engine RENAULT CLIO 2003 X65 / 2.G Workshop Manual
[x] Cancel search | Manufacturer: RENAULT, Model Year: 2003, Model line: CLIO, Model: RENAULT CLIO 2003 X65 / 2.GPages: 210, PDF Size: 5.64 MB
Page 179 of 210
A
J
Q X B I U D B * T [ G 3 D J H
nu654-6 - CLIO IIC:\Documentum\Checkout
u654-6_eng_T5.WIN 30/10/2002 12:28-page25
5.25
TOWING breakdown,(continued)
• Renault recommends
using a rigid towing bar.
If a rope or cable is used
(where the law allows
this), the vehicle being towed
must be able to brake.
• A vehicle must not be towed if it
is not fit to be driven.
• Do not accelerate or brake
suddenly when towing, as this
may result in damage to the
vehicle.
• When towing a vehicle, do not
exceed15 mph (25 km/h).Towing a vehicle with
automatic transmission: special
notes
Engine switched off:The transmission
is no longer lubricated. It is preferable
to tow this type of vehicle on a trailer
or tow it with the front wheels off the
ground.
In exceptional cases, you can tow the
vehicle with all four wheels on the
ground for a maximum distance of 30
miles (50 km).
The selector lever must be in
neutral (position N).
If the lever becomes jammed in P
position,even though you are
pressing down the brake pedal, the
lever can be released manually.
To do this, unclip coverJ.Presson
both the raised part (under coverJ)
and the unlocking buttonAat the
same time to move the lever from
positionP.
Page 182 of 210
Q X B I U D B * T [ G 3 D J H
nu654-6 - CLIO IIC:\Documentum\Checkout
u654-6_eng_T5.WIN 30/10/2002 12:28-page28
5.28
ACCESSORIES
Using mobile phones and
CB equipment.
Mobile phone equipment
with integrated aerials may
cause interference to the original
electronic systems fitted to the
vehicle: we recommend that you
only use equipment with an
exterior aerial.
Furthermore, we remind you of
the need to conform to the
legislation in force concerning the
use of such equipment.After-sales installation of
non-electrical accessories
(roof bars, towing
attachments, etc.)
Accessories approved by Renault
are based on a strict specification
and are regularly tested. We would
recommend that you use approved
accessories (particularly where
these affect safety) because they are
particularly reliable and
appropriate for your vehicle.
After-sales installation of electric
or electronic accessories
•Any work on the electric circuit
of the vehicle must be carried out
by Renault network engineers: if
the system is connected
incorrectly, it may result in
damage being caused to the
electrical installation and/or the
units connected to it.
• If the vehicle is retrofitted with
any electrical equipment, make
sure that the unit is correctly
protected by a fuse. Ask for
information on the rating and
position of this fuse.
Page 183 of 210
Q X B I U D B * T [ G 3 D J H
nu654-6 - CLIO IIC:\Documentum\Checkout
u654-6_eng_T5.WIN 30/10/2002 12:28-page29
5.29
OPERATING FAULTS
Your vehicle should not be affected by faults likely to keep it off the road for long periods if you have followed the Renault
Servicing Programme regularly.
The following advice will allow you to get going again quickly, albeit temporarily: for reasons of safety, you should
always consult a Renault Dealer as soon as possible.
When starter is activated CAUSES REMEDIAL ACTION
• There is no response. The warning
lights fail to illuminate and the starter
does not turn.Battery lead disconnected or terminals
oxidised.Check battery terminals: scrape clean
if oxidised and re-tighten.
Battery discharged. Connect another battery to the faulty
battery.
Battery unserviceable. Replace the battery.
• Warning lights go dim and starter
turns very slowly.Battery terminals not tight.
Battery terminals oxidised.Check battery terminals: scrape clean
if oxidised and re-tighten.
Battery discharged. Connect another battery to the faulty
battery.
• The engine is difficult to start in
damp conditions or after washing.Poor ignition, ignition system damp. Dry the plug leads and ignition coil.
• The engine is difficult to start when
hot.Poor carburation (bubbles of vaporised
fuel in the circuit).Let the engine cool down.
Lack of compression. Consult a Renault Dealer.
Page 184 of 210
Q X B I U D B * T [ G 3 D J H
nu654-6 - CLIO IIC:\Documentum\Checkout
u654-6_eng_T5.WIN 30/10/2002 12:28-page30
5.30
OPERATING FAULTS(continued)
When starter is activated CAUSES REMEDIAL ACTION
• The engine fires once or twice then
dies and is difficult to start when cold.Immobiliser active. Refer to the “Engine immobiliser”
section.
Starting procedure incorrect Refer to the “starting the engine”
section.
or
Poor fuel supply or ignition fault. If the vehicle will not start, do not
keeptryingtostartit.
Consult a Renault Dealer.
System for cutting off fuel supply
activated if vehicle has been subject to
severe impact.See a Renault Dealer. (Refer to
information on fuel cut-off system in
section 5.)
• Vibrations. Tyres incorrectly inflated, incorrectly
balanced or damaged.Check the tyre pressures and, if they
are correct, have a Renault Dealer check
the condition of the tyres.
• Coolant boiling in expansion bottle. Mechanical fault: cylinder head gasket
blown, water pump faulty.Stop the engine.
Consult a Renault Dealer.
Engine cooling fan not working. Check the appropriate fuse, otherwise
consult a Renault Dealer.
Page 185 of 210
Q X B I U D B * T [ G 3 D J H
nu654-6 - CLIO IIC:\Documentum\Checkout
u654-6_eng_T5.WIN 30/10/2002 12:28-page31
5.31
OPERATING FAULTS(continued)
On the open road CAUSES REMEDIAL ACTION
• Abnormal white smoke from the
exhaust.Mechanical fault: cylinder head gasket
blown.Stop the engine.
Consult a Renault Dealer.
• Smoke under the bonnet. Short circuit. Stop the vehicle, switch off the
ignition, disconnect the battery.
Cooling circuit fault. Consult a Renault Dealer.
• The oil pressure warning light
illuminates
- when cornering or braking. The level is too low. Top up the oil.
- at idle speed. The oil pressure is too low. Consult the nearest Renault Dealer.
- is slow to extinguish or remains
illuminated on acceleration.Loss of oil pressure. Stop and call for the assistance of a
Renault Dealer.
• The engine lacks power. Dirty air filter. Replace the cartridge.
Fuel supply fault. Check the fuel level.
Spark plugs faulty, incorrect gap. Consult a Renault Dealer.
• Idle speed unsteady or engine stalls. Lack of compression (spark plugs,
ignition, air leak)Consult a Renault Dealer.
Page 186 of 210
Q X B I U D B * T [ G 3 D J H
nu654-6 - CLIO IIC:\Documentum\Checkout
u654-6_eng_T5.WIN 30/10/2002 12:28-page32
5.32
OPERATING FAULTS(continued)
On the open road CAUSES REMEDIAL ACTION
• Steering becomes hard to turn. Belt broken. Have the belt replaced.
Lack of oil in pump. Top up oil (see maintenance section).
If the fault persists, consult your
Renault Dealer.
• The engine overheats. The coolant
temperature warning light illuminates
(or the needle on the gauge is in the
red zone).Water pump: belt slack or broken.
Faulty engine cooling fan.Stop the vehicle, switch off the engine
and call for the assistance of a Renault
Dealer.
Coolant leaks. Check the condition of the hoses and
clips.
Check the expansion bottle: it should
contain coolant. If it does not, top up
the level(after letting the engine cool
down).Take care not to burn yourself.
This action is only temporary: consult
your Renault Dealer as soon as
possible.
Radiator
Never fill a hot radiator with cold coolant if a considerable quantity has been lost. After any operation
on the vehicle which has involved even partial draining of the cooling system, it must be refilled with a
new mixture prepared in the correct proportions. Reminder: only products approved by our Technical
Department may be used for this purpose.
Page 189 of 210
Q X B I U D B * T [ G 3 D J H
nu654-6 - CLIO IIC:\Documentum\Checkout
u654-6_eng_T6.WIN 28/10/2002 12:31-page1
6.01
Section 6: Technical specifications
Identification plates ............................................................................................................................. 6.02 ¬6.04
Engine specifications ........................................................................................................................................ 6.05
Weights .................................................................................................................................................. 6.06
¬6.14
Towing weights .................................................................................................................................... 6.06
¬6.14
Dimensions ........................................................................................................................................................ 6.15
Replacement parts ............................................................................................................................................ 6.16
Page 191 of 210
1
3
B
B
B
B 2
B
1.2 1.2 16V
1.4 16V - 1.6 16V 2.0 16V
Q X B I U D B * T [ G 3 D J H
nu654-6 - CLIO IIC:\Documentum\Checkout
u654-6_eng_T6.WIN 28/10/2002 12:31- page 3
6.03
IDENTIFICATION PLATES(continued)
The information on the vehicle
identification plate and the engine
plateBmust be quoted when
writing or ordering parts.
B- Engine plate or engine label
(location differs depending on engine)
1Engine type
2Engine suffix
3Engine number
Page 192 of 210
1
3
B
2
B
B
1.5 dCi
1.9 dTi
Q X B I U D B * T [ G 3 D J H
nu654-6 - CLIO IIC:\Documentum\Checkout
u654-6_eng_T6.WIN 28/10/2002 12:31- page 4
6.04
IDENTIFICATION PLATES(continued)
The information on the vehicle
identification plate and the engine
plateBmust be quoted when
writing or ordering parts.
B- Engine plate or engine label
(location differs depending on
engine)
1Engine type
2Engine suffix
3Engine number
Page 193 of 210
Q X B I U D B * T [ G 3 D J H
nu654-6 - CLIO IIC:\Documentum\Checkout
u654-6_eng_T6.WIN 28/10/2002 12:31- page 5
6.05
ENGINE SPECIFICATIONS
Versions 1.2 1.216V1.416V1.616V2.016V1.5 dCi 1.9 dTi
Vehicle type
(see vehicle
identification plate)B/C/SB0F
B/C/SB10
B/C/SB1K
B/CB2DB/C/SB05
B/C/SB11
B/C/SB0WB/CB1L
B/CB0P
B/CB13B/CB14
B/CB1DCB15
CB1C
CB1G
CB1N
CB1S
CB1TB/C/SB07
B/C/SB08
SB09
BB1WB/CB2C
Engine type
(see engine
plate)
D7F D4F K4J K4M F4R K9K F9Q turbo
Capacity(cm³) 1 149 1 149 1 390 1 598 1 998 1 461 1 870
Fuel gradeUnleaded fuel Diesel
Octane rating95 or 98 (1) 98 – –
Spark plugsOnly use the type specified
for your vehicle’s engine.
Their type is shown on a label in
the engine compartment,
otherwise consult your RENAULT Dealer.
Fitting spark plugs which
are not to specification
may damage the engine.––
(1) If unavailable, unleaded fuel with an octane rating of 91 may be used.