fuel cap Ram 5500 Chassis Cab 2015 User Guide

(EVIC)” or “Driver Information Display (DID)” in “Un-
derstanding Your Instrument Panel” for further informa-
tion. Tighten the fuel filler cap properly and press the
SELECT button to turn off the message. If the problem
continues, the message will appear the next time the
vehicle is started.
A loose, improperly installed, or damaged fuel filler cap
may also turn on the Malfunction Indicator Light (MIL).
EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMS
In some localities, it may be a legal requirement to pass
an inspection of your vehicle’s emissions control system.
Failure to pass could prevent vehicle registration.For states that require an Inspection and Mainte-
nance (I/M), this check verifies the “Malfunction
Indicator Light (MIL)” is functioning and is not
on when the engine is running, and that the OBD II
system is ready for testing. Normally, the OBD II system will be ready. The OBD II
system may
notbe ready if your vehicle was recently
serviced, recently had a dead battery or a battery replace-
ment. If the OBD II system should be determined not
ready for the I/M test, your vehicle may fail the test.
Your vehicle has a simple ignition actuated test, which
you can use prior to going to the test station. To check if
your vehicle’s OBD II system is ready, you must do the
following:
1. Cycle the ignition switch to the ON position, but do not crank or start the engine.
NOTE: If you crank or start the engine, you will have to
start this test over.
2. As soon as you cycle the ignition switch to the ON position, you will see the Malfunction Indicator Light
(MIL) symbol come on as part of a normal bulb check.
490 MAINTAINING YOUR VEHICLE

CAUTION!
Do not use chemical flushes in your engine oil as the
chemicals can damage your engine. Such damage is
not covered by the New Vehicle Limited Warranty.
Engine Oil Viscosity — 5.7L Engine
MOPAR® SAE 5W-20 engine oil or equivalent Pennzoil®
or Shell Helix® is recommended for all operating tem-
peratures. This engine oil improves low temperature
starting and vehicle fuel economy.
For information on engine oil filler cap location, refer to
“Engine Compartment” in “Maintaining Your Vehicle”
for further information.
Lubricants which do not have both the engine oil certi-
fication mark and the correct SAE viscosity grade num-
ber should not be used.NOTE:
For trucks with a 5.7L engine operating under a
gross combined weight rating of 14,000 lbs (6 350 kg) or
greater, MOPAR® SAE 5W-30 engine oil or equivalent
Pennzoil® or Shell Helix® is recommended for all oper-
ating temperatures.
Engine Oil Viscosity — 6.4L Engine
Use Pennzoil Ultra™ 0W–40 engine or equivalent
MOPAR® oil meeting the Chrysler Material Standard
MS-12633 for use in all operating temperatures.
The engine oil filler cap also shows the recommended
engine oil viscosity for your engine. For information on
engine oil filler cap location, refer to the “Engine Com-
partment” in this section.
7
MAINTAINING YOUR VEHICLE 495

FLUID CAPACITIES
U.S.Metric
Fuel (Approximate)
Standard Rear Tank 52 Gallons197 Liters
Optional Midship Tank 22 Gallons83 Liters
Engine Oil With Filter
5.7L Engine (SAE 5W-20, API Certified) 7 Quarts6.6 Liters
6.4L Engine (SAE 0W-40, Synthetic API Certified) 7 Quarts6.6 Liters
Cooling System
5.7L Engine (MOPAR® Antifreeze/Coolant 10 Year/150,000 Mile
Formula). 18.3 Quarts
17.3 Liters
6.4L Engine (MOPAR® Antifreeze/Coolant 10 Year/150,000 Mile
Formula). 16.6 Quarts
15.7 Liters
554 MAINTAINING YOUR VEHICLE

Adding Engine Coolant (Antifreeze)............515
Adding Fuel ............................ .426
Additives, Fuel .......................... .424
Adjustable Pedals ........................ .167
Airbag.................................64
Air Bag Advance Front Air Bag ....................65
Air bag Operation .......................67
Air Bag Warning Light ....................71
Enhanced Accident Response ................70
Event Data Recorder (EDR) .................74
FrontAirBag...........................64
If A Deployment Occurs ...................69
Knee Impact Bolsters .....................68
Maintaining Your Air Bag System ............73
Air bag Deployment ........................64
Air bag Light .............................71
Air bag Maintenance ........................73
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .496 Air Conditioner Maintenance
.................503
Air Conditioning ......................... .283
Air Conditioning Controls ...................283
Air Conditioning, Operating Tips ..............303
Air Conditioning Refrigerant .................503
Air Conditioning System ....................283
Air Pressure, Tires ........................ .395
Alarm Light ............................ .206
Alarm, Panic .............................26
Alarm (Security Alarm) ......................20
Alarm System (Security Alarm) ................20
Alterations/Modifications, Vehicle ...............7
Antifreeze (Engine Coolant) ..................514
Capacities ........................... .554
Disposal ............................. .518
Anti-Lock Brake System (ABS) ................371
Anti-Lock Warning Light ....................201
Appearance Care ........................ .528
Ashtray ............................... .182
578 INDEX

Dual Rear Wheels........................ .410
Electrical Power Outlets .....................176
Electric Rear Window Defrost .................193
Electronically Shifted Transfer Case .............355
Electronic Brake Control System ...............371
Anti-Lock Brake System ..................371
Traction Control System ...................372
Electronic Range Select (ERS) .................344
Electronic Speed Control (Cruise Control) ........170
Electronic Stability Control (ESC) ..............375
Electronic Vehicle Information Center (EVIC) ......213
Electronic Vehicle Information Center (EVIC) . . . .213
Electronic Vehicle Information Center (EVIC)
Setup Menu .......................... .213
EVIC Messages ........................ .213
Selectable Menu Items ....................226
Emergency Brake ........................ .367Emergency, In Case of
Freeing Vehicle When Stuck ................477
Hazard Warning Flasher ..................460
Jump Starting ......................... .472
Tow Hooks ........................... .479
Emission Control System Maintenance ..........490
Engine ................................ .487
Air Cleaner .......................... .496
Break-In Recommendations ................106
Compartment Identification ................487
Coolant (Antifreeze) .....................555
Exhaust Gas Caution .....................109
Flooded, Starting ...................... .331
Fuel Requirements ..................... .421
Jump Starting ......................... .472
Oil................................. .493
Oil Filler Cap ......................... .495
Oil Selection .......................... .494
Oil Synthetic ......................... .496
582 INDEX

Overheating.......................... .460
Engine Oil Viscosity ...................... .495
Enhanced Accident Response Feature ............70
Entry System, Illuminated ....................22
Ethanol ............................... .422
Event Data Recorder ........................74
Exhaust Gas Caution ...................... .109
Exhaust System .......................... .109
Exterior Lighting ......................... .151
Exterior Lights ...........................112
Filters Air Cleaner .......................... .496
Engine Fuel .......................... .555
Engine Oil ........................... .496
Engine Oil Disposal .....................496
Flashers Turn Signal ............................112
Flat Tire Stowage ........................ .472Flooded Engine Starting
....................331
Fluid, Brake ............................ .558
Fluid Capacities ......................... .554
Fluid Leaks .............................112
Fluid Level Checks Automatic Transmission ..................526
Brake ............................... .521
Power Steering ........................ .366
Fluids, Lubricants and Genuine Parts ...........555
Fog Lights ............................. .155
Four-Way Hazard Flasher ...................460
Four Wheel Drive ........................ .351
Freeing A Stuck Vehicle .....................477
Front Axle (Differential) .....................523
Fuel .................................. .421
Adding ............................. .426
Additives ............................ .424
Clean Air ............................ .422
Ethanol ............................. .422
10
INDEX 583

Filler Cap (Gas Cap).....................427
Filter ............................... .555
Gasoline ............................. .421
Materials Added ....................... .424
Methanol ............................ .422
Octane Rating ......................... .421
Requirements ......................... .421
Tank Capacity ......................... .554
Fuses ................................. .535
Gas Cap (Fuel Filler Cap) ...................427
Gasoline, Clean Air ....................... .422
Gasoline (Fuel) .......................... .421
Gasoline, Reformulated .....................422
Gauges Speedometer ......................... .206
Tachometer ........................... .201
Gear Ranges ............................ .337
Gear Select Lever Override ..................480 General Information
...................... .421
Glass Cleaning .......................... .533
Grocery Bag Retainer ...................... .193
Gross Axle Weight Rating ...................431
Gross Vehicle Weight Rating ..................430
Guide, Body Builders ........................6
GVWR ................................ .428
Hazard Driving Through Flowing, Rising, or Shallow
Standing Water ........................ .363
Hazard Warning Flasher ....................460
Headlights ............................. .547
Automatic ........................... .151
Cleaning ............................ .533
High Beam ........................... .162
High Beam/Low Beam Select Switch .........162
Passing ............................. .161
Switch .............................. .151
584 INDEX

Heated.............................. .128
Memory ............................. .143
Outside ............................. .125
Rearview .............................117
Trailer Towing ........................ .129
Modifications/Alterations, Vehicle ...............7
Monitor, Tire Pressure System ................411
MOPAR® Parts .......................... .491
MTBE/ETBE ........................... .422
Multi-Function Control Lever .................160
New Vehicle Break-In Period .................106
Occupant Restraints ........................47
Octane Rating, Gasoline (Fuel) ................421
Oil, Engine ............................. .493
Capacity ............................ .554
Change Interval ....................... .494
Dipstick ............................. .493Disposal
............................. .496
Filter ............................... .496
Filter Disposal ........................ .496
Identification Logo ..................... .494
Recommendation ...................... .494
Synthetic ............................ .496
Viscosity ............................ .495
Onboard Diagnostic System ..................489
Operating Precautions ..................... .489
Operator Manual (Owner’s Manual) .............4
Outside Rearview Mirrors ...................125
Overdrive .............................. .345
Overdrive OFF Switch ..................... .345
Overhead Console ........................ .174
Overheating, Engine ...................... .460
Owner’s Manual (Operator Manual) .............4
Paint Care ............................. .528
Panic Alarm ..............................26
588 INDEX