warning light Ram ProMaster 2016 Diesel Supplement

NOTE:If theGeneric Warning Light comes on, a
Service Fuel Filter message displays and a single chime is
heard with the ignition in the ON/RUN position or while
driving, there may there may be a problem with your
water separator wiring or sensor.
Please see your authorized dealer for service.
CAUTION!
If the “Generic Warning Lamp” remains on and a
Service Fuel Filter message displays, DO NOT
START engine before you drain the water from the
fuel filter to avoid engine damage.
Fuel Filter Replacement
Please see your authorized dealer for fuel filter replace-
ment.
Priming If The Engine Has Run Out Of Fuel
WARNING!
• Do not open the high pressure fuel system with the
engine running. Engine operation causes high fuel
pressure. High pressure fuel spray can cause seri-
ous injury or death.
• Do not drain the fuel filter/water separator when
the engine is running. Fuel and fuel vapors may
escape causing as fire that can result in serious
injury or death.
1. Add a substantial amount of fuel to the tank, approxi- mately 2 to 5 gal (8L to 19L).
2. Turn the ignition to the ON/RUN position. This will activate the in-tank fuel pump for approximately 30
seconds. Repeat this process twice.
108 MAINTAINING YOUR VEHICLE

Brake System
Brake Master Cylinder — Brake Fluid Level Check
The fluid level of the master cylinder should be checked
when performing under the hood service, or immedi-
ately if the “Brake System Warning Light” indicates
system failure.
The brake master cylinder has a translucent plastic
reservoir. On the outboard side of the reservoir, there is a
“MAX” mark and a “MIN” mark. The fluid level must be
kept within these two marks. Do not add fluid above the
full mark because leakage may occur at the cap.
With disc brakes, the fluid level can be expected to fall as
the brake linings wear. However, an unexpected drop in
fluid level may be caused by a leak and a system check
should be conducted.Refer to “Fluids, Lubricants, And Genuine Parts” in
“Maintaining Your Vehicle” for further information.WARNING!
•
Use only manufacturer’s recommended brake
fluid. Refer to “Fluids, Lubricants, and Genuine
Parts” in “Maintaining Your Vehicle” for further
information. Using the wrong type of brake fluid
can severely damage your brake system and/or
impair its performance. The proper type of brake
fluid for your vehicle is also identified on the
original factory installed hydraulic master cylinder
reservoir.
• To avoid contamination from foreign matter or
moisture, use only new brake fluid or fluid that has
been in a tightly closed container. Keep the master
cylinder reservoir cap secured at all times. Brake
(Continued)
6
MAINTAINING YOUR VEHICLE 117

Adding Engine Coolant (Antifreeze)............113
Adding Fuel ..............................82
Air Bag Light .............................19
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .106
Antifreeze (Engine Coolant) ...............112,119
Disposal ..............................115
Anti-Lock Warning Light .....................40
Automated Manual Transmission Fluid Type ........................... .123
Battery ............................. .20, 110
Charging System Light ....................20
Brake Fluid ............................ .123
Brake System ............................117
Fluid Check ...........................117
Master Cylinder ........................117
Warning Light ..........................26
Capacities, Fluid ..........................119 Caps, Filler
Oil (Engine) .......................... .105
Radiator (Coolant Pressure) ................115
Coolant Pressure Cap (Radiator Cap) ...........115
Cooling System ...........................111
Adding Coolant (Antifreeze) ...............113
Coolant Capacity .......................119
Coolant Level ..........................111
Disposal Of Used Coolant .................115
Drain, Flush, And Refill ...................112
Points To Remember .....................116
Pressure Cap ..........................115
Radiator Cap ..........................115
Selection Of Coolant (Antifreeze) ......112,119,120
Cruise Light .......................... .46, 47
Diesel Exhaust Fluid (DEF) ..................120
Diesel Fuel .......................... .76, 120
Diesel Fuel Requirements .................76, 120
136 INDEX

Bulk Storage Of.........................83
Diesel Fuel System, Re-Priming ...............108
Disposal Antifreeze (Engine Coolant) ................115
Door Ajar ...............................20
Door Ajar Light ...........................20
Draining Fuel/Water Separator Filter ...........107
Electronic Speed Control (Cruise Control) .........11
Electronic Throttle Control Warning Light .........21
Electronic Vehicle Information Center (EVIC) ......48
Engine ................................ .102
Air Cleaner .......................... .106
Block Heater ...........................61
Break-In Recommendations ..................8
Compartment ......................... .102
Coolant (Antifreeze) .....................120
Fuel Requirements ......................119
Identification ......................... .102Idling
................................59
Oil .......................... .104, 119, 120
Oil Filler Cap ......................... .105
Oil Selection ...........................119
Filters Air Cleaner .......................... .106
Engine Fuel .......................... .107
Engine Oil ........................ .106, 120
Engine Oil Disposal .....................106
Flashers Turn Signal ............................44
Fluid Capacities ..........................119
Fluid Level Checks Brake ................................117
Fluids, Lubricants And Genuine Parts ...........120
Fuel ................................ .76, 82
Adding ...............................82
Diesel ......................... .76, 82, 120
8
INDEX 137

Filter............................ .107, 120
Requirements ....................... .76, 119
Specifications ...........................78
Tank Capacity ..........................119
Gear Ranges ..............................64
Gross Axle Weight Rating ....................89
Gross Vehicle Weight Rating ..................88
Hitches Trailer Towing ..........................91
Information Center, Vehicle ...................48
Instrument Cluster ..................14, 22, 24, 44
Intervention Regeneration Strategy .............110
Lights AirBag ...............................19
Brake Warning ..........................26 Cruise
............................ .46, 47
Engine Temperature Warning ................22
Malfunction Indicator (Check Engine) ..........37
Park .................................45
Seat Belt Reminder .......................18
Tire Pressure Monitoring (TPMS) .............32
Turn Signal ............................44
Warning (Instrument Cluster Description) . . . .22, 44
Maintenance Procedures ....................103
Maintenance Schedule ..................... .126
Malfunction Indicator Light (Check Engine) .......37
New Vehicle Break-In Period ...................8
Oil, Engine ......................... .104, 120
Capacity ..............................119
Change Interval ....................... .105
Dipstick ............................. .104
138 INDEX

Disposal............................. .106
Filter ............................ .106, 120
Filter Disposal ........................ .106
Materials Added To ..................... .106
Pressure Warning Light ....................28
Recommendation ....................104, 119
Viscosity ......................... .105, 119
Oil Pressure Light ..........................28
Power Steering Fluid ...................... .123
Radiator Cap (Coolant Pressure Cap) ........112,115
Schedule, Maintenance .....................126
Seat Belts Reminder ..............................18
Selection Of Coolant (Antifreeze) ..............120
Signals, Turn .............................44
Speed Control (Cruise Control) ................11Starting
.................................53
Engine Block Heater ......................61
Starting Procedures .........................53
Starting Procedures (Diesel Engines) .............53
Ti re s Pressure Warning Light ....................32
Trailer Towing ..........................95
Tongue Weight/Trailer Weight .................92
Towing .................................88
Guide ................................92
Weight ...............................92
Trailer Towing ............................88
Cooling System Tips ......................99
Hitches ...............................91
Minimum Requirements ...................93
Tips .................................98
Trailer And Tongue Weight .................92
Wiring ................................96
8
INDEX 139