belt Ram ProMaster 2015 Service Manual

STARTING PROCEDURES
Before starting your vehicle, adjust your seat, adjust both
inside and outside mirrors, and fasten your seat belts.
WARNING!
•Never leave children alone in a vehicle, or with
access to an unlocked vehicle.
• Allowing children to be in a vehicle unattended is
dangerous for a number of reasons. A child or
others could be seriously or fatally injured. Chil-
dren should be warned not to touch the parking
brake, brake pedal or the transmission gear selec-
tor.
• Do not leave the Key Fob in or near the vehicle (or
in a location accessible to children). A child could
operate power windows, other controls, or move
the vehicle.
Automatic Transmission — If Equipped
The shift lever must be in the PARK or NEUTRAL
position before you can start the engine. Press the brake
pedal before shifting to any driving gear.
NOTE: You must press the brake pedal before shifting
out of PARK.
Normal Starting
NOTE: Normal starting of either a cold or a warm
engine is obtained without pumping or pressing the
accelerator pedal.
Turn the ignition switch to the AVV/ACC (START)
position and release it when the engine starts. If the
engine fails to start within 10 seconds, turn the ignition
switch to the STOP (OFF/LOCK) position, wait 10 to 15
seconds, then repeat the “Normal Starting” procedure.
200 STARTING AND OPERATING

CAUTION!
•It is essential when replacing the cables on the
battery that the positive cable is attached to the
positive post and the negative cable is attached to
the negative post. Battery posts are marked positive
(+) and negative (-) and are identified on the
battery case. Cable clamps should be tight on the
terminal posts and free of corrosion.
• If a “fast charger” is used while the battery is in the
vehicle, disconnect both vehicle battery cables be-
fore connecting the charger to the battery. Do not
use a “fast charger” to provide starting voltage.
Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance test. Drive belt tension should also be checked at this
time.
WARNING!
•
Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause the
system to fail, requiring costly repairs. Refer to
Warranty Information Book, located on the DVD,
for further warranty information.
• The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced technician.
7
MAINTAINING YOUR VEHICLE 341

Plastic is not as scratch resistant as glass and therefore
different lens cleaning procedures must be followed.
To minimize the possibility of scratching the lenses and
reducing light output, avoid wiping with a dry cloth. To
remove road dirt, wash with a mild soap solution fol-
lowed by rinsing.
Do not use abrasive cleaning components, solvents, steel
wool or other aggressive material to clean the lenses.
Glass Surfaces
All glass surfaces should be cleaned on a regular basis
with MOPAR® Glass Cleaner, or any commercial
household-type glass cleaner. Never use an abrasive type
cleaner. Use caution when cleaning the inside rear win-
dow equipped with electric defrosters or windows
equipped with radio antennas. Do not use scrapers or
other sharp instrument that may scratch the elements.When cleaning the rear view mirror, spray cleaner on the
towel or cloth that you are using. Do not spray cleaner
directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft cloth. A mild soap solution may
be used, but do not use high alcohol content or
abrasive cleaners. If soap is used, wipe clean with a
clean damp cloth.
2. Dry with a soft cloth.
Seat Belt Maintenance
Do not bleach, dye, or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
360 MAINTAINING YOUR VEHICLE

If the belts need cleaning, use MOPAR® Total Clean, a
mild soap solution, or lukewarm water. Do not remove
the belts from the vehicle to wash them. Dry with a soft
cloth.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
WARNING!
A frayed or torn belt could rip apart in a collision and
leave you with no protection. Inspect the belt system
periodically, checking for cuts, frays, or loose parts.
Damaged parts must be replaced immediately. Do
not disassemble or modify the system. Seat belt
assemblies must be replaced after a collision if they
have been damaged (i.e., bent retractor, torn web-
bing, etc.).
Cleaning The Instrument Panel Cupholders
Removal
Pull the flexible liner from the cupholder drawer starting
at one edge to ease removal.
Cleaning
The liner is top shelf dishwasher safe, or you may follow
the cleaning procedure below.
Soak the liner in a mixture of medium hot tap water and
one teaspoon of mild liquid dish soap. Let soak for
approximately 30 minutes. After 30 minutes, pull the
liner from the water and dip it back into the water about
six times. This will loosen any remaining debris. Rinse
the liner thoroughly under warm running water. Shake
the excess water from the liner and dry the outer surfaces
with a clean soft cloth.
7
MAINTAINING YOUR VEHICLE 361

Audio Systems (Radio).....................179
Auto Down Power Windows ..................23
Automatic Door Locks ......................22
Automatic Transaxle ........................11
Automatic Transmission .................202, 355
Adding Fluid .......................354, 355
Fluid And Filter Changes ..................355
Fluid Change ..........................355
Fluid Level Check .......................354
Fluid Type ........................ .353, 385
Gear Ranges .......................... .205
Special Additives .......................354
Battery .................................340
Keyless Transmitter Replacement (RKE) ........18
Belts, Seat ...............................65
Body Builders Guide ........................6
Body Mechanism Lubrication .................344
B-Pillar Location ..........................237 Brake Assist System
.......................223
Brake Control System, Electronic ..............221
Brake Fluid ............................ .385
Brake, Parking .......................... .218
Brake System ........................ .220, 351
Anti-Lock (ABS) ........................221
Fluid Check .......................... .352
Parking ............................. .218
Warning Light ........................ .128
Brake/Transmission Interlock .................204
Bulb Replacement ..................... .376, 378
Bulbs, Light .......................... .67, 376
Camera, Rear ............................111
Capacities, Fluid ..........................382
Caps, Filler Fuel .................................266
Power Steering ........................ .218
Radiator (Coolant Pressure) ................349
10
INDEX 407

Ignition Key Removal.......................11
Illuminated Entry ..........................16
Immobilizer (Sentry Key) ....................13
Inside Rearview Mirror ......................72
Instrument Cluster .....................127, 128
Instrument Panel And Controls ...............126
Instrument Panel Cover .....................358
Instrument Panel Lens Cleaning ...............360
Interior Appearance Care ....................358
Intermittent Wipers (Delay Wipers) .............98
Introduction ..............................4
Jump Starting ............................317
Key-In Reminder ..........................13
Key, Replacement ..........................14
Keys ...................................11
Key, Sentry (Immobilizer) ....................13 Lane Change Assist
........................94
Lap/Shoulder Belts .........................27
Latches .................................68
Lead Free Gasoline ........................262
Leaks, Fluid ..............................68
Life Of Tires ............................ .252
Light Bulbs .......................... .67, 376
Lights ............................... .67, 91
AirBag .........................48, 65, 128
Anti-Lock ............................ .128
Brake Assist Warning ....................226
Brake Warning ........................ .128
Bulb Replacement .......................378
Check Engine (Malfunction Indicator) .........128
Cruise ...............................128
Daytime Running ........................92
Dimmer Switch, Headlight ...............91, 94
Electronic Stability Program (ESP) Indicator .....226
Engine Temperature Warning ...............128
10
INDEX 413

Exterior...............................67
Fog ................................ .128
Hazard Warning Flasher ..................287
Headlights .............................92
High Beam ........................ .94, 128
High Beam Indicator .....................128
Illuminated Entry ........................16
Instrument Cluster ..................... .128
Low Fuel ............................ .128
Map Reading ........................95, 114
Oil Pressure .......................... .128
Park .................................94
Passing ...............................94
Seat Belt Reminder ..................... .128
Service ...............................378
Tire Pressure Monitoring (TPMS) ............128
Traction Control ........................226
Turn Signal ..........................67, 91
Warning (Instrument Cluster Description) ......128Loading Vehicle
.......................269, 271
Capacities ............................271
Tires ............................... .237
Locks Automatic Door .........................22
Door .................................20
Lubrication, Body ........................ .344
Lug Nuts ...............................288
Maintenance Free Battery ....................340
Maintenance, General ..................... .128
Maintenance Procedures ....................333
Maintenance Schedule ..................... .388
Malfunction Indicator Light (Check Engine) .......331
Manual, Service ..........................401
Map/Reading Lights ....................95, 114
Methanol ...............................263
Mirrors .................................72
Electric Remote .........................73
414 INDEX

Owner’s Manual (Operator Manual)..........4,401
Paint Care ............................. .355
Parking Brake ............................218
ParkSense® System, Rear ....................105
Passing Light .............................94
Personal Settings ..........................169
Pets ....................................61
Placard, Tire And Loading Information ..........238
Power Mirrors ...............................73
Steering .......................... .217, 218
Windows ..............................22
Power Steering Fluid .......................385
Pregnant Women And Seat Belts ...............33
Pretensioners Seat Belts ..............................34
Radial Ply Tires ..........................245 Radiator Cap (Coolant Pressure Cap)
...........349
Radio Operation ..........................182
Rear Camera .............................111
Rear ParkSense System .....................105
Rearview Mirrors ..........................72
Recorder, Event Data .......................51
Recreational Towing .......................283
Reformulated Gasoline .....................262
Refrigerant ............................. .342
Reminder, Seat Belt .........................26
Remote Keyless Entry (RKE) FCC General Information ..................19
Remote Sound System (Radio) Controls .........181
Replacement Bulbs ........................376
Replacement Keys .........................14
Replacement Parts ........................ .333
Replacement Tires ........................ .253
Reporting Safety Defects ....................400
Restraint, Head ...........................86
416 INDEX

Restraints, Child...........................52
Restraints, Occupant ........................24
Rotation, Tires .......................... .256
Safety Checks Inside Vehicle ..................65
Safety Checks Outside Vehicle .................67
Safety Defects, Reporting ....................400
Safety, Exhaust Gas .........................64
Safety Information, Tire .....................230
Safety Tips ...............................63
Schedule, Maintenance .....................388
Seat Belt Adjustable Upper Shoulder Belt Anchorage ......32
Automatic Locking Retractor (ALR) ...........34
Energy Management Feature ................34
Lap/Shoulder Belt Operation ................29
Lap/Shoulder Belts .......................27
Lap/Shoulder Belt Untwisting ...............31
Pregnant Women ........................33 Seat Belt Pretensioner
.....................34
Seat Belt Reminder .......................26
Seat Belt System .........................24
Seat Belt Maintenance ..................... .360
Seat Belt Reminder .........................26
Seat Belts ............................ .25, 65
Adjustable Shoulder Belt ...................32
Adjustable Upper Shoulder Anchorage .........32
Child Restraint ..........................52
Front Seat ........................25, 27, 29
Inspection .............................65
Operating Instructions ....................29
Pregnant Women ........................33
Pretensioners ...........................34
Rear Seat ..............................27
Reminder ............................ .128
Untwisting Procedure .....................31
Seats ...................................76
Adjustment ............................76
10
INDEX 417

Heated...............................85
Security Alarm ............................15
Selection Of Coolant (Antifreeze) ..............383
SENTRY KEY® FCC General Information ..................14
Sentry Key (Immobilizer) ....................13
Service Assistance ........................ .397
Service Contract ..........................399
Service Manuals ..........................401
Service Reminder Indicator ..................128
Shift Lever Override .......................324
Shoulder Belts ............................27
Signals, Turn ..........................67, 128
Snow Chains (Tire Chains) ...................254
Snow Tires ............................. .247
Spare Tire .......................... .249, 250
Spark Plugs ............................ .383
Speed Control (Cruise Control) ................101
Speedometer ............................ .128Starting
............................... .200
Automatic Transmission ..................200
Cold Weather ..........................201
Engine Fails To Start .....................201
Steering Column Lock ..........................100
Power ............................217, 218
Steering Wheel Audio Controls ...............181
Steering Wheel Mounted Sound System Controls . . .181
Storage ............................... .375
Storage, Vehicle .......................... .375
Storing Your Vehicle .......................375
Supplemental Restraint System - Air Bag .........38
Sway Control, Trailer .......................227
Synthetic Engine Oil .......................336
Tachometer ............................. .128
Telescoping Steering Column .................100
Tire And Loading Information Placard .......237, 238
418 INDEX