check engine Ram 3500 2011 Owner's Guide

Fluid Level Check
If equipped with a dipstick, use the following procedure.
If your vehicle has a capped dipstick tube, it is sealed and
should not be tampered with. Your authorized dealer has
the proper tools to ensure that the fluid level is set
properly. The fluid level should be checked when the
engine is fully warmed up and the fluid in the transmis-
sion is at normal operating temperature. Operation of the
transmission with an improper fluid level will greatly
reduce the life of the transmission and of the fluid. Check
the fluid level whenever the vehicle is serviced.
Fluid Level Check – 42RLE/545RFE
Check the fluid level while the transmission is at normal
operating temperature 82°C (180°F). This occurs after at
least 15 miles (25 km) of driving. At normal operating
temperature the fluid cannot be held comfortably be-
tween the fingertips.To check the automatic transmission fluid level properly,
the following procedure must be used:
1. Operate the engine at idle speed and normal operating
temperature.
2. The vehicle must be on level ground.
3. Fully apply the parking brake and press the brake
pedal.
4. Place the shift lever momentarily into each gear posi-
tion ending with the lever in PARK.
5. Remove the dipstick, wipe it clean and reinsert it until
seated.
6. Remove the dipstick again and note the fluid level on
both sides. The fluid level should be between the “HOT”
(upper) reference holes on the dipstick at normal operat-
ing temperature. Verify that solid coating of oil is seen on
both sides of the dipstick. If the fluid is low, add as
544 MAINTAINING YOUR VEHICLE

VEHICLE STORAGE
If you are storing your vehicle for more than 21 days, we
recommend that you take the following steps to mini-
mize the drain on your vehicle’s battery:
•Disconnect the Ignition-Off Draw (IOD) fuse located in
the Integrated Power Module, located in the engine
compartment. The IOD cavity includes a snap-in re-
tainer that allows the fuse to be disconnected without
removing it from the fuse block.
•As an alternative to the above steps you may discon-
nect the negative cables from both batteries.
•Any time you store your vehicle or keep it out of
service (i.e., vacation) for two weeks or more, run the
air conditioning system at idle for about five minutes
in the fresh air and high blower setting. This will
ensure adequate system lubrication to minimize the
possibility of compressor damage when the system is
started again.NOTE:
•When reinstalling the IOD fuse push firmly until fully
seated; the gauges in the instrument cluster will do a
full sweep when the ignition switch is turned to the
RUN position. This is a normal condition.
•When the vehicle is shipped from the factory, the IOD
fuse is in the up or extracted position. If the radio,
interior lamps, keyless entry or other features do not
work with the key OFF, check the position of the fuse
(or check to see if the fuse is blown) to ensure that it is
fully seated. When the IOD fuse is extracted, the
instrument cluster in the odometer window will dis-
playNO FUSE.”
558 MAINTAINING YOUR VEHICLE

NOTE:
•The oil change indicator message will not monitor the
time since the last oil change. Change your vehicle’s
oil if it has been six months since your last oil change
even if the oil change indicator message is NOT
illuminated.
•Change your engine oil more often if you drive your
vehicle off-road for an extended period of time.
•Under no circumstances should oil change intervals
exceed 8,000 miles (13 000 km) or six months, which-
ever comes first.
Your authorized dealer will reset the oil change indicator
message after completing the scheduled oil change. If a
scheduled oil change is performed by someone other
than your authorized dealer, the message can be reset by
referring to the steps described under “Electronic Vehicle
Information Center (EVIC)/Oil Change Required” in“Understanding Your Instrument Panel” or under “In-
strument Cluster Description/Odometer/Trip Odom-
eter” in “Understanding Your Instrument Panel” for
further information.
At Each Stop for Fuel
•Check the engine oil level about five minutes after a
fully warmed engine is shut off. Checking the oil level
while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when
the level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
SMAINTENANCE SCHEDULES 575

•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of the coolant reservoir, brake
master cylinder, and transmission and add as needed.
•Check all lights and other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the brake hoses and lines.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
NOTE:** Vehicles built with the 4.7L engine are
equipped with sixteen spark plugs. One set is located on
the top of the engine under the coils and the second set is
located on the side of the engine.
The spark plugs located under the coils are a standard
plug and must be changed every 48,000 miles
(78 000 km).
The spark plugs located on the side of the engine are a
premium plug and must be changed every 96,000 miles
(156 000 km).
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S576 MAINTENANCE SCHEDULES

Fluid Level Check...................543,544
Fluid Type........................543,572
Gear Ranges.......................... 311
Shifting............................. 316
Special Additives...................... 546
Torque Converter...................... 316
Axle Fluid..........................541,572
Axle Lubrication (Axle Fluid)............... 541
Back-Up Camera........................ 147
Battery............................... 526
Keyless Transmitter Replacement (RKE)....... 24
Saving Feature (Protection)............... 127
Belts, Seat............................40,84
Body Builders Guide....................... 6
Body Mechanism Lubrication............... 529
B-Pillar Location........................ 407
Brake Assist System...................... 392
Brake Control System, Electronic............. 390Brake Fluid.........................539,572
Brake System........................390,539
Anti-Lock (ABS)....................... 390
Fluid Check.......................... 539
Master Cylinder....................... 539
Parking............................. 387
Warning Light........................ 215
Brake/Transmission Interlock............... 309
Break-In Recommendations, New Vehicle........ 81
Bulb Replacement....................... 559
Bulbs, Light..........................86,559
Cab Top Clearance Lights.................. 565
Calibration, Compass..................... 237
Camera, Rear........................... 147
Camper............................... 193
Capacities, Fluid........................ 569
Caps, Filler
Oil (Engine).......................... 524
10
INDEX 603

Power Steering........................ 386
Radiator (Coolant Pressure)............... 536
Car Washes............................ 547
Carbon Monoxide Warning...............83,440
Cargo Light............................ 126
Cellular Phone.......................100,285
Center High Mounted Stop Light............ 564
Center Lap Belts......................... 48
Center Seat Storage Compartment............ 171
Certification Label....................... 446
Chart, Tire Sizing........................ 403
Check Engine Light
(Malfunction Indicator Light).............219,520
Checking Your Vehicle For Safety............. 82
Checks, Safety........................... 82
Child Restraint........................68,69
Child Restraint Tether Anchors.............73,76
Child Seat............................69,75
Cigar Lighter........................... 163Cleaning
Wheels............................. 548
Climate Control......................... 285
Clock.............................246,256
Compact Disc (CD) Maintenance............. 285
Compass.............................. 236
Compass Calibration..................... 237
Compass Variance....................... 237
Computer, Trip/Travel.................... 233
Connector
UCI .............................270,276
Universal Consumer Interface (UCI)......270,276
Conserving Fuel......................231,233
Console, Overhead....................... 149
Contract, Service........................ 595
Coolant Pressure Cap (Radiator Cap).......... 536
Cooling System......................... 534
Adding Coolant (Antifreeze).............. 535
Coolant Capacity...................... 569
604 INDEX

Exhaust Gas Caution...................83,440
Exhaust System.......................83,531
Exterior Lighting........................ 123
Exterior Lights.......................... 86
Filters
Air Cleaner.......................... 526
Engine Oil........................525,571
Engine Oil Disposal.................... 525
Flashers
Turn Signal......................86,128,206
Flat Tire Stowage........................ 500
Flexible Fuel Vehicles
Cruising Range....................... 443
Engine Oil........................... 443
Fuel Requirements..................440,442
Maintenance......................... 444
Replacement Parts..................... 443
Starting............................. 443Flooded Engine Starting................... 306
Fluid, Brake........................... 572
Fluid Capacities......................... 569
Fluid Leaks............................. 86
Fluid Level Checks
Automatic Transmission................. 544
Brake.............................. 539
Power Steering........................ 386
Fluids, Lubricants and Genuine Parts.......... 571
Fog Lights.......................124,221,562
Fold Flat Load Floor..................... 177
Four Wheel Drive....................... 323
Four-Way Hazard Flasher.................. 482
Freeing A Stuck Vehicle................... 505
Front Axle (Differential)................... 541
Fuel................................. 435
Adding............................. 444
Conserving........................231,233
Ethanol............................. 437
10
INDEX 607

Center Mounted Stop................... 564
Check Engine (Malfunction Indicator)........ 219
Courtesy/Reading..................... 149
Daytime Running...................... 127
Electronic Stability Program (ESP) Indicator . . . 399
Exterior.............................. 86
Fog ..........................124,221,562
Four-Wheel Drive Indicator............... 327
Hazard Warning Flasher................. 482
Headlights........................... 123
High Beam........................129,215
High Beam Indicator.................... 215
High Beam/Low Beam Select............. 129
Illuminated Entry....................... 19
Instrument Cluster..................202,206
Interior..........................125,149
Lights On Reminder.................... 127
Low Fuel............................ 214
Oil Pressure.......................... 217Passing............................. 128
Seat Belt Reminder..................... 222
Security Alarm (Theft Alarm).............. 210
Service............................. 559
Side Marker.......................... 568
Theft Alarm (Security Alarm).............. 210
Tire Pressure Monitoring (TPMS)........217,424
Traction Control....................... 399
Transfer Case......................... 327
Turn Signal...................86,128,559,562
Warning (Instrument Cluster Description) . . 202,206
Limited-Slip Differential................360,542
Loading Vehicle......................... 446
Tires ............................... 407
Locks................................. 29
Child Protection........................ 33
Door................................ 29
Power Door........................... 30
Low Tire Pressure System.................. 424
10
INDEX 611

Lower Anchors and Tether for CHildren
(LATCH).............................. 73
Lubrication, Body....................... 529
Maintenance Free Battery.................. 526
Maintenance Procedures................... 522
Maintenance Schedule.................... 574
Malfunction Indicator Light (Check Engine)..... 520
Manual, Service......................... 597
Manual Transmission
Fluid Level Check..................... 543
Lubricant Selection..................... 572
Memory Seat........................... 116
Methanol............................. 437
Mini-Trip Computer...................... 233
Mirrors................................ 93
Automatic Dimming..................... 94
Electric Powered....................... 96
Heated.............................. 97Memory............................. 116
Outside.............................. 94
Rearview............................. 93
Trailer Towing......................... 99
Mode
Fuel Saver........................231,233
Modifications/Alterations, Vehicle............. 7
Monitor, Tire Pressure System............... 424
Mopar Parts.........................521,596
MTBE/ETBE........................... 437
Multi-Displacement Engine System........... 387
Multi-Function Control Lever............... 127
Navigation System (Uconnect™ gps).......... 147
New Vehicle Break-In Period................ 81
Occupant Restraints...................38,61,64
Occupant Restraints (Sedan).............57,61,63
Octane Rating, Gasoline (Fuel).............. 435
612 INDEX