check engine light Ram ProMaster 2015 User Guide

“Electronic Vehicle Information Center (EVIC)” in ”Un-
derstanding Your Instrument Panel” for further informa-
tion. Tighten the gas cap until aclickingsound is heard.
This is an indication that the gas cap is properly tight-
ened.
Push the odometer reset button to turn the message off. If
the problem persists, the message will appear the next
time the vehicle is started. This might indicate a damaged
cap. If the problem is detected twice in a row, the system
will turn on the MIL. Resolving the problem will turn the
MIL light off.EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMS
In some localities, it may be a legal requirement to pass
an inspection of your vehicle’s emissions control system.
Failure to pass could prevent vehicle registration.
For states that require an Inspection and Mainte-
nance (I/M), this check verifies the “Malfunction
Indicator Light (MIL)” is functioning and is not
on when the engine is running, and that the OBD II
system is ready for testing.
Normally, the OBD II system will be ready. The OBD II
system may notbe ready if your vehicle was recently
serviced, recently had a dead battery or a battery replace-
ment. If the OBD II system should be determined not
ready for the I/M test, your vehicle may fail the test.
7
MAINTAINING YOUR VEHICLE 331

Your vehicle has a simple ignition actuated test, which
you can use prior to going to the test station. To check if
your vehicle’s OBD II system is ready, you must do the
following:
1. Cycle the ignition switch to the ON position, but donot crank or start the engine.
NOTE: If you crank or start the engine, you will have to
start this test over.
2. As soon as you cycle the ignition switch to the ON position, you will see the Malfunction Indicator Light
(MIL) symbol come on as part of a normal bulb check.
3. Approximately 15 seconds later, one of two things will happen:
• The MIL will flash for about 10 seconds and then
return to being fully illuminated until you turn OFF the ignition or start the engine. This means that your
vehicle’s OBD II system is
not readyand you should
not proceed to the I/M station.
• The MIL will not flash at all and will remain fully
illuminated until you place the ignition in the off
position or start the engine. This means that your
vehicle’s OBD II system is readyand you can proceed
to the I/M station.
If your OBD II system is not ready,you should see your
authorized dealer or repair facility. If your vehicle was
recently serviced or had a battery failure or replacement,
you may need to do nothing more than drive your
vehicle as you normally would in order for your OBD II
system to update. A recheck with the above test routine
may then indicate that the system is now ready.
Regardless of whether your vehicle’s OBD II system is
ready or not, if the MIL is illuminated during normal
vehicle operation you should have your vehicle serviced
332 MAINTAINING YOUR VEHICLE

Avoid using the wiper blades to remove frost or ice from
the windshield. Keep the blade rubber out of contact with
petroleum products such as engine oil, gasoline, etc.
NOTE:Life expectancy of wiper blades varies depend-
ing on geographical area and frequency of use. Poor
performance of blades may be present with chattering,
marks, water lines or wet spots. If any of these conditions
are present, clean the wiper blades or replace as neces-
sary.
Adding Washer Fluid
The fluid reservoir is located in the engine compartment
and should be checked at regular intervals. Fill the
reservoir with windshield washer solvent (not radiator
antifreeze) and operate the system for a few seconds to
flush out any residual water.
The washer fluid reservoir will hold a full gallon of fluid
when the Low Washer Fluid Light illuminates.
WARNING!
Commercially available windshield washer solvents
are flammable. They could ignite and burn you. Care
must be exercised when filling or working around
the washer solution.
After the engine has warmed, operate the defroster for a
few minutes to reduce the possibility of smearing or
freezing the fluid on the cold windshield. MOPAR® All
Weather Windshield Washer Solution or equivalent, used
with water as directed on the container, aids cleaning
action, reduces the freezing point to avoid line clogging,
and is not harmful to paint or trim.
7
MAINTAINING YOUR VEHICLE 345

•Check the fluid levels of the coolant reservoir, brake
master cylinder, and power steering and fill as needed
• Check function of all interior and exterior lights
Required Maintenance Intervals
Refer to the maintenance schedules on the following
page for the required maintenance intervals.
At Every Oil Change Interval As Indicated By Oil Change Indicator System:
•Change oil and filter.
• Rotate the tires. Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
• Inspect battery and clean and tighten terminals as
required.
At Every Oil Change Interval As Indicated By Oil
Change Indicator System:
•Inspect brake pads, shoes, rotors, drums, hoses
and park brake.
• Inspect engine cooling system protection and
hoses.
• Inspect exhaust system.
• Inspect engine air cleaner if using in dusty or
off-road conditions.
Maintenance Chart
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.8
MAINTENANCE SCHEDULES 389

Carbon Monoxide Warning...................64
Cargo Light ..............................96
Car Washes ............................ .356
Cellular Phone .......................... .182
Certification Label ........................ .269
Chains, Tire ............................ .254
Chart, Tire Sizing ........................ .232
Check Engine Light (Malfunction Indicator Light) ............128, 331
Checking Your Vehicle For Safety ...............63
Checks, Safety ............................63
Child Restraint ............................52
Child Restraints Booster Seats ...........................57
Child Restraints .........................52
Infants And Child Restraints ................55
Older Children And Child Restraints ..........55
Cigar Lighter ............................118
Clean Air Gasoline ........................262 Climate Control
..........................183
Manual ............................. .183
Cold Weather Operation ....................201
Compact Disc (CD) Maintenance ..............182
Compact Spare Tire ........................249
Console, Overhead ........................114
Contract, Service ..........................399
Coolant Pressure Cap (Radiator Cap) ...........349
Cooling System .......................... .346
Adding Coolant (Antifreeze) ...............348
Coolant Capacity .......................382
Coolant Level ..................... .346, 350
Disposal Of Used Coolant .................350
Drain, Flush, And Refill ...................346
Inspection ............................350
Points To Remember .....................350
Pressure Cap ..........................349
Radiator Cap ..........................349
Selection Of Coolant (Antifreeze) ......347, 382, 383
408 INDEX

Jump Starting..........................317
Emission Control System Maintenance ..........331
Engine Air Cleaner .......................... .337
Block Heater ..........................202
Break-In Recommendations .................63
Checking Oil Level ..................... .334
Compartment ..........................329
Compartment Identification ................329
Coolant (Antifreeze) ..................346, 383
Cooling ............................. .346
Exhaust Gas Caution .....................64
Fails To Start ..........................201
Flooded, Starting .......................201
Fuel Requirements ...................262, 382
Jump Starting ..........................317
Oil ...........................334, 382, 383
Oil Filter ............................ .337
Oil Selection .......................335, 382 Oil Synthetic
..........................336
Overheating .......................... .287
Starting ............................. .200
Engine Oil Viscosity .......................336
Engine Oil Viscosity Chart ...................336
Enhanced Accident Response Feature ............48
Entry System, Illuminated ....................16
Ethanol ............................... .263
Event Data Recorder ........................51
Exhaust Gas Caution ........................64
Exhaust System ........................64, 338
Exterior Lighting ..........................92
Exterior Lights ............................67
Fabric Care ............................. .358
Filters Air Cleaner .......................... .337
Air Conditioning .......................342
Engine Oil ........................ .337, 383
410 INDEX

Engine Oil Disposal.....................337
Flashers Hazard Warning ........................287
Turn Signal ........................ .67, 128
Flooded Engine Starting ....................201
Fluid Capacities ..........................382
Fluid Leaks ..............................68
Fluid Level Checks Automatic Transmission ..................354
Brake ............................... .352
Cooling System ........................ .346
Power Steering ........................ .218
Fluids, Lubricants And Genuine Parts ...........383
Fog Lights ............................93, 128
Four-Way Hazard Flasher ...................287
Freeing A Stuck Vehicle .....................323
Fuel .................................. .262
Adding ............................. .266
Additives ............................ .264Clean Air
............................ .262
Ethanol ............................. .263
Filler Cap (Gas Cap) .....................266
Gasoline ............................. .262
Gauge ...............................128
Light ............................... .128
Materials Added ........................264
Methanol ............................ .263
Octane Rating ..................... .262, 383
Requirements .......................262, 382
Tank Capacity ..........................382
Fueling ............................... .266
Fuses ................................. .362
Gas Cap (Fuel Filler Cap) .............266, 268, 330
Gasoline, Clean Air ........................262
Gasoline (Fuel) .......................... .262
Gasoline, Reformulated .....................262
10
INDEX 411

Ignition Key Removal.......................11
Illuminated Entry ..........................16
Immobilizer (Sentry Key) ....................13
Inside Rearview Mirror ......................72
Instrument Cluster .....................127, 128
Instrument Panel And Controls ...............126
Instrument Panel Cover .....................358
Instrument Panel Lens Cleaning ...............360
Interior Appearance Care ....................358
Intermittent Wipers (Delay Wipers) .............98
Introduction ..............................4
Jump Starting ............................317
Key-In Reminder ..........................13
Key, Replacement ..........................14
Keys ...................................11
Key, Sentry (Immobilizer) ....................13 Lane Change Assist
........................94
Lap/Shoulder Belts .........................27
Latches .................................68
Lead Free Gasoline ........................262
Leaks, Fluid ..............................68
Life Of Tires ............................ .252
Light Bulbs .......................... .67, 376
Lights ............................... .67, 91
AirBag .........................48, 65, 128
Anti-Lock ............................ .128
Brake Assist Warning ....................226
Brake Warning ........................ .128
Bulb Replacement .......................378
Check Engine (Malfunction Indicator) .........128
Cruise ...............................128
Daytime Running ........................92
Dimmer Switch, Headlight ...............91, 94
Electronic Stability Program (ESP) Indicator .....226
Engine Temperature Warning ...............128
10
INDEX 413

Exterior...............................67
Fog ................................ .128
Hazard Warning Flasher ..................287
Headlights .............................92
High Beam ........................ .94, 128
High Beam Indicator .....................128
Illuminated Entry ........................16
Instrument Cluster ..................... .128
Low Fuel ............................ .128
Map Reading ........................95, 114
Oil Pressure .......................... .128
Park .................................94
Passing ...............................94
Seat Belt Reminder ..................... .128
Service ...............................378
Tire Pressure Monitoring (TPMS) ............128
Traction Control ........................226
Turn Signal ..........................67, 91
Warning (Instrument Cluster Description) ......128Loading Vehicle
.......................269, 271
Capacities ............................271
Tires ............................... .237
Locks Automatic Door .........................22
Door .................................20
Lubrication, Body ........................ .344
Lug Nuts ...............................288
Maintenance Free Battery ....................340
Maintenance, General ..................... .128
Maintenance Procedures ....................333
Maintenance Schedule ..................... .388
Malfunction Indicator Light (Check Engine) .......331
Manual, Service ..........................401
Map/Reading Lights ....................95, 114
Methanol ...............................263
Mirrors .................................72
Electric Remote .........................73
414 INDEX