transmission Ram ProMaster City 2017 Service Manual

WARNING!(Continued)
•Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts, causing the
brake fluid to catch fire. Brake fluid can also damage
painted and vinyl surfaces, care should be taken to
avoid its contact with these surfaces.
• Do not allow petroleum based fluid to contaminate
the brake fluid. Brake seal components could be
damaged, causing partial or complete brake failure.
This could result in a collision.
Power Steering Fluid
Check the fluid level with the vehicle on flat ground and
engine cold. Fluid should be between MIN and MAX
references on the reservoir body.
The level may go over the MAX line when oil is hot.
If topping off is required, make sure the oil you use is
approved. Refer to “Fluids, Lubricants and Genuine Parts”
in the section for further information.
WARNING!
Because it is flammable, do not allow the power
steering fluid to come into contact with hot engine
parts
NOTE: Power steering fluid consumption is very low. If
you need to top off your fluid often and multiple times
have your system inspected by your authorized dealer.
Automatic Transmission
Selection Of Lubricant
It is important to use the proper transmission fluid to
ensure optimum transmission performance and life. Use
only the manufacturer’s specified transmission fluid. Refer
to “Fluids, Lubricants, And Genuine Parts” in this section
for fluid specifications. It is important to maintain the
transmission fluid at the correct level using the recom-
mended fluid.
NOTE: No chemical flushes should be used in any trans-
mission; only the approved lubricant should be used.
294 MAINTAINING YOUR VEHICLE

CAUTION!
Using a transmission fluid other than the manufactur-
er ’s recommended fluid may cause deterioration in
transmission shift quality and/or torque converter
shudder. Refer to “Fluids, Lubricants, And Genuine
Parts” in this section for fluid specifications.
Special Additives
The manufacturer strongly recommends against using any
special additives in the transmission. Automatic Transmis-
sion Fluid (ATF) is an engineered product and its perfor-
mance may be impaired by supplemental additives. There-
fore, do not add any fluid additives to the transmission.
Avoid using transmission sealers as they may adversely
affect seals.
CAUTION!
Do not use chemical flushes in your transmission as
the chemicals can damage your transmission compo-
nents. Such damage is not covered by the New Vehicle
Limited Warranty.
Fluid Level Check
The fluid level is preset at the factory and does not require
adjustment under normal operating conditions. Routine
fluid level checks are not required, therefore the transmis-
sion has no dipstick. Your authorized dealer can check
your transmission fluid level using special service tools. If
you notice fluid leakage or transmission malfunction, visit
your authorized dealer immediately to have the transmis-
sion fluid level checked. Operating the vehicle with an
improper fluid level can cause severe transmission dam-
age.
CAUTION!
If a transmission fluid leak occurs, visit your autho-
rized dealer immediately. Severe transmission damage
may occur. Your authorized dealer has the proper tools
to adjust the fluid level accurately.
Fluid And Filter Changes
Under normal operating conditions, the fluid installed at
the factory will provide satisfactory lubrication for the life
of the vehicle.
7
MAINTAINING YOUR VEHICLE 295

Routine fluid and filter changes are not required. However,
change the fluid and filter if the fluid becomes contami-
nated (with water, etc.), or if the transmission is disas-
sembled for any reason.
Appearance Care And Protection From Corrosion
Protection Of Body And Paint From Corrosion
Vehicle body care requirements vary according to geo-
graphic locations and usage. Chemicals that make roads
passable in snow and ice and those that are sprayed on
trees and road surfaces during other seasons are highly
corrosive to the metal in your vehicle. Outside parking,
which exposes your vehicle to airborne contaminants, road
surfaces on which the vehicle is operated, extreme hot or
cold weather and other extreme conditions will have an
adverse effect on paint, metal trim, and underbody protec-
tion.
The following maintenance recommendations will enable
you to obtain maximum benefit from the corrosion resis-
tance built into your vehicle.
What Causes Corrosion?
Corrosion is the result of deterioration or removal of paint
and protective coatings from your vehicle.The most common causes are:
•
Road salt, dirt and moisture accumulation.
• Stone and gravel impact.
• Insects, tree sap and tar.
• Salt in the air near seacoast localities.
• Atmospheric fallout/industrial pollutants.
Washing
•Wash your vehicle regularly. Always wash your vehicle
in the shade using MOPAR Car Wash, or a mild car wash
soap, and rinse the panels completely with clear water.
• If insects, tar, or other similar deposits have accumulated
on your vehicle, use MOPAR Super Kleen Bug and Tar
Remover to remove.
• Use a high quality cleaner wax, such as MOPAR Cleaner
Wax to remove road film, stains and to protect your
paint finish. Take care never to scratch the paint.
• Avoid using abrasive compounds and power buffing
that may diminish the gloss or thin out the paint finish.
296 MAINTAINING YOUR VEHICLE

CavityMaxi Fuse Mini Fuse Description
F02 20 Amp Yellow –Front Heated Seats
F03 20 Amp Yellow –Ignition Switch
F04 40 Amp Orange –BSM System Module
F06 20 Amp Yellow –Radiator Fan - Low Speed
F07 50 Amp Red –Radiator Fan - High Speed
F08 40 Amp Orange –Blower Motor
F10 –10 Amp Red Horn
F11 –15 Amp Blue Secondary Loads ECM
F14 –15 Amp Blue High Beam
F16 –5 Amp Tan ECM and Transmission Shifter
F17 –25 Amp Clear ECM Power Loads
F18 –5 Amp Tan ECM Load, Main Relay
F19 –7.5 Amp Brown Air Conditioning
F20 –30 Amp Green Rear Defroster
F21 –5 Amp Tan Key Unlock
F22 –10 Amp Red Primary ECM Loads
F23 –20 Amp Yellow BSM System
F24 –5 Amp Tan BSM System, Positive Key and Steering
Angle Sensor
302 MAINTAINING YOUR VEHICLE

Chassis
ComponentFluid, Lubricant, or Genuine Part
Automatic Transmission Use only MOPAR ZF 8&9 Speed ATF Automatic Transmission Fluid, or equivalent.
Failure to use the correct fluid may affect the function or performance of your
transmission.
Brake Master Cylinder We recommend you use MOPAR DOT 4.
The fluid must be changed every 24 months. This interval is time based only,
mileage intervals do not apply.
Power Steering Reservoir Use Pentosin CHF 11S power steering fluid meeting FCA Material Standard
MS-11655.
316 MAINTAINING YOUR VEHICLE

Adding Engine Coolant (Antifreeze).............290
Additives, Fuel ........................... .228
AirBag ..................................38 Air Bag Operation .........................40
Driver Knee Air Bag .......................40
Enhanced Accident Response ................271
Event Data Recorder (EDR) .................271
If A Deployment Occurs ....................44
Knee Impact Bolsters .......................40
Maintaining Your Air Bag System ..............47
Transporting Pets .........................66
Air Bag Light .......................... .68, 132
Air Bag Maintenance .........................47
Air Cleaner, Engine (Engine Air Cleaner Filter) ......282
Air Conditioner Maintenance ..................283
Air Conditioning Filter ...................... .167
Air Conditioning, Operating Tips ............166, 168
Air Conditioning Refrigerant ...............283, 284
Air Conditioning System .....................283
Air Filter ............................... .282
Air Pressure, Tires ..........................211
Alarm (Security Alarm) .......................14
Alarm System (Security Alarm) .................14
Alterations/Modifications, Vehicle ................7
Antifreeze (Engine Coolant) ................289, 313 Disposal
.............................. .291
Anti-Lock Brake System (ABS) .................194
Appearance Care .......................... .296
Ashtray ................................ .106
Audio Systems (Radio) ...................... .159
Auto Down Power Windows ...................22
Automatic Transaxle ......................11,178
Automatic Transmission ...............181, 182, 295
Adding Fluid ....................... .295, 316
Fluid And Filter Changes ...................295
Fluid Change .......................... .295
Fluid Level Check .....................294, 295
Fluid Type ......................... .294, 316
Special Additives ........................ .295
Auto

Up Power Windows .....................22
Auxiliary Electrical Outlet (Power Outlet) .........104
Axle Lubrication .......................... .316
Battery .............................. .133, 282
Charging System Light ....................133
Keyless Key Fob Replacement ................16
Belts, Seat .................................68
Body Builders Guide ..........................6
Body Mechanism Lubrication ..................285
B-Pillar Location .......................... .206
330 INDEX

Brake Assist System........................ .195
Brake Fluid .............................. .316
Brake, Parking ............................ .192
Brake System ......................... .194, 293
Anti-Lock (ABS) ........................ .194
Fluid Check ........................ .293, 316
Master Cylinder ........................ .293
Parking .............................. .192
Warning Light .......................... .135
Brake/Transmission Interlock ..................182
Bulb Replacement ...................... .307, 308
Bulbs, Light ........................... .71, 307
Camera, Rear ............................ .103
Capacities, Fluid .......................... .313
Caps, Filler Fuel ................................. .229
Oil (Engine) ........................ .275, 281
Power Steering ......................... .191
Radiator (Coolant Pressure) .................291
Carbon Monoxide Warning .................68, 229
Cargo Tie-Downs .......................... .109
Car Washes .............................. .296
Cellular Phone ........................... .160
Certification Label ......................... .230Chains, Tire
............................. .219
Chart, Tire Sizing .......................... .202
Check Engine Light (Malfunction Indicator Light). . . .277
Checking Your Vehicle For Safety ................67
Checks, Safety .............................67
Child Restraint .............................48
Child Restraints Booster Seats ............................52
Child Restraints ..........................48
Child Seat Installation ......................61
How To Stow An Unused ALR Seat Belt .........58
Infants And Child Restraints .................50
Locating The LATCH Anchorages ..............56
Lower Anchors And Tethers For Children ........54
Older Children And Child Restraints ...........51
Seating Positions ..........................
53
Cigar Lighter ............................ .106
Clean Air Gasoline ........................ .226
Cleaning Wheels ............................... .297
Climate Control ........................... .161
Manual ............................... .161
Cold Weather Operation ..................... .178
Compact Spare Tire ........................ .214
Contract, Service .......................... .32610
INDEX 331

Schedule, Maintenance...................... .318
Seat Belt Adjustable Upper Shoulder Belt Anchorage .......32
Automatic Locking Retractor (ALR) ............35
Energy Management Feature .................35
Lap/Shoulder Belt Operation .................31
Lap/Shoulder Belts ........................28
Lap/Shoulder Belt Untwisting ................32
Pregnant Women .........................34
Seat Belt Pretensioner ......................35
Seat Belt Reminder ........................27
Seat Belt Maintenance ...................... .300
Seat Belt Reminder ..........................27
Seat Belts ............................. .27, 68
Adjustable Shoulder Belt ....................32
Adjustable Upper Shoulder Anchorage ..........32
Child Restraint ...........................48
Front Seat ........................ .27, 28, 31
Inspection ..............................68
Operating Instructions ......................31
Pregnant Women .........................34
Pretensioners ............................35
Rear Seat ...............................28
Reminder ............................. .132
Untwisting Procedure ......................32 Seats
....................................78
Adjustment .............................78
Heated .................................81
Security Alarm .............................14
Selection Of Coolant (Antifreeze) ...............314
Sentry Key (Immobilizer) ......................13
Service Assistance ......................... .324
Service Contract .......................... .326
Service Manuals .......................... .327
Shifting Automatic Transmission ....................182
Shift Lever Override ....................... .269
Shoulder Belts .............................28
Signals, Turn .......................... .71, 144
Snow Chains (Tire Chains) ....................219
Snow Tires .............................. .213
Spare Tire ............................ .214, 216
Spark Plugs ............................. .314
Specifications Fuel (Gasoline) ......................... .314
O
il.................................. .314
Speed Control Accel/Decel .............................98
Speed Control (Cruise Control) ..................95
Starting ................................ .178
338 INDEX

Automatic Transmission....................178
Cold Weather .......................... .178
Engine Fails To Start ..................... .179
Steering Power ............................... .191
Tilt Column .............................95
Wheel, Tilt ..............................95
Steering Wheel Audio Controls .................159
Steering Wheel Mounted Sound System Controls . . . .159
Storage ................................. .307
Storage, Vehicle ....................... .166, 307
Storing Your Vehicle ....................... .307
Supplemental Restraint System - Air Bag ...........38
Synthetic Engine Oil ....................... .281
Telescoping Steering Column ...................95
Tie Down Hooks, Cargo ..................... .109
Tilt Steering Column .........................95
Tire And Loading Information Placard ........206, 207
Tire Markings ............................ .200
Tires.......................... .71, 209, 214, 220
Aging (Life Of Tires) ..................... .218
Air Pressure ........................... .209
Chains ............................... .219
Compact Spare ......................... .214General Information
...................209, 214
High Speed .............................211
Inflation Pressures ........................211
Life Of Tires ........................... .218
Load Capacity ...................... .206, 207
Pressure Monitor System (TPMS) .............222
Pressure Warning Light ....................139
Quality Grading ........................ .220
Radial ............................... .212
Replacement ........................... .218
Rotation .............................. .220
Safety ............................ .200, 209
Sizes ................................ .202
Snow Tires ............................ .213
Spar

e Tire ......................... .214, 216
Spinning .............................. .216
Trailer Towing .......................... .237
Tread Wear Indicators .....................217
Tire Safety Information ...................... .200
Tire Service Kit ........................... .247
Tongue Weight/Trailer Weight .................235
Towing ................................. .232
Disabled Vehicle ........................ .268
Guide ................................ .235
Recreational ........................... .241
10
INDEX 339

Weight............................... .235
Towing Vehicle Behind A Motorhome ............241
Traction ................................ .189
Traction Control .......................... .196
Trailer Towing ............................ .232
Cooling System Tips ..................... .241
Hitches ............................... .234
Minimum Requirements ....................236
Tips ................................. .240
Trailer And Tongue Weight ..................235
Wiring ............................... .238
Trailer Towing Guide ....................... .235
Trailer Weight ............................ .235
Transaxle Automatic ...........................11,178
Transmission ............................. .182
Automatic ...................... .181, 182, 294
Maintenance ........................... .294
Transporting Pets ...........................66
Tread Wear Indicators ...................... .217
Turn Signals ............................. .144
Uconnect Voice Command ....................169
Uniform Tire Quality Grades ..................220
Unleaded Gasoline ........................ .226Untwisting Procedure, Seat Belt
.................32
Vehicle Certification Label ....................230
Vehicle Identification Number (VIN) ...............6
Vehicle Loading .....................207, 230, 232
Vehicle Modifications/Alterations .................7
Vehicle Storage ........................ .166, 307
Viscosity, Engine Oil ....................... .281
Voice Recognition System (VR) .................169
Warnings And Cautions .......................6
Warranty Information ...................... .327
Washers, Windshield ..................... .93, 286
Washing Vehicle .......................... .296
Water Driving Through ........................ .189
Wheel

And Wheel Trim ..................... .297
Wheel And Wheel Trim Care ..................297
Wind Buffeting .............................23
Window Fogging .......................... .167
Windows .................................21
Power .................................21
Windshield Defroster .........................69
Windshield Washers ..................... .93, 286
Fluid ................................ .286
340 INDEX