radiator Ram ProMaster City 2018 User Guide

WARNING!(Continued)
overheated engine. Heat causes pressure to build up
in the cooling system. To prevent scalding or injury,
do not remove the pressure cap while the system is
hot or under pressure.
• Do not use a pressure cap other than the one speci-
fied for your vehicle. Personal injury or engine
damage may result.
Disposal Of Used Coolant
Used ethylene glycol-based coolant (antifreeze) is a regu-
lated substance requiring proper disposal. Check with your
local authorities to determine the disposal rules for your
community. To prevent ingestion by animals or children,
do not store ethylene glycol-based coolant in open contain-
ers or allow it to remain in puddles on the ground. If
ingested by a child or pet, seek emergency assistance
immediately. Clean up any ground spills immediately.
Coolant Level
The coolant expansion bottle provides a quick visual
method for determining that the coolant level is adequate.
With the engine OFF and cold, the level of the engine
coolant (antifreeze) in the bottle should be between the
“MIN” and “MAX” marks. The radiator normally remains completely full, so there is
no need to remove the radiator/coolant pressure cap
unless checking for engine coolant (antifreeze) freeze point
or replacing coolant. Advise your service attendant of this.
As long as the engine operating temperature is satisfactory,
the coolant bottle need only be checked once a month.
When additional engine coolant (antifreeze) is needed to
maintain the proper level, only OAT coolant that meets the
requirements of FCA Material Standard MS.90032 should
be added to the coolant bottle. Do not overfill.
Points To Remember
NOTE:
When the vehicle is stopped after a few miles/
kilometers of operation, you may observe vapor coming
from the front of the engine compartment. This is normally
a result of moisture from rain, snow, or high humidity
accumulating on the radiator and being vaporized when
the thermostat opens, allowing hot engine coolant (anti-
freeze) to enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
• Do not overfill the coolant expansion bottle.
254 SERVICING AND MAINTENANCE

•Check the coolant freeze point in the radiator and in the
coolant expansion bottle. If engine coolant (antifreeze)
needs to be added, the contents of the coolant expansion
bottle must also be protected against freezing.
• If frequent engine coolant (antifreeze) additions are
required, the cooling system should be pressure tested
for leaks.
• Maintain engine coolant (antifreeze) concentration at a
minimum of 50% OAT coolant (conforming to
MS.90032) and distilled water for proper corrosion pro-
tection of your engine which contains aluminum com-
ponents.
• Make sure that the coolant expansion bottle overflow
hoses are not kinked or obstructed.
• Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean.
• Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install ONLY
the correct type thermostat. Other designs may result in
unsatisfactory engine coolant (antifreeze) performance,
poor gas mileage, and increased emissions.Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically. Refer
to the “Maintenance Plan” in this section for the proper
maintenance intervals.
WARNING!
Riding the brakes can lead to brake failure and possi-
bly a collision. Driving with your foot resting or riding
on the brake pedal can result in abnormally high brake
temperatures, excessive lining wear, and possible
brake damage. You would not have your full braking
capacity in an emergency.
Brake Master Cylinder
The fluid in the master cylinder should be checked when
performing under hood services or immediately if the
“Brake Warning Light” is illuminated.
Be sure to clean the top of the master cylinder area before
removing the cap. If necessary, add fluid to bring the fluid
level up to the requirements described on the brake fluid
reservoir. With disc brakes, fluid level can be expected to
fall as the brake pads wear. Brake fluid level should be
8
SERVICING AND MAINTENANCE 255

CAUTION!(Continued)
introduced into the cooling system in an emergency,
the cooling system will need to be drained, flushed,
and refilled with fresh OAT coolant (conforming to
MS.90032), by an authorized dealer as soon as pos-
sible.
• Do not use water alone or alcohol-based engine
coolant (antifreeze) products. Do not use additional
(Continued)
CAUTION! (Continued)
rust inhibitors or antirust products, as they may not
be compatible with the radiator engine coolant and
may plug the radiator.
• This vehicle has not been designed for use with
propylene glycol-based engine coolant (antifreeze).
Use of propylene glycol-based engine coolant (anti-
freeze) is not recommended.
Chassis
Component Fluid, Lubricant, or Genuine Part
Automatic Transmission Use only Mopar ZF 8&9 Speed ATF Automatic Transmission Fluid, or equivalent.
Failure to use the correct fluid may affect the function or performance of your
transmission.
Brake Master Cylinder We recommend you use Mopar DOT 4.
The fluid must be changed every 24 months. This interval is time based only,
mileage intervals do not apply.
Power Steering Reservoir Use Pentosin CHF 11S power steering fluid meeting FCA Material Standard
MS-11655.
298 TECHNICAL SPECIFICATIONS

B-Pillar Location.......................... .267
Brake Assist System .........................97
Brake Fluid .............................. .298
Brake, Parking ............................ .158
Brake System ......................... .255, 290
Anti-Lock (ABS) ..........................96
Fluid Check ........................ .255, 298
Master Cylinder ........................ .255
Parking .............................. .158
Warning Light ...........................83
Brake/Transmission Interlock ..................161
Bulb Replacement ......................... .197
Bulbs, Light .......................... .151, 197
Camera, Rear ............................ .177
Capacities, Fluid .......................... .296
Caps, Filler Fuel ................................. .178
Oil (Engine) ........................ .241, 245
Power Steering ......................... .169
Radiator (Coolant Pressure) .................253
Carbon Monoxide Warning ................148, 295
Cargo Area Features .........................62
Cargo Compartment .........................62
Cargo Tie-Downs ...........................62 Car Washes
.............................. .285
Cellular Phone ........................... .315
Certification Label ......................... .180
Chains, Tire ............................. .282
Changing A Flat Tire .....................209, 261
Chart, Tire Sizing .......................... .263
Check Engine Light (Malfunction Indicator Light) ....93
Checking Your Vehicle For Safety ...............147
Checks, Safety ............................ .147
Child Restraint ........................... .129
Child Restraints Booster Seats ........................... .132
Child Restraints ........................ .129
Child Seat Installation ..................141,
145
How To Stow An Unused ALR Seat Belt ........138
Infants And Child Restraints ................131
Locating The LATCH Anchorages .............136
Lower Anchors And Tethers For Children .......134
Older Children And Child Restraints ...........131
Seating Positions ........................ .133
Cigar Lighter ..............................67
Clean Air Gasoline ........................ .293
Cleaning Wheels ............................... .281
Climate Control ............................49
12
INDEX 333

Manual................................49
Cold Weather Operation ..................... .155
Compact Disc (CD) Maintenance ................323
Compact Spare Tire ........................ .279
Contract, Service .......................... .328
Coolant Pressure Cap (Radiator Cap) .............253
Cooling System ........................... .250
Adding Coolant (Antifreeze) .................252
Coolant Capacity ........................ .296
Coolant Level .......................... .254
Disposal Of Used Coolant ..................254
Drain, Flush, And Refill ....................251
Inspection ......................... .251, 254
Points To Remember ..................... .254
Pressure Cap ........................... .253
Radiator Cap .......................... .253
Selection Of Coolant (Antifreeze) .......251, 296, 297
Corrosion Protection ....................... .285
Cruise Light ...............................92
Cupholders ...............................65
Customer Assistance ....................... .326
Customer Programmable Features ...............301
Daytime Running Lights ......................42
Dealer Service ............................ .244Defroster, Windshield
....................... .149
Diagnostic System, Onboard ....................92
Dipsticks Oil (Engine) ........................... .242
Power Steering ......................... .169
Disabled Vehicle Towing .....................233
Disposal Antifreeze (Engine Coolant) .................254
Door Ajar .................................85
Door Ajar Light ............................85
Door Locks ................................23
Doors ....................................23
Driver’s Seat Back Tilt ........................29
Driving Through Flowing, Rising, Or Shallow Standing
Water ................................ .192
Electrical Outlet, Auxiliary (Power Outlet) ..........
65
Electric Remote Mirrors .......................40
Electronic Brake Control System .................97
Electronic Range Select (ERS)..................167
Electronic Speed Control (Cruise Control) .........170
Electronic Stability Control (ESC) ................99
Electronic Throttle Control Warning Light ..........85
334 INDEX

Viscosity.......................... .245, 296
Oil Filter, Change ......................... .246
Oil Filter, Selection ......................... .246
Oil Pressure Light ...........................86
Onboard Diagnostic System ....................92
Operating Precautions ........................92
Operator Manual (Owner’s Manual) ...............5
Outside Rearview Mirrors .....................38
Overheating, Engine ....................... .230
Owner’s Manual (Operator Manual) ...........5,330
Paint Care ............................... .285
Parking Brake ............................ .158
ParkSense System, Rear ..................... .173
Passing Light ..............................42
Personal Settings .......................... .301
Pets ................................... .147
Placard, Tire And Loading Information ...........267
Power Mirrors ................................40
Steering ........................... .168, 169
Windows ...............................57
Pregnant Women And Seat Belts ................114
Preparation For Jacking ..................... .213Radial Ply Tires
........................... .273
Radiator Cap (Coolant Pressure Cap) .............253
Radio Frequency General Information .....................19, 21
Radio Operation .......................... .315
Rear Camera ............................. .177
Rear ParkSense System ..................... .173
Rear Seat, Folding ...........................29
Recreational Towing ........................ .191
Reformulated Gasoline ...................... .293
Refrigerant .............................. .247
Release, Hood ..............................60
Reminder, Seat Belt ........................ .107
Remote Keyless Entry Programming Additional Key Fobs .............19
Remote Sound System (Radio) Controls ...........314
Replacement Bulbs ........................ .197
Replacement Keys ...........................
21
Replacement Tires ......................... .276
Reporting Safety Defects .....................329
Restraint, Head .............................34
Restraints, Child .......................... .129
Rotation, Tires ............................ .282
Safety Checks Inside Vehicle ...................149
12
INDEX 339