Power steering Ram ProMaster 2019 User Guide
[x] Cancel search | Manufacturer: RAM, Model Year: 2019, Model line: ProMaster, Model: Ram ProMaster 2019Pages: 332, PDF Size: 3.66 MB
Page 227 of 332
SCHEDULED SERVICING
Your vehicle is equipped with an automatic oil change
indicator system. The oil change indicator system will
remind you that it is time to take your vehicle in for
scheduled maintenance.
Based on engine operation conditions, the oil change
indicator message will illuminate in the instrument cluster.
This means that service is required for your vehicle.
Operating conditions such as frequent short-trips, trailer
tow, and extremely hot or cold ambient temperatures will
influence when the “Oil Change Required” message is
displayed. Severe Operating Conditions can cause the
change oil message to illuminate as early as 3,500 miles
(5,600 km) since last reset. Have your vehicle serviced as
soon as possible, within the next 500 miles (805 km).
Your authorized dealer will reset the oil change indicator
message after completing the scheduled oil change. If a
scheduled oil change is performed by someone other than
your authorized dealer, the message can be reset by
referring to the steps described under “Instrument Cluster
Display” in “Getting To Know Your Instrument Panel” for
further information.NOTE:
Under no circumstances should oil change inter-
vals exceed 10,000 miles (16,000 km), twelve months or 350
hours of engine run time, whichever comes first. The 350
hours of engine run or idle time is generally only a concern
for fleet customers.
Severe Duty All Models
Change Engine Oil at 4,000 miles (6,500 km) or 350 hours of
engine run time if the vehicle is operated in a dusty and off
road environment or is operated predominately at idle or
only very low engine RPM’s. This type of vehicle use is
considered Severe Duty.
Once A Month Or Before A Long Trip:
• Check engine oil level.
• Check windshield washer fluid level.
• Check the tire inflation pressures and look for unusual
wear or damage. Rotate at the first sign of irregular
wear, even if it occurs before the oil indicator system
turns on.
• Check the fluid levels of the coolant reservoir, brake
master cylinder, and power steering and fill as needed.
• Check function of all interior and exterior lights.
8
SERVICING AND MAINTENANCE 225
Page 231 of 332
ENGINE COMPARTMENT
3.6L Engine
1 — Washer Fluid Reservoir
2 — Engine Oil Fill
3 — Engine Oil Dipstick
4 — Brake Fluid Reservoir5 — Power Distribution Center (Fuses)
6 — Coolant Reservoir
7 — Power Steering Reservoir
8
SERVICING AND MAINTENANCE 229
Page 286 of 332
Chassis
ComponentFluid, Lubricant, Or Genuine Part
Automatic Transmission Use Only ATF+4 Automatic Transmission Fluid. Failure to
use ATF+4 fluid may affect the function or performance of
your transmission. We recommend Mopar ATF+4 Fluid.
Brake Master Cylinder We recommend you use Mopar DOT 4.
DOT 4 brake fluid must be changed every two years
regardless of mileage.
Power Steering Reservoir Use Pentosin CHF 11S power steering fluid meeting FCA
Material Standard MS-11655.
284 TECHNICAL SPECIFICATIONS
Page 319 of 332
Belts, Seat............................... .131
Body Builders Guide ..........................5
Body Mechanism Lubrication ..................236
B-Pillar Location .......................... .251
Brake Assist System .........................90
Brake Control System, Electronic ................89
Brake Fluid .......................... .243, 284
Brake, Parking ............................ .139
Brake System ......................... .243, 276
Anti-Lock (ABS) ..........................88
Fluid Check ........................... .243
Master Cylinder ........................ .243
Parking .............................. .139
Warning Light ...........................75
Brake/Transmission Interlock ..................142
Bulb Replacement ......................... .179
Bulbs, Light .......................... .133, 179
Camera, Rear ............................ .158
Capacities, Fluid .......................... .282
Caps, Filler Fuel ................................. .160
Oil (Engine) ........................... .229
Power Steering ......................... .150
Radiator (Coolant Pressure) .................241 Carbon Monoxide Warning
................130, 281
Cargo Area Cover ...........................57
Cargo Compartment .........................57
Cargo Light ...............................42
Car Washes .............................. .270
Certification Label ......................... .161
Change Oil Indicator .........................70
Changing A Flat Tire .....................194, 245
Chart, Tire Sizing .......................... .247
Check Engine Light (Malfunction Indicator Light) ....84
Checking Your Vehicle For Safety ...............130
Checks, Safety ............................ .130
Child Restraint ........................... .123
Child Restraints Booster Seats ........................... .126
Child
Seat Installation .....................128
Infant And Child Restraints .................125
Older Children And Child Restraints ...........125
Clean Air Gasoline ........................ .278
Cleaning Wheels ............................... .265
Climate Control ............................45
Manual ................................46
Rear ..................................49
Cold Weather Operation ..................... .137
12
INDEX 317
Page 320 of 332
Compact Spare Tire........................ .263
Contract, Service .......................... .312
Cooling Pressure Cap (Radiator Cap) ............241
Cooling System ........................... .238
Adding Coolant (Antifreeze) .................240
Coolant Level ....................... .239, 242
Cooling Capacity ........................ .282
Disposal Of Used Coolant ..................242
Drain, Flush, And Refill ....................239
Inspection ............................. .242
Points To Remember ..................... .242
Pressure Cap ........................... .241
Radiator Cap .......................... .241
Selection Of Coolant (Antifreeze) ..........239, 282
Corrosion Protection ....................... .269
Cruise Light ...............................82
Cupholders ........................... .60, 273
Customer Assistance ....................... .310
Customer Programmable Features ...............287
Cybersecurity ............................ .286
Dealer Service ............................ .231
Defroster, Windshield ....................... .131
Diagnostic System, Onboard ....................83
Dimmer Control Switch .......................43 Dimmer Switch
Headlight ...............................39
Dipsticks Automatic Transmission ....................245
Power Steering ......................... .150
Disable Vehicle Towing ..................... .220
Disposal Antifreeze (Engine Coolant) .................242
Door Ajar .................................75
Door Ajar Light ............................75
Door Locks ................................22
Automatic ..............................23
Doors ....................................22
Driver ’s Seat Back Tilt ........................23
Driving Through Flowing, Rising, Or Shallow Standing
Water ................................ .175
Electrical
Power Outlets .......................60
Electric Brake Control System ...................89
Electric Remote Mirrors .......................36
Electronic Speed Control (Cruise Control) .........151
Electronic Stability Control (ESC) ................90
Electronic Throttle Control Warning Light ..........75
318 INDEX
Page 321 of 332
Emergency, In Case OfFreeing Vehicle When Stuck .................219
Jacking ........................... .194, 245
Jump Starting .......................... .213
Emission Control System Maintenance ............84
Engine ................................. .229
Air Cleaner ............................ .233
Block Heater ........................... .138
Break-In Recommendations .................139
Compartment .......................... .229
Compartment Identification .................229
Coolant (Antifreeze) ...................239, 282
Cooling .............................. .238
Exhaust Gas Caution ...................130, 281
Fails To Start ........................... .137
Flooded, Starting ........................ .137
Fuel Requirements ....................278, 282
Jump Starting .......................... .213
Oil .............................. .232, 282
Oil Filler Cap .......................... .229
Oil Filter .............................. .233
Oil Selection ........................ .232, 282
Oil Synthetic ........................... .233
Overheating ........................... .217
Starting .............................. .137Engine Oil Viscosity
........................ .232
Engine Oil Viscosity Chart ....................232
Enhanced Accident Response Feature ............222
Entry System, Illuminated .....................44
Ethanol ................................. .279
Exhaust Gas Cautions ....................130, 281
Exhaust System ....................... .130, 237
Exterior Lights ......................... .38, 133
Filters Air Cleaner ............................ .233
Air Conditioning ..................... .52, 235
Engine Oil ......................... .233,
282
Engine Oil Disposal ...................... .233
Flashers Hazard Warning ........................ .179
Turn Signals ......................... .82, 133
Flooded Engine Starting ..................... .137
Fluid Capacities ........................... .282
Fluid Leaks .............................. .133
Fluid Level Checks Automatic Transmission ....................245
Brake ................................ .243
Cooling System ......................... .239
Power Steering ......................... .150
12
INDEX 319
Page 325 of 332
Oil, Engine........................... .232, 282
Capacity .............................. .282
Change Interval ........................ .232
Dipstick .............................. .230
Disposal .............................. .233
Filter ............................. .233, 282
Filter Disposal .......................... .233
Identification Logo ...................... .232
Materials Added To ...................... .233
Pressure Warning Light .....................77
Recommendation .....................232, 282
Synthetic ............................. .233
Viscosity .......................... .232, 282
Oil Filter, Change ......................... .233
Oil Filter, Selection ......................... .233
Oil Pressure Light ...........................77
Onboard Diagnostic System ....................83
Operating Precautions ........................83
Operator Manual Owner’s Manual .......................5,314
Outside Rearview Mirrors ...................34, 35
Overheating, Engine ....................... .217
Paint Care ............................... .269
Parking Brake ............................ .139ParkSense System, Rear
..................... .154
Passing Light ..............................40
Pets ................................... .129
Placard, Tire And Loading Information ...........251
Power Mirrors ................................36
Outlet (Auxiliary Electrical Outlet) .............60
Steering ........................... .149, 150
Windows ...............................53
Power Steering Fluid ....................... .284
Pregnant Women And Seat Belts ................108
Preparation For Jacking ...................194, 200
Radial Ply Tires ........................... .257
Radiator Cap (Coolant Pressure Cap) .............241
Radio Frequency General
Information .................18, 21, 300
Rear Camera ............................. .158
Rear ParkSense System ..................... .154
Rearview Mirror ............................34
Recreational Towing ........................ .173
Reformulated Gasoline ...................... .278
Refrigerant .............................. .235
Release, Hood ..............................55
Reminder, Seat Belt ........................ .101
12
INDEX 323
Page 327 of 332
Signals, Turn.......................... .82, 133
Snow Chains (Tire Chains) ....................266
Snow Tires .............................. .262
Spare Tires ........................ .262, 263, 264
Spark Plugs ............................. .282
Speed Control (Cruise Control) .................151
Starting ................................ .137
Automatic Transmission ....................137
Button .................................18
Cold Weather .......................... .137
Engine Fails To Start ..................... .137
Steering ..................................34
Column Lock ............................34
Power ............................ .149, 150
Steering Wheel Audio Controls .................298
Storage, Vehicle ........................ .51, 269
Storing Your Vehicle ....................... .269
Supplemental Restraint System – Air Bag ..........112
Sway Control, Trailer .........................93
Synthetic Engine Oil ....................... .233
Telescoping Steering Column ...................34
Tire And Loading Information Placard ............251
Tire Markings ............................ .246
Tires......................... .133, 254, 262, 267Aging (Life Of Tires)
..................... .259
Air Pressure ........................... .254
Chains ............................... .266
Changing .......................... .194, 245
Compact Spare ......................... .263
General Information ...................254, 262
High Speed ............................ .257
Inflation Pressure ....................... .256
Jacking ........................... .194, 245
Life Of Tires ........................... .259
Load Capacity ...................... .251, 252
Pressure Monitoring System (TPMS) .........77, 95
Quality Grading ........................ .267
Radial ............................... .257
Replacement ........................... .260
Rotation .............................. .267
Safety ............................ .245,
254
Sizes ................................ .247
Snow Tires ............................ .262
Spare Tires ......................... .262, 264
Spinning .............................. .258
Trailer Towing .......................... .169
Tread Wear Indicators .....................258
Wheel Nut Torque ....................... .276
Tire Safety Information ...................... .245
12
INDEX 325