key Ram ProMaster City 2015 Service Manual

CAUTION!
•The tow eye must be used exclusively for roadside
assistance operations. Only use the tow eye with an
appropriate device in accordance with the highway
code (a rigid bar or rope) to flat tow the vehicle for
a short distance to the nearest service location.
• Tow eyes MUST NOT be used to tow vehicles off
the road or where there are obstacles.
• In compliance with the above conditions, towing
with a tow eye must take place with two vehicles
(one towing, the other towed) aligned as much as
possible along the same center line. Damage to
your vehicle may occur if these guidelines are not
followed.
Front Tow Eye Installation
The front tow eye receptacle is located behind a door,
located on the right front bumper fascia. To install the
tow eye, open the door using the vehicle key or a small
screwdriver, and thread the tow eye into the receptacle.
Insert the wheel bolt wrench handle through the eye and
tighten, refer to “Jacking and Tire Changing” for further
information. The tow eye must be fully seated to the
attaching bracket through the lower front fascia as
shown. If the tow eye is not fully seated to the attaching
bracket, the vehicle should not be towed.
Rear Tow Eye Installation
The rear tow eye receptacle is located behind a door on
the rear bumper fascia.
To install the tow eye, open the door using the vehicle
key or a small screwdriver, and thread the tow eye into
the receptacle.
6
WHAT TO DO IN EMERGENCIES 319

If the ignition key is unavailable, or the vehicle’s battery
is discharged, refer to “SHIFT LEVER OVERRIDE” in
this section for instructions on shifting the transmission
out of PARK for towing.
CAUTION!
•Do not use sling-type equipment when towing.
Vehicle damage may occur.
• When securing the vehicle to a flatbed truck, do not
attach to front or rear suspension components.
Damage to your vehicle may result from improper
towing.
The manufacturer recommends towing your vehicle with
all four wheels OFF the ground using a flatbed.
If flatbed equipment is not available, this vehicle must be
towed with the front wheels OFF the ground (using a
towing dolly, or wheel lift equipment with the front
wheels raised).
CAUTION!
Towing this vehicle in violation of the above require-
ments can cause severe transmission damage. Dam-
age from improper towing is not covered under the
New Vehicle Limited Warranty.
SHIFT LEVER OVERRIDE
If a malfunction occurs and the shift lever cannot be
moved out of the PARK position, you can use the
following procedure to temporarily move the shift lever:
1. Turn the engine OFF.
2. Firmly apply the parking brake.
3. Using a screwdriver or similar tool, carefully separate the shift lever boot from the center console.6
WHAT TO DO IN EMERGENCIES 321

IGNITION KEY REMOVAL OVERRIDE
This vehicle is equipped with a Key Ignition Park Inter-
lock which requires the transmission to be in PARK
before the ignition switch can be turned to the LOCK/
OFF (key removal) position. To remove the key manually,
proceed as follows:
1. Firmly apply the parking brake
2. Remove the Allen Key located in the rear cargo area, inthe tool bag (if equipped) or on the left side in the
cargo box.
3. Unlock the steering column, pull the tilt/telescoping control handle down.
4. Pull the steering wheel outward until it is in the end of the travel position, then lock the steering column in
position, push the control handle up until fully en-
gaged. 5. Using the Allen key, undo the lower steering column
cover screws, and remove the lower cover.
6. Pull the release tab downwards using one hand and with the other one remove the key, sliding it outwards.
Lower Steering Column Screw Locations
6
WHAT TO DO IN EMERGENCIES 323

7. Once the key is removed, reinstall the steering columncover.
CAUTION!
It is advisable to contact your Authorized Dealer to
have the reinstall procedure carried out. If you would
like to proceed in performing the reinstall procedure
special attention must be paid to the correct coupling
of the clips. Otherwise damage to the cover or noise
might be heard due to incorrect fastening of the
lower cover.
Release Tab Location
324 WHAT TO DO IN EMERGENCIES

CavityMaxi Fuse Mini Fuse Description
F15 15 Amp Blue Available
F16 5 Amp Tan ECM and Transmission Shifter
F17 25 Amp Clear ECM Power Loads
F18 5 Amp Tan ECM Load, Main Relay
F19 7.5 Amp Brown Air Conditioning
F20 30 Amp Green Rear Defroster
F21 5 Amp Tan Key Unlock
F22 10 Amp Red Primary ECM Loads
F23 20 Amp Yellow BSM System
F24 5 Amp Tan BSM System, Positive Key and Steering
Angle Sensor
F30 15 Amp Blue Fog Lamp
F81 – Available
F82 20 Amp Yellow Available
F83 20 Amp Yellow Fuel Pump
7
MAINTAINING YOUR VEHICLE 363

Adding Fluid...................... .353, 377
Fluid and Filter Changes ..................353
Fluid Change ......................... .353
Fluid Level Check ...................352, 353
Fluid Type ........................ .352, 377
Special Additives ...................... .352
Auto Up Power Windows ....................27
Auxiliary Electrical Outlet (Power Outlet) ........131
Axle Lubrication ......................... .377
Battery ................................ .336
Keyless Transmitter Replacement (RKE) ........19
Belts, Seat ...............................88
Body Builders Guide ........................6
Body Mechanism Lubrication .................338
B-Pillar Location ......................... .236
Brake Assist System ...................... .222
Brake Fluid ............................ .377
Brake, Parking .......................... .218Brake System
........................ .220, 349
Anti-Lock (ABS) ....................... .221
Fluid Check ....................... .350, 377
Master Cylinder ....................... .350
Parking ............................. .218
Warning Light ........................ .147
Brake/Transmission Interlock .................204
Bulb Replacement ..................... .370, 371
Bulbs, Light .......................... .90, 370
Camera, Rear ........................... .129
Capacities, Fluid ......................... .374
Caps, Filler Fuel ................................ .265
Oil (Engine) ....................... .327, 334
Power Steering ........................ .217
Radiator (Coolant Pressure) ................347
Carbon Monoxide Warning ................87, 264
Cargo Tie-Downs ........................ .137
10
INDEX 397

Speedometer......................... .147
Tachometer ........................... .147
Gear Ranges ............................ .206
Gear Select Lever Override ..................321
General Information ....................180, 260
Glass Cleaning .......................... .358
Gross Axle Weight Rating ................267, 270
Gross Vehicle Weight Rating ..............267, 270
Guide, Body Builders ........................6
GVWR ................................ .267
Hazard Driving Through Flowing, Rising, or Shallow
Standing Water ........................ .214
Hazard Warning Flasher ....................287
Headlights ..............................110
Cleaning ............................ .358
Passing ..............................111
Head Restraints ......................... .103Heated Mirrors
.......................... .140
Heated Seats ............................ .102
Heater, Engine Block ...................... .201
Hill Start Assist .......................... .223
Hitches Trailer Towing ........................ .273
Holder, Cup ............................ .135
Hood Release ........................... .107
Ignition .................................12
Key..................................12
Ignition Key Removal .......................12
Immobilizer (Sentry Key) ....................14
Inside Rearview Mirror ......................94
Instrument Cluster .....................146, 147
Instrument Panel and Controls ................145
Instrument Panel Cover .....................357
Instrument Panel Lens Cleaning ...............359
Interior Appearance Care ....................357
402 INDEX

Introduction..............................4
iPod® Control .......................... .177
iPod®/USB/MP3 Control ...................177
Bluetooth® Streaming Audio ...............177
Jump Starting ............................311
Key-In Reminder ..........................14
Key, Replacement ..........................15
Keys ...................................12
Key, Sentry (Immobilizer) ....................14
Lane Change Assist ........................112
Lap/Shoulder Belts .........................35
Latches .................................90
Lead Free Gasoline ....................... .260
Leaks, Fluid ..............................90
Life of Tires ............................ .251
Light Bulbs .......................... .90, 370Lights
.............................. .90, 110
Airbag ......................... .57, 88, 147
Anti-Lock ............................ .147
Brake Assist Warning ....................226
Brake Warning ........................ .147
Bulb Replacement ...................... .371
Check Engine (Malfunction Indicator) .........147
Cruise .............................. .147
Exterior ...............................90
Fog ................................ .147
Hazard Warning Flasher ..................287
High Beam ........................... .147
High Beam Indicator .....................147
Instrument Cluster ..................... .147
Oil Pressure .......................... .147
Park .................................112
Passing ..............................111
Seat Belt Reminder ..................... .147
Service .............................. .371
10
INDEX 403

Radiator Cap (Coolant Pressure Cap)...........347
Radio Operation ......................... .180
Rear Camera ........................... .129
Rear ParkSense System .....................122
Rear Window Defroster .....................184
Recorder, Event Data .......................60
Recreational Towing ...................... .283
Reformulated Gasoline .....................261
Refrigerant ............................. .338
Reminder, Seat Belt .........................34
Remote Keyless Entry (RKE) FCC General Information ..................20
Remote Sound System (Radio) Controls .........178
Replacement Bulbs ....................... .370
Replacement Keys .........................15
Replacement Parts ........................ .331
Replacement Tires ........................ .251
Reporting Safety Defects ....................391
Restraint, Head .......................... .103Restraints, Child
...........................61
Restraints, Occupant ........................32
Rotation, Tires .......................... .253
Safety Checks Inside Vehicle ..................88
Safety Checks Outside Vehicle .................90
Safety Defects, Reporting ....................391
Safety, Exhaust Gas .........................87
Safety Information, Tire .....................229
Safety Tips ...............................86
Schedule, Maintenance .....................380
Seat Belt Adjustable Upper Shoulder Belt Anchorage ......41
Automatic Locking Retractor (ALR) ...........43
Energy Management Feature ................43
Lap/Shoulder Belt Operation ................38
Lap/Shoulder Belts .......................35
Lap/Shoulder Belt Untwisting ...............40
Pregnant Women ........................42
406 INDEX

Seat Belt Pretensioner.....................43
Seat Belt Reminder .......................34
Seat Belt System .........................32
Seat Belt Maintenance ..................... .359
Seat Belt Reminder .........................34
Seat Belts ............................ .34, 88
Adjustable Shoulder Belt ...................41
Adjustable Upper Shoulder Anchorage .........41
Child Restraint ..........................61
Front Seat ....................... .34, 35, 38
Inspection .............................88
Operating Instructions ....................38
Pregnant Women ........................42
Pretensioners ...........................43
Rear Seat ..............................35
Reminder ............................ .147
Untwisting Procedure .....................40
Seats ...................................98
Adjustment ............................98 Heated
.............................. .102
Security Alarm ............................16
Selection of Coolant (Antifreeze) ...............375
SENTRY KEY® FCC General Information ..................16
Sentry Key (Immobilizer) ....................14
Service Assistance ........................ .387
Service Contract ......................... .389
Service Manuals ......................... .392
Shifting Automatic Transmission ..................204
Shift Lever Override ...................... .321
Shoulder Belts ............................35
Signals, Turn ......................... .90, 147
Snow Chains (Tire Chains) ...................253
Snow Tires ............................. .246
Spare Tire .......................... .248, 249
Spark Plugs ............................ .375
10
INDEX 407