cooling Ram ProMaster 2017 User Guide

that meets the requirements of FCA Material Standard
MS.90032. When adding engine coolant (antifreeze):
•We recommend using MOPAR Antifreeze/Coolant
10 Year/150,000 Mile Formula OAT (Organic Additive
Technology) that meets the requirements of FCA Mate-
rial Standard MS.90032.
• Mix a minimum solution of 50% OAT engine coolant
that meets the requirements of FCA Material Standard
MS.90032 and distilled water. Use higher concentrations
(not to exceed 70%) if temperatures below 34°F (37°C)
are anticipated. Please contact your authorized dealer
for assistance.
• Use only high purity water such as distilled or deionized
water when mixing the water/engine coolant (anti-
freeze) solution. The use of lower quality water will
reduce the amount of corrosion protection in the engine
cooling system.
NOTE:
• It is the owner’s responsibility to maintain the proper
level of protection against freezing according to the
temperatures occurring in the area where the vehicle is
operated. •
Some vehicles require special tools to add coolant prop-
erly. Failure to fill these systems properly could lead to
severe internal engine damage. If any coolant is needed
to be added to the system, please contact your local
authorized dealer.
• Mixing engine coolant (antifreeze) types is not recom-
mended and can result in cooling system damage. If
HOAT and OAT coolant are mixed in an emergency,
have a authorized dealer drain, flush, and refill with
OAT coolant (conforming to MS.90032) as soon as pos-
sible.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of engine
coolant (antifreeze), and to ensure that engine coolant
(antifreeze) will return to the radiator from the coolant
recovery tank.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
292 MAINTAINING YOUR VEHICLE

WARNING!
•Do not open hot engine cooling system. Never add
engine coolant (antifreeze) when the engine is over-
heated. Do not loosen or remove the cap to cool an
overheated engine. Heat causes pressure to build up
in the cooling system. To prevent scalding or injury,
do not remove the pressure cap while the system is
hot or under pressure.
• Do not use a pressure cap other than the one speci-
fied for your vehicle. Personal injury or engine
damage may result.
Disposal Of Used Engine Coolant
Used ethylene glycol-based engine coolant (antifreeze) is a
regulated substance requiring proper disposal. Check with
your local authorities to determine the disposal rules for
your community. To prevent ingestion by animals or
children, do not store ethylene glycol-based engine coolant
in open containers or allow it to remain in puddles on the
ground. If ingested by a child or pet, seek emergency
assistance immediately. Clean up any ground spills imme-
diately.
Coolant Level
The coolant expansion bottle provides a quick visual
method for determining that the coolant level is adequate.
With engine off and cold, the level of the engine coolant
(antifreeze) in the bottle should be between the “MIN” and
“MAX” marks.
Points To Remember
NOTE: When the vehicle is stopped after a few miles/
kilometers of operation, you may observe vapor coming
from the front of the engine compartment. This is normally
a result of moisture from rain, snow, or high humidity
accumulating on the radiator and being vaporized when
the thermostat opens, allowing hot engine coolant (anti-
freeze) to enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
• Do not overfill the coolant expansion bottle.
• Check the coolant freeze point in the radiator and in the
coolant expansion bottle. If engine coolant (antifreeze)
needs to be added, the contents of the coolant expansion
bottle must also be protected against freezing.
7
MAINTAINING YOUR VEHICLE 293

•If frequent engine coolant (antifreeze) additions are
required, the cooling system should be pressure tested
for leaks.
• Maintain engine coolant (antifreeze) concentration at a
minimum of 50% OAT coolant (conforming to
MS.90032) and distilled water for proper corrosion pro-
tection of your engine which contains aluminum com-
ponents.
• Make sure that the coolant expansion bottle overflow
hoses are not kinked or obstructed.
• Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean.
• Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install ONLY
the correct type thermostat. Other designs may result in
unsatisfactory engine coolant (antifreeze) performance,
poor gas mileage, and increased emissions.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically. Refer to the “Maintenance Schedule” for the proper maintenance
intervals.
WARNING!
Riding the brakes can lead to brake failure and possi-
bly a collision. Driving with your foot resting or riding
on the brake pedal can result in abnormally high brake
temperatures, excessive lining wear, and possible
brake damage. You would not have your full braking
capacity in an emergency.
Master Cylinder — Brake Fluid Level Check
The fluid level in the master cylinder should be checked
when performing underhood services, or immediately if
the “Brake System Warning Light” indicates system failure.
Clean the top of the master cylinder area before removing
the cap. Add fluid to bring the level up to the top of the
“FULL” mark on the side of the master cylinder reservoir.
Overfilling of fluid is not recommended because it may
cause leaking in the system.
Add enough fluid to bring the level up to the requirements
described on the brake fluid reservoir. With disc brakes,
294 MAINTAINING YOUR VEHICLE

CavityMaxi Fuse Mini Fuse Description
F04 50 Amp Red
(3.6 Gasoline Engine) –
Secondary Power Distribution Center
(PDC) (Trans Power Relay, Vacuum Pump,
KL30 for the Shifter Transmission Module
[STM]) (3.6 Gasoline Engine)
F04 40 Amp Orange
(3.0 Diesel Engine) –
Fuel Filter Heater (3.0 Diesel Engine)
F05 30 Amp Green –SELESPEED Pump RELE (3.0 Diesel
Engine) - If Equipped
F06 40 Amp Orange
(non A/C)
60 Amp Blue (A/C) –
Engine Cooling Fan - 2nd Speed
F07 50 Amp Red
(non A/C)
60 Amp Blue (A/C) –
Engine Cooling Fan - 1st Speed
F08 40 Amp Orange –Passenger Compartment Blower
F09 –15 Amp Blue Rear Power Outlet
F10 –15 Amp Blue Horn
F11 –15 Amp Blue Fuel Pressure Regulator (MPROP)-DRV
(3.0 Diesel Engine) — If Equipped
F14 –20 Amp Yellow Power Outlet
F15 –7.5 Amp Brown USB Charger
304 MAINTAINING YOUR VEHICLE

Front, Rear Roof Lamps
1. Remove two screw and remove the lamp assembly.
2. Remove the socket bulb by turning counterclockwise.
3. Remove bulb and replace as needed.
4. Reinstall the bulb socket and rotate clockwise to lock inplace.
5. Reinstall lamp.
Rear Tail, Stop, Backup, Turn Signal And Rear Side
Marker Lamps
1. Open rear doors.
2. Remove the two screws and remove the tail lamp.
3. Remove the tail/stop, turn signal, backup and rear side marker bulb/socket by rotating counter-clockwise.
4. Remove the bulb and replace as needed.
5. Reinstall bulb/socket and rotate clockwise to lock in place.
6. Reinstall lamp.
FLUID CAPACITIES
U.S. Metric
Fuel (Approximate) 24 Gallons90 Liters
Engine Oil with Filter
3.6L Engine (SAE 5W-20,
API Certified) 6 Quarts
5.6 Liters
Cooling System *
3.6L Engine (MOPAR Antifreeze/
Engine Coolant 10 Year/150,000 Mile
Formula or equivalent) 10.5 Quarts
10 Liters
7
MAINTAINING YOUR VEHICLE 315

FLUIDS, LUBRICANTS, AND GENUINE PARTS
Engine
ComponentFluid, Lubricant, or Genuine Part
Engine Coolant We recommend you use MOPAR Antifreeze/Coolant 10 Year/150,000 Mile Formula OAT
(Organic Additive Technology) meeting the requirements of FCA Material Standard
MS.90032.
Engine Oil We recommend you use API Certified SAE 5W-20 Engine Oil, meeting the requirements
of FCA Material Standard MS-6395 such as MOPAR, Pennzoil, and Shell Helix. Refer to
your engine oil filler cap for correct SAE grade.
Engine Oil Filter We recommend you use MOPAR Engine Oil Filters.
Spark Plugs We recommend you use MOPAR Spark Plugs.
Fuel Selection 87 Octane, 0-15% Ethanol.
CAUTION!
•Mixing of engine coolant (antifreeze) other than speci-
fied Organic Additive Technology (OAT) engine cool-
ant (antifreeze), may result in engine damage and may
decrease corrosion protection. Organic Additive Tech-
nology (OAT) engine coolant is different and should
(Continued)
CAUTION! (Continued)
not be mixed with Hybrid Organic Additive Technol-
ogy (HOAT) engine coolant (antifreeze) or any “glob-
ally compatible” coolant (antifreeze). If a non-OAT
engine coolant (antifreeze) is introduced into the cool-
ing system in an emergency, the cooling system will
need to be drained, flushed, and refilled with fresh
(Continued)
316 MAINTAINING YOUR VEHICLE

Once A Month Or Before A Long Trip:
•Check engine oil level
• Check windshield washer fluid level
• Check the tire inflation pressures and look for unusual
wear or damage
• Check the fluid levels of the coolant reservoir, brake
master cylinder, and power steering and fill as needed
• Check function of all interior and exterior lights
Required Maintenance Intervals
Refer to the maintenance schedules on the following page
for the required maintenance intervals.At Every Oil Change Interval As Indicated By Oil Change Indicator System:
•Change oil and filter.
• Rotate the tires. Rotate at the first sign of irregular
wear, even if it occurs before the oil indicator
system turns on.
• Inspect battery and clean and tighten terminals as
required.
• Inspect brake pads, shoes, rotors, drums, hoses and
park brake.
• Inspect engine cooling system protection and hoses.
• Inspect exhaust system.
• Inspect engine air cleaner if using in dusty or
off-road conditions. 8
MAINTENANCE SCHEDULES 321

Brake Fluid.............................. .317
Brake, Parking ............................ .189
Brake System ......................... .191, 294
Anti-Lock (ABS) ........................ .191
Fluid Check ........................... .294
Parking .............................. .189
Warning Light .......................... .107
Brake/Transmission Interlock ..................179
Bulb Replacement .......................311,312
Bulbs, Light ........................... .53, 311
Camera, Rear ..............................89
Capacities, Fluid .......................... .315
Caps, Filler Fuel ................................. .227
Power Steering ......................... .189
Radiator (Coolant Pressure) .................292
Carbon Monoxide Warning .................50, 226
Cargo Light ...............................78
Car Washes .............................. .297
Cellular Phone ........................... .157
Certification Label ......................... .228
Chains, Tire ............................. .217
Chart, Tire Sizing .......................... .200
Check Engine Light (Malfunction Indicator Light). . . .279 Checking Your Vehicle For Safety
................50
Checks, Safety .............................50
Child Restraint .............................42
Child Restraints Booster Seats ............................45
Child Restraints ..........................42
Child Seat Installation ......................48
Infants And Child Restraints .................44
Older Children And Child Restraints ...........44
Clean Air Gasoline ........................ .223
Climate Control ........................... .157
Cold Weather Operation ..................... .176
Compact Disc (CD) Maintenance ................156
Compact Spare Tire ........................ .212
Console, Overhead ..........................91
Contract, Service .......................... .328
Coolant

Pressure Cap (Radiator Cap) .............292
Cooling System ........................... .290
Adding Coolant (Antifreeze) .................291
Coolant Capacity ........................ .315
Coolant Level ....................... .290, 293
Disposal Of Used Coolant ..................293
Drain, Flush, And Refill ....................290
Inspection ............................. .293
Points To Remember ..................... .29310
INDEX 335

Pressure Cap........................... .292
Radiator Cap .......................... .292
Selection Of Coolant (Antifreeze) .......291, 315, 316
Corrosion Protection ....................... .297
Cruise Light ..............................119
Cupholders ........................... .94, 301
Customer Assistance ....................... .326
Customer Programmable Features ...............144
Dealer Service ............................ .280
Defroster, Windshield ........................51
Diagnostic System, Onboard ...................278
Dimmer Control ............................75
Dimmer Switch, Headlight .....................76
Dipsticks Automatic Transmission ....................296
Oil (Engine) ........................... .281
Power Steering ......................... .189
Disabled Vehicle Towing .....................272
Disposal Antifreeze (Engine Coolant) .................293
Door Ajar ............................... .104
Door Ajar Light ........................... .104
Door Locks ................................17
Door Locks, Automatic .......................18 Driving
Through Flowing, Rising, Or Shallow Standing
Water ................................ .187
Electric Remote Mirrors .......................59
Electronic Brake Control System ................191
Brake Assist System ...................... .193
Electronic Speed Control (Cruise Control) ..........82
Electronic Stability Control (ESC) ...............193
Electronic Throttle Control Warning Light .........105
Emergency, In Case Of Freeing Vehicle When Stuck .................271
Jump Starting .......................... .267
Emission Control System Maintenance ............279
Engine Air Cleaner ............................ .284
Block Heater ........................... .177
Break-In Recommendations ..................49
Checking Oil Level ...................... .281
Compartment .......................... .277
Compartment

Identification .................277
Coolant (Antifreeze) ...................290, 316
Cooling .............................. .290
Exhaust Gas Caution ...................50, 226
Fails To Start ........................... .176
336 INDEX

Flooded, Starting........................ .176
Fuel Requirements ....................223, 315
Jump Starting .......................... .267
Oil ........................... .281, 315, 316
Oil Filter .............................. .283
Oil Selection ........................ .282, 315
Oil Synthetic ........................... .283
Overheating ........................... .242
Starting .............................. .176
Engine Oil Viscosity ........................ .282
Engine Oil Viscosity Chart ....................282
Enhanced Accident Response Feature ............274
Entry System, Illuminated .....................14
Ethanol ................................. .224
Exhaust Gas Caution .....................50, 226
Exhaust System ........................ .50, 284
Exterior Lighting ............................74
Exterior Lights .............................53
Filters Air Cleaner ............................ .284
Air Conditioning .....................164, 287
Engine Oil ......................... .283, 316
Engine Oil Disposal ...................... .283Flashers
Hazard Warning ........................ .242
Turn Signal ......................... .53, 118
Flooded Engine Starting ..................... .176
Fluid Capacities ........................... .315
Fluid Leaks ...............................53
Fluid Level Checks Automatic Transmission ....................296
Brake ................................ .294
Cooling System ......................... .290
Power Steering ......................... .189
Fluids, Lubricants And Genuine Parts ............316
Fog Lights ................................76
Four-Way Hazard Flasher .....................242
Freeing A Stuck Vehicle ..................... .271
Fuel ................................... .223
Adding .............................. .227
Additives ............................. .225
Clean

Air ............................. .223
Ethanol .............................. .224
Filler Cap (Gas Cap) ..................... .227
Gasoline .............................. .223
Materials Added ........................ .225
Methanol ............................. .224
Octane Rating ....................... .223, 316
Requirements ....................... .223, 315
10
INDEX 337