towing RAM CHASSIS CAB 2007 Workshop Manual

The fluid and filter(s) should be changed and the bands
adjusted (if equipped) as specified in the Maintenance
Schedule (Section 8). Vehicles equipped with gas engines
having severe usage should follow Maintenance Sched-
ule “B” of the Maintenance Schedule (Section 8).
Severe usage consists of:
• Off-the-highway operation;
• Trailer towing;
• Snow plow operation;
• Prolonged operation with heavy loading, especially in
hot weather.
NOTE: If the transmission is disassembled for any
reason, the fluid and filter should be changed, and the
bands adjusted (if equipped). Special Additives
The manufacturer recommends against the addition of
any additives to the transmission. Exception to this
policy is the use of special dyes to aid in detecting fluid
leaks. The use of transmission sealers should be avoided,
since they may adversely affect seals.
Front and rear Wheel Bearings
Front Wheel Bearings
Front wheel bearings for all Dodge Ram Trucks are
sealed-for-life. They do not require greasing or seal
replacement. In some instances, these bearings will
“purge” excess grease and the bearing will look slightly
wet. This is normal. Periodic inspection for excess play is
recommended.444 MAINTAINING YOUR VEHICLE

WARNING!You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
MAINTENANCE SCHEDULES – GAS ENGINES
There are two maintenance schedules that show the
required service for your vehicle.
First is Schedule “B” . It is for vehicles that are operated
under one or more of the following conditions that are
listed below and at the beginning of the schedule.
• Day or night temperatures are below 32° F (0° C).
• Stop and go driving. • Extensive engine idling.
• Driving in dusty conditions.
• Short trips of less than 10 miles (16 km).
• More than 50% of your driving is at sustained high
speeds during hot weather, above 90° F (32°C).
• Trailer towing.
• Snowplowing.
• Heavy Loading.
• Taxi, police, or delivery service (commercial service).
• Off-road or desert operation.
• If equipped for and operating with E-85 (ethanol)
fuel.
NOTE: If ANY of these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,484 MAINTENANCE SCHEDULES
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Schedule “B”
Follow schedule “B” if you usually operate your vehicle
under one or more of the following conditions.
• Day or night temperatures are below 32° F (0° C).
• Stop and go driving.
• Extensive engine idling.
• Driving in dusty conditions.
• Short trips of less than 10 miles (16 km).
• More than 50% of your driving is at sustained high
speeds during hot weather, above 90° F (32° C).
• Trailer towing.
• Snowplowing.
• Heavy Loading.
• Taxi, police, or delivery service (commercial service). • Off-road or desert operation.
• If equipped for and operating with E-85 (ethanol)
fuel.
NOTE: If ANY of these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule “B” of the
 Maintenance Schedules  section of this manual.
NOTE: If ANY of these apply to you then flush and
replace your engine coolant every 102,000 miles (170 000
km) or 60 months, whichever comes first and follow
schedule “B” of the  Maintenance Schedules  section of
this manual.
NOTE: If none of these apply to you, then change your
engine oil at every interval shown on schedule  A  of the
 Maintenance Schedules  section of this manual. SCHEDULE “B” 487
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 105,000 108,000 111,000 114,000 117,000 120,000
(Kilometers) (175 000) (180 000) (185 000) (190 000) (195 000) (200 000)
Inspect engine air cleaner filter, replace if
necessary. XX
Replace spark plugs. X
Inspect PCV valve, replace as necessary. X
Inspect auto tension drive belt and replace if
required.* XX
Flush and replace engine coolant if not done
at 102,000 miles (170 000 km). X
*This maintenance is not required if the belt was previ-
ously replaced.
** This applies only if the vehicle is used for frequent
trailer towing, snowplowing, fleet vehicle or commercial
service. Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts. SCHEDULE “B” 497
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Emergency, In Case of
Freeing Vehicle When Stuck ............... 385
Hazard Warning Flasher ................. 370
Jacking ............................. 372
Jump Starting ......................... 382
Tow Hooks .......................... 386
Towing ............................. 387
Emission Control System Maintenance ......... 474
Emission Related Components .............. 418
Engine ............................ 392,393
Air Cleaner ........................ 406,407
Block Heater .................... 252,259,265
Break-In Recommendations ................ 72
Compartment ......................... 392
Compartment Identification ............... 393
Coolant (Antifreeze) .................... 469
Cooling ............................. 426
Data Plate ........................... 395
Exhaust Gas Caution .................... 330 Flooded, Starting ...................... 249
Identification ......................... 392
Idling .............................. 261
Jump Starting ......................... 382
Oil .............................. 398,469
Oil Filler Cap ...................... 401,403
Oil Selection .......................... 401
Oil Synthetic ....................... 260,403
Runaway ............................ 327
Temperature Gauge ..................... 174
Event Data Recorder ...................... 57
Exhaust Brake .......................... 265
Exhaust Gas Caution ................ 75, 330,425
Exhaust System .................... 75, 425,446
ExteriorLighting ........................ 124
Fabric Care ............................ 454
Fan .................................. 432518 INDEX

Gasoline (Fuel) ......................... 327
Gasoline, Reformulated ................... 328
Gauges ............................... 172
Coolant Temperature .................... 174
Fuel ................................ 179
Oil Pressure .......................... 174
Speedometer ......................... 173
Tachometer .......................... 173
Voltmeter ......................... 172,257
Gear Ranges ...................... 267,273,280
General Information .................... 18,112
Glass Cleaning .......................... 456
Grocery Bag Retainer ..................... 159
Gross Axle Weight Rating .................. 342
Gross Vehicle Weight Rating ................ 341
GVWR ............................... 338
Hands-Free Phone (UConnect™) .............. 87
Hazard Warning Flasher ................... 370 Head Restraints ......................... 115
Headlights ............................ 462
Cleaning ............................ 455
High Beam ........................... 127
High Beam/Low Beam Select Switch ........ 127
Lights On Reminder .................... 125
Passing ............................. 126
Switch .............................. 124
Heated Mirrors ....................... 86,160
Heated Seats ........................... 118
Heater ............................... 233
Heater, Engine Block ..................... 265
High Beam/Low Beam Select (Dimmer) Switch . . 127
Hitches
TrailerTowing ........................ 345
Hoisting .............................. 381
Hood Release .......................... 120
Hoses ................................ 433
Hub Caps ............................. 377520 INDEX

Lug Nuts ............................. 376
Lumbar Support ........................ 116
Maintenance ........................... 396
Maintenance Free Battery .................. 418
Maintenance Procedures ................... 398
Maintenance Schedule ................. 474,484
Schedule “A” ......................... 498
Schedule “B” ......................... 487
Manual, Service ......................... 508
Manual Transmission .................. 279,438
Fluid Level Check ................... 437,438
Lubricant Selection ..................... 471
Shift Speeds .......................... 280
Map/Reading Lights ..................... 141
Mirrors ................................ 83
Automatic Dimming ..................... 84
Electric Powered ....................... 85
Outside .............................. 84 Rearview ............................. 83
TrailerTowing ...................... 86,354
Modifications/Alterations, Vehicle ............. 8
Mopar Parts ......................... 395,507
Multi-Function Control Lever ............... 125
Navigation Radio ........................ 218
Navigation System ....................... 218
New Vehicle Break-In Period ................ 72
Noise Control
Maintenance .......................... 445
Tampering Prohibited ................... 446
Noise Emission Warranty ............... 445,447
Occupant Restraints ....................... 34
Octane Rating, Gasoline (Fuel) .............. 327
Odometer .......................... 175,179
Trip ............................. 175,179
Off-Pavement Driving (Off-Road) ............ 298 INDEX 523
10

Seats ............................... 116
Sliding Rear Window ................. 33,160
Steering .......................... 304,421
Take-Off Adapter ...................... 296
Take-Off Operation ..................... 296
Windows ............................. 32
Power Steering Fluid ..................... 471
Pregnant Women and Seat Belts .............. 47
Pretensioners
Seat Belts ............................. 45
Programmable Electronic Features ............ 145
PTO (Power Take-Off) .................... 296
Radial Ply Tires ......................... 317
Radiator Cap (Coolant Pressure Cap) .......... 429
Radio Broadcast Signals ................... 181
Radio, Navigation ....................... 218
Radio Operation ................... 182,190,204
Radio Remote Controls .................... 226 Radio, Satellite ....................... 219,222
Radio (Sound Systems) .............. 182,190,204
Rear Axle (Differential) ................. 436,437
Rear Wheel Bearings ..................... 445
Rear Window Features .................... 160
Rear Window, Sliding ................... 34,161
Reclining Front Seats ..................... 114
Recorder, Event Data ...................... 57
Recreational Towing ...................... 360
Shifting into Transfer Case Neutral (N) .... 361,363
Shifting out of Transfer Case Neutral (N) . . . 362,365
Reformulated Gasoline .................... 328
Refrigerant ............................ 421
Reminder, Seat Belt ....................... 46
Remote Keyless Entry (RKE) ................. 20
Remote Sound System (Radio) Controls ........ 226
Remote Starting System .................... 25
Replacement Tires ....................... 321
Reporting Safety Defects ................... 507 INDEX 525
10

Snow Tires ........................... 324
Spinning ............................ 319
Tread Wear Indicators ................... 320
Wheel Mounting ....................... 372
Wheel Nut Torque ..................... 376
Tongue Weight/Trailer Weight .............. 346
Torque Converter Clutch ................ 272,278
Tow Hooks, Emergency ................... 386
Towing ............................... 341
Disabled Vehicle ....................... 387
Guide .............................. 346
Recreational .......................... 360
Weight .............................. 346
Traction .............................. 298
Traction Control ......................... 437
TrailerTowing .......................... 341
Cooling System Tips .................... 354
Hitches ............................. 345
Minimum Requirements ................. 347 Mirrors ........................... 86,354
Trailer and Tongue Weight ................ 346
Wiring .............................. 351
TrailerTowingGuide ..................... 346
TrailerWeight .......................... 346
Transaxle
Automatic ............................ 12
Manual .............................. 14
Transfer Case
Electronically Shifted .................... 288
Fluid ............................... 471
Transmission
Automatic ................... 267,273,438,441
Fluid ............................... 471
Maintenance ....................... 438,441
Manual ..................... 248,252,279,438
Shifting ............................. 266
Transmitter Battery Service (Remote Keyless Entry) . 24
Tread Wear Indicators .................... 320 INDEX 529
10