headlight RENAULT KANGOO VAN ZERO EMISSION 2012 X61 / 2.G User Guide

1.84
HEADLIGHT BEAM ADJUSTMENT (2/2)
Temporary adjustment
Open the bonnet and identify the mark-
ing B next to one of the front headlight
projectors.
For each headlight, using a screw-
driver, turn the screw 1 by a quarter
turn towards the - symbol to lower the
beams.
Return to the starting point once your
trip is over: turn the screw 1 by a quar-
ter turn towards the + symbol to raise
the beams.
When driving on the left in a left-
hand drive vehicle (or vice versa),
you must adjust your lights tempo-
rarily during your stay.B
1

4.10
Using a roller type car wash
Return the windscreen wiper stalk to
the Park position (refer to the informa-
tion on the “Windscreen washer, wiper”
in Section 1). Check the mounting of
external accessories, additional lights
and mirrors, and ensure that the wiper
blades are secured with adhesive tape.
Remove the radio aerial mast if your
vehicle is fitted with this equipment.
Remember to remove the tape and refit
the antenna after washing.
Observe the vehicle stopping distances
when driving on gravelled surfaces to
prevent paint damage.
Repair, or have repaired quickly, areas
where the paint has been damaged, to
prevent corrosion spreading.
Remember to visit the body shop pe-
riodically in order to maintain your
anti-corrosion warranty. Refer to the
Maintenance Document.
Respect local regulations about wash-
ing vehicles (e.g. do not wash your ve-
hicle on a public highway).
If it is necessary to clean mechani-
cal components, hinges, etc., spray
them with products approved by our
Technical Department to protect them
after they have been cleaned.
BODYWORK MAINTENANCE (2/2)
Cleaning the headlights
As the headlights are made of plastic
“glass”, use a soft cloth or cotton wool
to clean them. If this does not clean
them properly, moisten the cloth with
soapy water, then wipe clean with a soft
damp cloth or cotton wool.
Finally, carefully dry off with a soft dry
cloth.
Cleaning products containing alco-
hol must not be used.
Vehicles with a matte paint
finish
This type of paint requires certain pre-
cautions.
Do not do the following
– use wax-based products (polishing);
– rub too hard;
– wash the vehicle in a roller-type car
wash;
– wash the vehicle using a high-pres-
sure device;
– attach stickers to the paintwork (risk
of leaving marks).
You should do the following
Wash the vehicle by hand using plenty
of water, using a soft cloth or a gentle
sponge.
We have selected special products
to care for your vehicle and you can
obtain these from the manufactur-
er’s accessory outlets.
Washing the vehicle
Never wash the engine
compartment, the charging
connection or the traction
battery with a high-pressure jet.
This risks damaging the electric cir-
cuit.
Never wash the vehicle while it is
charging.
Risk of electric shock and a risk to
life.

5.1
Section 5: Practical advice
Puncture . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.2
Emergency spare wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . . . . . . . . . . . . . . 5.2
Tyre inflation kit . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.3
Tool kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.6
Wheels, trim . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.7
Changing a wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . . . . . . . . . . . . . . . . . . . 5.8
Tyres . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.10
Headlights: changing bulbs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . . . 5.13
Fog lights: changing bulbs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . . . . 5.15
Rear lights: changing bulbs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . . . 5.16
Indicator lights: changing bulbs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . 5.19
Interior lights: changing bulbs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . . . . . . . . . . 5.20
12 volt battery: troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . 5.22
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.24
Wiper blades . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.26
Towing, breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . . . . . . . . . . . . . . . . . . 5.28
Fitted audio equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . . . . . . . . . . . . . . . 5.31
Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.32
Radio frequency remote control unit: batteries . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . 5.33
Operating faults . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.34

5.13
Front side light
Open the cover 1.
Disconnect the bulb holder wiring 4.
Remove bulb holder 4 from its housing.
Replace the bulb.
Bulb type: W5W
To refit it, carry out the above opera-
tions in reverse order.
Bulb type: H4 It is essential to use 55W anti UV bulbs
to prevent damage to the lights' plastic
glass.
Do not touch the bulb glass. Hold it
by its base.
To refit it, carry out the above opera-
tions in reverse order.
Make sure you reposition the wiring in
its housing before closing the cover 1.
The bulbs are under pres-
sure and can break when
replaced.
Risk of injury.
HEADLIGHTS : changing bulbs (1/2)
The engine may be hot
during operations in close
proximity. In addition, the
engine cooling fan may
start at any moment.
Risk of injury.
Do not do any work under
the bonnet when the vehicle
is charging or when the igni-
tion is switched on.
Dipped beam/main beam
headlights
Open the cover 1.
Disconnect the bulb holder wiring 2.
Unclip spring 3 to remove the bulb
holder 2.
2
1
4
3

5.14
HEADLIGHTS : changing bulbs (2/2)
Direction indicator lights
Turn the bulb holder 5 to release it and
remove it from its location without dis-
connecting the wiring. Replace the
bulb.
Bulb type: PY21W
To refit it, carry out the above opera-
tions in reverse order.
The bulbs are under pres-
sure and can break when
replaced.
Risk of injury.
To comply with local legislation, or
as a precaution, you can obtain an
emergency kit containing a set of
spare bulbs and fuses from an ap-
proved Dealer.
5

5.15
Front fog lights 1
As it is necessary to remove parts or
components (front bumper), you are
advised to have your bulbs replaced
by an approved dealer.
Bulb type: H16
Additional lights
If you wish to fit your car with fog lights
or long range headlights, contact an au-
thorised dealer.
FOG LIGHTS: changing bulbs
1
The engine may be hot
during operations in close
proximity. In addition, the
engine cooling fan may
start at any moment.
Risk of injury.
Any operation on (or modi-
fication to) the electrical
system must be performed
by an approved dealer
since an incorrect connection might
damage the electrical equipment
(harness, components and in partic-
ular the alternator). In addition, your
Dealer has all the parts required for
fitting these units.
Rear fog lights 2
As it is necessary to remove parts or
components (rear bumper), you are
advised to have your bulbs replaced
by an approved dealer.
Bulb type: P21 W
2
The bulbs are under pres-
sure and can break when
replaced.
Risk of injury.

5.37
Electrical equipmentPOSSIBLE CAUSES WHAT TO DO
The wipers do not work. Wiper blades stuck. Free the blades before using the wipers.
Faulty electrical circuit. Consult an approved Dealer.
Fuse damaged. Replace the fuse, refer to the information on
“Fuses”.
The wiper does not stop. Faulty electrical controls. Consult an approved Dealer.
Direction indicators flashing more
quickly. Blown bulb.
Replace the bulb.
The direction indicators do not
work. Faulty electrical circuit.
Consult an approved Dealer.
Fuse damaged. Replace the fuse, refer to the information on
“Fuses”.
The headlights do not switch on or
off. Faulty electrical circuit or control. Consult an approved Dealer.
Fuse damaged.
Replace the fuse, refer to the information on
“Fuses”.
Traces of condensation in the
lights. This is not a fault. Traces of condensation are a natural phenomenon caused by vari-
ations in temperature.
The traces will disappear slowly once the lights are switched on.
OPERATING FAULTS (4/4)

7.2
ALPHABETICAL INDEX (2/5)
driving positionsettings ............................................................1.3\
4 → 1.37
E
»ECO» mode function .................................................. 2.5, 2.9
ECO driving ........................................................................\
. 2.9
»400 volt» electrical circuit ........................................1.2 → 1.7
electric vehicle vehicle range ................................................................. 2.5
batteries ..............................................................\
........... 1.4
noise ..................................................................\
............ 1.6
charge ................................................................1.8 → 1.14
driving .............................................................. 1.6, 2.3, 2.5
»ECO» mode ................................................................. 2.9
important recommendations ................................. 1.7, 1.11
electric windows ..................................................... 3.15 – 3.16
electrical installation .......................................................... 1.11
electronic stability control: ESC .............................2.10 → 2.12
emergency brake assist.........................................2.10 → 2.12
emergency braking ................................................2.10 → 2.12
emergency spare wheel ...................................................... 5.2
energy recovery ...............................................................\
. 1.66, 2.8
»ECO» mode ................................................................. 2.9
saving ................................................................... 2.5 – 2.6
charge meter (function) .................................................. 2.8
consumption .............................................. 1.65 – 1.66, 2.8
charge ................................................................1.8 → 1.14
range ..................................................................\
............ 2.8
energy saving ............................................................. 2.5 – 2.6
energy consumption ............................................ 2.5 – 2.6, 2.8
energy recovery ................................................................... 2.8
engine specifications ........................................................... 6.3
environment ............................................................\
............. 2.7
ESC: electronic stability control .............................2.10 → 2.12
external temperature ......................................................... 1.77 F
faults
operating faults ................................................5.34 → 5.37
fitting a radio ...................................................................... 5.31
fittings ...............................................................\
.....3.18 → 3.20
fog lights ................................................................... 1.82, 5.15
front lights changing bulbs .................................................. 5.13 – 5.14
front passenger air bag deactivation .....................1.54 → 1.56
front seat adjustment .............................................. 1.29 – 1.30
front seats adjustment ........................................................ 1.29 – 1.30
fuel capacity ...............................................................\
......... 1.88
filling ................................................................\
............. 1.88
grade ..................................................................\
.......... 1.88
fuel filler cap ...................................................................... 1.88
fuses ....................................................................... 5.24 – 5.25
G
gear lever..............................................................\
...... 2.3 – 2.4
glove box ........................................................................\
... 3.18
H
handbrake...............................................................\
............. 2.4
hazard warning lights signal .............................................. 1.78
headlight beam adjustment .................................... 1.83 – 1.84
headrest........................................................1.26 → 1.28, 3.23
heated seats ........................................................... 1.29 – 1.30
heating and air conditioning system .................................. 3.11
heating, air conditioning: programming ............... 2.6, 3.7 – 3.8
heating system ........................................................ 3.4 → 3.11
horn ...................................................................\
................ 1.78
horn: flash ..................................................................\
........... 1.78
sounding the horn ........................................................ 1.78

7.3
ALPHABETICAL INDEX (3/5)
hubcap tool ........................................................................\
.. 5.6
I
indicators ......................................................... 1.78, 5.14, 5.19
indicators:direction indicators .............................................. 5.14, 5.19
instrument panel ..............................................1.62 → 1.67
instrument panel ....................................................1.62 → 1.76
instrument panel messages...................................1.68 → 1.76
interior lighting: changing bulbs .................................................. 5.20 – 5.21
interior trim maintenance ..................................................... 4.11 – 4.12
Isofix .................................................................\
.....1.47 → 1.53
J
jack ...................................................................\
............ 5.6, 5.8
L
levels: brake fluid ...................................................................... 4.5
coolant ................................................................\
........... 4.4
windscreen washer reservoir ......................................... 4.5
lifting the vehicle changing a wheel .................................................. 5.8 – 5.9
lighting: interior ............................................................... 3.12 – 3.13
lights adjustment ........................................................ 1.83 – 1.84
changing bulbs .................................................. 5.13 – 5.14
fog lights ...................................................................... 5.15
front ................................................................... 5.13 – 5.14
lights: brake lights .................................................................. 5.16
dipped beam headlights ............................. 1.62, 1.80, 5.13
direction indicators ..................................... 1.62, 1.78, 5.16 fog lights .................................................... 1.62, 1.82, 5.15
hazard warning ............................................................ 1.78
main beam headlights .............................. 1.62, 1.80 – 1.81
number plate lights ...................................................... 5.18
reversing lights ............................................................. 5.16
side lights ..................................................................... 1.80
lights-on warning buzzer........................................... 1.18, 1.81
locking the doors .................................................... 1.23 – 1.24
luggage retaining net ......................................................... 3.26
M
maintenance: bodywork ............................................................ 4.9 – 4.10
interior trim ........................................................ 4.11 – 4.12
mechanical .........................................4.2 – 4.3, 6.8 → 6.13
map reading lights .................................................. 3.12 – 3.13
methods of restraint in addition to the front seat belts ..............
1.38 → 1.40
methods of restraint in addition to the seat belts ...1.38 → 1.42
multimedia (equipment) ..................................................... 3.27
multimedia equipment .............................................. 3.27, 5.31
N
navigation .............................................................\
............. 3.27
navigation system .............................................................. 3.27
O
opening the doors ..................................................1.18 → 1.22
operating faults ................................ 1.62 → 1.64, 5.34 → 5.37
P
paintwork maintenance ....................................................... 4.9 – 4.10
reference ..............................................................\
.......... 6.2
parking distance control.......................................... 2.20 – 2.21
partition ..............................................................\
................ 1.33