
sent higher levels of performance on the laboratory test
wheel than the minimum required by law.WARNING!
The temperature grade for this tire is established for
a tire that is properly inflated and not overloaded.
Excessive speed, under inflation, or excessive load-
ing, either separately or in combination, can cause
heat buildup and possible tire failure.
IF YOU NEED CONSUMER ASSISTANCE 531
9

Adding Fuel........................... 352
Adjustable Pedals....................... 138
Air Cleaner, Engine
(Engine Air Cleaner Filter)............422,424,460
Air Conditioner Maintenance............... 438
Air Conditioning Refrigerant.............438,439
Air Conditioning System................259,438
Air Conditioning System, Zone Control........ 262
AirFilter ...........................422,424
Air Pressure, Tires....................335,343
Airbag.............................. 46,52
Airbag Light......................... 77,199
Airbag On/Off Switch..................... 52
Airbag, Side............................ 55
Alarm, Out of Park Sense...............296,302
Alarm, Panic............................ 23
Alarm (Security Alarm)................. 18,201
Alarm System (Security Alarm)............... 18
Alignment and Balance................... 342Alterations/Modifications, Vehicle............. 8
Antenna, Satellite Radio................... 252
Antifreeze (Engine Coolant)..............446,447
Capacities........................... 487
Anti-Lock Warning Light...............204,324
Anti-Theft Security Alarm (Theft Alarm)........ 18
Anti-Theft System..................... 18,201
Appearance Care........................ 463
Ashtray............................... 171
AutomaticDimmingMirror ................. 85
Automatic Door Locks.................... 153
Automatic Transaxle...................... 12
Interlock System........................ 15
Automatic Transmission................... 455
Adding Fluid......................... 456
Fluid and Filter Changes................. 457
Fluid Level Check...................... 455
FluidType ........................457,491
Shift Indicator........................ 201
534 INDEX

General Information.................... 18,114
Glass Cleaning.......................... 466
Grocery Bag Retainer..................... 181
Gross Axle Weight Rating.................. 359
Gross Vehicle Weight Rating................ 358
GVWR ............................... 355
Hands-Free Phone (UConnect™).............. 89
Hazard Warning Flasher................... 386
Head Restraints......................... 117
Headlights............................ 474
High Beam........................... 134
High Beam/Low Beam Select Switch........ 134
Lights On Reminder.................... 132
Passing............................. 134
Switch .............................. 130
Heated Mirrors....................... 88,181
Heated Seats........................... 125
Heater............................... 259High Beam/Low Beam Select (Dimmer) Switch . . 134
Hitches
TrailerTowing ........................ 362
Hoisting .............................. 398
HomeLink(Garage Door Opener) Transmitter . . . 160
Hood Release.......................... 127
Hoses.............................451,453
Hub Caps............................. 394
Hydraulic Clutch Fluid.................... 453
Ignition............................... 12
Key ................................. 12
Ignition Key Removal..................... 12
Illuminated Entry........................ 19
Infant Restraint........................ 60,61
Inflation Pressure Tires.................... 343
Information Center...................... 151
Information Center, Vehicle................. 151
Inside Rearview Mirror.................... 84
540 INDEX

Instrument Cluster....................196,198
Instrument Panel and Controls.............. 195
Instrument Panel Lens Cleaning............. 467
Integrated Power Module (Fuses)............ 468
Interior Appearance Care.................. 466
Interior Lights.......................... 129
Intermittent Wipers (Delay Wipers)........... 135
Intervention Regeneration Strategy........... 434
Introduction............................. 4
Jack Location........................... 387
Jack Operation.......................... 389
Jump Starting.......................... 399
Key, Replacement........................ 16
Key, Sentry (Immobilizer)................... 15
Keyless Entry System...................... 20
Keys................................. 12Lane Change and Turn Signals.............. 133
LapBelts .............................. 43
Lap/Shoulder Belts....................... 34
LATCH (Lower Anchors and Tether for CHildren) . 65
LifeofTires ............................ 340
Lights .............................. 78,128
Airbag............................ 57,199
Anti-Lock Warning..................204,324
Brake Warning........................ 203
Bulb Replacement...................473,474
Cap Top Clearance..................... 482
Cargo .............................. 132
Center Mounted Stop................... 481
Check Engine (Malfunction Indicator)........ 202
Courtesy/Reading..................... 142
Cruise .............................. 206
Daytime Running...................... 131
Dome.............................. 150
Dual Wheel Assembly Rear............... 484
INDEX 541
10

Fog ..........................132,202,477
Four-Wheel Drive Indicator............... 309
Hazard Warning Flasher................. 386
Headlights........................... 130
High Beam........................134,199
High Beam Indicator.................... 199
High Beam/Low Beam Select............. 134
Illuminated Entry....................... 19
Instrument Cluster..................... 198
Intensity Control....................... 129
Interior..........................129,142
Lights On Reminder.................... 132
Passing............................. 134
Reading............................. 150
Seat Belt Reminder..................... 199
Service...........................473,474
Side Marker.......................... 486
Transfer Case......................... 309
Transmission Warning................... 205Turn Signal..................133,199,474,478
Warning (Instrument Cluster Description)..... 198
Limited-Slip Differential................317,454
Loading Vehicle......................... 355
Tires ............................... 330
Locks................................. 25
Child Protection........................ 29
Door................................ 25
Keys................................ 12
Power Door........................... 26
Steering Wheel......................... 15
Lower Anchors and Tether for CHildren (LATCH) . 65
Lubrication, Body....................... 441
LugNuts ............................. 394
Lumbar Support........................ 118
Maintenance........................... 411
Maintenance Procedures................... 414
Maintenance Schedule..................494,511
542 INDEX

Sunroof............................. 166
Windows............................. 30
Power Steering Fluid..................... 491
Pregnant Women and Seat Belts.............. 45
Pretensioners
Seat Belts............................. 44
Programmable Electronic Features......153,162,165
Radial Ply Tires......................... 337
Radiator Cap (Coolant Pressure Cap).......... 447
Radio Broadcast Signals................... 207
Radio, Navigation....................... 245
Radio Operation...................209,217,231
Radio Remote Controls.................... 253
Radio, Satellite.......................245,249
Radio (Sound Systems)..............209,217,231
Rear Axle (Differential).................... 454
Rear Seat, Folding....................120,122
Rear Wheel Bearings..................... 458Rear Window Features.................... 181
Rear Window, Sliding................... 32,182
Reclining Front Seats..................... 116
Reclining Rear Seats...................... 120
Recorder, Event Data...................... 58
Recreational Towing...................... 377
Shifting into Transfer Case Neutral (N)....378,380
Shifting out of Transfer Case Neutral (N) . . . 379,382
Refrigerant............................ 439
Reminder, Seat Belt....................... 44
Remote Keyless Entry (RKE)................. 20
Remote Sound System (Radio) Controls........ 253
Replacement Tires....................... 341
Reporting Safety Defects................... 527
Resetting Oil Change Indicator...........153,156
Resetting Perform Service Indicator........... 513
Restraint, Head......................... 117
Restraints, Child....................... 60,68
Rotation, Tires.......................... 345
INDEX 545
10

Automatic Transmission...............291,297
Manual Transmission................... 303
Transfer Case......................... 308
Transfer Case, Shifting into Transfer Case
Neutral (N).........................378,380
Transfer Case, Shifting out of Transfer Case
Neutral (N).........................379,382
Shoulder Belt Upper Anchorage.............. 42
Shoulder Belts........................... 34
Side Airbag............................. 55
Signals, Turn........................... 133
Sliding Rear Window
Power............................ 32,182
Slippery Surfaces, Driving On............... 318
Snow Chains (Tire Chains)................. 343
Snow Plow............................ 373
Snow Tires............................ 345
Soot Filter............................. 434
Spare Tire............................. 338Speed Control (Cruise Control).............. 139
Speedometer........................... 199
Starting............................... 275
Automatic Transmission................. 276
Engine Block Heater.................276,283
Manual Transmission................... 275
Starting Procedures...................... 275
Starting Procedures (Diesel Engines).......... 275
Steering
Linkage............................. 440
Power...........................324,439
Wheel Lock........................... 15
Wheel, Tilt........................... 137
Steering Wheel Mounted Sound System Controls . 253
Storage, Behind the Seat................... 176
Storage Compartment, Center Seat.........176,177
Storage, Vehicle......................... 472
StoringYourVehicle ...................... 472
Sun Roof.............................. 166
INDEX 547
10